SERVICE MANUAL
UHF FM TRANSCEIVERS
1-1-32, Kamiminami, Hirano-ku, Osaka, 547-0003, Japan
S-13713IZ-C1U-1 © 2000 Icom Inc.
INTRODUCTION This service manual describes the latest service information for the IC-F4GT and IC-F4GS at the time of publication. To upgrade quality, all electrical or mechanical parts and internal circuits are subject to change without notice or obligation.
DANGER NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than 16 V. Such a connection could cause a fire hazard and/or electric shock. DO NOT expose the transceiver to rain, snow or any liquids. DO NOT reverse the polarities of the power supply when connecting the transceiver. DO NOT apply an RF signal of more than 20 dBm (100mW) to the antenna connector. This could damage the transceiver’s front end.
ORDERING PARTS Be sure to include the following four points when ordering replacement parts: 1. 2. 3. 4.
10-digit order numbers Component part number and name Equipment model name and unit name Quantity required
IC-F4GT
1130007610 S.IC µPD3140GS IC-F4GT 8810009510 Screw BT M2 x 4 NI-ZU IC-F4GS
IC-F4GS
MAIN UNIT 1 pieces Chassis 10 pieces
Addresses are provided on the inside back cover for your convenience.
REPAIR NOTES 1. 2. 3. 4. 5. 6. 7.
Make sure a problem is internal before disassembling the transceiver. DO NOT open the transceiver until the transceiver is disconnected from its power source. DO NOT force any of the variable components. Turn them slowly and smoothly. DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments. DO NOT keep power ON for a long time when the transceiver is defective. DO NOT transmit power into a signal generator or a sweep generator. ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when using such test equipment. 8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.
TABLE OF CONTENTS SECTION
1
SPECIFICATIONS
SECTION
2
INSIDE VIEWS
SECTION
3
DISASSEMBLY AND OPTION INSTRUCTIONS
SECTION
SECTION
3-1
DISASSEMBLY INSTRUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1
3-2
OPTIONAL UNIT INSTALLATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-2
4
CIRCUIT DESCRIPTION
4-1
RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1
4-2
TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1
4-3
PLL CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2
4-4
POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3
4-5
CPU PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4
5
ADJUSTMENT PROCEDURES
5-1
PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-1
5-2
PLL ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-4
5-3
SOFTWARE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-5
SECTION
6
PARTS LIST
SECTION
7
MECHANICAL PARTS AND DISASSEMBLY
SECTION
8
SEMI-CONDUCTOR INFORMATION
SECTION
9
BOARD LAYOUTS
SECTION
9-1
LOW BAND . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-1
9-2
440–470 MHz BAND EXCEPT W/N-TYPE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-3
9-3
470–500 MHz AND HIGH BANDS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-5
9-4
W/N-TYPE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-7
10 BC-137 OPTIONAL DESKTOP CHARGER INFORMATION 10-1
PARTS LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-1
10-2
DISASSEMBLY INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-1
10-3
VOLTAGE DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-2
10-4
BOARD LAYOUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-2
SECTION
11
BLOCK DIAGRAM
SECTION
12 VOLTAGE DIAGRAM
SECTION 1
SPECIFICATIONS ETS 300 086
Frequency coverage Type of emission
GENERAL
Power supply requirement
Current drain (approx.) RX
400–430 MHz, 440–470 MHz, 470–500 MHz*1*2, 490–512 MHz*1, 490–520 MHz*2 16K0F3E (25 kHz: W-type), 14K0F3E (20 kHz: M-type), 8K50F3E (12.5 kHz: N-type)
Number of channels
TX
EIA/TIA 603
100 ch (100 channel version, except ETS) 32 ch (16 channels × 2 banks: 2-BANK version), 16 ch (16 channel version) 7.2 V DC (negative ground; supplied battery pack)
at High
1.55 A
at Low
800 mA
rated audio
250 mA
stand-by
70 mA
Frequency stability Usable temperature range Dimensions (proj. not included)
±2.0 kHz (W/M-type), ±1.5 kHz (N-type) –25˚C to +55˚C
–30˚C to +60˚C (–22˚C to +140˚C)
54(W) × 132(H) × 35(D) mm; 25⁄32(W) × 53⁄16(H) × 13⁄8(D) inch
Weight (with BP-209)
355 g; 12.5 oz High 4 W Low 1 W
Output power
TRANSMITTER
Modulation system Max. freqequency deviation Spurious emissions Adjacent channel power Transmitter audio distortion
Variable reactance frequency modulation ±5.0 kHz (W-type), ±4.0 kHz (M-type)*3, ±2.5 kHz (N-type) 0.25 µW @ < 1 GHz, 1.0 µW @ < 1 GHz
73 dBc typical
70 dB (W/M-type) 60 dB (N-type)
70 dB typical (25 kHz) 60 dB typical (12.5 kHz)
Less than 5% at 1 kHz, 60% deviation
Less than 3% at 1 kHz, 40% deviation
Limitting charact of modulator
70–100% of max. deviation 3-conductor 2.5(d) mm (1⁄10")/2.2 kΩ
Ext. microphone connector Receive system
Double-conversion superheterodyne system
Intermediate frequencies Sensitivity (typical)
1st: 46.350 MHz, 2nd: 450 kHz 0.3 µV at 12 dB SINAD 0.79 µV (emf) at 20 dB SINAD
Squelch sencitivity
RECEIVER
±0.00025%
0.3 µV at 12 dB SINAD
0.3 µV typical (at threshold) 70 dB (W/M-type) 60 dB (N-type)
75 dB typical (W-type) 65 dB typical (N-type)
Spurious response
70 dB
70 dB typical
Intermoduration rejection ratio
65 dB
70 dB typical
45 dB typical (W/M-type) 43 dB typical (N-type)
45 dB typical (25 kHz) 40 dB typical (12.5 kHz)
Adjacent channel selectivity
Hum and noise Audio output power (at 7.2 V DC)
500 mW typical at 5% distortion with an 8 Ω load 3-conductor 3.5(d) mm (1⁄8")/8 Ω
External SP connector
Measurements made in accordance with EIA/TIA-152-C, 204-D, 603 or ETS 300-086. *1EIA/TIA version only, *2General version only, *3ETS/CEPT version only All stated specifications are subject to change without notice or obligation.
1-1
SECTION 2
INSIDE VIEWS
• MAIN UNIT
TOP VIEW
BOTTOM VIEW Antenna switcing circuit (D1: 1SV307)
Antenna switcing circuit (D2, D8: MA77)
Power amplifier (Q1: 2SK2974) APC IC3A: NJM3403AV Q37: DTA144EU
1st mixer (Q13: 3SK239A)
IF amplifier (Q14: 2SC4215 O)
VCO circuit
PLL IC (IC1: µPD3140GS) D/A converter (IC10: M62363FP-650C) EEPROM IC7: HN58X2432TI [OTHER] HN58X2464TI [100 channel version]
TX/RX switch (D3, D4: MA77)
(
)
CPU (IC8: HD6433876B50H) Low pass filter circuit
Mic amplifier circuit
2-1
SECTION 3
DISASSEMBLY AND OPTION INSTRUCTIONS
3-1 DISASSEMBLY INSTRUCTION • REMOVING THE CHASSIS PANEL 1 2 3 4
Unscrew 1 nut A, and remove 1 knob B. Unscrew 2 screws C. Take off the chassis in the direction of the arrow. Unplug J6 to separate front panel and chassis.
C (nickel, 2 mm) x 2 Chassis
B
J6 (Speaker connector)
A
Front panel
• REMOVING THE MAIN UNIT 1 2 3 4
Remove the searing rubber. Unsolder 4 points D, and unscrew 1 nut E. Unscrew 3 screws F, and 6 screws G (silver, 2 mm) to separate the chassis and the MAIN unit. Take off the MAIN unit in the direction of the arrow.
D
F G
(silver, 2 mm) x 6 Shield cover
F G
F
D
G
MAIN unit
D
E
Guide holes Sealing rubber Chassis
3-1
3-2 OPTIONAL UNIT INSTALLATIONS 1 Remove the option cover. 2 Connect one of UT-96, UT-105, UT-108, UT-109, UT-110, UT-111, and UT-113 optional units to J5. 3 Replace the option cover to the chassis-hole.
Option cover
Option unit
J5
3-2
SECTION 4 CIRCUIT DESCRIPTION The signals from the RF circuit are mixed at the 1st mixer (Q13) with a 1st LO signal coming from the VCO circuit to produce a 46.35 MHz 1st IF signal.
4-1 RECEIVER CIRCUITS 4-1-1 ANTENNA SWITCHING CIRCUIT The antenna switching circuit functions as a low-pass filter while receiving. However, its impedance becomes very high while D2 and D8 are turned ON. Thus transmit signals are blocked from entering the receiver circuits. The antenna switching circuit employs a λ⁄4 type diode switching system.
The 1st IF signal is applied to a pair of crystal filters (FI1) to suppress out-of-band signals. The filtered 1st IF signal is applied to the IF amplifier (Q14), then applied to the 2nd mixer circuit (IC2, pin 16).
Received signals are passed through the low-pass filter (L1, L2, C3, C8, C666). The filtered signals are applied to the λ⁄4 type antenna switching circuit (D2, D8). The passed signals are then applied to the RF amplifier circuit.
4-1-4 2ND IF AND DEMODULATOR CIRCUITS The 2nd mixer circuit converts the 1st IF signal into a 2nd IF signal. A double conversion superheterodyne system (which converts receive signals twice) improves the image rejection ratio and obtains stable receiver gain.
4-1-2 RF CIRCUIT
The 1st IF signal from the IF amplifier is applied to the 2nd mixer section of the FM IF IC (IC2, pin 16), and is mixed with the 2nd LO signal to be converted into a 450 kHz 2nd IF signal.
The RF circuit amplifies signals within the range of frequency coverage and filters out-of-band signals. The signals from the antenna switching circuit are amplified at the RF amplifier (Q12) after passing through the tunable bandpass filter (L17, D10, C85, C86). The amplified signals are applied to the 1st mixer circuit (Q13) after out-of-band signals are suppressed at the 3 stages tunable bandpass filter (D401, L18, C89, C406, D11, L402, C91, C92, C94, D12, L19, C97, C98).
The FM IF IC contains the 2nd mixer, limiter amplifier, quadrature detector and active filter circuits. A 2nd LO signal (30.6 MHz) is produced at the PLL circuit by doubling it’s reference frequency. The 2nd IF signal from the 2nd mixer (IC2, pin 3) passes through a ceramic filter (FI2) to remove unwanted heterodyned frequencies. It is then amplified at the limiter amplifier (IC2, pin 5) and applied to the quadrature detector (IC2, pins 10, 11) to demodulate the 2nd IF signal into AF signals.
Varactor diodes are employed at the bandpass filters that track the filters and are controlled by the CPU (IC8) via the expander IC (IC10) using T1–T4 signals. These diodes tune the center frequency of an RF passband for wide bandwidth receiving and good image response rejection.
4-1-3 1ST MIXER AND 1ST IF CIRCUITS The 1st mixer circuit converts the received signal into a fixed frequency of the 1st IF signal with a PLL output frequency. By changing the PLL frequency, only the desired frequency will pass through a crystal filter at the next stage of the 1st mixer.
2ND IF AND DEMODULATOR CIRCUITS 2nd IF filter 450 kHz C122 R87
R86 8
R88
Active filter "SQLIN" signal to the D/A convertor (IC10, pin 23)
C121
PLL IC IC1 17
FI2
7
5 Noise detector
3
×3
16
2
Noise comp. Mixer
Limiter amp.
FM detector
X4 15.3 MHz
RSSI
IC2 TA31136F 9 AF signal "DET"
R83 C112
10 C116 11
12
16
1st IF from the IF amplifier (Q14)
"NOIS" signal to the CPU pin 19
R82 C113
R5 X3
13
R84
4-2
"SD" signal to the CPU pin 98
4-1-5 AF CIRCUIT
4-2 TRANSMITTER CIRCUITS
AF signals from the FM IF IC (IC2, pin 9) are applied to the mute switch (IC4, pin 1) via the AF filter circuit (IC3b, pins 6, 7). The output signals from pin 11 are applied to the AF power amplifier (IC5, pin 4) after being passed through the [VOL] control (R143).
4-2-1 MICROPHONE AMPLIFIER CIRCUIT
The applied AF signals are amplified at the AF power amplifier circuit (IC5, pin 4) to obtain the specified audio level. The amplified AF signals, output from pin 10, are applied to the internal speaker (SP1) as the “SP” signal via the [SP] jack when no plug is connected to the jack.
The AF signals from the microphone are applied to the microphone amplifier circuit (IC3c, pin 10). The amplified AF signals are passed through the low-pass filter circuit (IC3d, pins 13, 14) via the mute switch (IC4, pins 4, 3). The filtered AF signals are applied to the modulator circuit after being passed through the mute switch (IC4, pins 9, 8).
The microphone amplifier circuit amplifies audio signals with +6 dB/octave pre-emphasis characteristics from the microphone to a level needed for the modulation circuit.
4-1-6 SQUELCH CIRCUIT A squelch circuit cuts out AF signals when no RF signals are received. By detecting noise components in the AF signals, the squelch switches the AF mute switch.
4-2-2 MODULATION CIRCUIT The modulation circuit modulates the VCO oscillating signal (RF signal) using the microphone audio signal.
A portion of the AF signals from the FM IF IC (IC2, pin 9) are applied to the active filter section (IC2, pin 8) where noise components are amplified and detected with an internal noise detector.
The audio signals change the reactance of a diode (D404) to modulate an oscillated signal at the VCO circuit (Q7, Q8). The oscillated signal is amplified at the buffer-amplifiers (Q4, Q6), then applied to the T/R switching circuit (D3, D4).
The active filter section amplifies noise components. The filtered signals are rectified at the noise detector section and converted into “NOIS” (pulse type) signals at the noise comparator section. The “NOIS” signal is applied to the CPU (IC8, pin 19).
4-2-3 DRIVE/POWER AMPLIFIER CIRCUITS
The CPU detects the receiving signal strength from the number of the pulses, and outputs an “RMUT” signal from pin 49. This signal controls the mute switch (IC4, pin 13) to cut the AF signal line.
The signal from the VCO circuit passes through the T/R switching circuit (D3) and is amplified at the buffer (Q403, Q3), pre-drive (Q2) and power amplifier (Q1) to obtain 4 W of RF power (at 7.2 V DC). The amplified signal passes through the antenna switching circuit (D1), and low-pass filter and is then applied to the antenna connector.
4-1-7 WIDE AND NARROW SWITCHING CIRCUIT
The bias current of the pre-drive (Q2) and the power amplifier (Q1) is controlled by the APC circuit.
The “NWC” signal from the CPU (IC8, pin 38) is applied to the Q41. Q41 is switched ON or OFF by the signal. Q41 controls IC2’s detector output to same level both wide band mode and narrow band mode.
4-2-5 APC CIRCUIT The APC circuit (IC3a, Q37) protects the drive and the power amplifiers from excessive current drive, and selects HIGH or LOW output power.
APC CIRCUIT VCC
RF signal from PLL
to antenna
LPF D33
S5
D32
—
TXC Q37 T4
L4
Q1 Power amp.
Q2 Driver amp.
IC3a
Power detector circuit (D32, D33)
+ APC control circuit
4-3
The signal output from the power detector circuit (D32, D33) is applied to the differential amplifier (IC3a, pin 2), and the “T4” signal from the expander (IC10, pin 11), controlled by the CPU (IC8), is applied to the other input for reference.
4-4 POWER SUPPLY CIRCUITS VOLTAGE LINE DESCRIPTION
LINE
The voltage from the attached battery pack.
HV When the driving current is increased, input voltage of the differential amplifier (pin 2) will be increased. In such cases, the differential amplifier output voltage (pin 1) is decreased to reduce the driving current.
VCC
The same voltage as the HV line (battery voltage) which is controlled by the power swtich ([VOL] control).
CPU5
Common 5 V converted from the VCC line by the reference regulator circuit (IC6). The output voltage is applied to the CPU (IC8), the 5 V regulator controller (Q20), reset circuit (IC11) and etc.
T5
5 V for transmitter circuits regulated by the T5 regulator circuit (Q22). The output voltage is applied to the low-pass filter (Q35), buffer amplifiers (Q403, Q3) and etc.
R5
5 V for receiver circuits regulated by the R5 regulator circuit (Q21). The output voltage is applied to the low-pass filter (IC12), analog swtich (IC4), 1st mixer (Q13), RF amplifier (Q12), and etc.
S5
Common 5 V converted from the VCC line by the S5 regulator circuit (Q18, Q19). The output voltage is applied to the buffer amplifier (Q36), APC circuit (IC3A, Q37), and etc.
OPT
The same voltage as the CPU5 line for the optional HM-46L, HM-75A or HS-51 through a resistor (R132).
4-3 PLL CIRCUIT A PLL circuit provides stable oscillation of the transmit frequency and receive 1st LO frequency. The PLL output compares the phase of the divided VCO frequency to the reference frequency. The PLL output frequency is controlled by the divided ratio (N-data) of a programmable divider. The PLL circuit contains the VCO circuit (Q7, Q8). The oscillated signal is amplified at the buffer-amplifiers (Q6, Q5) and then applied to the PLL IC (IC1, pin 2). The PLL IC contains a prescaler, programmable counter, programmable divider and phase detector, etc. The entered signal is divided at the prescaler and programmable counter section by the N-data ratio from the CPU. The divided signal is detected on phase at the phase detector using the reference frequency. If the oscillated signal drifts, its phase changes from that of the reference frequency, causing a lock voltage change to compensate for the drift in the oscillated frequency. A portion of the VCO signal is amplified at the buffer-amplifier (Q4), and is then applied to the receive 1st mixer (Q13) or transmit buffer-amplifier circuit (Q403) via the T/R switching diode (D3, D4).
PLL CIRCUIT VCO circuit Q7, Q8 Buffer Q6
"DEV" signal from the D/A convertor (IC10, pin 22) when transmitting
D3
Buffer Q4
to transmitter circuit to 1st mixer circuit
D4 Buffer Q5
Loop filter
Phase detector
8 45.9 MHz signal to the FM IF IC 17
3
Programmable counter
Programmable divider 16 X4 15.3 MHz
4-4
Prescaler
Shift register
2 3 4 5
PLST SCK SO
4-5 PORT ALLOCATIONS CPU (IC8)–continued
4-5-1 CPU (IC8) Pin number
Port name
Description
1
VIN
Input port for battely voltage detection.
9
RESET
Input port for RESET signal.
11
CSIFT
Outputs reference oscillator for the CPU control signal.
SCK
Outputs clock signal to the PLL IC (IC1), EEPROM (IC7), etc.
15
DAST
• Outputs strobe signals to the expander IC (IC10, pin 6). • Input port for the initial version signal.
16
CLIN
Input port for the cloning signal.
17
CLOUT
12
18
PLST
19
NOIS
Input for for noise signals (pulse type).
21
BUSY
Outputs BUSY detection. Low: The channel is busy.
Input port for the optional unit detecOPV1–3 tion signal from J5.
38
NWC
Outputs Wide/Narrow mode control signal. High: Wide mode is selected.
44–47
KR3– KR0
Output ports for key matrix. Low: When the key is pushed.
49
RMUT
• Outputs RX mute control signal. • Input port for the RX mute signal from optional units.
MMUT
• Output TX mute control signal. • Input port for the TX mute signal from optional units.
50
Port name
63
UNLK
90
MTONE
91
DTMF
Outputs DTMF tone signal while transmitting.
94
CTCIN
CTCSS/DTCS signals input port for decording.
95
PTT
96
BDET
Input port for the battery’s type detection.
97
REMO
Input port for the remote-control signal from external MIC (HM-75).
98
SD
99
LVIN
100
TEMP
Outputs the cloning signal. Outputs strobe signals to the PLL IC (IC1, pin 3).
26, 36, 37
Pin number
DUSE
52
S5C
Outputs S5 regulator control signal. Low: While power is ON.
53
R5C
Outputs R5 regulator control signal. Low: While receiving.
54
T5C
Outputs T5 regulator control signal. Low: While transmitting.
55
TXC
Outputs APC circuit control signal. High: While transmitting.
56
AFON
Outputs control signal for the regulator circuit of AF power amplifier. High: When squelch is open, etc.
57
LIGT
Outputs LCD backlight control signal. High: Lights ON.
58
ESCK
Outputs EEPROM (IC7, pin 6) clock signal.
59
ESDA
I/O port for data signals from/to EEPROM (IC7, pin 5)
Input port for unlock signal. High: PLL is unlocked. Low: PLL is locked. Output port for: Beep audio while receiving. 2/5-tone signals while transmitting.
Input port for the [PTT] switch. High: While [PTT] switch is pushed.
Input port for the RSSI detection. Input port for the PLL lock voltage. Input port for the transceiver’s internal temperature detection.
4-5-2 OUTPUT EXPANDER IC (IC10)
Outputs low-pass filter cut-off frequency control signal when DTCS is activated.
51
Description
4-5
Pin number
Port name
Description
2, 3, 10, 11
T1–T4
Output tunable bandpass filter control signals.
6
DAST
Input port for strobe signal from the CPU (IC8, pin 15).
7
SCK
Input port for clock signal from the CPU (IC8, pin 12).
SECTION 5 ADJUSTMENT PROCEDURES 5-1 PREPARATION When you adjust the contents on page 5-5 or 5-6, SOFTWARE ADJUSTMENT, the optional CS-F3G ADJ ADJUSTMENT SOFTWARE (Rev. 2.0 or later), OPC-478 CLONING CABLE and a JIG CABLE (see illustration at page 5-2) are required.
■ REQUIRED TEST EQUIPMENT EQUIPMENT
GRADE AND RANGE
DC power supply
Output voltage Current capacity
: 7.2 V DC : 5 A or more
RF power meter (terminated type)
Measuring range Frequency range Impedance SWR
: : : :
Frequency counter
1–10 W 300–600 MHz 50 Ω Less than 1.2 : 1
Frequency range : 0.1–600 MHz Frequency accuracy : ±1 ppm or better Sensitivity : 100 mV or better
EQUIPMENT
GRADE AND RANGE
Audio generator
Frequency range Output level
: 300–3000 Hz : 1–500 mV
Attenuator
Power attenuation Capacity
: 40 or 50 dB : 10 W or more
Standard signal generator (SSG)
Frequency range Output level
: 120–600 MHz : 0.1 µV–32 mV (–127 to –17 dBm)
DC voltmeter
Input impedance
: 50 kΩ/V DC or better
Oscilloscope
Frequency range Measuring range
: DC–20 MHz : 0.01–20 V
Measuring range
: 10 mV–10 V
FM deviation meter
Frequency range Measuring range
: DC–600 MHz : 0 to ±5 kHz
Digital multimeter
Input impedance
: 10 MΩ/V DC or better AC millivoltmeter
■ SYSTEM REQUIREMENTS
■ STARTING SOFTWARE ADJUSTMENT
• IBM PC compatible computer with an RS -232C serial port (38400 bps or faster) • Microsoft Windows 95 or Windows 98 • Intel i486DX processor or faster (Pentium 100 MHz or faster recommended) • At least 16 MB RAM and 10 MB of hard disk space • 640×480 pixel display (800×600 pixel display recommended)
q Connect IC-F4GT/GS and PC with the optional OPC-478 and the JIG cable. w Boot up Windows, and turn the transceiver power ON. e Click the program group ‘CS-F3G ADJ’ in the ‘Programs’ folder of the [Start] menu, then CS-F3G ADJ’s window is appeared. r Click the TCXO tag. t Click ‘Connect’ on the CS-F3G’s window, then appears IC-F4GT/GS’s up-to-date condition. y Set or modify adjustment data as desired.
■ ADJUSTMENT SOFTWARE INSTALLATION q Boot up Windows. - Quit all applications when Windows is running. w Insert the cloning software CD-ROM into the apropriate CD-ROM drive. e Select ‘Run’ from the [Start] menu. r Type the setup program name using the full path name, then push the [Enter] key. (For example; D:\ setup) t Follow the prompts. y Program group ‘CS-F3G ADJ’ appears in the ‘Programs’ folder of the [Start] menu.
IBM is a registered trademark of International Bussiness Machines Corporation in the U.S.A. and other countries. Microsoft and Windows are registered trademarks of Microsoft Corporation in the U.S.A. and other countries. Screen shots produced with permission from Microsoft Corporation. All other products or brands are registered trademarks or trademarks of their respective holders.
5-1
SCREEN DISPLAY EXAMPLE
CS-F3G ADJ Rev.2.0 File Option COM 1: OPEN
2 Connect
Reload (F5)
Disp para
TCXO
3
1 5 6
7 8 9 10 11 12 13 14
[A / D] VIN TEMPS LVIN SD REMOT BDET
: : : : : :
197 190 98 0 14 255
CH No. Power (Hi) Power (Lo) DTCS BAL MOD SQL BPF ALL BPF T1 BPF T2 BPF T3 BPF T4 TXF
: : : : : :
C5h BEh 62h 00h 0Eh FFh
: : : : : :
[D / A] BPF T1 : BPF T2 : BPF T3 : T4/POW : REF : DTCS BL. : Dev : SQL Lev :
7.73 V 32.23 ’C 1.92 V 0.00 V 0.27 V 5.00 V
90 45 76 60 112 90 45 0
: : : : : : : :
5Ah 2Dh 4Ch 3Ch 70h 5Ah 2Dh 00h
: : : : : : : :
1.76 V 0.88 V 1.49 V 1.18 V 2.20V 1.76 V 0.88 V 1.18 V
: 01 (RX Freq = 216.050, TX Freq = < ) RF Power: High : 98 [ # # # # # # # # ] : 54 [ # # # # ] : 132 [ # # # # # # # # # # ] : 95 [ # # # # # # # ] : 85 [ # # # # # # # ] : [Enter] to sweep : 23 [ # # # # # # # # # # # # ] [Enter] to sweep : 22 [ # # # # # # # # ] [Enter] to sweep : 9 [########### ] [Enter] to sweep : 7 [######### ] [Enter] to sweep : [Enter] to start
15
NOTE: The above values for settings are example only. Each transceiver has its own specific values for each setting.
1 2 3 4 5 6 7 8
: Transceiver’s connection state : Reload adjustment data : TCXO tag (must check for F4G adjustment) : Receive sensitivity measurement : Connected DC voltage : PLL lock voltage : Operating channel select : RF output power
JIG CABLE
9 10 11 12 13 14 15
: DTCS wave balance : FM deviation : Squelch level : Receive sensitivity (automatically) : Receive sensitivity (manually) : Reference frequency : Adjustment items
( + SP) (
SPE)
(
GND)
3-conductor 3.5(d) mm plug to IC-F4GT/GS [SP] jack
JIG cable
OPC-478 ( + CLONE)
5-2
4
CONNECTION Standard signal generator to the antenna connector 0.1 V to 32 mV ( 127 dBm to 17 dBm)
to [MIC]
Audio generator
CAUTION: DO NOT transmit while an SSG is connected to the antenna connector.
to an RS-232C port Personal computer
OPC-478
FM deviation meter
Attenuator 40 dB or 50 dB RF power meter 0.1 10 W/50
DB9 female plug (incl. level converter circuit)
Frequency counter to [SP]
SINAD meter JIG cable
Speaker (8
)
DC POWER CABLE CONNECTIONS PLL ADJUSTMENT
SOFTWARE ADJUSTMENT + DC POWER SUPPLY + DC POWER SUPPLY Soldering DC cable here
GND Battery type detector
Top view
NOTE: When you adjust the output power (high power), the battery type detector must be connected to GND (see illustration at above). Ohterwise the transceiver does not transmit high power, the output power will be low.
5-3
5-2 PLL ADJUSTMENT MEASUREMENT ADJUSTMENT
ADJUSTMENT CONDITIONS UNIT
PLL LOCK VOLTAGE
1 • Operating frequency: 400.000 440.000 470.000 490.000 • Receiving
MHz A MHz B NHz C MHz D, E
LOCATION
MAIN Connect a digital multi meter to check point LV.
2 • Transmitting 3 • Operating frequency: 430.000 470.000 500.000 512.000 520.000 • Receiving
MHz MHz MHz MHz MHz
A B C D E
B: 440–470 MHz „: W-type
UNIT ADJUST 1.3 V
MAIN
C: 470–500 MHz ˜: M-type
MAIN UNIT
RF power meter
L405 L11 PLL lock voltage adjustment
LV PLL lock voltage check point
Bottom view
5-4
D: 490–512 MHz
L11
1.3 V B 1.05 V (except B)
L405
3.0–4.5 V (A, B, C) 2.0–3.7 V D 2.5–4.2 V E
Verify
3.0–4.5 V A, C 2.7–4.2 V B 2.0–3.7 V D 2.5–4.2 V E
4 • Transmitting
A: 400–430 MHz ˆ: N-type
ADJUSTMENT VALUE
E: 490–520 MHz
5-3 SOFTWARE ADJUSTMENT Select an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard. ADJUSTMENT
ADJUSTMENT CONDITION
MEASUREMENT UNIT
VALUE
LOCATION
REFERENCE FREQUENCY [TXF]
Top Loosely couple a frequnecy 400.0000 MHz A 1 • Operating frequency: 400.000 MHz A panel counter to the antenna connec- 440.0000 MHz B 440.000 MHz B tor. 470.0000 MHz C 470.000 MHz C 490.0000 MHz D, E 490.000 MHz D, E • High/Low switch : Low • Connect the RF power meter or 50 Ω dummy load to the antenna connector. • Transmitting
OUTPUT POWER [POWER(LO)]
1 • Operating frequency: 415.000 MHz [EUR] of A 430.000 MHz [OTHER] of A 455.000 MHz [EUR] of B 470.000 MHz [OTHER] of B 500.000 MHz C 512.000 MHz D 520.000 MHz E • High/Low switch : Low • Transmitting
[POWER(HI)]
2 • High/Low switch • Transmitting
FM DEVIATION [MOD]
Top Connect an FM deviation meter 1 • Operating frequency: 400.000 MHz A panel to the antenna connector through the attenuator. 440.000 MHz B 470.000 MHz C 490.000 MHz D, E • High/Low switch : Low • Connect the audio generator to the [MIC] jack and set as: 1.0 kHz/150 mVrms • Set the FM deviation meter as: HPF : OFF LPF : 20 kHz De-emphasis : OFF Detector : (P–P)/2 • Transmitting
±3.9 kHz*1 „ ±3.2 kHz ˜ ±1.95 kHz*2 ˆ
DTCS WAVE FORM [DTCS BAL]
1 • Operating frequency: 430.000 MHz A 470.000 MHz B 500.000 MHz C 512.000 MHz D 520.000 MHz E • High/Low switch : Low • No audio applied to the [MIC] jack. • DTCS code : 007 • Transmitting
Top Connect an FM deviation meter panel with an oscilloscope to the antenna connector through an attenuator.
Set to flat wave form
Top Connect an RF power meter to panel the antenna connector.
: High
1.0 W
4.0 W
*1, *2W/N-type must be adjusted both *1 and *2 on the FM DEVIATION ADJUSTMENT. A: 400–430 MHz ˆ: N-type
B: 440–470 MHz „: W-type
C: 470–500 MHz ˜: M-type
5-6
D: 490–512 MHz
E: 490–520 MHz
SOFTWARE ADJUSTMENT – continued Select an operation using [↑] / [↓] keys, then set specified value using [←] / [→] keys on the connected computer keyboard. ADJUSTMENT RX SENSITIVITY [BPF T1] – [BPF T4]
ADJUSTMENT CONDITION
MEASUREMENT UNIT
VALUE
LOCATION
Top Connect a SINAD meter with an Minimum distortion 1 • Operating frequency: level 400.000 MHz A panel 8Ω load to the [SP] jack. 440.000 MHz B 470.000 MHz C 490.000 MHz D, E • Connect a standard signal generator to the antenna connector and set as: Frequency : 400.000 MHz A 440.000 MHz B 470.000 MHz C 490.000 MHz D, E Level : 10 µV* (–87 dBm) Modulation : 1 kHz Deviation : ±3.5 kHz*1 „ ±2.8 kHz ˜ ±1.75 kHz*2 ˆ • Receiving
CONVENIENT: The BPF T1–BPF T4 can be adjusted automatically. q-1: Set the cursol to “BPF ALL” on the adjustment program and then push [ENTER] key. q-2: The connected PC tunes BPF T1–BPF T4 to peak levels. or w-1: Set the cursol to one of BPF T1, T2, T3, or T4 as desired. w-2: Push [ENTER] key to start tuning. w-3: Repeat w-1 and w-2 to perform additional BPF tuning. SQUELCH LEVEL [SQL]
1 • Operating frequency: Top Connect a SINAD meter with an 400.000 MHz A panel 8Ω load to the [SP] jack. 440.000 MHz B 470.000 MHz C 490.000 MHz D, E • Connect a standard signal generator to the antenna connector and set as: Frequency : 400.000 MHz A 440.000 MHz B 470.000 MHz C 490.000 MHz D, E Level : 0.2 µV* (–121 dBm) Modulation : 1 kHz Deviation : ±3.5 kHz*1 „ ±2.8 kHz ˜ ±1.75 kHz*2 ˆ • Receiving 2 • Receiving
12 dB SINAD
At the point where the audio signals just appears.
*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit. *1, *2W/N-type must be set the standard signal generator deviation level both *1 and *2 on the RX SENSITIVITY AND SQUELCH LEVEL ADJUSTMENTS. A: 400–430 MHz ˆ: N-type
B: 440–470 MHz „: W-type
C: 470–500 MHz ˜: M-type
5-7
D: 490–512 MHz
E: 490–520 MHz
SECTION 6
PARTS LIST
[MAIN UNIT] REF NO. IC1 IC2 IC3 IC4 IC5 IC6
[MAIN UNIT]
ORDER NO.
IC8 IC10 IC11 IC12 IC13 IC14 IC15
1130007610 1110003490 1110005140 1130008090 1110001810 1110005350 1180001740 1130009680 1140008650 1140010000 1190000350 1130009110 1110003800 1110002750 1130007020 1130007020
S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC
µPD3140GS-E1 (DS8) TA31136FN (D,EL) NJM3403AV-TE1 BU4066BCFV-E1 TA7368F (TP1) NJM2870F05-TE1 TK11250BMCL HN58X2432TI HN58X2464TI HD6433876B50H M62363FP-650C S-80942ANMP-DD6-T2 NJM2904V-TE1 TA75S01F (TE85R) TC7S66FU (TE85R) TC7S66FU (TE85R)
Q1 Q2 Q3 Q4 Q5 Q6 Q7 Q8 Q10 Q11 Q12 Q13 Q14 Q15 Q16 Q17 Q18 Q19 Q20 Q21 Q22 Q25 Q31 Q34 Q35 Q36 Q37 Q38 Q41 Q42 Q401 Q402 Q403 Q405
1560001050 1560001020 1530002620 1530003310 1530003310 1530003310 1530003230 1530003230 1530002690 1590001190 1580000720 1580000720 1530002600 1520000460 1590001190 1590002530 1520000460 1590001190 1590000720 1510000920 1510000920 1530002690 1590000660 1560000540 1530002690 1530002690 1590000720 1590001940 1530002690 1590000430 1590001400 1590000430 1530003310 1590001770
S.FET S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR
2SK2974 2SK2973 (MTS101P) 2SC3585 R44-T2B 2SC5107-O (TE85R) 2SC5107-O (TE85R) 2SC5107-O (TE85R) 2SC5085-Y (TE85R) 2SC5085-Y (TE85R) 2SC4116-GR (TE85R) XP6501-(TX) .AB 3SK239AXRTL 3SK239AXRTL 2SC4215-O (TE85R) 2SB1132 T100 R XP6501-(TX) .AB UN911H (TX) 2SB1132 T100 R XP6501-(TX) .AB DTA144EUA T106 2SA1577 T107 Q 2SA1577 T107 Q 2SC4116-GR (TE85R) DTC144TU T107 2SK880-Y (TE85R) 2SC4116-GR (TE85R) 2SC4116-GR (TE85R) DTA144EUA T106 DTC144EE TL 2SC4116-GR (TE85R) DTC144EUA T106 XP1214 (TX) DTC144EUA T106 2SC5107-O (TE85R) XP1213 (TX)
D1 D2 D3 D4 D5 D8 D10 D11 D12 D14 D26 D27 D29 D32 D33 D401
1750000580 1790000620 1790000620 1790000620 1720000780 1790000620 1720000780 1720000780 1720000780 1790000620 1160000070 1790001670 1730002260 1790001670 1790001670 1720000780
S.DIODE S.DIODE S.DIODE S.DIODE S.VARICAP S.DIODE S.VARICAP S.VARICAP S.VARICAP S.DIODE S.DIODE S.DIODE S.ZENER S.DIODE S.DIODE S.VARICAP
1SV307 (TPH3) MA77 (TX) MA77 (TX) MA77 (TX) HVU350B TRF MA77 (TX) HVU350B TRF HVU350B TRF HVU350B TRF MA77 (TX) DAN202K T146 RB706F-40T106 MA8030-H (TX) RB706F-40T106 RB706F-40T106 HVU350B TRF
IC7
REF NO.
DESCRIPTION
1720000780 S.VARICAP 1720000400 S.VARICAP
HVU350B TRF 1SV245 (TPH3)
FI1
2010002450 2010002500 2030000150 2030000160 2020001080 2020001490 2020001930
FL-313 (46.35 MHz) FL-321 (46.350MHZ) FL-335 (46.350 MHz) FL-336 (46.350 MHz) SFPC450G-TC01 SFPC450E-TC01 CFWC450F
[OTHER] [OTHER] FI2
D only
S.XTAL S.XTAL S.MONOLITH S.MONOLITH S.CERAMIC S.CERAMIC S.CERAMIC
X2 X3 X4
6050010870 S.XTAL CR-663 (9.200 MHz) 6070000190 S.DISCRIMINATOR CDBC450CX24 6050010930 S.XTAL CR-662 (15.3 MHz)
L1
6200008240 6200008250 6200009710 6200008240 6200008250 6200009710 6200008240 6200008540 6200009710 6200005660 6200005670 6200005680 6200005690 6200005700 6200005700 6200005710 6200005700 6200005710 6200003690 6200004110 6200003550 6200003960 6200005680 6200008240 6200008440 6200008440 6200008440 6200002850 6200005700 6200005710 6200005720 6200005730 6200007680 6200008240 6200009250 6200004480 6200003590 6200008520 6200008720 6200009110 6200009210 6200008440 6200004660 6200004110 6200004660 6200003550 6200005700 6200005710
L2
L4
L7
L8 L9 L11 L12 L13 L14 L15 L17 L18 L19 L20 L21
D only D only
DESCRIPTION
D403 D404
D O
ORDER NO.
L22 L24 L25 L26 L31
L33 L402 L404 L405 L406 L407 L411
S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL
L G M [OTHER]
I [OTHER]
D
E 0.30-0.9-5TL 14N 0.30-0.9-7TL 21N B 0.30-0.9-4TL 10.5N J, C 0.30-0.9-5TL 14N E 0.30-0.9-7TL 21N B 0.30-0.9-4TL 10.5N J, C 0.30-0.9-5TL 14N E 0.26-0.9-6TR 19N B 0.30-0.9-4TL 10.5N J, C ELJRE 10NG-F C ELJRE 12NG-F J ELJRE 15NG-F F ELJRE 18NG-F K ELJRE 22NG-F B ELJRE 22NG-F J, C ELJRE 27NG-F E, B ELJRE 22NG-F C ELJRE 27NG-F [OTHER] MC152-E558ANA-100051=P3 B MC152-E558ANA-100050 [OTHER] MLF1608A 4R7K-T MLF1608A 1R0K-T ELJRE 15NG-F 0.30-0.9-5TL 14N LQN21A 8N2D04 LQN21A 8N2D04 LQN21A 8N2D04 NL 252018T-R82J C ELJRE 22NG-F ELJRE 27NG-F J ELJRE 33NG-F E ELJRE 39NG-F B LQN21A 12NJ04 A 0.30-0.9-5TL 14N [OTHER] LQW1608A R22G00 MLF1608D R82K-T EXCCL3225U1 0.30-0.7-3TR 4.9N [OTHER] B 0.30-0.8-3TL 6N 0.30-0.9-2TR 4.1N C NL 252018T-390J LQN21A 8N2D04 MLF1608A 1R8K-T except E, J MC152-E558ANA-100050 MLF1608A 1R8K-T MLF1608A 4R7K-T ELJRE 22NG-F [OTHER] B ELJRE 27NG-F S.=Surface mount
A: F: K: N:
L-band of ETS/CEPT version M1-band of [GEN] and EIA/TIA version M1-band of ETS/CEPT version M1-band except W/N-type
B: G: L: O:
L-band C: H-band W-type of [GEN] H: W-type N-type of [GEN] and EIA/TIA version 100 channel version
6-1
D: I: M: P:
W/N-type E: M1 (440–470 MHz)-band N-type J: M2 (470–500 MHz)-band N-type of ETS/CEPT version M (20 kHz)-type
[MAIN UNIT] REF NO.
[MAIN UNIT]
ORDER NO.
DESCRIPTION
L441 L442 L443
6200003960 S.COIL 6200004720 S.COIL 6200006190 S.COIL
MLF1608A 1R0K-T MLF1608D R10K-T BLM21P300S
R1 R2 R3 R7 R9 R12 R13 R14 R15 R17 R18 R19 R20 R21 R22 R23 R30 R32 R33 R34 R41 R44
7030003670 7030003580 7030003580 7030004980 7030005050 7030005040 7030005530 7030003320 7030005050 7030005040 7030003640 7030004980 7030003660 7030003360 7030003660 7030003320 7030003480 7030003540 7030008410 7030005120 7030004970 7030003550 7030003560 7030005090 7030003630 7030003750 7030003760 7030003700 7030003560 7030003700 7030003440 7030003340 7030003280 7030003720 7030003560 7030003720 7030005050 7030003700 7030003560 7030003560 7030003440 7030003520 7030003640 7030003350 7030003320 7030003350 7030003390 7030005310 7030005120 7030003470 7030003510 7030003380 7030003280 7030003460 7030003630 7030003640 7030003440 7030003480 7030003610 7030003620 7030003630 7030003450 7030003780 7030003610 7030003800 7030003800 7030003640 7030003720 7030003710 7030003590
ERJ3GEYJ 823 V (82 kΩ) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 153 V (15 kΩ) ERJ2GEJ 101 X (100 Ω) ERJ2GEJ 103 X (10 kΩ) ERJ2GEJ 472 X (4.7 kΩ) ERJ2GEJ 100 X (10 Ω) ERJ3GEYJ 101 V (100 Ω) ERJ2GEJ 103 X (10 kΩ) ERJ2GEJ 472 X (4.7 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ2GEJ 101 X (100 Ω) ERJ3GEYJ 683 V (68 kΩ) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 683 V (68 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 682 V (6.8 kΩ) ERJ2GEJ 392 X (3.9 kΩ) ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 470 X (47 Ω) ERJ3GEYJ 822 V (8.2 kΩ) [OTHER] ERJ3GEYJ 103 V (10 kΩ) H ERJ2GEJ 104 X (100 kΩ) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 394 V (390 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 151 V (150 Ω) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ2GEJ 103 X (10 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 181 V (180 Ω) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 181 V (180 Ω) [OTHER] H ERJ3GEYJ 391 V (390 Ω) ERJ2GEJ 124 X (120 kΩ) ERJ2GEJ 102 X (1 kΩ) H ERJ3GEYJ 182 V (1.8 kΩ) ERJ3GEYJ 392 V (3.9 kΩ) [OTHER] ERJ3GEYJ 331 V (330 Ω) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 152 V (1.5 kΩ) H ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 473 V (47 kΩ) [OTHER] H ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) [OTHER] ERJ3GEYJ 273 V (27 kΩ) H ERJ3GEYJ 333 V (33 kΩ) [OTHER] D ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 684 V (680 kΩ) ERJ3GEYJ 273 V (27 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 184 V (180 kΩ) ERJ3GEYJ 183 V (18 kΩ)
R48 R49 R50 R51 R52 R53 R54 R55 R59 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R72 R75 R77 R79 R80 R81 R82 R83 R84 R85 R86 R87 R88
R89 R90 R93 R94 R95 R96 R97 R98 R99
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
REF NO.
ORDER NO.
R100 R101 R102 R103 R104 R105
7030008060 7030003800 7030003200 7030003570 7030003680 7030005000 7030009280 7030003670 7030003700 7030003710 7030005050 7030003800 7030003660 7030003600 7030003620 7030005310 7030005120 7030003460 7030003660 7030005120 7030003490 7030009140 7030007300 7030003610 7030003560 7030003260 7030003200 7030003680 7030003400 7030003400 7030004040 7030003480 7030003560 7030003320 7030003320 7030003520 7030003680 7030003520 7030004980 7210003060 7030003620 7030003800 7030003570 7030003570 7030003640 7030003400 7030005170 7030005170 7030005170 7030003320 7030003680 7030003320 7030003440 7030003440 7030003560 7030005310
R107 R108 R109 R112 R113 R114 R115 R116 R117 R120 R121 R122 R123 R125 R126 R127 R128 R130 R131 R132 R133 R134 R135 R136 R137 R139 R140 R141 R142 R143 R144 R145 R146 R147 R148 R150 R152 R153 R154 R155 R159 R160 R161 R162 R163 R164 R165 R168 R169 R170 R171 R174 R176 R177 R178 R181 R182 R184 R185 R186 R190 R191 R192 R193
DESCRIPTION S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR VARIABLE S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
RR0816P-222-D (2.2 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 100 V (10 Ω) ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ2GEJ 471 X (470 Ω) [OTHER] H ERJ2GE ERJ3GEYJ 823 V (82 kΩ) I ERJ3GEYJ 154 V (150 kΩ) [OTHER] ERJ3GEYJ 184 V (180 kΩ) ERJ2GEJ 103 X (10 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 683 V (68 kΩ) H ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 333 V (33 kΩ) [OTHER] ERJ2GEJ 124 X (120 kΩ) ERJ2GEJ 102 X (1 kΩ) ERJ3GEYJ 152 V (1.5 kΩ) ERJ3GEYJ 683 V (68 kΩ) ERJ2GEJ 102 X (1 kΩ) E ERJ3GEYJ 272 V (2.7 kΩ) ERJ2GEJ 272 X (2.7 kΩ) [OTHER] ERJ2GEJ 332 X (3.3 kΩ) ERJ3GEYJ 273 V (27 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 330 V (33 Ω) ERJ3GEYJ 100 V (10 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 471 V (470 Ω) ERJ3GEYJ 471 V (470 Ω) ERJ3GEYJ 4R7 V (4.7 Ω) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ2GEJ 101 X (100 Ω) TP76N00N-15F-10KA-2251 ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 471 V (470 Ω) ERJ2GEJ 474 X (470 kΩ) ERJ2GEJ 474 X (470 kΩ) ERJ2GEJ 474 X (470 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ2GEJ 124 X (120 kΩ) [F4GT] only 7030005310 S.RESISTOR ERJ2GEJ 124 X (120 kΩ) [F4GS] only 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ) 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 7030005340 S.RESISTOR RR0816P-332-D (3.3 kΩ) 7030005870 S.RESISTOR RR0816R-104-D (100 kΩ) 7510001280 S.THERMISTOR NTCCM20124AG473J-T 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) 7030005120 S.RESISTOR ERJ2GEJ 102 X (1 kΩ) 7030005240 S.RESISTOR ERJ2GEJ 473 X (47 kΩ) 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
S.=Surface mount A: F: K: N:
L-band of ETS/CEPT version M1-band of [GEN] and EIA/TIA version M1-band of ETS/CEPT version M1-band except W/N-type
B: G: L: O:
L-band C: H-band W-type of [GEN] H: W-type N-type of [GEN] and EIA/TIA version 100 channel version
6-2
D: I: M: P:
W/N-type E: M1 (440–470 MHz)-band N-type J: M2 (470–500 MHz)-band N-type of ETS/CEPT version M (20 kHz)-type
[MAIN UNIT] REF NO.
ORDER NO.
R194 R195 R196 R197 R198 R199 R200 R202 R203 R204 R205 R207 R208 R209 R210 R211 R212 R213 R215 R216 R218
7030003680 7030003680 7030003680 7030003720 7030003590 7030003640 7030003640 7030005240 7030003640 7030003500 7030003460 7030005240 7030003680 7030003680 7030003480 7030003690 7030003660 7030003400 7030005870 7030005870 7030003680 7030003690 7030003680 7030003690 7030003740 7030003750 7030005310 7030003570 7030003610 7030003680 7410000950 7030005240 7030003560 7030003710 7030003770 7030003650 7030003710 7030003600 7030003660 7410000950 7030003560 7030003600 7030003780 7410000950 7410000950 7410000950 7030003440 7030003440 7030003800 7030003800 7030003800 7030005090 7030003680 7030003680 7030003740 7030003520 7030003400 7030009320 7030003620 7030003560 7030003560 7030003300 7030004050 7030009140 7030003640 7030003640 7030003680 7030003680 7030003560 7030003520 7030003560 7030003680 7030003640 7030003720 7030003560
R219 R220 R221 R223 R224 R225 R226 R227 R228 R229 R230 R231 R232 R234 R235 R236 R237 R238 R239 R240 R241 R242 R243 R244 R245 R246 R251 R252 R253 R257 R258 R260 R261 R262 R269 R270 R271 R272 R273 R274 R275 R276 R401 R402 R404 R405
[MAIN UNIT] DESCRIPTION S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.ARRAY S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.ARRAY S.RESISTOR S.RESISTOR S.RESISTOR S.ARRAY S.ARRAY S.ARRAY S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ2GEJ 473 X (47 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 152 V (1.5 kΩ) ERJ2GEJ 473 X (47 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 124 V (120 kΩ) ERJ3GEYJ 683 V (68 kΩ) ERJ3GEYJ 471 V (470 Ω) RR0816R-104-D (100 kΩ) RR0816R-104-D (100 kΩ) I ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 124 V (120 kΩ) [OTHER] ERJ3GEYJ 104 V (100 kΩ) I ERJ3GEYJ 124 V (120 kΩ) [OTHER] ERJ3GEYJ 334 V (330 kΩ) ERJ3GEYJ 394 V (390 kΩ) ERJ2GEJ 124 X (120 kΩ) D ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 273 V (27 kΩ) [OTHER] ERJ3GEYJ 104 V (100 kΩ) EXB-V8V 102JV ERJ2GEJ 473 X (47 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 184 V (180 kΩ) [OTHER] ERJ3GEYJ 564 V (560 kΩ) I ERJ3GEYJ 563 V (56 kΩ) [OTHER] I ERJ3GEYJ 184 V (180 kΩ) ERJ3GEYJ 223 V (22 kΩ) [OTHER] I ERJ3GEYJ 683 V (68 kΩ) EXB-V8V 102JV D ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 223 V (22 kΩ) [OTHER] ERJ3GEYJ 684 V (680 kΩ) EXB-V8V 102JV EXB-V8V 102JV EXB-V8V 102JV ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ2GEJ 104 X (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 334 V (330 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 471 V (470 Ω) ERJ2GEJ 4R7 X (4.7 Ω) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 680 V (68 Ω) [OTHER] I ERJ3GEYJ 1R0 V (1 Ω) ERJ2GEJ 272 X (2.7 kΩ) D only ERJ3GEYJ 473 V (47 kΩ) D only ERJ3GEYJ 473 V (47 kΩ) D only ERJ3GEYJ 104 V (100 kΩ) D only ERJ3GEYJ 104 V (100 kΩ) D only ERJ3GEYJ 103 V (10 kΩ) D only ERJ3GEYJ 472 V (4.7 kΩ) D only ERJ3GEYJ 103 V (10 kΩ) D only ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 103 V (10 kΩ)
REF NO.
ORDER NO.
R410 R411 R413 R414
7030003500 7030003490 7030003230 7030003380 7030003390 7030003400 7030003500 7030003500 7030003400 7030005050 7030003720 7030003360 7030003650 7030005000 7030003280 7030005000 7030004980 7030003440 7030003410 7030003440 7030003260 7030003490 7030004970 7030003680 7030003590 7030003640 7030005120 7030005050 7030003380 7030003440 7030003440 7030005120 7030005120 7030005050 7030003440 7030007350 7030003490 7030005310 7030003580 7030005070 7030008300 7030005120 7030005120 7030007280 7030007280 7030003200 7030008410 7510001300 7030005120 7030005120 7030005120 7030005120 7030005120 7030004980 7030003760 7030003680 7030005120
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.THERMISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 272 V (2.7 kΩ) C only ERJ3GEYJ 180 V (18 Ω) ERJ3GEYJ 331 V (330 Ω) [OTHER] ERJ3GEYJ 391 V (390 Ω) J, C ERJ3GEYJ 471 V (470 Ω) A ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 471 V (470 Ω) ERJ2GEJ 103 X (10 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 563 V (56 kΩ) ERJ2GEJ 471 X (470 Ω) ERJ3GEYJ 470 V (47 Ω) ERJ2GEJ 471 X (470 Ω) ERJ2GEJ 101 X (100 Ω) ERJ3GEYJ 102 V (1 kΩ) I ERJ3GEYJ 561 V (560 Ω) ERJ3GEYJ 102 V (1 kΩ) [OTHER] ERJ3GEYJ 330 V (33 Ω) ERJ3GEYJ 272 V (2.7 kΩ) I only ERJ2GEJ 470 X (47 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 183 V (18 kΩ) I ERJ3GEYJ 473 V (47 kΩ) [OTHER] ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 103 X (10 kΩ) ERJ3GEYJ 331 V (330 Ω) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 103 X (10 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ2GEJ 393 X (39 kΩ) ERJ3GEYJ 272 V (2.7 kΩ) ERJ2GEJ 124 X (120 kΩ) ERJ3GEYJ 153 V (15 kΩ) I ERJ2GEJ 683 X (68 kΩ) ERJ2GEJ 184 X (180 kΩ) [OTHER] ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 331 X (330 Ω) ERJ2GEJ 331 X (330 Ω) ERJ3GEYJ 100 V (10 Ω) ERJ2GEJ 392 X (3.9 kΩ) NTCCM1608 4LH 223KC ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 102 X (1 kΩ) ERJ2GEJ 101 X (100 Ω) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ2GEJ 102 X (1 kΩ)
4030006980 4030006990 4030009520 4030006860 4030006860 4030006860 4030011770 4030006860 4030006860 4030006900 4030017500 4030017670 4030006860 4030006850 4030006860 4030016790
S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 CH 1H 070D-T-A [OTHER] B C1608 CH 1H 080D-T-A C1608 CH 1H 020B-T-A J, C only C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 060B-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 103K-T-A except A ECJ0EC1H560J J, C ECJ0EC1H390J [OTHER] C1608 JB 1H 102K-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 102K-T-A A only ECJ0EB1C103K
R416 R417 R420 R421 R422 R445 R446 R447 R448 R449 R457 R458 R464 R465 R469 R473 R500 R501 R502 R503 R504 R505 R506 R507 R508 R509 R510 R511 R512 R515 R516 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R528 R529 R530 R532 R533 R534
C3 C4 C8 C9 C10 C11 C12 C13 C14 C15 C17 C18 C19 C20
DESCRIPTION
S.=Surface mount A: F: K: N:
L-band of ETS/CEPT version M1-band of [GEN] and EIA/TIA version M1-band of ETS/CEPT version M1-band except W/N-type
B: G: L: O:
L-band C: H-band W-type of [GEN] H: W-type N-type of [GEN] and EIA/TIA version 100 channel version
6-3
D: I: M: P:
W/N-type E: M1 (440–470 MHz)-band N-type J: M2 (470–500 MHz)-band N-type of ETS/CEPT version M (20 kHz)-type
[MAIN UNIT] REF NO.
ORDER NO.
C21 C22
4550006540 4030007000 4030007010 4030007020 4030006850 4030009530 4030009910 4030017460 4030009920 4030006990 4030007020 4030006850 4030006990 4030007020 4030009520 4030009530 4030006850 4030006850 4030013850 4550006360 4550006450 4550006200 4030007010 4030006990 4030007010 4030007030 4030013850 4030016790 4030016790 4030013850 4030011770 4030011770 4030007010 4030009910 4030006980 4030009530 4030006860 4550006320 4030011600 4030016930 4030006980 4030006990 4030011770 4030009530 4030009910 4030011770 4030009520 4030009540 4030007090 4030006980 4030007010 4030009920 4030011770 4030006980 4030009350 4030009910 4030009920 4030007090 4030006860 4030009500 4030006860 4030006970 4030006990 4030009920 4030006990 4030007010 4030009920 4030011770 4030014180 4030009500 4030009510 4030014180
C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C42 C47 C48 C50 C51 C52 C53 C54 C55 C56 C60 C61 C62 C63 C65 C66 C67 C71 C72 C73 C75 C76
C78
C79 C84 C85
C86
C87 C88 C89 C90 C91
C92
C93 C94 C95
[MAIN UNIT] DESCRIPTION S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.TANTALUM S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
ECST1CY475R C C1608 CH 1H 090D-T-A C1608 CH 1H 100D-T-A B C1608 CH 1H 120J-T-A [OTHER] C1608 JB 1H 471K-T-A E C1608 CH 1H 030B-T-A C1608 CH 1H 040B-T-A [OTHER] ECJ0EB1E102K C1608 CH 1H 050B-T-A C1608 CH 1H 080D-T-A [OTHER] E C1608 CH 1H 120J-T-A C1608 JB 1H 471K-T-A B, E only C1608 CH 1H 080D-T-A [OTHER] C1608 CH 1H 120J-T-A E C1608 CH 1H 020B-T-A [OTHER] E C1608 CH 1H 030B-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A ECUE1E102KBQ ECST1VY104R ECST1EY105R ECST0JY106R C1608 CH 1H 100D-T-A J, C C1608 CH 1H 080D-T-A C1608 CH 1H 100D-T-A [OTHER] C1608 CH 1H 150J-T-A ECUE1E102KBQ ECJ0EB1C103K ECJ0EB1C103K ECUE1E102KBQ C1608 CH 1H 060B-T-A C1608 CH 1H 060B-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 040B-T-A C1608 CH 1H 070D-T-A C1608 CH 1H 030B-T-A C1608 JB 1H 102K-T-A ECST0JY475R C1608 JB 1E 104K-T-N ECJ0EB1A104K E C1608 CH 1H 070D-T-A C1608 CH 1H 080D-T-A B C1608 CH 1H 060B-T-A [OTHER] C1608 CH 1H 030B-T-A [OTHER] E C1608 CH 1H 040B-T-A C1608 CH 1H 060B-T-A B C1608 CH 1H 020B-T-A B C1608 CH 1H 1R5B-T-A [OTHER] C1608 CH 1H 470J-T-A E C1608 CH 1H 070D-T-A C1608 CH 1H 100D-T-A B C1608 CH 1H 050B-T-A C C1608 CH 1H 060B-T-A J C1608 CH 1H 070D-T-A B C1608 CH 1H 3R5B-T-A C C1608 CH 1H 040B-T-A J C1608 CH 1H 050B-T-A E C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 0R5B-T-A C1608 JB 1H 102K-T-A E C1608 CH 1H 060D-T-A C1608 CH 1H 080D-T-A C C1608 CH 1H 050B-T-A [OTHER] E C1608 CH 1H 080D-T-A C1608 CH 1H 100D-T-A B C1608 CH 1H 050B-T-A C C1608 CH 1H 060B-T-A J ECUE1H470JCQ C1608 CH 1H 0R5B-T-A [OTHER] B C1608 CH 1H 010B-T-A ECUE1H470JCQ
REF NO.
ORDER NO.
C96
4030006990 4030007010 4030009920 4030011770 4030006970 4030006990 4030009920 4030007050 4030006860 4030006990 4030013850 4030014180 4030007030 4030006900 4030006860 4030007020 4030009990 4030013850 4030006860 4030006860 4030006860 4030007130 4030014200 4030014440 4030006860 4030006860 4030008680 4030011600 4030007170 4030010760 4030007170 4030010760 4030013850 4030006900 4030006870 4030008470 4030008680 4550006680 4030008770 4030016930 4030007160 4030007160 4030008770 4030008850 4030008890 4030008900 4030011600 4030016930 4030006860 4510004630 4030011810 4030008630 4030006900 4030011600 4550006200 4030014180 4030008920 4510006940 4550006200 4510004630 4030006900 4030011600 4030016930 4550006620 4030006850 4030006900 4030006900 4030006900 4030013850 4030006860 4030006860 4030007090 4030006860 4030006860
C97
C98 C99 C100 C104 C105 C106 C107 C109 C110 C111 C112 C113 C114 C115 C116 C117 C118 C119 C120 C121 C122 C123 C124 C125 C126 C128 C129 C132 C133 C134 C135 C136 C137
C139 C140 C144 C145 C146 C147 C148 C149 C150 C151 C152 C153 C154 C155 C156
C158 C159 C160 C161 C162 C163 C164 C165 C167 C168 C169
DESCRIPTION S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.TANTALUM S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 CH 1H 080D-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 050B-T-A C1608 CH 1H 060B-T-A C1608 CH 1H 060D-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 050B-T-A C1608 CH 1H 220J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 080D-T-A ECUE1E102KBQ ECUE1H470JCQ C1608 CH 1H 150J-T-A C1608 JB 1H 103K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 120J-T-A C1608 CH 1H 200J-T-A ECUE1E102KBQ C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 101J-T-A ECUE1H101JCQ ECUE1H820JCQ C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C2012 JF 1C 105Z-T-A C1608 JB 1E 104K-T-N C1608 CH 1H 221J-T-A C1608 CH 1H 331J-T-A C1608 CH 1H 221J-T-A C1608 CH 1H 331J-T-A ECUE1E102KBQ C1608 JB 1H 103K-T-A C1608 JB 1H 222K-T-A C1608 JB 1H 272K-T-A C2012 JF 1C 105Z-T-A ECST0JY156R C1608 JB 1H 562K-T-A ECJ0EB1A104K C1608 CH 1H 181J-T-A C1608 CH 1H 181J-T-A C1608 JB 1H 562K-T-A C1608 JB 1H 123K-T-A C1608 JB 1H 273K-T-A C1608 JB 1H 333K-T-A C1608 JB 1E 104K-T-N ECJ0EB1A104K C1608 JB 1H 102K-T-A ECEV1CA100SR C1608 JB 1A 224K-T-N C1608 JF 1H 104Z-T-A C1608 JB 1H 103K-T-A C1608 JB 1E 104K-T-N ECST0JY106R ECUE1H470JCQ C1608 JB 1H 473K-T-A EEVFC0J101P ECST0JY106R ECEV1CA100SR C1608 JB 1H 103K-T-A C1608 JB 1E 104K-T-N ECJ0EB1A104K ECST0JY226R C1608 JB 1H 471K-T-A C1608 JB 1H 103K-T-A C1608 JB 1H 103K-T-A C1608 JB 1H 103K-T-A ECUE1E102KBQ C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A
E B C J E B [OTHER]
H, P [OTHER]
H, P [OTHER]
[OTHER] H, P [OTHER] H, P
D [OTHER]
I
D B, E J, C
S.=Surface mount A: F: K: N:
L-band of ETS/CEPT version M1-band of [GEN] and EIA/TIA version M1-band of ETS/CEPT version M1-band except W/N-type
B: G: L: O:
L-band C: H-band W-type of [GEN] H: W-type N-type of [GEN] and EIA/TIA version 100 channel version
6-4
D: I: M: P:
W/N-type E: M1 (440–470 MHz)-band N-type J: M2 (470–500 MHz)-band N-type of ETS/CEPT version M (20 kHz)-type
[MAIN UNIT] REF NO.
ORDER NO.
C173
4510004640 4550006760 4510005430 4030006900 4030006990 4030007020 4030007080 4030006850 4030011600 4550006170 4030011600 4030008900 4030011600 4030006900 4030007090 4030006860 4030011600 4550006320 4030006900 4550006170 4030008900 4030011600 4030016930 4030016930 4030013850 4030009630 4030008910 4030011600 4030006900 4030006900 4030009880 4030008920 4030011600 4030009490 4030006860 4030008880 4030008630 4030008630 4030013850 4030013850 4030006900 4030006860 4030006900 4030006900 4030006900 4030006900 4030006900 4030006860 4030006860 4030013850 4030013850 4030009650 4030016920 4030006860 4030007090 4030011340 4030016930 4030013850 4030006900 4030011600 4030007090 4030006860 4030006990 4030009920 4030011770 4030006980 4030006990 4030007010 4030009920 4030007090 4030006990 4030007010 4030007020
C174 C179 C193 C194 C195 C196 C197 C198 C199 C200 C201 C202 C204 C205 C209 C211 C212 C213 C214 C215 C216 C217 C218 C219 C221 C222 C223 C224 C225 C227 C228 C229 C230 C231 C232 C233 C234 C236 C243 C244 C245 C248 C249 C250 C251 C252 C282 C283 C285 C286 C288 C289 C289 C291 C307 C308 C311 C403 C404 C405
C406
C407 C410
[MAIN UNIT] DESCRIPTION S.ELECTROLYTIC S.TANTALUM S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
ECEV1CA470SP TEMSVB2 1A 336M-8R ECEV0JA220SR C1608 JB 1H 103K-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 120J-T-A C1608 CH 1H 390J-T-A C1608 JB 1H 471K-T-A C1608 JB 1E 104K-T-N ECST1AY225R C1608 JB 1E 104K-T-N C1608 JB 1H 333K-T-A C1608 JB 1E 104K-T-N C1608 JB 1H 103K-T-A C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 104K-T-N ECST0JY475R C1608 JB 1H 103K-T-A ECST1AY225R C1608 JB 1H 333K-T-A C1608 JB 1E 104K-T-N ECJ0EB1A104K ECJ0EB1A104K ECUE1E102KBQ C1608 JB 1H 822K-T-A C1608 JB 1H 393K-T-A C1608 JB 1E 104K-T-N C1608 JB 1H 103K-T-A C1608 JB 1H 103K-T-A C1608 JB 1H 682K-T-A C1608 JB 1H 473K-T-A C1608 JB 1E 104K-T-N C1608 JB 1H 821K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 223K-T-A C1608 JF 1H 104Z-T-A C1608 JF 1H 104Z-T-A ECUE1E102KBQ ECUE1E102KBQ C1608 JB 1H 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 103K-T-A C1608 JB 1H 103K-T-A C1608 JB 1H 103K-T-A C1608 JB 1H 103K-T-A C1608 JB 1H 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A ECUE1E102KBQ ECUE1E102KBQ C1608 CH 1H 240J-T-A ECUE1H222KBQ C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 CH 1H 471J-T-A ECJ0EB1A104K ECUE1E102KBQ C1608 JB 1H 103K-T-A C1608 JB 1E 104K-T-N C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 050B-T-A C1608 CH 1H 060B-T-A C1608 CH 1H 070D-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 050B-T-A C1608 CH 1H 470J-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 100D-T-A C1608 CH 1H 120J-T-A
[OTHER]
REF NO.
ORDER NO.
C411
4030009530 4030009910 4030011770 4030011770 4030006980 4030006990 4030007000 4030006860 4030009500 4030009560 4030014100 4030014110 4030014290 4030014130 4030009570 4030007020 4030009990 4030006980 4030011770 4030007090 4030006860 4030009500 4030016950 4030009910 4030006990 4030007010 4030006850 4030006980 4030006990 4030007000 4030007090 4030014180 4030007090 4030014420 4030014000 4030014070 4030006980 4030009920 4550006450 4030007010 4030016930 4030006880 4550006200 4550006620 4030006860 4030006860 4030014180 4030006850 4030009530 4030009920 4030011770 4030014180 4030007090 4030014180 4030007090 4030007090 4030014180 4030007090 4030007090 4030007090 4030014180 4030007090 4030007090 4030014180 4030014180 4030014180 4030006860 4030014180 4030006860 4030016930 4030008920 4030013850 4030014180
D C412 C413 C414 C416 C417 C418
C419 C421 C422 C423 C424 C426 C427 C443 C450 C452 C455 C467
D
C471 C472 C473 C475
[OTHER]
C486 C491 C492 C495 C496 C501 C550 C551 C552 C553 C554 C555
C556 C557 C558 C559 C560 C561 C562 C563 C564 C565 C566 C567 C571 C572 C573 C574 C575 C659 C662 C663 C664 C665
[OTHER]
B D D D B [OTHER]
E J E B C C [OTHER]
E
DESCRIPTION S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 CH 1H 030B-T-A C1608 CH 1H 040B-T-A C1608 CH 1H 060B-T-A C1608 CH 1H 060B-T-A C1608 CH 1H 070D-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 090D-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 0R5B-T-A C1608 CH 1H R75B-T-A ECUE1H070CCQ ECUE1H080CCQ ECUE1H090CCQ ECUE1H120JCQ C1608 CH 1H 0R3B-T-A C1608 CH 1H 120J-T-A C1608 CH 1H 200J-T-A C1608 CH 1H 070D-T-A C1608 CH 1H 060B-T-A C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 0R5B-T-A ECJ0EB1A473K C1608 CH 1H 040B-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 100D-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 070D-T-A C1608 CH 1H 080D-T-A C1608 CH 1H 090D-T-A C1608 CH 1H 470J-T-A ECUE1H470JCQ C1608 CH 1H 470J-T-A ECUE1H0R5BCQ ECUE1H1R5BCQ ECUE1H040BCQ C1608 CH 1H 070D-T-A C1608 CH 1H 050B-T-A ECST1EY105R C1608 CH 1H 100D-T-A ECJ0EB1A104K C1608 JB 1H 472K-T-A ECST0JY106R ECST0JY226R C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A ECUE1H470JCQ C1608 JB 1H 471K-T-A C1608 CH 1H 030B-T-A C1608 CH 1H 050B-T-A C1608 CH 1H 060B-T-A ECUE1H470JCQ C1608 CH 1H 470J-T-A ECUE1H470JCQ C1608 CH 1H 470J-T-A C1608 CH 1H 470J-T-A ECUE1H470JCQ C1608 CH 1H 470J-T-A C1608 CH 1H 470J-T-A C1608 CH 1H 470J-T-A ECUE1H470JCQ C1608 CH 1H 470J-T-A C1608 CH 1H 470J-T-A ECUE1H470JCQ ECUE1H470JCQ ECUE1H470JCQ C1608 JB 1H 102K-T-A ECUE1H470JCQ C1608 JB 1H 102K-T-A ECJ0EB1A104K C1608 JB 1H 473K-T-A ECUE1E102KBQ ECUE1H470JCQ
C J E [OTHER]
B [OTHER]
A C J E B C [OTHER]
C [OTHER] [OTHER]
E B
C E B B [OTHER]
A [OTHER]
C
C only
S.=Surface mount A: F: K: N:
L-band of ETS/CEPT version M1-band of [GEN] and EIA/TIA version M1-band of ETS/CEPT version M1-band except W/N-type
B: G: L: O:
L-band C: H-band W-type of [GEN] H: W-type N-type of [GEN] and EIA/TIA version 100 channel version
6-5
D: I: M: P:
W/N-type E: M1 (440–470 MHz)-band N-type J: M2 (470–500 MHz)-band N-type of ETS/CEPT version M (20 kHz)-type
[MAIN UNIT] REF NO.
ORDER NO.
C666
C672 C673 C674 C675 C677 C678 C678 C679
4030009910 4030009920 4030009530 4030014180 4030006850 4030017730 4030014180 4030014180 4030014180 4030014220 4030014220 4030013850 4030017730 4030017420
S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
C1608 CH 1H 040B-T-A [OTHER] J C1608 CH 1H 050B-T-A C1608 CH 1H 030B-T-A H, P ECUE1H470JCQ C1608 JB 1H 471K-T-A except B ECJ0EB1E471K A ECUE1H470JCQ ECUE1H470JCQ ECUE1H470JCQ ECUE1E471KBQ ECUE1E471KBQ B ECJ0EB1E102K ECJ0EB1E471K J ECJ0EC1H470J D
J2 J3 J5 J6
6450001680 6450001690 6510018430 6510021900
CONNECTOR CONNECTOR S.CONNECTOR S.CONNECTOR
HSJ1122-010010 HSJ1456-01-220 AXN330C038P BM02B-ASRS-TF
DS1 DS2 DS3
5030001800 LCD 5010000160 S.LED 5010000160 S.LED
LM-7045B LNJ310M6URA LNJ310M6URA
MC1
7700002160 MICROPHON
KUC3523-040245
S1 S2 S3
2230001070 S.SWITCH 2230001070 S.SWITCH 2230001070 S.SWITCH
JPM1990-2711R JPM1990-2711R JPM1990-2711R
SP1
2510001060 SPEAKER
K036NA500-47
W1 W5 W10 W11 W12 W15 W16
8900009640 7030009970 7030003860 7030003860 7030003860 7030010040 7030003860
CABLE S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER
OPC-963 MJ-0.1 ERJ3GE JPW V ERJ3GE JPW V ERJ3GE JPW V ERJ2GE-JPW ERJ3GE JPW V
EP1
0910052735 0910053271 0910053762 0910054202 8930051310 6910013370 6910013370 6910013370 6910013370 6910013370 6910013370
PCB PCB PCB PCB LCD CONTACT S.BEAD S.BEAD S.BEAD S.BEAD S.BEAD S.BEAD
B 5387E B 5541A B 5542B B 5688B SRCN-2251-SP-N-W BLM11B221SB BLM11B221SB BLM11B221SB BLM11B221SB BLM11B221SB BLM11B221SB
C668 C669 C670
EP2 EP10 EP11 EP12 EP13 EP14 EP15
DESCRIPTION
except C
N B J, C D
E, J only
S.=Surface mount A: F: K: N:
L-band of ETS/CEPT version M1-band of [GEN] and EIA/TIA version M1-band of ETS/CEPT version M1-band except W/N-type
B: G: L: O:
L-band C: H-band W-type of [GEN] H: W-type N-type of [GEN] and EIA/TIA version 100 channel version
6-6
D: I: M: P:
W/N-type E: M1 (440–470 MHz)-band N-type J: M2 (470–500 MHz)-band N-type of ETS/CEPT version M (20 kHz)-type
SECTION 7
MECHANICAL PARTS AND DISASSEMBLY
[CHASSIS PARTS]
[ACCESSORIES]
REF. NO. ODER NO. MP1 MP2 MP3 MP4 MP5 MP6 MP7 MP8 MP9 MP10 MP12 MP13 MP14 MP15 MP17 MP18 MP20 MP21 MP22 MP23 MP24 MP25 MP26 MP27 MP29 MP31 MP32 MP33 MP36 MP37 MP38 MP39 MP41 MP42 MP43
8210016541 8210016671 8930050890 8010017991 8210016570 8930050870 8210016560 8310047580 8930051350 8210016550 8610010780 8930050820 8930050790 8930050590 8930050840 8930050850 8930050860 8930050880 8930042350 8930051300 8930051290 8830001340 8930050900 8930036751 8950005260 8830001250 8930040390 8810009510 8810009560 8810000100 8930051330 8930050800 8950005240 8860001210 8510013022 8930053110 8510013210
DESCRIPTION
QTY.
2251 T-front panel-1 2251 S-front panel-1 2251 terminal holder 2251 chassis-1 2251 rear panel 2251 release button 2251 PTT panel 2251 window plate 2251 jack rubber 2251 jack panel Knob N-276 2251 main seal 2251 10-key 2251 6-key 2251 minus terminal 2251 plus terminal 2251 PTT button 2251 spring holder 1922 mic sheet 2251 mic sponge 2251 opt sheet 1903 hex nut 2251 window sheet Spring Ant connector-102 Ant connector-101 SP net (B) Screw BT M2 x 4 NI-ZU Screw BT M2 x 6 ZK Screw M2 x 4 2251 contact rubber 2251 jack cap 2251 contact spring 2251 ANT rug 2252 shield plate-2 Aluminum sheet (AE) 2252 jack shield
[F4GT] [F4GS]
[F4GT] [F4GS]
REF. NO. ODER NO.
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 8 7 4 1 1 1
EP1
EP2
MP1 MP2
DESCRIPTION
1
SP1
2510001060 Speaker K036NA500-47
1
EP2
8930051310 LCD contact SRCN-2251-SP-N-W
1
MP1 MP3 MP4 MP5 MP6 MP8 MP9
8510011111 8930050811 8210016580 8410002230 8510011180 8930052270 8930053200
1 1 1 1 1 1 1
1922 VCO case-1 2251 LCD holder-1 2251 reflector 2078 PA heatsink 1923 VCO cover Shield sponge (d) 2252 CPU plate
Screw abbreviations
[ETS/CEPT]
8930042041 1922 Belt clip-1 8930051290 2251 OPT sheet
EP2
MP1
BT: Self-tapping NI-ZU: Nickel-zinc ZK: Black
7-1
1 1 1 1 1 1 1
EP1
QTY.
5030001800 LM-7045B
QTY. A B C [other] [EIA/TIA]
(color)
1 1 1
DS1
DESCRIPTION Antenna FA-SC25U (Blue) Antenna FA-SC57U (Red) Antenna FA-SC72U (Green) Battery BP-209 Exp-recycle ACC Battery BP-209 RBRC-recycle ACC
A: L-band B: 440–470 MHz band C: 470–500 MHz and H-band
[MAIN UNIT] REF. NO. ODER NO.
Optional product Optional product Optional product Optional product Optional product
MP2
MP33 (C)
MP26 (C) MP33 (C)
MP39 (C) MP32 (C) MP23 (C)
MP32 (C)
MP31 (C)
MP4 (C)
MP15 (C)
MP3 (C)
MP25 (C)
MP2 (C)
MP5 (C) MP12 (C)
MP31 (C) MP14 (C)
MP38 (C) MP36 (C)
MP5 (M)
MP8 (C)
MP1 (M)
MP32 (C)
MP37 (C)
MP9 (C)
MP8 (M) MP6 (M)
MP31 (C)
MP41 (C) MP33 (C) MP22 (C) MP32 (C)
MP18 (C) MP32 (C)
MP42 (C)
MP31 (C)
MP10 (C)
IC-F4GS parts MP27 (C)
SP1 (M) MP31 (C)
MP4 (M) EP2 (M) DS1 (M)
MP1 (C)
MP3 (M)
MAIN unit MP31 (C)
MP21 (C) MP20 (C)
MP24 (C) MP13 (C)
MP7 (C)
MP13 (C) MP1 (C)
UNIT abbreviation (C): CHASSIS PARTS, (M): MAIN UNIT 7-2
SECTION 8
SEMI-CONDUCTOR INFORMATION
• TRANSISTOR AND FET’S 2SA1577 Q (Symbol: HQ)
2SB1132 R (Symbol: BARB)
2SC3585 R44 (Symbol: R44)
B
B C E
2SC5085 Y (Symbol: MCY)
E
E
E
2SK2973 (Symbol: K1)
C
2SK2974 (Symbol: K2974) D
S S
S
S D
D
DTA144 EU (Symbol: 16) G2
DTC144 EE (Symbol: 26)
B
G1
E
UN911 H (Symbol: 6P)
XP1213 (Symbol: 9L)
B
B1
C E
C1
B2
C2
B
B C
C
E
E
XP1214 (Symbol: 9H)
XP6501 AB (Symbol: 5N)
B1
C1
E1
E1
DTC144 TU (Symbol: 06)
DTC144 EU (Symbol: 26)
B
C2
B2
G D
G (top view)
C S
2SK880 Y (Symbol: XY)
E
3SK239 A (Symbol: XR)
C E
G
B C
B C
C
2SC5107 O (Symbol: MFO)
B
B
B
C E
2SC4215 O (Symbol: QO)
2SC4116 GR (Symbol: LG)
C E
E1
C1
E2
B1
B2
C2
• DIODES 1SV245 (Symbol: T3)
1SV307 (Symbol: TX)
DAN202K (Symbol: N)
HVU350B (Symbol: BO)
MA77 (Symbol: 4B)
A1 A
C
C A2
MA8030 H (Symbol: 3^0)
RB706F-40 (Symbol: 3J)
8-1
A
C
SECTION 9
BOARD LAYOUTS
9-1 LOW BAND • MAIN UNIT (TOP VIEW)
9-1
R174
Q31
C659
Q1
C15 R7
C252
L22
R63 R252 R62 C84
R258
C90
R457
D32
C52 D2 C78
L18
C405 C92
R401
R530
C73
R52 R64
C89
L31 R2
C551
R163
C11
R523
R161
D11 C96
D12
R524
C9
IC3
R53
R458
C467
D8
R1
R9
Q37
R251 R503
R210
C665
R54
R522
C574
C285
W5
C14
C289
C12
W12
C19
R142
C282
C21
L26
R86 R85
W11
C24 C75
C558
R93
C17
W15 R509
R116
R108
R109 C133
C156
IC6 C121
C122
Q20
IC2 C664
C25
C124
C136
R521
C13
C18 C179
R61
D27
MC1
R155 R205
Q25
J6
C117
R84
R79 R445 R117
R67
R204
C492
R66
R505
C552
R520
++
C119
R65
R112
C128
C118
Q2
R176
Q403
C217
R177 C556
C452
R17
R113
C135
C93
C677
R133
C113 R253
R15 C26
C561
R14
C672
R87
C22
Q3
R114 R115
R98
R88
R12
C134 R105
IC4
R135
C472
C95
DS3
C159
R83
C112
R89
C473
Q401 R257
C286
D3
L441
C212
R107
R446
C137
C214
R508
C283
L443
L7
R13
L411
D4
R125
C148
R44
R169
+
C213 +
R215
R257
C673
R507
Q11
C471
C674
R97
R30
+ +
R80
R81
R502
C573
Q34
R186
C234
L12
R168
R170
R420
C42 C571
R421
EP14
C233
C50
C115
Q14
C120
R82
C116
R518
IC1 R184
Q402
L406
R511
R422
L404
+ +
R414
C48
R33
+ +
C560
UHF
C291
+ C491 +
C160
C111
C443
R32
R529
L407
DS1
C51
R34
C47
R223
Q10
R526
C218
R185
L13
R244
C54
C572 R527
R528
DS2
C63
C60
R41
X3
C675
Q18
C56 R473
R90
C55
C495
R512
C496
+ C501 +
Q19
R134
C149 R126
X2 C195 R146 C550 + + C154
+ +
R131
C197
9-2 30
C132
C663
BUSY
R137
R510
R516
C
R243
J5
J5
C147
B5541A
OPTION
R235
R240
C566
C244
R150
W10
R533
IC14
C72
C222
R192
R190
C221
R209
R500
C236
R199 R213
S2
S2
X4
IC12
C229
R208
R501
R200
ICOM
Q405
R136
C194
R239
R228
R225
R231
C71
IC13
R50
IC7
R171
R216
R101
C562
R220
R515
R147 C209
Q38 R241
R194
R242
R195
R130
R232
R122
Q17
R525
C554
L33
LV
R196
C224
C168 R238
C144
R218 R226
R246
IC11
C145
R219
R236
C223
C152 L442
R234
C61
L14
C62
R49
R148
IC5
R229
R245
C200
D14
C151
R237
R198 R211
C196
R127 R102
++
C250
R207
C139
R120
C564
R197
R103
C140
R517 C216
R224
C249
C193
EP12
C565
C202
C245
R215
C557
R164
C225
C231
C227
R154
C201
C662
D26
Q35
R203
R165
R145
R227
L405
C423
Q7
L9 C30
IC10
R181
C153
R230
C232
R506
R202
C475
R121
C411
R519
R182
W6
D403 C228
R123
D5 C219
C418
R534
C410
C421
C422
C427
C32
C65
R191
C248
Q16
R19
L11
R410
C414
D404
R153
Q15
C412
Q6
C33
C424
C426
S3
S3
X4
R140
R68 C413
Q36
C99 C417
C419
R51
F
EP10 C416 R22
+
C211 +
PTTIN PTTOUT MICOUT MICIN AUX BUSY MOWN SIGOUT OPT1 OPT2 OPT3 GND OPV3 OPV2 OPV1
C165 R152
++
R221
R449
R504
L25
C146
R448 R416
C150
C486 R23
Q5
C66
C164
C27 C670 C678
R417
R411
C29
Q8
R464 R21
C31
R139
C53
R128
C104
R18
C28
L8
C110 R465
C67
R141
C161
C123
R48
GND 5V VCC MICMUTE AFONOP BEEPOUT RXMUTE DISCIN AFOUT REM CCS CIRQ SO SI SCK
R404 C553
C555
C169
L21 R20
R69
C106 Q4
EP13
FI1
C163
L19 R77
C450
C455
Q13 C114
R144
R159 L20 C107
R469
J3
C98 C162
Q22 C669
C167
MP5 FI1
C173
R447
R70 Q21
R132
C105
EP11
R260
R261
C559
C243 R75
R109
FI2
R262
FI2
+ C158 +
R72
MP5
C97
R405
R99 R104
R160
S1
S1
C174
J2
C406 C94
++
C129
R178
R95
C126
C288 C204
R143
C155
C91
C100
L402
R94
D29
R100
R96 C125
C10
C407
C87 C88
R55
D401
C3
Q12
C79
C404
R59
C76
R402
C666 L15
D1
C403
L1 D10
C251
D33
L24
C85
C8
C205
R3
R162
C86
L17
L2
C4
L4
• MAIN UNIT (BOTTOM VIEW)
R212
+ C198 +
R532
R193
C199
IC8
C563
1
C230
C567
1 15
J5 to the OPTIONAL unit 16
9-2 440–470 MHz BAND EXCEPT W/N-TYPE • MAIN UNIT (TOP VIEW)
9-3
R174
Q31
C156
IC6 C121
C659
Q1
C15
C24
R7
IC3
R53
C252
L22
R63 R252 R62 C84
R258
C90
R457
D32
C52 D2 C78
L18
C405 C92
R401
R530
C73
R52 R64
C89
L31 R2
C551
C11
R523
R161
D11 C96
R524
C9
R503
R458
C467
R163
R54
R210
C665
W15 R509
R522
C574
D8
R1
R9
Q37
R251
C75
C558
R93
C17
C285
W5
C14
C289
W12
C19
R142
C282
C21
L26
R86 R85
W11
C12
C122
Q20
IC2 C664
C25 C133
C136
R108
R109
R61
D27
MC1
R155 R205
Q25
J6
C124
R116
R117
R67
R204
C117
R84
R79 R445
C135
R521
C13
C18 C179
D12
R505
C492
R66
R112
C128
C552
R520
++
C119
R65
R115
R113
C118
Q2
R176
Q403
C217
R177 C556
C452
R17
C672
R87
C22
Q3
R114
C93
C677
R133
C113 R253
R15 C26
C561
R14
R257
C286
R98
R88
R12
C134 R105
IC4
R135
C472
C95
DS3
C159
R83
C112
R89
C473
Q401
EP15
D3
L441
C212
R107
R446
C137
C214
R508
C283
L443
L7
R13
L411
D4
R125
C148
R44
R169
+
C213 +
R215
C673
R97
Q11
C471
C674
R507
R30
+ +
R80
R81
R502
C573
Q34
C234
L12
R168
R170
R420
C42 C571
R421
EP14
C233
C50
C115
Q14
C120
R82
C116
R518
IC1 R422
R184
Q402
L406
R511
R414
+ +
C560
C48
R33
+ +
R186
UHF
C291
+ C491 +
C160
C111
C443
R32
R529
L407
DS1
C51
R34
C47
R223
Q10
R526
C218
R185
L13
R244
C54
C572 R527
R528
DS2
C63
C60
R41
X3
C675
Q18
C56 R473
R90
C55
C495
R512
C496
+ C501 +
Q19
R134
C149 R126
X2 C195 R146 C197
C550 + + C154
+ +
9-4 30
C663
J5
J5
C132
BUSY
R137
R510
R516
C
R243
R136
C194
B5387E
ICOM
R533
IC14
C72
C222
R192
R190
C221
R209
R500
C236
R199 R213
S2
S2
X4
IC12
C229
R208
R501
R239
R240
C244
R150
R200
OPTION
R235
R228
C566 W10
Q405
R171
R216
R131
C562
R220 R101
C147
R194
C224
C168 R515
R147 C209
Q38 R241
R195
R242
R196
R130
R232
R122
Q17
L33
C554
R525
C144
R231 R225
C71
IC13
R50
IC7
R238
LV
R234
R246
C223
C152 R219
R236
IC11
IC5
R229
C61
L14
C62
R49
R148
C145
R218 R226
C216
R245
C200
D14
C151
R237
R198 R211
C196
C557
C564
R197
R103
R127 R102
++
L442
R120
C202
C245
R215
R224
C139
R207
C250
C475
R517
C565
C249
C193
EP12
C140
R164
C225
C231
D26
R154
C201
C662
C227
R165
R145
R203
Q35
R152
R121
R227
L405
C423
Q7
L9 C30
IC10
R181
C153
R230
C232
R506 R202
C219
C411
R519
R182
W16 D403
R123
D5
R534
C410
C421
C422
C427
C32
C65
R191
C248
R19
L11
R410
Q6
C33
C424
S3
S3
X4
R140
Q16
C412
C414 C418
C228
Q15
C413
Q36
R68 C670 D404
R51
F
EP10 C99 C417
C419
+
C211 +
PTTIN PTTOUT MICOUT MICIN AUX BUSY MOWN SIGOUT OPT1 OPT2 OPT3 GND OPV3 OPV2 OPV1
C165 C416 R22
R153
++
R221
R449
C426
L25
C146
R448 R416
C150
C486 R504
Q5
C66
C164
C27 R23 R417
R411
C29
Q8
R464 R21
C31
R139
C53
R128
C104
R18
C28
L8
C110 R465
C67
R141
C161
C123
R48
GND 5V VCC MICMUTE AFONOP BEEPOUT RXMUTE DISCIN AFOUT REM CCS CIRQ SO SI SCK
R404 C553
C555
C169
L21 R20
R69
C106 Q4
EP13
FI1
C163
L19 R77
C450
C455
Q13 C114
R144
R159 L20 C107
R469
J3
C98 C162
Q22 C669
C167
MP5 FI1
C173
R447
R70 Q21
R132
C105
EP11
R260 R261
C559
C243 R75
R109
FI2
R262
FI2
+ C158 +
R72
MP5
C97
R405
R99 R104
R160
S1
S1
C174
J2
C406 C94
++
C129
R178
R95
C126
C288 C204
R143
C155
C91
C100
L402
R94
D29
R100
R96 C125
C10
C407
C87 C88
R55
D401
C3
Q12
C79
C404
R59
C76
R402
C666 L15
D1
C403
L1 D10
L24
C85
C8
C251
D33
R3
R162
C86
L17
L2
C205
L4
• MAIN UNIT (BOTTOM VIEW)
R212
+ C198 +
R532
R193
C199
IC8
C563
1
C230
C567
1 15
J5 to the OPTIONAL unit 16
9-3 470–500 MHz AND HIGH BANDS • MAIN UNIT (TOP VIEW)
9-5
R174
Q31
C156
IC6
C575
C121
C21
L26
Q1
C15
R7
C252
L22
R63 R252 R62 C84
R258
C90
R457
D32
C52 D2 C78
L18
C405 C92
R401
R530
C73
R52 R64
C89
L31 R2
C551
C11
R523
R161
D11 C96
D12
R524
C9
IC3
R53
R458
C467
R163
R503
R210
C665
R54
R522
C574
D8
R1
R9
Q37
R251
C75
C558
R93
C17
W15 R509
R116
R108
R109 C133
C285
W5
C14
C289
W12
C19
C659 C24
C25
C124
C136
R142
C282
C122 R86 R85
W11
C12
Q20
IC2 C664
R521
C13
C18 C179
R61
D27
MC1
R155 R205
Q25
C117
R84
R79 R445
R502
R117
R67
J6
C119
C552
R520
++
Q2
R176
Q403
C217
R505
C492
R66
R112
C128
C135
C93
R204
R133
C113 R244
R253
R15
R177 C556
C452
R113
C118
C22
Q3
C134
C95
C677
C159
R83
C112
R89 C26
C561
R14
R507
R257
C672
R87
R12
R114 R115
R98
R88
R65
IC4
R135
C472
R105
C212
R107
C473
Q401
EP15
R414
D3
L441
C137
C214
DS3
C120
C283
L443
L7
R13
L411
D4
R125
C148
R44
R169
+
C471
R446
R97
Q11
R508
R80
R81
R17
C573
R30
+ +
C213 +
R215
C115
Q14
C674
R257
C673 C286
Q34
R186
C234
L12
R168
R170
R420
C42 C571
R421
EP14
C233
C50
R82
C116
R518
IC1 R422
R184
Q402
L406
R511
C560
C48
+ +
R33
+ +
UHF C291
+ C491 +
C160
C111
C443
R32
R529
L407
DS1
C51
R34
C47
R223
Q10
R526
C218
R185
C63
C54
C572 R527
R528
DS2
C675
Q18
C56
C60
R41
X3
L13
R473
R90
C55
C495
R512
C496
+ C501 +
Q19
R134
C149 R126 C195 R146 C550 + + C154
+ +
R131
C197
9-6 30
C132
C663
BUSY
R137
R510
R516
C
R243
J5
J5
C147
R241
Q38
R136
C194
R147 C209
R207
R242
B5542B
R228
ICOM
R533
C72
C222
R192
R190
C221
R209
R500
C236
R199 R213
IC14
R240
S2
S2
X4
IC12
C229
R208
R501
R239
OPTION
R235
R195
R130
R232
R122
Q17
R194
C554
R525
R171
R216
R101
LV
R196
C562
R515
Q405
R238
C144
R218 R226
L33
D14
R231
IC7 R200
R246
F
X2
R236
C224
C152 R225
R49
C223
IC5 R220
R102
R245
C200
C196
C151
R237
R198 R211
IC11
C145
R219
C564
R197
R103
C557
C249
C193
R127
C202
C245
R215
++
C225
C231
R120
C201
C662
R224
R181
C565
L442
R164
C139
R234
IC10
C232
EP12
C140
R154
R229
R230
R182
D26
C216
C244
R150
W10
C566
R50
C71
IC13
R519
R140
C227
R165
C250
C61
L14
C62
C65
R191
C248
C153
+
C211 +
R148
C168 Q36
R506 R203 R517
D403 C228 Q35
L405
C423
Q7
C30
L9
C32
S3
S3
X4
R145
R227
R152
R121
C411 R202
C421
C422
C427
C424
C426
R153
R123
D5 C219
C418
R534
C410
Q6
R22 D404
R51
R221
W16
L11
R410
C414
Q16
R19
C412
C417
C419
Q15
C413 R411
C416 C33
R416
C146
R68 R504
L25
++
PTTIN PTTOUT MICOUT MICIN AUX BUSY MOWN SIGOUT OPT1 OPT2 OPT3 GND OPV3 OPV2 OPV1
EP10 C99 R23 R417
C150
R464 Q8
C670 C678
Q5
C66
C164
R449
R21
C31
R139
C53
R128
R448 R18
R465 C28
L8
C106 Q4
C110
C27
EP13
C67
R141
C161
C123
R48
GND 5V VCC MICMUTE AFONOP BEEPOUT RXMUTE DISCIN AFOUT REM CCS CIRQ SO SI SCK
C165 C553
C555
C169
L21 R20
R69
C104
C486
R77
C450
C455
Q13 C114
C163
L19
FI1
R144
R159 L20 C107
R469
J3
C98 C162
Q22 C669
C167
MP5 FI1
C173
R447
R70 Q21
R132
C105
EP11
R260 R261
C559
C243 R75
R109
FI2
R262
+ C158 +
R72
FI2
S1
S1
C174
J2
R404 C94
R99 R104
R160
MP5
C97
++
C129
R178
R95
C126
C288 C204
R143
C155
C91
C406
L402
C100 R405
R94
D29
R100
R96 C125
C10
C407
C87 C88
R55
D401
C3
Q12
C79
C404
R59
C76
R402
C666 L15
D1
C403
L1 D10
C251
D33
L24
C85
C8
C205
R3
R162
C86
L17
L2
C4
L4
• MAIN UNIT (BOTTOM VIEW)
R212
+ C198 +
R532
R193
C199
IC8
C563
1
C230
C567
1 15
J5 to the OPTIONAL unit 16
9-4 W/N-TYPE • MAIN UNIT (TOP VIEW)
R174
J6
Q19
C121
C659
C252
R457
C52 D2
R62 C84
D8
R1
L22
R63 R252 R258
C90
D32
C78
L18
C405 C92
R401
C551
R2
R530
C73
R52 R64
C89
L31
C11
R523
R161
D11 C96
R524
C9
IC3
R53
R458
C467
R163
R503
R210
C665
R54
R522
C574
C285
W5
C14
C12
C289
Q1
R7
R9
Q37
R251
C75
C558
R93
C17
W15 R509
R116
C133
R108
R109
C136
C156 C21
W12 C15
C24
C25
C124
R61 Q31
IC6 L26
R86 R85
C19
Q20 C122
R133
IC2 C664
C117
R84 R502
Q403
D27
R155 R205
Q25 R204
9-7
MC1
R67
C13
C18 C179
D12
W/N
C93
C677
C492
R66
R505
R117
W11
Q2
R65
R115
R112
C95
DS3
C113
R518
R79 R445 C217
R177
C452
R113
R521
++
C119
C552
R520
L7
R176
C134
C135
R142 C282
C118
R12
R114
C672
C128
C159
C308 C112
R253
C473
R15 C26
C561
R14
R507
R257
C286
IC4
R98 R107
R83
R89
Q401
EP15
C212
R88
R87
C472
R105
C137
C214
D3
L441
D4
R125
C148
+
C213 +
R215
R44
R169
R168
R446
R97
Q11
R508
C120
C283
L443
R135
C22
Q3
R13
L411
R17
C573
+ +
R30
EP14
C471
C674
R257
C673
R80
C556
IC1 L12
C115
Q14
R81
R421
R420
C42 C571
Q34
C234
C50
Q402
L406
R511
R422
R184
C233
R170
+ C491 +
R414
+ +
R186
UHF
C291
C51
C560
C48
L407
DS1
Q10
C160
R82
C116
C111
R33
+ +
R223
R269
R34
C443
R32
R529
C47
C307
R526
C218
R185
L13 C56
X3
C675
Q18
R244
C54
C572 R527
R528
DS2
C63
C60
R41
Q41
R473
R90
C55
C495
R512
C496
+ C501 +
R134
C149 R126
X2 C550 + + C154
+ +
C197
9-8
C663
J5
30
J5
C132
BUSY
C
R243
R137
R510
Q42
R274
C199
B5688B
OPTION
R273
C567
1
J5 to the OPTIONAL unit
IC15
R146
R235
R275
C195
R131
R242
C566
C244
R150
W10
X4
R533
IC14
C72
C221
R209
R500
C222
R192
R190
R199 R213
S2
S2
S3
S3
C236
IC12
C229
R208
R501
R200
ICOM
Q405
R136
C194
R270
R240
C71
IC13
R50
IC7
R171
R216
R101
C209
R193
R516
R194
R130
Q38 R241
R195
C147
R232
R122
Q17
R525
C554
R196 R271
C562
R515
R147
LV
R246
R239
R238
C144
R218 R226
L33
D14
R228
R225
R231
C61
L14
C62
R236
C200
C196
R102
R234 R229
L9 C30
R49
R103
C216
R245
R198 R211
C224
C152 R237
R197
C223
IC5 R220
C564
C193
C151
C249
IC11
C145
R219
C202
C245
R215
C557
C225
C231
R127
L442
R120 C139
R207
C250
R152
R145
L405
C423
Q7
C565
C201
C662
EP12
C140
R154
R181
D26
R224 R517
C227
R165
R164
R182
R227
C475
R121
R203
Q35
C421
C422
C427
C32
IC10
C232
C153
R230
C248
R506 R202
C219
C411
R519
R140
W16 D403
C228
R123
D5
R534
C410
Q6
C33
C424
C426
R139
C161
X4 R191
R148
C168 Q36
Q16
R19
L11
R410
C417 C418
R51
R221
C413 C412
C414
D404
+
C211 +
F
EP10 R68 C670 C419 R153
++
PTTIN PTTOUT MICOUT MICIN AUX BUSY MOWN SIGOUT OPT1 OPT2 OPT3 GND OPV3 OPV2 OPV1
C165 C99 R22
Q15
C486 R504
L25
C146
R449
C416
C150
C27 R23
Q5
R141
C66
C164
R448 R21
C31
C67
C162
R260
C53
R128
R464 R416
C123
R48
GND 5V VCC MICMUTE AFONOP BEEPOUT RXMUTE DISCIN AFOUT REM CCS CIRQ SO SI SCK
R404 C553
C104
R18 R417
R411
C29
Q8
C110 R465 C28
L8
C106 Q4
EP13
FI1 R20
R144
L19 C555
C169
L21
C65
C163
C98 C114
R69
Q13
C455
C450 R77
R469
J3
R159 L20 C107
MP5 FI1
Q22 C669
C167
R70 Q21
R447
C105
EP11
R75
R109 R261
C559
C243
R262
FI2
R72
FI2
+ +
R132
R405
R99 R104
MP5
C97
++
C129
R178
R160
S1
S1
C174
J2
C406 C94
R94
R95
+ C173 +
R143
C155
C91
C100 R100
D29
L402
C87
C126
C288 C204
C10
C407
C3 C88
R55
D401
C79 Q12
C76
C404
R59
C125
R96
D1
R402
C666 L15
L24
C403
L1 D10
R162
C85
C8
C251
D33
R3
C158
C86
L17
L2
C205
L4
• MAIN UNIT (BOTTOM VIEW)
R212
+ C198 +
R532
R272
IC8
C563
1 R276
C230 C311
C679
15
16
SECTION 10
BC-137 OPTIONAL DESKTOP CHARGER INFORMASION
10-1 PARTS LIST
10-2 DISASSEMBLY INFORMATION
[MAIN UNIT] REF. NO. ODER NO. Q1 Q2 Q3 Q4
1520000650 1590000480 1590000510 1530001950
D1 D2 D3
DESCRIPTION S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR
QTY.
2SB1201-S-TL RN2402 (TE85R) RN1409 (TE85R) 2SC2712-GR (TE85R)
1 1 1 1
1750000550 S.DIODE 1750000020 S.DIODE 1790000950 S.ZENER
1SS355 TE-17 1SS184 (TE85R) MA8056-M (TX)
1 1 1
R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11
7030010000 7030010000 7030000190 7030000500 7030000500 7030000190 7030001740 7030001740 7030000590 7030000500 7030000380
S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR
MCR10EZHF 24R0 Ω (240) MCR10EZHF 24R0 Ω (240) MCR10EZHJ 27 Ω (270) MCR10EZHJ 10 kΩ MCR10EZHJ 10 kΩ MCR10EZHJ 27 Ω (270) MCR10EZHJ 2 kΩ MCR10EZHJ 2 kΩ MCR10EZHJ 56 kΩ MCR10EZHJ 10 kΩ MCR10EZHJ 1 kΩ
1 1 1 1 1 1 1 1 1 1 1
C1 C2 C3 C4
4030001150 4030001150 4030001150 4030001150
S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC
GRM40 F 104Z 25PT GRM40 F 104Z 25PT GRM40 F 104Z 25PT GRM40 F 104Z 25PT
1 1 1 1
J1 J2
6510021470 CONNECTOR 6510021470 CONNECTOR
HEC0470-01-230 HEC0470-01-230
1 1
DS1
5040001390 LED
TLG124A
1
W1
7030003970 S.JUMPER
MCR18EZHJ JPW (000)
1
EP1 EP2
0910052602 PCB 6910012240 SPACER
B 5493B TLE60-05
1 1
MP1
8930051340 2338 TERMINAL
MP3 (C)
MP1 (C)
MP1 (M)
MAIN unit
MP2 (C)
MP4 (C)
MP4 (C) MP5 (C) MP4 (C)
3
S.=Surface mount
NOTE: (C) : CHASSIS (M) : MAIN UNIT
[CHASSIS UNIT] REF. NO. ODER NO. MP1 MP2 MP3 MP4 MP5
8010018030 8110007080 8930050920 8930039620 8810008660
CONVENIENT: DESCRIPTION 2338 case 2338 cover 2327 spacer Leg cushion (A) Screw BT M3 x 8 NI-ZU
BC-137 is connectable max. 6 pieces in parallel. When connect BC-137 in parallel, JIG cable (as shown below) is required.
QTY. 1 1 1 4 1
• CONNECTION JIG cable
AC adaptor (BC-122) or DC power supply
Screw abbreviations BT : Self-tapping NI : Nickel J2
J1
J2
BC-137
J1
BC-137 Max. 6 pieces of BC-137
• JIG CABLE ( – GND)
( + 13.8 V) AP-301 (Order No: 5610000010)
10 - 1
J2
J1
BC-137
10-3 VOLTAGE DIAGRAM
12.49 V 12.47 V
13.80 V J1
R1 24
R5 10 k 8.01 V 7.98 V 7.20 V D2 1SS184
W1
Q1 2SB1201 S
R2 24
J2
CHARGE+ C1 0.1
C4 0.1
R6 27
13.63 V 12.46 V
Q2 RN2404
C3 0.1
11.82 V 11.80 V
R3 27
TEMP DS1 TLG124A R8 2k
R7 2k
C2 0.1
GND
R4 10 k D1 1SS355
Q3 RN1409
0.23 V 0.22 V R9 56 k
Q4 2SC2712 GR
R11 1k
R10 10 k
0.74 V 0.73 V
0V 13.77 V
D3 MA8056 M 5.62 V 0V
10-4 BOARD LAYOUT
C3
D2
C4
R9
C2
R1
C1
R10
R7
R3 Q4
Q2
R2
D1
W1
R6 Q3
R4
D3
R11
R8
R5
Q1
10 - 2
SECTION 11
BLOCK DIAGRAM
J5 AXN330C038 REF
OPTION UNIT
VCO Q7 2SC5085 Y Q8 2SC5085 Y
IC1 UPD3140GS
2TONE or 5TONE
DBAL
FRQCON
PLL IC
MIC, AF, PTT, MMUT RMUT, AFONOP SIGOUT
Q6 2SC5107 O
Q4 2SC5107 O
BUFF
BUFF
LOOP FIL
D3 MA77 D4 MA77
Q403 2SC5107 O
TX/RX SW
Q3 2SC3585 R44
BUFF
Q2 2SK2973 PRE DRIVE
BUFF
PWR AMP
ANT SW
LPF
LPF
X4 CR-662 (15.3 MHz) Q5 2SC5107 O D32 RB706F-40 D33 RB706F-40
IC3A NJM3403AV Q37 DTA144EU
BUFF DEV
TXC
PTT CONT
APC
PWR DET
Q12 3SK239A
D10 HVU350B
Q34 2SK880 Y Q10 2SC4116 GR
BUFF
Q17 UN911H
PTT
ANT
D1 1SV307 D2 MA77 D8 MA77
Q1 2SK2974
BUFF
BPF
MIC VCC
Q15 2SB1132 R Q16 XP6501 AB D26 DAN202K
(45.9 MHz)
AF REG
DET
D401 HVU350B D11 HVU350B D12 HVU350B
Q14 2SC4215 O
IC2 TA31136FN(D)
IF AMP
IF DET IC
BPF
RF AMP
BPF
BPF
Q13 3SK239A
BPF Q41 2SC4116 GR A only
FI2 SFPC450G C SFPC450E [OTHER] CFWC450F A
NWC
W/N SWITCHING CIRCUIT
IC10 M62363FP-650C T1
SP
T4
SQL
AF AMP
T2, T3, T4
FI1 FL-313 D FL-321 B FL-335 E FL-336 [OTHER]
IC5 TA7368F
D/A
SD NOIS
IC10 M62363FP-650C D/A
VCC
5V
VR OPT
IC6 TK11250BM [OTHER] NJM2870 A
CPU5 Q18 2SB1132 R Q19 XP6501 AB
EXT.MIC S5 MIC JACK
REG S5
Q20 DTA144EU S5 CONT
+5 CPU S5C
IC3B NJM3403AV AF OUT SP CLONE
CPU5 IC11 S-80942ANMP-DD6
IC4 BU4066BCFV
Q31 DTC144TU D27 RB706F-40
HPF ANALOG SW
BUFF
RESET
Q21 2SA1577 Q R5
REG R5
R5C
IC3D NJM3403AV
IC3C NJM3403AV SP JACK MIC AMP
LPF
T5
X2 CR-663
CPU
LPF
Q22 2SA1577 Q PRE ENPHA
IC12 NJM2904V
REG T5
T5C
LCD
IC8 HD6433876B44H (9.2 MHz)
Q35 2SC4116 GR CTCSS DTCS LPF
VCC CTCSS
Q36 2SC4116 GR DTMF
TONE
BATT
BUFF
MTONE
MMUT
RMUT
POWER SW
KEY MATRIX
BDET EEPROM GND IC7 HN58X2432TI [OTHER] HN58X2464TI F COMMON LINE RX LINE TX LINE
11 - 1
NOTE A: W/N-type E: N-type of ETS/CEPT version
B: W-type of [GEN] F: 100 channel version
C: N-type
D: N-type of [GEN] and EIA/TIA version
SECTION 12
VOLTAGE DIAGRAM
J5 AXN330C038
S5 CPU5 R5 S5 CPU5
S5 CPU5 R5 S5 CPU5
R5
R5
S5 CPU5
S5
Tx: 2.19 V Rx: 2.20 V VCC
R104 100 k
R132 470
R140 100 k CLIN
R174 15 k D27 RB706F-40
C165 0.001
CLONE 4.89 V
R220 330 k
KR0 KR1 KR2 KR3
Q31 DTC144TU
UP
4
S2 JPM1990-2711R
DN
2
5
3
6
R239 1k
P1
R238 1k
8
9
DTMF 2.2 Vp-p BEEP 2.5 Vp-p
0
#
C311 0.1 D
5
R219 100 k I 120 k [OTHER]
2
IC15 3 TC7S66FU D only R275 4.7 k D only
R221 390 k
R533 100 k
IC12A NJM2904V
R190 22 k
R192 22k R191 22 k
Tx: 0.03 V Rx: 1.99 V
R534 1k
C173 47 [OTHER] 33 D
C201 0.1
R198 18 k
4
3
8 1
R199 47 k
R197 220 k
C222 0.1
4.84 V BDET
5
IC12B NJM2904V
C198 2.2
C221 0.039
C225 0.0068
78 mVp-p ( a)88.5 Hz CTCSS, –0.35 kHz)
R212 68 k
4
3 2
Q405 XP1213 5
CTCIN
5V
C216 0.1
C196 470 P
R225 100 k
1 A0 2 A1 3 A2 4 VSS
TEMPS
100 99 98 97 96 95 94 93 92 91 90 89 88 87
R181 100 k
R102 10 C194 12 P
R101 1M
1 2 3 4 5 6 7 XIN 8 XOUT RESET 9 10 CSIFT 11 12 SCK 13 SI 14 SO 15 DAST 16 CLIN CLOUT 17 18 PLST 19 NOIS 20 CIRQ BUSY 21 22 CCS 23 OPT1 24 OPT2 25 OPT3 VIN
R226 1k SCK SI SO DAST
C245 0.01
R234 22 k [OTHER] 10 k D
CLOUT
R230 180 k I 56 k [OTHER]
Q35 2SC4116 GR R203 47 k
R231 68 k I 22 k [OTHER] CTDA2
CTDA1
R229 560 k I 180 k [OTHER] Tx: 3.46 V Rx: 1.52 V R202 47 k
LVIN SD REMO BDET PTT CTCIN CPU5 CPU5 DTMF MTONE CPU5
C232 0.1
C230 0.022
840 mVp-p
R224 27 k [OTHER] 12 k D
R182
R232 1k
PLST NOIS CIRQ BUSY CCS OPT1 OPT2 OPT3
PB0/AN0 AVSS TEST X2 X1 VSS OSC1 OSC2 RES NMI P20/IRQ4/ADTRG P21/SCK1 P22/SI1 P23/SO1 P24/SCK3 P25/RXD P26/TXD P27/IRQ0 P17/IRQ3/TMIF P16/IRQ2 P15/IRQ1 P14 P13/TMIG P12/TMOFH P11/TMOFL
CTDA0
CTCSS 3 Vp-p
R227 47 k
IC8 HD64
R235 680 k R243 1M
R242 1M
CONT
R241 1M
DTCS C228 820 P R207 47 k
R517 68 k I 180 k [OTHER]
1
C227 0.1 [OTHER] 0.047 D
Q38 DTC144EE
C219 0.0082
2.8 Vp-p
3.2 Vp-p R193 100 k
L442 0.1 H
R194 100 k
R195 100 k
R196 100 k C199 0.1
R273 100 k D only R272 100 k D only
DUSE 1.2 Vp-p ( a)88.5 Hz CTCSS, –0.35 kHz), 3.7 V P-P(DTCS)
COM4 COM3 COM2 COM1
BDET
DET
6
C200 0.033
C144 0.001
IC11 S-80942ANMP-DD6
R525 1k
7 4
C249 0.01
NC
C195 39 P R146 12 k C193 8P
CLIN
720 mVp-p
C231 0.1
X2 CR-663 D14 MA77
IC7 HN58X2432TI [OTHER] HN58X2464TI O
R228 10 k
C250 0.01
2
P3
S1 JPM1990-2711R
Tx: 1.07 V Rx: 0.07 V
R532 470 k
R215 100 k
C550 22
R147 12 k
1 OUT 2 VDD 3 VSS
CD
8 VCC 7 WP 6 SCL 5 SDA
2 3
C202 0.01 C283 0.001
4
DTCS
5
R200 47 k
C675 470 P
5
C679 R213 47 P D 470
1
R211 120 k
C197 0.1
R216 100 k
IC14 TC7S66FU
T5
R103 12 k
R148 47 k CTCSS 1.08 Vp-p
Q42 DTC144EU D only
4
C662 0.1
CTCIN REMO
C566 47 P
C236 0.01
R218 100 k I 120 k [OTHER]
R5
R240 1k S1
DC
24 23 22 21 20 19 18 17 16 15 14 13
R276 10 k D only
Q36 2SC4116 GR
C248 0.01
P2
L443 BLM21P300S
VIN8 VOUT8 VOUT7 VIN7 GND RESET VDAREF DO VIN6 VOUT6 VOUT5 VIN5
VIN1 VOUT1 VOUT2 VIN2 VDD LD CLK DI VIN3 VOUT3 VOUT4 VIN4
1
KS4
C168 C169 0.001 0.001
7
1 2 3 4 5 6 7 8 9 10 11 12
2.59 V
KS3 KS2 KS1 KS0
P0
C244 C565 R154 R165 0.01 47 P 470 k 120 k [F4GS] only
R152 470 k
C156 C155 0.1 [OTHER] 10 0.01 D
C158 22
R182 NTCCM20124AG473JCT
R519 C123 0.001 1k
ESCK
C160 0.01
R153 470 k
3 2 1
S5 T5 R5
1
J3 HSJ1456-01-220A C167 47 P
R 1.4 Vp-p ( a) 1 kHz, –1.5 kHz) T 2.3 Vp-p ( a) 1 kHz, 15 mV mic input)
L33 39 H
IC10 M62363FP-650C
DEV
C159 470 P
Q20 DTA144 EU
R150 470
DBAL
C174 R134 22 2.2 k
R164 120 k [F4GT] only T1 T2 T3 T4 DAST SCK SO
MIC
CLOUT
EXT.SP
3
R133 4.7
R515 120 k
EP11 BLM11B221SB
AFOUT SP
2
12 - 1
C1 0.1
Q16 XP650
KS4
OPT EP10 BLM11B221SB
1
R145 C139 R121 1 M 0.1 1k
P10/TMOW VSS V3 V2 V1 VCC PA3/COM4 PA2/COM3 PA1/COM2 PA0/COM1 P50/WKP0/SEG1 P51/WKP1/SEG2 P52/WKP2/SEG3 P53/WKP3/SEG4
HV
J2 HSJ1122-010010 EXT.MIC
5V S5 T5 R5
R142 100
4
5
ESDA
A (VR)
C161 0.01
5
4
DET
VCC C282 0.001
R5C
C669 47 P
C162 0.01
6
BDET
VOLIN
T5C
R521 330
D26 DAN202K
VCC CPU5
FRQCOM
R139 4.7 k
R143 TP76N00N-15F-10KA-2251 VOLOUT
Q19 XP6501 AB
R261 10 k
2
VOLOUT AFOUT
CTCIN
R141 4.7 k
R520 330
R159 100 k
C136 0.0056
1
R120 68 k
R178 3.3 k
R100 C129 2.2 k 15
CTCSS
R260 10 k
Q21 2SA1577 Q
S5C
C553 47 P
S3 JPM1990-2711R
VOL/ PWR SWITCH
R135 10 k
5V VCC CPU5 T5 R5 S5
VOLIN VOLOUT AFOUT MIC SP
R144 33 K
R170 10 k
5
4.99 V
IC6 TK11250BM [OTHER] NJM2870 D
Tx: 0.00 V Rx: 4.97 V
Q22 2SA1577 Q
MIC
R168 10 k
R99 18 k
R117 1.5 k
R116
IC3D 1k NJM3403AV
6
C677 470 P
Q18 2SB1132 R
T5
MIC
14 12
C128 1 R112 1M
AFON 3.96 V
C137 0.033 I 0.027 [OTHER] 0.012 D
13
VCC CPU5
Tx: 4.84 V Rx: 0.19 V C163 0.001
R114 33 k [OTHER] 22 k H
C214 R113 0.033 68 k
R505 1k
R506 1k
L441 1.0 H
R107 C213 82 k I 150 k [OTHER] 2.2
P81/AN1 P82/AN2 P83/AN3 P84/AN4 P85/AN5 P86/AN6 P87/AN7 AVREF VTREF TONED TONEM AVCC PE3/SEG52/CL1 /S G /C
MICIN
R171 47 k
VCC CPU5 R5 S5
PTT SWITCH
C215 0.1
C164 0.001
SPEAKER
C672 47 P
R44 8.2 k [OTHER] R169 10 k H 10 k
VOLIN VOLOUT AFOUT
BEEPOUT
R125 27 k
5.01 V
MC1 KUC3523-040245
C674 47 P
VOLIN VOLOUT AFOUT
C148 0.01
TONE
IC4 BU4066BCFV
C665 47 P
R109 10 k
R516 15 k
R96 47 k
14 13 12 11 10 9 8
AFON
C133 0.1
IC3B NJM3403AV
VDD CONT.A CONT.D I/O O/I O/I I/O
NWC
SP
1 2
R108 180 k
R94 1M
5
REM
2 1
J6 BM028-ASRS-TF
R93 27 k
R176 3.9 k
VIN
W1 OPC-963
C126 0.0027
VOUT
SP1 K036NA500-47
C R137 100
C563 47 P
VOLIN VOLOUT AFOUT MIC 5V VCC CPU5 T5 R5 S5
C223 C224 0.01 0.01
C134 180 P
R105 470 [OTHER] 390 H
C124 0.01
I/O O/I O/I I/O CONT.B CONT.C VEE
26 27 28 29 30 31 32 33 34 35 36 37 38 39
C147 C154 R130 0.1 10 100 k
C217 0.1 R509 10 k
R508 1k
AFONOP
C209 0.1
D
C562 47 P
C663 0.047
C286 R257 0.0022 4.7
TONE CTCSS SIGOUT
R510 1k
PTT
7
9
Q17 UN911H
1 2 3 4 5 6 7
6 8
Tx: 2.20 V Rx: 2.21 V
Tx: 2.20 V C135 Rx: 2.20 V 180 P
C212 R98 0.01 180 k
MMUT R5C
MMUTE
10
Q15 2SB1132 R
R115 120 k
R97 220 k
R507 1k
R503 10 k
C125 0.0022
MTONE DTMF
BUSY
C132 0.0056
R131 470
C554 470 P
R95 1M
R177 1k
IC3C NJM3403AV
2.5 Vp-p ( a)1 kHz, –1.5 kHz)
RMUT
5V
Tx: 2.19 V Rx: 2.20 V
C556 47 P
4 Vp-p (a)1 kHz, 15 mV mic input)
TONE
RMUTE
VCC
VCC
Tx: 4.79 V Rx: 0.00 V
NB GND CTRL
to Optional unit
SCK OPV1 SI OPV2 SO OPV3 CIRQ GND CCS OPT3 REM OPT2 AFOUT OPT1 DISCIN SIGOUT RXMUTE MOWN BEEPOUT BUSY AFONOP AUX MICMUTE MICIN VCC MICOUT 5V PTTOUT GND PTTIN
AFOUT DISCIN VCC T5
MICOUT
16 15 17 14 18 13 19 12 20 11 21 10 22 9 23 8 24 7 25 6 26 5 27 4 28 3 29 2 30 1
AFOUT DISCIN VCC T5
AFOUT DISCIN VCC T5
AFOUT DISCIN VCC T5
S5 CPU5 R5 S5 CPU5
S5 CPU5 R5 S5 CPU5
VCC T5 S5 CPU5 W10 ERJ3GE-JPW
IC13 TA75S01F
R51 470 k
FRQCON
1 R50 390 k
3
Q15 2SB1132 R
1 2 3 4 5
Tx: 2.20 V Rx: 2.21 V AFON 3.96 V
4 2
1
2
00 C129 k 15
C150 10
R145 C139 R121 1 M 0.1 1k
C140 0.1
R123 3.3 k
Q16 XP6501 AB
GND 2
1.49 V R512 2.7 k C63 10 P
C496 0.0047
6
1
5
2
4
3
C560 47 P
R128 10
C151 C152 47 P 0.047
C145 C146 10 0.22
1 2 3 4 5 6 7 8 9 10
R529 1k
L14 15 nH C291 0.1
C62 6P
C61 6P
GND1 IN2 VCC2 XB XI XO GND2 CP2 FI2 FO2
Q34 2SK880 Y
20 19 18 17 16 15 14 13 12 11
C418 12 P B 9PE 8PJ 7P C
R184 10 k R186 C233 47 k 0.001 C54 0.001
Tx: 1.33 V Rx: 1.31 V
C571 47 P
AFON
5V
R34 1k
R33 3.9 k
C417 0.75 P A L404 0.5 P [OTHER] 1.8 H except E, J R414 330 [OTHER] 390 J, C 470 A
DS2 LNJ310M6URA
T5
Tx: 1.80 V Rx: 0.03 V
R19 100 R23 100
L406 1.8 H
C427 0.5 P
3.68 V
Q401 XP1214 Q402 5 1 DTC144EU
C32 R20 470 P 68 k
C473 47 P
Q6 2SC5107 O
L9 22 nH C 27 nH [OTHER]
3.48 V
C29 470 P B, E only C28 8 P [OTHER] 12 P E
C31 2 P [OTHER] 3PE
R421 10 k
Q5 2SC5107 O
C30 8 P [OTHER] 12 P E
DS3 LNJ310M6URA
R223 120 k
R465 33
R155 100
R274 10 k D only
SEG12 SEG11 SEG10 SEG9 SEG8 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 SEG7 UNLK CTDA2 CTDA1 CTDA0 ESDA ESCK AFON TXC T5C R5C
S5C DUSE MMUT RMUT R236 1k
NWC OPV2 OPV3 OPV1
R246 R245 100 k 100 k KS4 KS3 KS2 KS1 KS0 KR3 KR2 KR1 KR0 S1
C199 0.1
R273 100 k D only R272 100 k D only
COM4 COM3 COM2 COM1
R196 100 k
C501 10
L13 1.0 H
C65 4P
C56 0.01
Q10 2SC4116 GR
C67 3P
L25 0.82 H C53 15 P
O
IC2 TA31136FN(D) 1 2 3 4 5 6 7 8
I
C66 7P
SQLIN R88 39 k D 33 k [OTHER] 27 k H R87 1kH 2.2 k [OTHER]
C121 220 P [OTHER] 330 P H, P R86 47 k [OTHER] 39 k H
OSCIN OSCOUT MIXOUT VCC IFIN DEC FILOUT FILIN
MIXIN GND N-REC N-DET RSSI IFOUT QUAD AFOUT
X3 CDBC450CX24
16 15 14 13 12 11 10 9
R518 1k
C116 82 P [OTHER] 100 P H, P
C119 1
C114 0.001
C113 0.001
Q14 2SC4215 O
C112 0.001
DISCIN F(DET)
C111 R253 0.001 470 R80 120 k
C115 100 P
C664 0.001
R464 560 I C106 1 k [OTHER] 15 P
Tx: 0.00 V Rx: 2.98 V
R269 2.7 k D only
FI1 FL-313 L FL-321 G FL-335 M FL-336 [OTHER]
R17 4.7 k
C668 3 P HP
C109 0.001
R270 47 k D only
C555 3PA 5 P [OTHER] 6PC
C25 4 P [OTHER] 3PE
R262 1I 68 [OTHER]
C492 10 P
Q403 2SC5107 O
Q4 2SC5107 O
D4 MA77
Tx: 1.30 V Rx: 1.28 V
R72 47 k
R447 470
R68 10 k
C455 470 P
R449 470
R69 1k
R61 47 C99 0.001
C405 5 P [OTHER] 6 P E L18 R401 8 P B 8.2 nH 100 k
C90 0.001 C40 47 P
Tx: 0.05 V Rx: 4.64 V
Tx: 0.05 V Rx: 0.62 V
R 4.
C24 470 P
S5 R5 R448 47
R77 100
L20 0.82 H
C107 0.01
C450 4P R79 180 [OTHER] 390 H C110 R469 C307 2.7 k I 20 P [OTHER] 0.001 D 12 P H, P R271 C308 0.01 D 47 k D only
Q41 2SC4116 GR D only
R446 56 k
S5 R5 EP13 BLM11B221SB
R81 1k
R82 3.9 k [OTHER} 1.8 k H
C117 0.001
R83 330
C120 C118 0.1 0.001
C122 220 P [OTHER] 330 P H, P
R244 100 k
Tx: 0.00 V Rx: 4.81 V
R85 FI2 1.5 k SFPC450E [OTHER] SFPC450G I CFWC450F D
R502 1k
R70 4.7 k
Q13 3SK239A
C104 C105 0.001 47 P
C89 C91 C94 5 P [OTHER] 0.5 P 1PB 6PE C98 L19 D12 0.5 P [OTHER] D11 8 P C C406 22 P 8.2 nH HVU350B HVU350B 5PC 7PJ C92 C96 8PE 5PC 5PC 10 P B 6PJ 6PJ 8PE 8PE 10 P B 10 P B C97 5 P [OTHER] R404 L21 6PE R64 R66 220 k 22 nH C 8PB 220 k 150 k 27 nH J D401 L402 33 nH E 8.2 nH HVU350B 39 nH B
R75 180
C557 47 P
R67 10 k C95 47 P
R65 10 k C93 47 P
C559 47 P
Q12 3SK23
C87 C88 R59 47 P 0.001 150
R405 10 k C407 47 P
AFOUT
MMUT RMUT
CONT
R89 1.2 k
R136 100
R237 1k
26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
R235 680 k
C561 47 P R84 47
Tx: 3.64 V Rx: 0.19 V
C452 10 P [OTHER] 8PC
R500 100 k
T4
Tx: 0.00 V Rx: 3.50 V R90 680 k
NWC
75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
P10/TMOW VSS V3 V2 V1 VCC PA3/COM4 PA2/COM3 PA1/COM2 PA0/COM1 P50/WKP0/SEG1 P51/WKP1/SEG2 P52/WKP2/SEG3 P53/WKP3/SEG4 P54/WKP4/SEG5 P55/WKP5/SEG6 P56/WKP6/SEG7 P57/WKP7/SEG8 P60/SEG9 P61/SEG10 P62/SEG11 P63/SEG12 P64/SEG13 P65/SEG14 P66/SEG15
IC8 HD6433876B50H
P97/SEG40 P96/SEG39 P95/SEG38 P94/SEG37 P93/SEG36 P92/SEG35 P91/SEG34 P90/SEG33 P87/SEG32 P86/SEG31 P85/SEG30 P84/SEG29 P83/SEG28 P82/SEG27 P81/SEG26 P80/SEG25 P77/SEG24 P76/SEG23 P75/SEG22 P74/SEG21 P73/SEG20 P72/SEG19 P71/SEG18 P70/SEG17 P67/SEG16
R501 18 k I 47 k [OTHER]
C211 4.7
L411 27 nH B 22 nH [OTHER] R14 100
C486 5 P [OTHER] D3 7PB MA77
1LO
DET
P81/AN1 P82/AN2 P83/AN3 P84/AN4 P85/AN5 P86/AN6 P87/AN7 AVREF VTREF TONED TONEM AVCC PE3/SEG52/CL1 PE2/SEG51/CL2 PE1/SEG50/DO PE0/SEG49/M PD7/SEG48 PD6/SEG47 PD5/SEG46 PD4/SEG45 PD3/SEG44 PD2/SEG43 PD1/SEG42 PD0/SEG41 VCC PB0/AN0 AVSS TEST X2 X1 VSS OSC1 OSC2 RES NMI P20/IRQ4/ADTRG P21/SCK1 P22/SI1 P23/SO1 P24/SCK3 P25/RXD P26/TXD P27/IRQ0 P17/IRQ3/TMIF P16/IRQ2 P15/IRQ1 P14 P13/TMIG P12/TMOFH P11/TMOFL
R209 100 k
S5 R5
Q25 2SC4116 GR
C51 10 P 1 2 3 4 5 6 7 XIN 8 XOUT RESET 9 10 CSIFT 11 12 SCK 13 SI 14 SO 15 DAST 16 CLIN CLOUT 17 18 PLST 19 NOIS 20 CIRQ BUSY 21 22 CCS 23 OPT1 24 OPT2 25 OPT3 VIN
C229 0.001
R18 47 k
DEV
R204 3.3 k
R205 1.5 k
R208 100 k
6P CPU5
NOIS SD
SEG22 SEG21 SEG20 SEG19 SEG18 SEG17 SEG16 SEG15 SEG14 SEG13
LVIN SD REMO BDET PTT CTCIN CPU5 CPU5 DTMF MTONE CPU5
100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76
Light ON 1.46 V
C471 47 P
R445 220
C26 0.001 L8 22 nH J, C 27 nH E, B
C27 5P
5V
TEMPS
R15 10 k
C472 47 P
R504 330
3
Tx: 0.04 V Rx: 1.62 V
C670 470 P
3.19 V
C33 R22 470 P 68 k
2 4
C42 0.001 R511 39 k
C218 0.001
VCC R21 220
C424 C426 47 P 0.001
C422 7P
R422 220 k
C47 0.1 C48 1
5 k
Q7 2SC5085 Y
C423 6P L405 MC152-E558ANA-100050 R420 C475 470 0.5 P C 1.5 P E 4PB D404 1SV245
R32 6.8 k
C443 0.047
R5 S5
AFONOP
LVIN
C662 0.1
4.15 V
D403 HVU350B
AFOUT
CTCIN REMO
R417 3.3 k
C421 20 P [OTHER] 12 P C
C419 0.3 P
L407 4.7 H
C416 0.001
R413 18 C only C413 7P C414 9PB 8 P [OTHER] EP15 BLM11B221SB E, J only
R416 3.3 k
Tx: 2.10 V Rx: 2.09 V
C573 47 P
C678 0.001 B 470 P [OTHER]
W16 ERJ3GE-JPW except C
L11 MC152-E558ANA -100051=P3 B MC152-E558ANA -100050 [OTHER]
D5 HVU350B
Q8 2SC5085 Y
C412 6P
C411 4PJ 3PC 6PE
L12 4.7
CP1 (LV check ponit)
Tx: 2.29 V Rx: 2.25 V
C491 1
C50 10
Tx: 0.90 V Rx: 0.99 V
C55 C572 0.01 47 P
C60 0.001
+
C410 8PC 10 P [OTHER] 12 P E
IC1 UPD3140GS
R41 47
VOLOUT
VCC1 IN1 ENB CLK DATA T1 LOK CP1 FI1 FO1
R411 2.7 k
R410 3.3 k
C673 47 P
R30 2.2 k
C234 0.001
R527 1k R528 1k
C149 0.1
D26 DAN202K
OUT
R185 1k
R526 1k
PLST SCK SO UNLK
3
3
EP14 BLM11B221SB
Q11 XP6501 AB
4.99 V
R127 33
R122 2.7 k
R120 68 k
R178 3.3 k
R126 10 k
4
VCON 1
R48 100K
C72 4.7
10 9 8 7 6
DISCIN AFOUT CPU5
5
POUT PWGND PREGND PHASE NF
VCC
R49 39 k
+
DBAL
C153 100
AFOUT
6
NC VCC NC VIN RIPPLE
AFON 3.31 V
4
—
C71 0.001
IC5 TA7368F
150 mVp-p
X4 CR-662
C495 0.1
5
+
VCC AF min 7.23 V AF max 7.03 V
R473 47
T3 T2
R5 S5
C564 47 P
C567 47 P
SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 COM1 COM2 COM3 COM4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
COM4 COM3 COM2 COM1 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 COM1 COM2 COM3 COM4
DS1 LM-7045B
LCD HOLDER
EP12 BLM11B221SB
NOTE
A: L-band of ETS/CEPT version F: M1-band of [GEN] and EIA/TIA version K: M1-band of ETS/CEPT version O: 100 channel version
B: L-band C: H-band G: W-type of [GEN] H: W-type L: N-type of [GEN] and EIA/TIA version P: M (20 kHz)-type
VCC T5
R15 10 k
C471 47 P
R445 220
R13 10
Tx: 4.53 V Rx: 0.19 V
C472 47 P L411 27 nH B 22 nH [OTHER] R14 100
C26 0.001 L8 22 nH J, C 27 nH E, B
R502 1k
R446 56 k
C486 5 P [OTHER] D3 7PB MA77
R17 4.7 k
C24 470 P
C25 4 P [OTHER] 3PE
C452 10 P [OTHER] 8PC
C27 5P
L7 10 nH C 12 nH J 15 nH F R12 18 nH K 4.7 k 22 nH B C22 9PC 10 P B 12 P [OTHER]
Tx: 3.64 V Rx: 0.19 V
C659 0.001
C492 10 P
W5 MJ-0.1 W12 ERJ3GE-JPW
L31 6 nH B 4.1 nH C 4.9 nH [OTHER]
D4 MA77
Tx: 1.30 V Rx: 1.28 V
C18 470 P
R522 10 R457 100
Q1 W11 2SK2974 ERJ3GE-JPW
C251 0.001
D1 1SV307
R2 15 k
D32 RB706-F40
D33 RB706-F40
R162 1k
R161 1k
C10 0.001
C9 0.001
C666 4 P [OTHER] 5PJ
C252 0.001
S5
R69 1k
C405 5 P [OTHER] 6 P E L18 R401 8 P B 8.2 nH 100 k
R402 47 k
C73 0.1
Tx: 0.05 V Rx: 0.58 V
4
Q12 3SK239A
C87 C88 R59 47 P 0.001 150
R405 10 k C407 47 P
C: H-band EN] H: W-type EN] and EIA/TIA version ype
R252 4.7 k
L17 8.2 nH
D2 MA77 C86 3.5 P C 4PJ 5PE 7PB
R62 220 k
C85 5PC 6PJ 7PE 10 P B
R63 10 k
Tx: 1.77 V Rx: 4.35 V R53 10 k
2
1
D10 HVU350B
Tx: 0.05 V Rx: 1.16 V
R524 NTCCM16084LH 223KC
C574 0.001
R52 150 k
C79 L22 L15 1.5 P [OTHER] 12 nH A 2PB 14 nH [OTHER] 14 nH
C100 8P
T1
T3 T2
C559 47 P
W15 ERJ2GE-JPW R210 2.2 k
R258 33 k
C403 C404 47 P 0.001 C89 C91 5 P [OTHER] 0.5 P 6PE THER] D11 8 P C C406 HVU350B 5PC 7PJ C92 8PE 5PC 10 P B 6PJ 8PE 10 P B R404 R64 220 k 220 k D401 L402 8.2 nH HVU350B
Tx: 1.66 V Rx: 0.01 V
Tx: 0.00 V Rx: 1.45 V
D8 MA77 C78 3 P [OTHER] 4PE 6PB C84 47 P
C52 8 P J, C 10 P[OTHER]
R530 100
3 R54 150 k
11
D29 MA8030 H C76 6 P [OTHER] 7PE 8PB
C179 0.01
R55 1k
IC3A NJM3403AV
R251 330 k
C75 0.1
C243 R163 0.001 10 k
C558 47 P T4
R61 47 C99 0.001 C90 0.001
R65 10 k C93 47 P
C3 7 P [OTHER] 8PB
Q37 DTA144EU
S5 R5 R68 10 k
L1 10.5 nH J, C 14 nH E 21 nH B
R1 82 k
C467 7 P [OTHER] 8PE 9PB
R458 C13 1k 0.001
C17 0.001
C205 0.001
R3 15 k
C11 6P C285 24 P
C12 0.001
1LO
L24 LQW1608A R22G00 L2 10.5 nH J, C 14 nH E C8 21 nH B 0.001
ANT C551 0.001
C15 39 P [OTHER] 56 P J, C
Q2 2SK2973 R7 100
C204 47 P
C288 0.001 L4 10.5 nH J, C 14 nH E 19 nH B
+
R9 10 k
07 O
C289 47 P [OTHER] 470 P B
C14 0.01 except A
Q3 2SC3585 R44
Q403 2SC5107 O
C21 4.7
C19 0.001
C552 0.001
R160 100
Tx: 1.81 V Rx: 0.20 V
L26 3225 H
TXC
C670 470 P
D: W/N-type E: M1 (440-470 MHz)-band I: N-type J: M2 (470-500 MHz)-band M: N-type of ETS/CEPT version N: M1-band except W/N-type
R523 3.9 k
VOLTAGE DIAGRAM
S5 CPU5 R5 S5 CPU5
S5 CPU5 R5 S5 CPU5
S5 CPU5 R5 S5 CPU5
CLIN
D27 RB706F-40
CLONE 4.89 V
Q31 DTC144TU
UP
KR0 KR1 KR2 KR3
1
J3 HSJ1456-01-220A
4 C167 47 P
S2 JPM1990-2711R
DN
2
5
3
6
R239 1k
8
9
0
#
R219 100 k I 120 k [OTHER]
IC15 3 TC7S66FU D only
R238 1k
R275 4.7 k D only
R533 100 k
IC12A NJM2904V
R190 22 k
R192 22k R191 22 k
Tx: 0.03 V Rx: 1.99 V
R534 1k
C173 47 [OTHER] 33 D
C201 0.1
R198 18 k
3
BDET
12 - 1
R529 1k
DISCIN AFOUT CPU5
AFOUT
L14 15 nH C291 0.1
C62 6P
C61 6P
GND1 IN2 VCC2 XB XI XO GND2 CP2 FI2 FO2
Q34 2SK880 Y
20 19 18 17 16 15 14 13 12 11
5 4
3
1
R199 47 k
R197 220 k
720 mVp-p
C418 12 P B 9PE 8PJ 7P C
R186 C233 47 k 0.001 C54 0.001
Tx: 1.33 V Rx: 1.31 V
C221 0.039
C250 0.01
5
R225 100 k
840 mVp-p
C198 2.2 C225 0.0068
78 mVp-p ( a)88.5 Hz CTCSS, –0.35 kHz)
R212 68 k
4
IC12B NJM2904V
3 2
Q405 XP1213 5
1 A0 2 A1 3 A2 4 VSS
AFON
5V
R33 3.9 k
C216 0.1
R102 10 C194 12 P
R234 22 k [OTHER] 10 k D
R231 68 k I 22 k [OTHER] CTDA2
CTDA1
R229 560 k I 180 k [OTHER]
Q35 2SC4116 GR
R232 1k
PLST NOIS CIRQ BUSY CCS OPT1 OPT2 OPT3
PB0/AN0 AVSS TEST X2 X1 VSS OSC1 OSC2 RES NMI P20/IRQ4/ADTRG P21/SCK1 P22/SI1 P23/SO1 P24/SCK3 P25/RXD P26/TXD P27/IRQ0 P17/IRQ3/TMIF P16/IRQ2 P15/IRQ1 P14 P13/TMIG P12/TMOFH P11/TMOFL
CTDA0
Tx: 3.46 V Rx: 1.52 V
R235 680 k
R203 47 k
R202 47 k
R227 47 k
C228 820 P
C227 0.1 [OTHER] 0.047 D
C219 0.0082
SEG22 SEG21 SEG20 SEG19 SEG18 SEG17 SEG16 SEG15 SEG14 SEG13
LVIN SD REMO BDET PTT CTCIN CPU5 CPU5 DTMF MTONE CPU5
1 2 3 4 5 6 7 XIN 8 XOUT RESET 9 10 CSIFT 11 12 SCK 13 SI 14 SO 15 DAST 16 CLIN CLOUT 17 18 PLST 19 NOIS 20 CIRQ BUSY 21 22 CCS 23 OPT1 24 OPT2 25 OPT3 VIN
CLOUT
CTCSS 3 Vp-p
R243 1M
R242 1M
Light ON 1.46 V
DS3 LNJ310M6URA
R223 120 k
R207 47 k
R517 68 k I 180 k [OTHER]
1
Q38 DTC144EE
IC8 HD6433876B50H
R205 1.5 k
P97/SEG40 P96/SEG39 P95/SEG38 P94/SEG37 P93/SEG36 P92/SEG35 P91/SEG34 P90/SEG33 P87/SEG32 P86/SEG31 P85/SEG30 P84/SEG29 P83/SEG28 P82/SEG27 P81/SEG26 P80/SEG25 P77/SEG24 P76/SEG23 P75/SEG22 P74/SEG21 P73/SEG20 P72/SEG19 P71/SEG18 P70/SEG17 P67/SEG16
L442 0.1 H
Tx: 0.00 V Rx: 3.50 V R90 680 k
R155 100
R274 10 k D only
SEG12 SEG11 SEG10 SEG9 SEG8 SEG6 SEG5 SEG4 SEG3 SEG2 SEG1 SEG7 UNLK CTDA2 CTDA1 CTDA0 ESDA ESCK
75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
AFON TXC T5C R5C
5
3.68 V
Q401 XP1214 Q402 1 DTC144EU
C33 R22 470 P 68 k
2
R421 10 k C473 47 P
3.48 V
C29 470 P B, E only
C28 8 P [OTHER] 12 P E
C31 2 P [OTHER] 3PE
C42 0.001 Tx: 0.04 V Rx: 1.62 V
C32 R20 470 P 68 k
L9 22 nH C 27 nH [OTHER]
R504 330
3
4
Q6 2SC5107 O
R237 1k
R196 100 k C199 0.1
R273 100 k D only R272 100 k D only
DUSE 1.2 Vp-p ( a)88.5 Hz CTCSS, –0.35 kHz), 3.7 V P-P(DTCS)
R13 10
Tx: 4.53 V Rx: 0.19 V
R160 100
L411 27 nH B 22 nH [OTHER] R14 100
Q5 2SC5107 O
C30 8 P [OTHER] 12 P E
R18 47 k
C26 0.001 L8 22 nH J, C 27 nH E, B C486 5 P [OTHER] D3 7PB MA77
R17 4.7 k
C24 470 P
C25 4 P [OTHER] 3PE
C452 10 P [OTHER] 8PC
C27 5P R465 33
R502 1k
R446 56 k
L7 10 nH C 12 nH J 15 nH F R12 18 nH K 4.7 k 22 nH B C22 9PC 10 P B 12 P [OTHER]
Tx: 3.64 V Rx: 0.19 V
C659 0.001
+
R9 10 k
Q4 2SC5107 O
C289 47 P [OTHER] 470 P B
C14 0.01 except A
W5 MJ-0.1 W12 ERJ3GE-JPW
R209 100 k
R501 18 k I 47 k [OTHER]
C211 4.7
R500 100 k
D4 MA77
C561 47 P R89 1.2 k
C501 10
L13 1.0 H
C65 4P
C56 0.01
Q10 2SC4116 GR
R84 47
C67 3P
L25 0.82 H C53 15 P
O
IC2 TA31136FN(D) 1 2 3 4 5 6 7 8
I
C66 7P
SQLIN R88 39 k D 33 k [OTHER] 27 k H R87 1kH 2.2 k [OTHER]
C121 220 P [OTHER] 330 P H, P R86 47 k [OTHER] 39 k H
OSCIN OSCOUT MIXOUT VCC IFIN DEC FILOUT FILIN
MIXIN GND N-REC N-DET RSSI IFOUT QUAD AFOUT
X3 CDBC450CX24
C117 0.001 16 15 14 13 12 11 10 9
R518 1k
C116 82 P [OTHER] 100 P H, P
R269 2.7 k D only
R83 330
C119 1
C114 0.001
C113 0.001
C115 100 P
Q14 2SC4215 O
C112 0.001
DISCIN F(DET)
C111 R253 0.001 470 R80 120 k
R464 560 I C106 1 k [OTHER] 15 P
FI1 FL-313 L FL-321 G FL-335 M FL-336 [OTHER] C668 3 P HP
C109 0.001
R270 47 k D only
R77 100
L20 0.82 H
C107 0.01
C450 4P R79 180 [OTHER] 390 H C110 R469 C307 2.7 k I 20 P [OTHER] 0.001 D 12 P H, P R271 C308 0.01 D 47 k D only
Q41 2SC4116 GR D only
R448 47
EP13 BLM11B221SB
Tx: 0.00 V Rx: 2.98 V
Tx: 0.05 V Rx: 0.62 V R262 1I 68 [OTHER]
C18 470 P
C551 0.001
R3 15 k
C11 6P C285 24 P
R457 100
C555 3PA 5 P [OTHER] 6PC
Q1 W11 2SK2974 ERJ3GE-JPW
C251 0.001
D1 1SV307
R2 15 k
D32 RB706-F40
D33 RB706-F40
R162 1k
R161 1k
C10 0.001
C9 0.001
C666 4 P [OTHER] 5PJ
C252 0.001
R449 470
R70 4.7 k
Q13 3SK239A
C104 C105 0.001 47 P
R61 47 C99 0.001
C405 5 P [OTHER] 6 P E L18 R401 8 P B 8.2 nH 100 k
C557 47 P
R67 10 k C95 47 P
R65 10 k C93 47 P
C559 47 P
Tx: 1.66 V Rx: 0.01 V
Tx: 0.00 V Rx: 1.45 V
Q37 DTA144EU
W15 ERJ2GE-JPW R210 2.2 k
C90 0.001
C89 C91 C94 5 P [OTHER] 0.5 P 1PB 6PE C98 L19 D12 0.5 P [OTHER] D11 8 P C C406 22 P 8.2 nH HVU350B HVU350B 5PC 7PJ C92 C96 8PE 5PC 5PC 10 P B 6PJ 6PJ 8PE 8PE 10 P B 10 P B C97 5 P [OTHER] R404 L21 6PE R64 R66 220 k 22 nH C 8PB 220 k 150 k 27 nH J D401 L402 33 nH E 8.2 nH HVU350B 39 nH B
R75 180
C3 7 P [OTHER] 8PB
S5
R69 1k
R258 33 k
C403 C404 47 P 0.001
Tx: 0.05 V Rx: 4.64 V R72 47 k
R447 470
R68 10 k
C455 470 P
R236 1k
C564 47 P
C567 47 P
SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 COM1 COM2 COM3 COM4
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
COM4 COM3 COM2 COM1 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 COM1 COM2 COM3 COM4
DS1 LM-7045B
LCD HOLDER
R402 47 k
C73 0.1
Tx: 0.05 V Rx: 0.58 V
4
Q12 3SK239A
R405 10 k C407 47 P
R252 4.7 k
L17 8.2 nH
D2 MA77 C86 3.5 P C 4PJ 5PE 7PB
R62 220 k
C85 5PC 6PJ 7PE 10 P B
R63 10 k
Tx: 1.77 V Rx: 4.35 V R53 10 k
2
1
D10 HVU350B
Tx: 0.05 V Rx: 1.16 V C87 C88 R59 47 P 0.001 150
R52 150 k
C79 L22 L15 1.5 P [OTHER] 12 nH A 2PB 14 nH [OTHER] 14 nH
C100 8P
R524 NTCCM16084LH 223KC
C574 0.001
D8 MA77 C78 3 P [OTHER] 4PE 6PB C84 47 P
C52 8 P J, C 10 P[OTHER]
R530 100
3 R54 150 k
11
D29 MA8030 H C76 6 P [OTHER] 7PE 8PB
C179 0.01
R55 1k
IC3A NJM3403AV
R251 330 k
C75 0.1
C243 R163 0.001 10 k
C558 47 P
EP12 BLM11B221SB
NOTE
A: L-band of ETS/CEPT version F: M1-band of [GEN] and EIA/TIA version K: M1-band of ETS/CEPT version O: 100 channel version
L1 10.5 nH J, C 14 nH E 21 nH B
R1 82 k
C467 7 P [OTHER] 8PE 9PB
R458 C13 1k 0.001
C17 0.001
C205 0.001
S5 R5
S5 R5
R81 1k
R82 3.9 k [OTHER} 1.8 k H
C664 0.001 C120 C118 0.1 0.001
C122 220 P [OTHER] 330 P H, P
R244 100 k
Tx: 0.00 V Rx: 4.81 V
R85 FI2 1.5 k SFPC450E [OTHER] SFPC450G I CFWC450F D
Tx: 1.30 V Rx: 1.28 V
L24 LQW1608A R22G00 L2 10.5 nH J, C 14 nH E C8 21 nH B 0.001
ANT
R522 10
R7 100
C204 47 P
C288 0.001 L4 10.5 nH J, C 14 nH E 19 nH B
L31 6 nH B 4.1 nH C 4.9 nH [OTHER]
C15 39 P [OTHER] 56 P J, C
Q2 2SK2973
Q3 2SC3585 R44
Q403 2SC5107 O
C21 4.7
C19 0.001
C552 0.001
C492 10 P
Tx: 1.81 V Rx: 0.20 V
L26 3225 H
AFOUT S5C DUSE MMUT RMUT
R246 R245 100 k 100 k
C471 47 P
R445 220
3.19 V
1LO
R136 100
NWC OPV2 OPV3 OPV1 R195 100 k
C229 0.001
S5 R5
Q25 2SC4116 GR
MMUT RMUT
CONT
R241 1M
R194 100 k
C427 0.5 P
R15 10 k
C472 47 P
DEV
R204 3.3 k
3.2 Vp-p R193 100 k
L406 1.8 H
R511 39 k
R208 100 k
6P CPU5
DTCS 2.8 Vp-p
R23 100
C670 470 P
C12 0.001
C51 10 P
R226 1k
T5
R19 100
C422 7P
R422 220 k
VCC
T5
Tx: 1.80 V Rx: 0.03 V
L405 MC152-E558ANA-100050 R420 470
C218 0.001
VCC R21 220
C424 C426 47 P 0.001
5V
TEMPS
SCK SI SO DAST
C245 0.01
R230 180 k I 56 k [OTHER]
R224 27 k [OTHER] 12 k D
C232 0.1
C417 0.75 P A L404 0.5 P [OTHER] 1.8 H except E, J R414 330 [OTHER] 390 J, C 470 A
C475 0.5 P C 1.5 P E 4PB D404 1SV245
R32 6.8 k
R34 1k
Q7 2SC5085 Y
C423 6P
D403 HVU350B
DS2 LNJ310M6URA
C662 0.1
R181 100 k
R101 1M
L407 4.7 H
C571 47 P
R417 3.3 k
C421 20 P [OTHER] 12 P C
C419 0.3 P
4.15 V
R413 18 C only C413 7P C414 9PB 8 P [OTHER] EP15 BLM11B221SB E, J only
R416 3.3 k
Tx: 2.10 V Rx: 2.09 V
C48 1
C230 0.022
R525 1k
6
C200 0.033
C196 470 P
C195 39 P R146 12 k C193 8P
CLIN
7
C222 0.1
D14 MA77
C144 0.001
IC11 S-80942ANMP-DD6
CTCIN
5V
DET
NC
R182
D5 HVU350B
R184 10 k
C55 C572 0.01 47 P
C60 0.001
CP1 (LV check ponit)
C416 0.001
W16 ERJ3GE-JPW except C
L11 MC152-E558ANA -100051=P3 B MC152-E558ANA -100050 [OTHER]
L12 4.7
Tx: 0.90 V Rx: 0.99 V
IC1 UPD3140GS
R41 47
VOLOUT
VCC1 IN1 ENB CLK DATA T1 LOK CP1 FI1 FO1
C443 0.047
COM4 COM3 COM2 COM1
BDET
Tx: 1.07 V Rx: 0.07 V
2 4
C249 0.01
CD
DTCS
R532 470 k
P3
S1 JPM1990-2711R 4.84 V
C151 C152 47 P 0.047
1 2 3 4 5 6 7 8 9 10
Q8 2SC5085 Y
C412 6P
C411 4PJ 3PC 6PE
C410 8PC 10 P [OTHER] 12 P E
C234 0.001
Tx: 2.29 V Rx: 2.25 V
C491 1
C50 10
LVIN
X2 CR-663
IC7 HN58X2432TI [OTHER] HN58X2464TI O
R228 10 k
C231 0.1
C550 22
R147 12 k
1 OUT 2 VDD 3 VSS
8 VCC 7 WP 6 SCL 5 SDA
2 8
C202 0.01 C283 0.001
4
C679 R213 47 P D 470
1
R211 120 k
C197 0.1
R215 100 k
R216 100 k
IC14 TC7S66FU
T5
R200 47 k
C675 470 P
R148 47 k
5
Q42 DTC144EU D only
4 2
R221 390 k
R5
R240 1k S1
DC
5
R103 12 k
CTCSS 1.08 Vp-p
R276 10 k D only R218 100 k I 120 k [OTHER]
Q36 2SC4116 GR
C248 0.01
P2
L443 BLM21P300S
C311 0.1 D
2.59 V
C168 C169 0.001 0.001
7
C560 47 P
R48 100K
C673 47 P
R30 2.2 k
C47 0.1
CTCIN REMO
C566 47 P
C236 0.01
1
KS4 KS3 KS2 KS1 KS0
P0
P1
R512 2.7 k C63 10 P
C496 0.0047
R182 NTCCM20124AG473JCT
R519 C123 0.001 1k
24 23 22 21 20 19 18 17 16 15 14 13
3
C573 47 P
C678 0.001 B 470 P [OTHER]
TXC
R220 330 k
VIN8 VOUT8 VOUT7 VIN7 GND RESET VDAREF DO VIN6 VOUT6 VOUT5 VIN5
VIN1 VOUT1 VOUT2 VIN2 VDD LD CLK DI VIN3 VOUT3 VOUT4 VIN4
2
4
+ 1.49 V
R527 1k R528 1k
R5 S5
S5 T5 R5
1 2 3 4 5 6 7 8 9 10 11 12
5
R411 2.7 k
R410 3.3 k
T4
R140 100 k
C244 C565 R154 R165 0.01 47 P 470 k 120 k [F4GS] only
R152 470 k
C156 C155 0.1 [OTHER] 10 0.01 D
C158 22
R150 470
R153 470 k
DTMF 2.2 Vp-p BEEP 2.5 Vp-p R174 15 k
C165 0.001
R164 120 k [F4GT] only T1 T2 T3 T4 DAST SCK SO
MIC
CLOUT
EXT.SP
5
3 2 1
R515 120 k
EP11 BLM11B221SB
AFOUT SP
Q20 DTA144 EU
C160 0.01
4
1
AFOUT
L33 39 H
IC10 M62363FP-650C
6
T1
EP10 BLM11B221SB
R132 470
GND 2
NOIS SD
OPT
C159 470 P
OUT
EP14 BLM11B221SB
Q11 XP6501 AB
R185 1k
R526 1k
PLST SCK SO
R128 10
C145 C146 10 0.22
KS4 KS3 KS2 KS1 KS0 KR3 KR2 KR1 KR0 S1
HV
J2 HSJ1122-010010 EXT.MIC
5V S5 T5 R5
R142 100
C174 R134 22 2.2 k
3
R123 3.3 k
P10/TMOW VSS V3 V2 V1 VCC PA3/COM4 PA2/COM3 PA1/COM2 PA0/COM1 P50/WKP0/SEG1 P51/WKP1/SEG2 P52/WKP2/SEG3 P53/WKP3/SEG4 P54/WKP4/SEG5 P55/WKP5/SEG6 P56/WKP6/SEG7 P57/WKP7/SEG8 P60/SEG9 P61/SEG10 P62/SEG11 P63/SEG12 P64/SEG13 P65/SEG14 P66/SEG15
VCC A (VR)
C161 0.01
2
C140 0.1
Q16 XP6501 AB
R 1.4 Vp-p ( a) 1 kHz, –1.5 kHz) T 2.3 Vp-p ( a) 1 kHz, 15 mV mic input)
ESCK
C669 47 P
C162 0.01
1
4 2
C149 0.1 C150 10
R145 C139 R121 1 M 0.1 1k
3
R49 39 k
C72 4.7
UNLK
3
VCON 1
4.99 V
R127 33
D26 DAN202K
VOLOUT AFOUT
DEV
R139 4.7 k
2
VCC
—
+
10 9 8 7 6
R122 2.7 k 1
R159 100 k
C136 0.0056
VCC CPU5
DET
VOLIN
4
BDET
R521 330
5
R133 4.7
T5C
VOLOUT
Q19 XP6501 AB
R261 10 k 6
R143 TP76N00N-15F-10KA-2251
C282 0.001
Q21 2SA1577 Q
R141 4.7 k
R520 330
R170 10 k
R116
R178 3.3 k
R126 10 k
4
R120 68 k
R100 C129 2.2 k 15
ESDA
R260 10 k
S5C
C553 47 P
S3 JPM1990-2711R
VOL/ PWR SWITCH
R135 10 k
5V VCC CPU5 T5 R5 S5
VOLIN VOLOUT AFOUT MIC SP
R144 33 K
PTT SWITCH
IC6 TK11250BM [OTHER] NJM2870 D
Tx: 0.00 V Rx: 4.97 V
Q22 2SA1577 Q
MIC
R168 10 k
R117 1.5 k
IC3D 1k NJM3403AV
VCC CPU5
R5C
C163 0.001
C128 1 R112 1M
R99 18 k
5
DBAL
C153 100
4
4.99 V
T5
MIC
14
6
POUT PWGND PREGND PHASE NF
AFON 3.31 V
C677 470 P
VCC CPU5 R5 S5 Tx: 4.84 V Rx: 0.19 V
C137 0.033 I 0.027 [OTHER] 0.012 D
13
100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76
MICIN
R171 47 k
Q18 2SB1132 R
5.01 V
MC1 KUC3523-040245
C215 0.1
C164 0.001
SPEAKER
C672 47 P
R114 33 k [OTHER] 22 k H
C214 R113 0.033 68 k
R505 1k
R506 1k
L441 1.0 H
R107 C213 82 k I 150 k [OTHER] 2.2
12
DBAL
SP
1 2
IC4 BU4066BCFV
R44 8.2 k [OTHER] R169 10 k H 10 k
VOLIN VOLOUT AFOUT
BEEPOUT
R125 27 k
14 13 12 11 10 9 8
FRQCOM
J6 BM028-ASRS-TF
VDD CONT.A CONT.D I/O O/I O/I I/O
VOLIN VOLOUT AFOUT
C148 0.01
TONE
I/O O/I O/I I/O CONT.B CONT.C VEE
CTCIN
2 1
R516 15 k
R96 47 k C674 47 P
VIN
W1 OPC-963
R109 10 k
R104 100 k
VOLIN VOLOUT AFOUT MIC
IC3B NJM3403AV
C665 47 P
VOUT
SP1 K036NA500-47
R108 180 k
C133 0.1
C563 47 P
5V VCC CPU5 T5 R5 S5
C223 C224 0.01 0.01
C R137 100
R93 27 k
R176 3.9 k
R94 1M
R508 1k
P81/AN1 P82/AN2 P83/AN3 P84/AN4 P85/AN5 P86/AN6 P87/AN7 AVREF VTREF TONED TONEM AVCC PE3/SEG52/CL1 PE2/SEG51/CL2 PE1/SEG50/DO PE0/SEG49/M PD7/SEG48 PD6/SEG47 PD5/SEG46 PD4/SEG45 PD3/SEG44 PD2/SEG43 PD1/SEG42 PD0/SEG41 VCC
C147 C154 R130 0.1 10 100 k
C562 47 P
R105 470 [OTHER] 390 H
C286 R257 0.0022 4.7
5
AFON 3.96 V
NC VCC NC VIN RIPPLE
26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
C209 0.1
D
C134 180 P
C126 0.0027
CTCSS
PTT
C663 0.047
C124 0.01
1 2 3 4 5
Tx: 2.20 V Rx: 2.21 V
Tx: 2.20 V C135 Rx: 2.20 V 180 P
AFONOP
R510 1k
7 C217 0.1 R509 10 k
NWC
MMUTE
8
REM
BUSY
1 2 3 4 5 6 7
6
10 9
Q17 UN911H
C212 R98 0.01 180 k
IC5 TA7368F
AF min 7.23 V AF max 7.03 V
Q15 2SB1132 R
R115 120 k
R97 220 k
R507 1k
R503 10 k
C125 0.0022
TONE CTCSS SIGOUT
C554 470 P
2.5 Vp-p ( a)1 kHz, –1.5 kHz)
R95 1M
R177 1k
IC3C NJM3403AV
C132 0.0056
R131 470
Tx: 2.19 V Rx: 2.20 V
C556 47 P
4 Vp-p (a)1 kHz, 15 mV mic input)
5V
3
150 mVp-p
X4 CR-662
C495 0.1
5
+
VCC
VCC
MMUT R5C
RMUTE
R50 390 k
RMUT
Tx: 4.79 V Rx: 0.00 V
1
C71 0.001
Tx: 2.19 V Rx: 2.20 V
VCC
IC13 TA75S01F
R51 470 k
FRQCON
R473 47
T3 T2
S5
W10 ERJ3GE-JPW
T4
S5 CPU5
S5 CPU5 R5 S5
NWC
R5
VCC T5
DET
R5
NB GND CTRL
to Optional unit
SCK OPV1 SI OPV2 SO OPV3 CIRQ GND CCS OPT3 REM OPT2 AFOUT OPT1 DISCIN SIGOUT RXMUTE MOWN BEEPOUT BUSY AFONOP AUX MICMUTE MICIN VCC MICOUT 5V PTTOUT GND PTTIN
AFOUT DISCIN VCC T5
MICOUT
16 15 17 14 18 13 19 12 20 11 21 10 22 9 23 8 24 7 25 6 26 5 27 4 28 3 29 2 30 1
AFOUT DISCIN VCC T5
MTONE DTMF
J5 AXN330C038
AFOUT DISCIN VCC T5
TONE
SECTION 12
B: L-band C: H-band G: W-type of [GEN] H: W-type L: N-type of [GEN] and EIA/TIA version P: M (20 kHz)-type
D: W/N-type E: M1 (440-470 MHz)-band I: N-type J: M2 (470-500 MHz)-band M: N-type of ETS/CEPT version N: M1-band except W/N-type
R523 3.9 k
INTRODUCTION This service manual describes the latest service information for the IC-F4GT and IC-F4GS at the time of publication. To upgrade quality, all electrical or mechanical parts and internal circuits are subject to change without notice or obligation.
DANGER NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than 16 V. Such a connection could cause a fire hazard and/or electric shock. DO NOT expose the transceiver to rain, snow or any liquids. DO NOT reverse the polarities of the power supply when connecting the transceiver. DO NOT apply an RF signal of more than 20 dBm (100mW) to the antenna connector. This could damage the transceiver’s front end.
ORDERING PARTS Be sure to include the following four points when ordering replacement parts: 1. 2. 3. 4.
10-digit order numbers Component part number and name Equipment model name and unit name Quantity required
IC-F4GT
1130007610 S.IC µPD3140GS IC-F4GT 8810009510 Screw BT M2 x 4 NI-ZU IC-F4GS
IC-F4GS
MAIN UNIT 1 pieces Chassis 10 pieces
Addresses are provided on the inside back cover for your convenience.
REPAIR NOTES 1. 2. 3. 4. 5. 6. 7.
Make sure a problem is internal before disassembling the transceiver. DO NOT open the transceiver until the transceiver is disconnected from its power source. DO NOT force any of the variable components. Turn them slowly and smoothly. DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments. DO NOT keep power ON for a long time when the transceiver is defective. DO NOT transmit power into a signal generator or a sweep generator. ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when using such test equipment. 8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.
SERVICE MANUAL
UHF FM TRANSCEIVERS
1-1-32, Kamiminami, Hirano-ku, Osaka, 547-0003, Japan
S-13713IZ-C1U-1 © 2000 Icom Inc.
