XA-300 SERVICE MANUAL Ver 1.1 2002.08
SPECIFICATIONS Power requirement
12 V DC car battery (negative earth) Current drain 340 mA Operating temperature –10°C to +55°C (14° F to 131° F) Dimensions Approx. 148 × 34 × 101 mm (5 7/8 × 1 3/8 × 4 in.) (w/h/d) Mass Approx. 470 g (1 lb 16 oz.) Supplied accessories BUS cable RCA pin cord Velcro tape
US Model Canadian Model AEP Model UK Model E Model
FEATURES The XA-300 is an external selector for connecting a Sony BUS system-compatible CD/MD device or a non-compatible portable device (such as a DVD player, MD Walkman, or laptop computer) to a Sony BUS system-compatible master unit. Enjoy the sound of portable media in your car. WALKMAN is trademark of Sony Corporation.
Design and specifications are subject to change without notice.
AUX-IN SELECTOR 9-873-500-12
Sony Corporation
2002H0500-1 C 2002.08
e Vehicle Company Published by Sony Engineering Corporation
XA-300
TABLE OF CONTENTS
SECTION 1 SERVICING NOTES
1.
SERVICING NOTES ................................................ 2
2.
GENERAL ................................................................... 3
Connection to repair
3.
DIAGRAMS
This set is controled by master unit with serial communication.
3-1. Note for Printed Wiring Board and Schematic Diagram ......................................................... 3-2. Printed Wiring Board ...................................................... 3-3. Schematic Diagram ......................................................... 3-4. IC Pin Function Description ...........................................
3 4 5 6
4.
EXPLODED VIEW ................................................... 7
5.
ELECTRICAL PARTS LIST ............................... 8
SET
BUS CONTROL OUTPUT terminal
MASTER UNIT
BUS CONTROL INPUT terminal
Therefore, to operate this set, connect master unit as shown below. Connecting via USB This set can be connected via its USB connector to a parsonal computer with USB port. • Compatible operating systems – Windows® 98 Second Edition/ Windows® Me/Windows® 2000 (Windows® 2000 recommended) – Mac OS 8.6 or later (Mac OS 9.0 or later recommended)
Notes on chip component replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat.
2
XA-300 SECTION 2 GENERAL
Equipment used in illustrations (not supplied)/Equipements utilisés dans les illustrations (non fournis)/Apparecchiature utilizzate nelle illustrazioni (non in dotazione)/In den Abbildungen gezeigte Komponenten (nicht mitgeliefert)/Geïllustreerde apparatuur (niet meegeleverd)/Equipmento utilizado nas ilustrações (não fornecido)/Εξοπλισµς που χρησιµοποιείται στις εικνες (δεν παρέχεται)/Utrustning som används i illustrationerna (medföljer inte)/Equipo utilizado en las ilustraciones (no suministrado)
2 3
3
Master unit Appareil principal Unità principale Hauptgerät Master unit Unidade principal Κύρια συσκευή Huvudenhet Unidad principal
MD Walkman, etc. Walkman MD, etc. MD Walkman, e così via. MD-Walkman usw. MD Walkman, enz. Walkman de MD, etc. MD Walkman, κλπ. MD Walkman eller liknande Walkman de MD, etc.
CD/MD changer Changeur CD/MD Cambia CD/MD CD/MD-Wechsler CD/MD-wisselaar Carregador de CD/MD CD/MD changer CD/MD-växlare Cambiador de CD/MD
Laptop computer Ordinateur portable Computer portatile Laptop-Computer Laptop computer Computador laptop Φορητς υπολογιστής Bärbar dator Ordenador portátil
DVD player, etc. Lecteur DVD, etc. Lettore DVD, e così via. DVD-Player usw. DVD-speler, enz. Leitor de DVD, etc. DVD player, κλπ. DVD-spelare eller liknande Reproductor de DVD, etc.
Headphones Casque Cuffie Kopfhörer Hoofdtelefoon Auscultadores Ακουστικά Hörlurar Auriculares
3 ∗1
1 2
L AUDIO R
CONTROL
L AUDIO
3-1.
NOTE FOR PRINTED WIRING BOARD AND SCHEMATIC DIAGRAM
Note on Printed Wiring Board: • X : parts extracted from the component side. f • : internal component. : Pattern from the side which enables seeing. • (The other layers' patterns are not indicated.) Caution: Pattern face side: (Conductor Side) Parts face side: (Component Side)
Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
CONTROL
R
∗2
INPUT
OUTPUT
SECTION 3 DIAGRAMS
This section is extracted from instruction manual.
∗3 VOL
AUX IN 1 MIN
MAX
VOL HEADPHONE MIN MAX
USB
AUX IN 2 L AUDIO R
L AUDIO R
∗5
∗4
Place the unit under the passenger seat, etc. (2)
To select a device connected to the unit by the master unit
Before installation • Choose the installation location carefully so that the unit does not interfere with normal driving operations. • Avoid installing the unit where it would be subject to: — high temperatures, such as from direct sunlight or hot air from the heater. — draft, rain or moisture. — dust or dirt. — magnetic fields. • Use only the supplied mounting hardware for a safe and secure installation.
1 Press (SOURCE) repeatedly until “CD” is selected. 2 Press (MODE) repeatedly until the device you want to listen to is selected.
If you have any questions or problems concerning your unit that are not covered in this manual, please consult your nearest Sony dealer.
3 Start playing the device selected in 2.
Stick one piece of the Velcro tape provided to the bottom of the unit and the other to the surface of the car where you want to place it (such as the carpet underneath the passenger seat) in order to hold the unit in position. After removing the dust and dirt from the surface of Velcro tapes, stick them together.
Connection example (3) ∗1 You can connect the source selector (XAC30, etc.) compatible with the Sony BUS system. For details, refer to the user's manual for the source selector you are using. ∗2 Supplied with the CD/MD changer ∗3 Volume control for headphones connected to AUX IN 1. ∗4 Stereo mini-plug ∗5 USB connector • Computer with USB port • Compatible operating systems – Windows ® 98 Second Edition/ Windows ® Me/Windows ® 2000 (Windows ® 2000 recommended) – Mac OS 8.6 or later (Mac OS 9.0 or later recommended) Note
Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. f • : internal component. • C : panel designation. • A : B+ Line. • H : adjustment for repair. • Power voltage is dc 14.4V and fed with regulated dc power supply to master unit. • Voltages and waveforms are dc with respect to ground under the condition that master unit is connected. no mark : CD - C ( ) : AUX 1 [ ] : AUX 2 〈〈 〉〉 : USB • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. • Circled numbers refer to waveforms. • Signal path. F : AUDIO E : USB IN j : USB OUT
Example: Master unit display window B CD1 CD4/USB b
B CD2/AUX1 CD3/AUX2 b
Tip When you select a Sony BUS systemcompatible device, it will automatically start playing. For the playback method of the selected device, refer to its operating manual.
4 Adjust the volume of the master unit and selected device. Notes
• Waveforms
• Follow the steps below to play the audio file of the computer connected to the USB jack of this unit. 1 Press the MODE button of the master unit to select “USB.” 2 Open the playback software (Windows Media Player, etc.) on your computer. 3 Play the audio file (MP3,etc.). After playing the audio file on the computer, if you select “USB“ mode on the display of the master unit, this unit may not recognize the signal and sound may not come out. • As the volume settings of each connected device may differ, adjust the volume on each device separately. As the sound output differs on AUX IN 1 and AUX IN 2, connect the Sony car audio DVD changer to AUX IN 1, and connect a portable device (such as MD WALKMAN, etc.) to AUX IN 2. • While playing audio file in a device connected to AUX IN 1, AUX IN 2, or the USB jack on this unit, do not change any settings of the CD CUSTOM FILE function. If trouble occurs, press the SOURCE button again on the master unit to select the device you want.
1 IC1 es (XTAL)
2 IC3 wk (XTO)
3.6 Vp-p 3.9 Vp-p
99.5 ns
Depending on the device to be connected, you might need to buy a different connector cord. For further details, read the operating manual of the device to be connected or ask your local dealer.
3
3
83 ns
XA-300
Ver 1.1
3-2.
PRINTED WIRING BOARD 1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
CN101
23
CN102
INPUT CONTROL
A
R
OUTPUT CONTROL
CN108
CN104 INPUT AUDIO
L
OUTPUT AUDIO
R
L
MAIN BOARD MAIN BOARD (COMPONENT SIDE)
(CONDUCTOR SIDE)
B
R401 ZD401
ZD402
ZD406
R402 R407
3
1
R405
R101
ZD601
ZD602
5 R404
R410
R403
C106
Q104
Q901
3
D104
1
2
Q903
C112 Q804
R143
24
ZD101
R204 Q201 R301
IC8
Q904 Q803
IC2
C109
C110
Q203 R203
Q902
D103
Q103
Q202
ZD408
R409
C115
C108
ZD104 R102
4
ZD410
Q102
C104
6 5 R408 ZD409
7
R904
C107
R201
1
ZD403
ZD404
ZD103
2
8
4
Q101
R202
E
ZD407 3 R406
Q402 ZD405
C105 ZD102
D
R903
7 6
C
2
8
C101
ZD901
ZD902
C103
X101
C102
R302
D101
Q801
D102
R103 L902 Q802
Q301
41
1
1
F
L901
IC
Q303 C303 Q302
RY102
RY101
R303 ZD301
C114
RY103
C515
C507
C514
R501 X102
H
R503
R507
R612
C513
C608
R710
C707 C716
C715
C604
R706
C719
C718
C717 R717 C713
C702 R705
C730 (AEP, UK)
ZD701
ZD702
ZD603
RV101 VOL
ZD703
(11)
• Semiconductor Location Ref. No.
Location
D101 D102 D103 D104
E-18 E-20 D-15 D-13
IC1 IC2 IC3 IC4 IC5 IC6 IC7 IC8
F-15 D-16 H-13 G-14 H-17 G-19 H-22 D-15
Q101
D-13
Ref. No. Q102 Q103 Q104 Q201 Q202 Q203 Q301 Q302 Q303 Q402 Q801 Q802 Q803 Q804 Q901
Location D-14 D-13 D-15 E-13 D-13 D-13 F-13 F-13 F-13 C-16 E-17 E-17 D-17 E-19 D-19
Ref. No. Q902 Q903 Q904
Location D-20 D-21 D-21
ZD101 ZD102 ZD103 ZD104 ZD301 ZD401 ZD402 ZD403 ZD404 ZD405 ZD406
E-14 D-13 D-13 D-13 F-13 B-14 B-14 C-14 C-14 C-14 B-22
Ref. No. ZD407 ZD408 ZD409 ZD410 ZD601 ZD602 ZD603 ZD604 ZD701 ZD702 ZD703 ZD901 ZD902
Location B-22 C-22 C-22 C-22 B-17 C-16 I-17 I-16 I-19 I-18 I-20 C-20 C-19
4
4
CN106 AUX IN 2 AUDIO
L
R
CN105 AUX IN 1 AUDIO
L
11 1-682-009-
J R
R712
R718
R701
R605
C602
C710 R711
R715
R707
C705 R601
ZD604
CN103 USB
C721 C709
R702
R708
R504
1-682-009-
C711
R709
R719
C607
R608
11
IC7
C704
C606
C609
C603
R704
C706
R609
R606
R607
C504
I
R714 C701
C722
R610
R508 R509
C503 R502
R703
R722 R721
R604
C720 C610
R505
IC5
C517
FB501 C501
R611
R613
R506 C512
IC6
R720
R603
R513 C518
IC3
R514
C605
R614
R511 R510
C502
C601
C611
R512
IC4
C714
C509
C708
R716
C511
C703
R602
C506
C712
C516 64
C505
G
C113
C111 C510
C301
R713
C302
CN107 HEADPHONE
i
(11)
3-3.
SCHEMATIC DIAGRAM • See page 3 for Waveforms.
XA-300
Ver 1.1
• See page 6 for IC Block Diagram.
R401 10
SIRCS
R406 10
SIRCS
R407 10
RST
RST
R402 10
+B
+B L101 450µH R403 10
NC CLK
BUS_ON R405 10
ZD405 UDZ-TE-17-6.2B
R410 10 ZD406 UDZ-TE-17-6.2B
Q101 2SD1664-T100-QR D104 MA111-TX
BUS ON SWITCH R204 47k
R203 47k
C104 100 16V
ZD102 UDZ-TE-17-6.2B C106 47 16V
C105 0.1
Q203 DTC114EK -T146
C115 0.22
IC2 BA8272F-E2
Q103,104
C112 0.1
POWER ON SWITCH
NCO
NCO
NCO
NCO
VDD
NCO
NCO
NC
NCO
BUS SO
NCO
NCO
NCO
NCO
NCO
R143 47k
0.1
IC4 NJM2100E (TE2)
NCO
AUDIO SEL1
NCO
NCO
NCO
AUDIO SEL2
NCO
NCO
NCO
AUDIO SEL3 C110 0.1
NCO
NCO
NCO
NCO
NCO
NCO
NCO
NCO
NCO
RESET SIGNAL GENERATOR
GND
C510
C509 0.1
NCO
NCO
R509 100
R510 12k
C513 10 16V
NCO
R505
C109 0.1
C107 0.047F 5.5V
BUFFER
NCO
IC1 CXP83412-054Q
NCO
V
C108 47 16V
SYSTEM CONTROLLER
ATT
RST
C512 330p
C516 10 16V
NCO
NCO
VLC2
C507 0.1
G
VCC VBUS
NCO
BUS SI
VLC3
R504
NCO
BUS CLK
VL
D-
IC8 XC61AN4302MR
R507 3.9k
C517 1800p
USB R503
NCO
NCO
XTAL
R506 12k
C506 10 16V
PCM2702
C504 10 16V
R508 12k
R514 1k
IC3
R501 1M
D+
NCO
POWER ON
LINK OFF
C502 18p
USB D/A CONVERTER
FB501
NCO
NCO
NCO
X102 12MHz
C505 0.1
C501 18p
R502 1.5k
NCO
USB ON
Q201-203 BACK UP CHECK
C503 0.1
NCO
GND
USB ON SWITCH
NCO
NIL
EXTAL
Q303 DTC114EK-T146
ZD301 UDZ-TE-17-3.9B
MODE SW
NCO
C303 220 6.3V
C113 0.1
NCO
C302 0.1
C102 47 16V
Q104 DTC114EK-T146
C103 0.1
ZD101 UDZ-TE-17-5.6B
R101 10k
C111 0.1
SUB CLOCK
R102 4.7k
C114 0.1 BUS INTERFACE (FOR SONY BUS)
SUB CLOCK
Q103 DTA124EK -T146
C301 47 16V
ZD103 UDZ-TE-17-18B
R301 4.7k
R302 470
NCO
+5V REGULATOR R303 470
R202 1k
ZD104 UDZ-TE-17-7.5B
R201 1k
Q202 DTC144EK-T146
Q102 2SD1664-T100-QR
GND
Q402 DTA144EK
U-COM 5V REGULATOR
RESET
B+ SWITCH
CONTROL
ZD410 UDZ-TE-17-6.2B
NIL
Q301 2SB1132-T101-QR
C101 1000 16V
ZD409 UDZ-TE-17-6.2B
NCO
+3V REGULATOR
ZD408 UDZ-TE-17-6.2B
D103 MA111-TX
Q201 2SC2412K-T-146R
Q302 2SD1664-T100-QR
ZD407 UDZ-TE-17-6.2B
BUS ON
ZD404 UDZ-TE-17-6.2B
BU CHECK
ZD403 UDZ-TE-17-6.2B
NCO
ZD402 UDZ-TE-17-6.2B
GND
GND
OUTPUT
BUS_ON
ZD401 UDZ-TE-17-6.2B
CN103 4P
CN102 8P
DATA
NCO
CONTROL
NC CLK
R409 10
NCO
INPUT
R408 10
R404 10
DATA
VLC1
CN101 8P
R103 1k
C518 1800p
ZD601 UDZ-TE-17-3.9B
CN104 2P
R612 10k
C511 0.1
C514 330p R511 3.9k
R512 12k
C515 10 16V
R513 100
R611 10k
Q801 DTA144EK -T146
L C611 220 6.3V
INPUT AUDIO
Q802 DTC114EK -T146
R ZD602 UDZ-TE-17-3.9B
C607 47 16V
L102 220µH
R604 100 IC5 NJM2100E(TE2)
C601 470p
BUFFER
C605 10 16V
R613 10k
Q901 DTC114EK-T146
USB
R603 6.8k R614 10k
R601 1k
RY101
Q902 DTA114EK-T146 Q803 DTA144EK-T146
CD-C VCC
Q804 DTC114EK-T146
C609 1 R605 4.7k
AUX IN 2 R ZD604 UDZ-TE-17-3.9B
C604 470p
GND
C602 470p
R606 4.7k
C603 470p R607 1k
R608 4.7k
C606 10 16V
R609 6.8k C610 1
C608 47 16V
AUX1
R610 100
L
R719 10k
D101 MA111-TX
R720 10k
R703 1.8k
Q903 DTC314TK -T-146
L902 10µH
CN108 2P
C708 10 16V
AUX1/USB
L Q904 DTC314TK -T-146
BUFFER
R704 100
R903 10k
R714 470
IC7 LA4536M-TE-R
R710 100
CN106 2P
C707 1
R711 4.7k
RV101 (1/2)
L R705 4.7k
AUX IN 1
R706 4.7k
ZD702 UDZ-TE-17-3.9B
R707 1k
C702 470p
ZD902 UDZ-TE-17-3.9B
C713 0.1
R712 4.7k
CN107 R717 0
HEADPHONE
R715 2.2
GND R708 4.7k
R
R904 10k
C715 220 6.3V
VCC C719 1
R702 4.7k
AUDIO
AUX2/CD-C
R721 10k
C701 470p
OUTPUT R
RY102
C703 10 16V
C704 1
IC6 NJM2100E(TE2)
C717 47 16V
R701 1k
ZD901 UDZ-TE-17-3.9B
AUX2/CD-C
R713 100
ZD701 UDZ-TE-17-3.9B
DRIVE
RY103
AUX1/USB
AUX2
R722 10k
MUTING L901 10µH
RELAY DRIVE
D102 MA111-TX
AUX1
C722 220 6.3V
Q901-904 Q803,804
AUX2
USB
CN105 2P
R602 4.7k
CD-C
ZD603 UDZ-TE-17-3.9B
X101 10MHz
Q801,802 RELAY DRIVE
C705 470p
RV101 (2/2)
C720 1 C706 470p
R709 1.8k
C718 47 16V
C721 47 16V
C714 0.1
VOL C709 220p
C710 220p
HEADPHONE AMP
C711 220 6.3V
R716 2.2
C716 220 6.3V
R718 0
C712 47 16V
C730 0.001 ZD703 UDZ-TE-17-3.9B
5
5
(AEP,UK)
(CHASSIS)
XA-300
• IC Block Diagrams
BUS ON
LINK OFF
CLK OUT
DATA OUT
DATA IN
RESET
14
13
12
11
10
9
8
LA4536M-TE-R
POWER 1 SWITCH
POWER SWITCH
1
2
3
4
5
6
7
BUS ON OUT
BUS ON IN
GND
BUS CLK
VREF
BUS DATA
BUS RESET
1
MODE_SW
I
CD, AUX display change “H”: CD (fixed at “L” in this set)
I
Not used (fixed at “L”)
O
USB power supply switch (Turn on the power when USB in selected by PAS)
9 OUT1
4
NCO
O
Not used (open)
POWER 8 GND
5
POWER ON
O
Power on signal output terminal (Turn on the power when AUX1, AUX2 or USB is selected)
7 OUT2
6
NCO
O
Not used (open)
6 VCC
7
BUS_CLK
I
Serial data transfer clock signal input from the SONY bus interface (IC2)
8
BUS_SI
I
Serial data input from the SONY bus interface (IC2)
9
BUS_SO
O
Serial data output the SONY bus interface (IC2)
10, 11
NCO
O
Not used (open)
12
LINK_OFF
O
Bus link off control signal output terminal
13
NCO
O
Not used (open)
14
ATT
O
Audio line muting on/off control signal output terminal “H”: muting on
15
NCO
O
Not used (open)
16
AUDIO_SEL1
O
Audio signal selector control *1
17
NCO
O
Not used (open)
18
AUDIO_SEL2
O
Audio signal selector control *1
19
NCO
O
Not used (open)
20
AUDIO_SEL3
O
Not used (open)
20 to 29
NCO
O
Not used (open)
15
30
RESET
I
System reset signal input from the reset signal generator (IC8) “L”: reset
31
EXTAL
I
Main system clock input terminal (10MHz)
32
XTAL
O
Main system clock output terminal (10MHz)
33
GND
—
Ground terminal
34
VL
O
Not used (open)
35 to 37
VLC3-1
I
Not used (Ground connection)
BIAS
MUTE SWITCH
25
USB PACKET DATA
24
22
21
20
AUDIO DATA FIFO
8X OVERSAMPLING DIGITAL FILTER
SpAct TM
MULTILEVEL DELTASIGMA MODULATOR
19
18
TEST0
VCCR
AGNDR
VOUTR
AGND
VCOM
VCC
23
17
16
LOW-PASS FILTER
DAC
38 to 71
NCO
O
Not used (open)
72
VDD
—
Power supply terminal (+5V)
73
SUB CLOCK
O
Sub system clock output terminal Not used (open)
74
SUB CLOCK
I
Sub system clock input terminal Not used (open)
75
NC
—
Connected to the power supply (+5V)
76
NCO
O
Not used (open)
77
NCO
O
Not used (open)
78
BU_CHECK
I
Backup power supply detection signal input terminal “H”: active
79
BUS_ON
I
Bus on/off control signal input from the SONY bus interface (IC2)
80
NIL
I
Not used (fixed at “L”)
LOW-PASS FILTER
DAC
SYSTEM CLOCK AUDIO CLOCK GENERATOR
POWER SUPPLY
USB I/F
MCLK
*1 USB CLOCK GENERATOR
Source mode
AUX1
AUX2
USB
CD-C
AUDIO_SEL1 (pin qh)
“H”
“L”
“L”
“H”
AUDIO_SEL2 (pin qk)
“H”
“L”
“H”
“L”
Terminal
2
3
4
5
6
7
8
9
10
11
12
13 14
VDD
DGND
D+
D–
VBUS
DGNDU
PLYBCK
SSPND
ZERO
TEST3
TEST2
1
DGNDC
CRYSTAL OSC
VDDC
WRCLK
VOUTL
AGNDL
VCCL
AGNDP 26
RDCLK
27
XT1
28
VCCP
PCM2702E/2K
XTO
IC3
Description
NIL
AMP
REF 5
I/O
USB_ON
AMP
IN2 4
Pin Name
3
10
PRE 3 GND
RESET SWITCH
Pin No. 2
MUTE CIRCUIT
IN1 2
IC PIN FUNCTION DESCRIPTION
• IC1 CXP83412-053Q (SYSTEM CONTROLLER)
TEST1
IC7
BA8272F-E2
VCC
IC2
3-4.
6
6
XA-300 SECTION 4 EXPLODED VIEW NOTE: • -XX and -X mean standardized parts, so they may have some difference from the original one. • Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) ↑ ↑ Parts Color Cabinet's Color
• Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Accessories and packing materials are given in the last of the electrical parts list. • Accessories are given in the last of the electrical parts list.
#1
3 5
2 #1
#1
4 not supplied
#1
1
Ref. No. 1 2 3
Part No.
Description
3-229-695-01 CASE (LOWER) 3-229-698-01 KNOB (VOL) 3-229-694-01 CASE (UPPER)
Remark
Ref. No. 4 5 #1
Part No.
Description
Remark
1-590-519-72 CORD (WITH CONNECTOR) (BUS) 1-696-287-41 CORD, CONNECTION (RCA) 7-685-792-09 SCREW +PTT 2.6X6 (S)
7
XA-300 Ver 1.1
SECTION 5 ELECTRICAL PARTS LIST
MAIN NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable
Ref. No.
Part No.
• Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u: µ, for example: uA. . : µA. . uPA. . : µPA. . uPB. . : µPB. . uPC. . : µPC. . uPD. . : µPD. . • CAPACITORS uF: µF • COILS uH: µH
Description
Remark
MAIN BOARD *********** 7-685-535-19 SCREW +BTP
2.6X10 TYPE2 N-S
< CAPACITOR >
8
C101 C102 C103 C104 C105
1-126-767-11 1-124-589-11 1-107-826-11 1-126-382-11 1-107-826-11
ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP
1000uF 47uF 0.1uF 100uF 0.1uF
20% 20% 10% 20% 10%
16V 16V 16V 16V 16V
C106 C107 C108 C109 C110
1-124-589-11 1-110-654-11 1-124-589-11 1-107-826-11 1-107-826-11
ELECT ELECT (BLOCK) ELECT CERAMIC CHIP CERAMIC CHIP
47uF 0.047F 47uF 0.1uF 0.1uF
20% 20% 10% 10%
16V 5.5V 16V 16V 16V
C111 C112 C113 C114 C115
1-107-826-11 1-107-826-11 1-107-826-11 1-107-826-11 1-115-467-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 0.1uF 0.22uF
10% 10% 10% 10% 10%
16V 16V 16V 16V 10V
C301 C302 C303 C501 C502
1-124-589-11 1-107-826-11 1-124-635-00 1-162-918-11 1-162-918-11
ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
47uF 0.1uF 220uF 18PF 18PF
20% 10% 20% 5% 5%
16V 16V 6.3V 50V 50V
C503 C504 C505 C506 C507
1-107-826-11 1-124-233-11 1-107-826-11 1-124-233-11 1-107-826-11
CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP
0.1uF 10uF 0.1uF 10uF 0.1uF
10% 20% 10% 20% 10%
16V 16V 16V 16V 16V
C509 C510 C511 C512 C513
1-107-826-11 1-107-826-11 1-107-826-11 1-162-961-11 1-124-233-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
0.1uF 0.1uF 0.1uF 330PF 10uF
10% 10% 10% 10% 20%
16V 16V 16V 50V 16V
C514 C515 C516 C517 C518
1-162-961-11 1-124-233-11 1-124-233-11 1-162-977-11 1-162-977-11
CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP
330PF 10uF 10uF 0.0018uF 0.0018uF
10% 20% 20% 10% 10%
50V 16V 16V 50V 50V
C601 C602 C603
1-162-962-11 CERAMIC CHIP 1-162-962-11 CERAMIC CHIP 1-162-962-11 CERAMIC CHIP
470PF 470PF 470PF
10% 10% 10%
50V 50V 50V
Ref. No.
Part No.
Description
Remark
C604 C605
1-162-962-11 CERAMIC CHIP 1-124-233-11 ELECT
470PF 10uF
10% 20%
50V 16V
C606 C607 C608 C609 C610
1-124-233-11 1-124-589-11 1-124-589-11 1-125-837-11 1-125-837-11
ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP
10uF 47uF 47uF 1uF 1uF
20% 20% 20% 10% 10%
16V 16V 16V 6.3V 6.3V
C611 C701 C702 C703 C704
1-124-635-00 1-162-962-11 1-162-962-11 1-124-233-11 1-125-837-11
ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
220uF 470PF 470PF 10uF 1uF
20% 10% 10% 20% 10%
6.3V 50V 50V 16V 6.3V
C705 C706 C707 C708 C709
1-162-962-11 1-162-962-11 1-125-837-11 1-124-233-11 1-162-960-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
470PF 470PF 1uF 10uF 220PF
10% 10% 10% 20% 10%
50V 50V 6.3V 16V 50V
C710 C711 C712 C713 C714
1-162-960-11 1-124-635-00 1-124-589-11 1-107-826-11 1-107-826-11
CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP
220PF 220uF 47uF 0.1uF 0.1uF
10% 20% 20% 10% 10%
50V 6.3V 16V 16V 16V
C715 C716 C717 C718 C719
1-124-635-00 1-124-635-00 1-124-589-11 1-124-589-11 1-125-837-11
ELECT ELECT ELECT ELECT CERAMIC CHIP
220uF 220uF 47uF 47uF 1uF
20% 20% 20% 20% 10%
6.3V 6.3V 16V 16V 6.3V
C720 C721 C722 C730
1-125-837-11 1-124-589-11 1-124-635-00 1-162-964-11
CERAMIC CHIP ELECT ELECT CERAMIC CHIP
1uF 47uF 220uF 0.001uF
10% 20% 20% 10%
6.3V 16V 6.3V 50V (AEP, UK)
< CONNECTOR > CN101 CN102 CN103 CN104 CN105
1-580-907-31 1-580-907-31 1-815-194-11 1-778-940-11 1-764-593-21
CN106 CN107
1-764-593-21 JACK 2P (AUX IN 1) 1-764-270-21 JACK, STEREO MINIATURE (DIA.3.5) (i HEADPHONE) 1-778-940-11 JACK 2P (OUTPUT AUDIO)
CN108
PLUG, CONNECTOR (INPUT CONTROL) PLUG, CONNECTOR (OUTPUT CONTROL) CONNECTOR, USB (B) (USB) JACK 2P (INPUT AUDIO) JACK 2P (AUX IN 2)
XA-300
Ver 1.1
MAIN Ref. No.
Part No.
Description
Remark
< DIODE > D101 D102 D103 D104
8-719-404-50 8-719-404-50 8-719-404-50 8-719-404-50
DIODE DIODE DIODE DIODE
MA111-TX MA111-TX MA111-TX MA111-TX
< FERRITE BEAD > FB501
1-414-813-11 FERRITE, EMI (SMD)
Ref. No.
Part No.
Description
R303 R401 R402 R403 R404
1-216-817-11 1-216-797-11 1-216-797-11 1-216-797-11 1-216-797-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 10 10 10 10
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
Remark
R405 R406 R407 R408 R409
1-216-797-11 1-216-797-11 1-216-797-11 1-216-797-11 1-216-797-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10 10 10 10 10
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R410 R501 R502 R503 R504
1-216-797-11 1-216-857-11 1-216-823-11 1-414-813-11 1-414-813-11
METAL CHIP 10 METAL CHIP 1M METAL CHIP 1.5K FERRITE, EMI (SMD) FERRITE, EMI (SMD)
5% 5% 5%
1/10W 1/10W 1/10W
R505 R506 R507 R508 R509
1-414-813-11 1-216-834-11 1-216-828-11 1-216-834-11 1-216-809-11
FERRITE, EMI (SMD) METAL CHIP 12K METAL CHIP 3.9K METAL CHIP 12K METAL CHIP 100
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R510 R511 R512 R513 R514
1-216-834-11 1-216-828-11 1-216-834-11 1-216-809-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
12K 3.9K 12K 100 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R601 R602 R603 R604 R605
1-216-821-11 1-216-829-11 1-218-867-11 1-216-809-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 4.7K 6.8K 100 4.7K
5% 5% 0.5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R606 R607 R608 R609 R610
1-216-829-11 1-216-821-11 1-216-829-11 1-218-867-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 1K 4.7K 6.8K 100
5% 5% 5% 0.5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R611 R612 R613 R614 R701
1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R702 R703 R704 R705 R706
1-216-829-11 1-216-824-11 1-216-809-11 1-216-829-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 1.8K 100 4.7K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R707 R708 R709 R710 R711
1-216-821-11 1-216-829-11 1-216-824-11 1-216-809-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 4.7K 1.8K 100 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R712 R713 R714 R715 R716
1-216-829-11 1-216-809-11 1-216-817-11 1-216-789-11 1-216-789-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 100 470 2.2 2.2
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R717 R718 R719
1-216-864-11 SHORT 1-216-864-11 SHORT 1-216-833-11 METAL CHIP
0 0 10K
5%
1/10W
< IC > IC1 IC2 IC3 IC4 IC5
8-752-926-54 8-759-444-86 8-759-713-24 8-759-344-00 8-759-344-00
IC IC IC IC IC
CXP83412-054Q BA8272F-E2 PCM2702E/2K NJM2100E (TE2) NJM2100E (TE2)
IC6 IC7 IC8
8-759-344-00 IC NJM2100E (TE2) 8-759-052-53 IC LA4536M 8-759-682-69 IC XC61AN4302MR < COIL >
L101 L102 L901 L902
1-421-961-11 1-410-525-11 1-412-006-31 1-412-006-31
COIL, CHOKE 450uH INDUCTOR, MICRO 220uH CHIP, INDUCTOR 10uH CHIP, INDUCTOR 10uH < TRANSISTOR >
Q101 Q102 Q103 Q104 Q201
8-729-920-85 8-729-920-85 8-729-901-05 8-729-027-43 8-729-901-81
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SD1664-T100-QR 2SD1664-T100-QR DTA124EK-T146 DTC114EK-T146 2SC2412K-T-146-R
Q202 Q203 Q301 Q302 Q303
1-801-806-11 8-729-027-43 8-729-106-60 8-729-920-85 8-729-027-43
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC144EK-T146 DTC114EK-T146 2SB1132-T101-QR 2SD1664-T100-QR DTC114EK-T146
Q402 Q801 Q802 Q803 Q804
8-729-027-38 8-729-027-38 8-729-027-43 8-729-027-38 8-729-027-43
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTA144EK-T146 DTA144EK-T146 DTC114EK-T146 DTA144EK-T146 DTC114EK-T146
Q901 Q902 Q903 Q904
8-729-027-43 8-729-901-04 8-729-920-21 8-729-920-21
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC114EK-T146 DTA114EK-T146 DTC314TK-T-146 DTC314TK-T-146
< RESISTOR/FRRITE BEAD > R101 R102 R103 R143 R201
1-216-833-11 1-216-829-11 1-216-821-11 1-216-841-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 4.7K 1K 47K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R202 R203 R204 R301 R302
1-216-821-11 1-216-841-11 1-216-841-11 1-216-829-11 1-216-817-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 47K 47K 4.7K 470
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
9
XA-300 MAIN Ref. No.
Part No.
Description
Remark
R720 R721
1-216-833-11 METAL CHIP 1-216-833-11 METAL CHIP
10K 10K
5% 5%
1/10W 1/10W
R722 R903 R904
1-216-833-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-833-11 METAL CHIP
10K 10K 10K
5% 5% 5%
1/16W 1/16W 1/16W
< VARIABLE RESISTOR > RV101
Ref. No.
Part No.
Description
Remark
ACCESSORIES ************ 3-232-755-12 MANUAL, INSTRUCTION (ENGLISH, FRENCH, ITALIAN, GERMAN, DUTCH, PORTUGUESE, RUSSIAN, SWEDISH, SPANISH, TRADITIONAL CHINESE) ************************************************************
1-227-432-11 RES, VAR (VOL)
PARTS FOR INSTALLATION AND CONNECTION *************************************
< RELAY > RY101 RY102 RY103
1-515-762-11 RELAY 1-515-762-11 RELAY 1-515-762-11 RELAY
501 502 503 504
1-590-519-72 1-696-287-41 3-232-468-01 3-233-471-01
CORD (WITH CONNECTOR) (BUS) CORD, CONNECTION (RCA) TAPE, MAGIC TAPE(B), MAGIC
< VIBRATOR > X101 X102
1-795-004-21 VIBRATOR, CERAMIC (10MHz) 1-567-865-11 VIBRATOR, CRYSTAL (12MHz)
501
502 503
< DIODE > ZD101 ZD102 ZD103 ZD104 ZD301
8-719-069-55 8-719-069-56 8-719-056-93 8-719-056-84 8-719-056-77
DIODE UDZSTE-175.6B DIODE UDZSTE-176.2B DIODE UDZ-TE-17-18B DIODE UDZSTE-177.5B DIODE UDZ-TE-17-3.9B
ZD401 ZD402 ZD403 ZD404 ZD405
8-719-069-56 8-719-069-56 8-719-069-56 8-719-069-56 8-719-069-56
DIODE UDZSTE-176.2B DIODE UDZSTE-176.2B DIODE UDZSTE-176.2B DIODE UDZSTE-176.2B DIODE UDZSTE-176.2B
ZD406 ZD407 ZD408 ZD409 ZD410
8-719-069-56 8-719-069-56 8-719-069-56 8-719-069-56 8-719-069-56
DIODE UDZSTE-176.2B DIODE UDZSTE-176.2B DIODE UDZSTE-176.2B DIODE UDZSTE-176.2B DIODE UDZSTE-176.2B
ZD601 ZD602 ZD603 ZD604 ZD701
8-719-056-77 8-719-056-77 8-719-056-77 8-719-056-77 8-719-056-77
DIODE UDZ-TE-17-3.9B DIODE UDZ-TE-17-3.9B DIODE UDZ-TE-17-3.9B DIODE UDZ-TE-17-3.9B DIODE UDZ-TE-17-3.9B
ZD702 8-719-056-77 DIODE UDZ-TE-17-3.9B ZD703 8-719-056-77 DIODE UDZ-TE-17-3.9B ZD901 8-719-056-77 DIODE UDZ-TE-17-3.9B ZD902 8-719-056-77 DIODE UDZ-TE-17-3.9B ************************************************************
10
504 BUS CABLE × 1
RCA PIN CORD × 1
MAGIC TAPE × 2
XA-300
MEMO
11
XA-300
REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.0 1.1
Date 2001.03 2002.08
Description of Revision New Correction of Printed wiring board and Schematic diagram
(ECN-CSA05650)
