PROJECT : L.G. HOSPITAL BY AMC , AHMEDABAD PRINCIPAL CONSULTANT : BHAVESH SHAH AND PRITI SHAH MGPS CONSULTANT : SHETH TECHNO CONSULTANTS PVT. LTD. VOLUME I - MEDICAL GAS PIPELINE SYSTEM BILL OF QUANTITY ESTIMATE SR. NO.

DESCRIPTION

UNIT

QTY

UNIT RATES IN RS.

Total Rs.

NOS. A Note : 1)The below mentioned prices are all inclusive of Design / Supply / Installation / Leak Testing / Comissioning of the Medical Gas Pipe Line System as per tender specification. And the scope coveres the Defact Liability Period of 36 Months , during this period all the routine and break down maintanance shall be carried out by the contractor at his own cost. The prices are inclusive of all taxes / duties / freight / site handling / lifting / shifting etc. 2) For L1 Consideration the weitage on Volume I shall be given 75% and on Volume II 25%.

1.0

SITC of OXYGEN SYSTEM AS PER TENDER SPECIFICATION

1.1

20 + 20 Bulk cylindcer Manifold for Oxygen complete with middle fram , bottom frame , NRV and Tail piece, The cylinder manifold should be as per ISO7396-1:2007certification and EN 737 / NFPA 99 C standard.

SET

1

350000

350000

1.2

1 x 4 Cylinder Emergency Oxygen System Supply through regulator having Non Halogenated polymer in high pressure side , The cylinder manifold should be as per ISO7396-1:2007certification and EN 737 / NFPA 99 C standard.

SET

1

85000

85000

1.3

Fully Automatic Control Panel for Oxygen with automatic change over facility as Per ISO-7396-1/2007 certification and EN 737 / NFPA 99 C standard. , Suitable for 2 Banks of Ox Cylinder and provision for connection to liq oxigen tank supply.

SET

1

450000

450000

2.0

SITC of NITROUS OXIDE SYSTEM

2.1

2 + 2 Bulk cyliner Manifold for Nitrous Oxide complete with middle fram, bottom frame , NRVs, Tail pipes. The cylinder manifold should be as per ISO7396-1:2007certification and EN 737 / NFPA 99 C standard.

SET

1

95000

95000

2.2

Nitrus Cylinder with regulator and trolly for ready to use in case of emergency. ( One for Ground Floor and 2nd for tenth floor )

SET

2

30000

60000

2.3

Fully Automatic Control Panel for N2O with Automatic Change over facility. The control panel should be as per ISO7396-1:2007certification and EN 737 / NFPA 99 C standard.

SET

1

430000

430000

3.0

SITC of VACCUM SYSTEM

3.1

SITC of Triplex Vaccum Pump System complete with High Efficiency Electric motor and starter , silencer , NRV , shut off ball valve , and all other required acessories as specified in the technical specifications. The system should be as per ISO7396-1:2007 certification and EN 737 / NFPA 99 C standard. 2 Working + 1 Stand By ( 100 % Stand by system ) Capacity :: 2500 LPM at 0.1 mbar ( 7.5 HP Apx. ) The system should be supplied with 3000 Ltr Common receiver tank.

SET

1

3500000

3500000

4.0

MEDICAL AIR AT 4 BAR

4.1

SITC Duplex Air Cooled screw compressor system complete with Air Drier , inlet filter , High Efficiency Electrical Motor ( 30 HP - Apx. Rating ) and Motor starter , pully, pressure reducing station for Both 4 Bar and 7 Bar and common 3000 ltrs air Receiver etc. 1 Working + 1 Stand By ( 100 % Stand by system ) Capacity :: 2500 LPM at 8 Bar Pressure

SET

1

7500000

7500000

4.2

3-stage breathing air Filtration System

SET

2

120000

240000

5.0

SITC of Double Locking Outlet Points as per ISO 9170-1/2008 certification and EN 737 / NFPA 99 C standard having CE mark

5.1

Oxygen Outlet Point

Set

168

5500

924000

MGPS TENDER DOCUMENT

BILL OF QUANTITY - VOL I

PROJECT : L.G. HOSPITAL BY AMC , AHMEDABAD PRINCIPAL CONSULTANT : BHAVESH SHAH AND PRITI SHAH MGPS CONSULTANT : SHETH TECHNO CONSULTANTS PVT. LTD. VOLUME I - MEDICAL GAS PIPELINE SYSTEM BILL OF QUANTITY ESTIMATE SR. NO.

DESCRIPTION

UNIT

QTY

UNIT RATES IN RS.

Total Rs.

5.2

Nitrous Outlet Point

Set

14

5500

77000

5.3

C-Air-4 bar Outlet Point

Set

46

5500

253000

5.4

C-Air-7 bar Outlet Point

Set

5

12500

62500

5.5

Vaccum outlet Point

Set

168

5500

924000

6.0

SITC of Distribution Copper Pipe - Lloyd Certified

6.1

76 mm OD - 1.5 mm Thickness

Rmt

123

4050

498150

6.2

54 mm OD - 1.2 mm Thickness

Rmt

5

2050

10250

6.3

42 mm OD - 1.2 mm Thickness

Rmt

369

1700

627300

6.4

35 mm OD - 1.2 mm Thickness

Rmt

820

1550

1271000

6.5

28 mm OD - 0.9 mm Thickness

Rmt

2322

855

1985310

6.6

22 mm OD - 0.9 mm Thickness

Rmt

1428.3

647

924110.1

6.7

15 mm OD - 0.9 mm Thickness

Rmt

2451

500

1225500

6.8

12 mm OD- 0.7 mm Thickness

Rmt

60

330

19800

7.0

SITC of Isolation Valve fully compliant to ISO7396-1:2007 certification and EN 737 / NFPA 99 C standard.

7.1

15 mm

SET

12

2800

33600

7.2

22 mm

SET

4

3200

12800

7.3

28 mm

SET

4

5000

20000

7.4

35 mm

SET

2

7400

14800

7.5

42 mm

SET

2

10000

20000

7.6

76 mm

SET

2

14000

28000

8.0

Area Valve Box with Valves, Pressure gauges & Nist connect fully compliant to ISO7396-1:2007 certification and EN 737 / NFPA 99 C

8.1

5 Gas Line Valve Box

SET

15

55000

825000

8.2

4 Gas Line Valve Box

SET

11

45000

495000

8.3

3 Gas Line Valve Box

SET

1

40000

40000

8.4

2 Gas Line Valve Box

SET

37

27500

1017500

9.0

BPC Flowmeter with Humidifier ( Oxygen Line )

SET

168

1600

268800

10.0

Ward Vaccum Unit with 600 ml Collection Jar

SET

168

4500

756000

11.0

Theatre Suction Unit

SET

14

8150

114100

12.0

Conversion Kit for O2

SET

13

4500

58500

13.0

Conversion Kit for N20

SET

13

4500

58500

14.0

HP AIS Tubing

MGPS TENDER DOCUMENT

BILL OF QUANTITY - VOL I

PROJECT : L.G. HOSPITAL BY AMC , AHMEDABAD PRINCIPAL CONSULTANT : BHAVESH SHAH AND PRITI SHAH MGPS CONSULTANT : SHETH TECHNO CONSULTANTS PVT. LTD. VOLUME I - MEDICAL GAS PIPELINE SYSTEM BILL OF QUANTITY ESTIMATE SR. NO.

DESCRIPTION

UNIT

QTY

UNIT RATES IN RS.

Total Rs.

14.1

White for oxygen

Mtrs

3

625

1875

14.2

Blue for N2O

Mtrs

3

625

1875

14.3

Black for Air

Mtrs

3

625

1875

14.4

Yellow for Vaccum

Mtrs

3

625

1875

15.0

High Quality Refined Rubber L P Tubing ( Vaccum Jar Connection )

Mtr

1050

200

210000

16.0

Area Alarm Panel at OT and ICU Floor having in built isolation valves comply to ISO 7396 - 1 : 2007 certification and EN 737 / NFPA 99 C standard.

16.1.1 5-gas

SET

2

175000

350000

16.2.2 3-gas

SET

4

130000

520000

16.2

Master Alarm Management System - 5 gas line - comply to ISO 7396 - 1 : 2007 certification and EN 737 / NFPA 99 C standard.

SET

1

1050000

1050000

17.1

SITC of Common Electrical Panel and cabling from electrical panel to compressed Air & Vaccum System complete with required foundation

SET

1

280000

280000

17.2

Supply, laying, connection, testing and commissioning of heavy duty medium voltage cables as per Specification and IS 7098 PART I XLPE insulated and outer sheeth of FRLS and inner PVC sheeth stranded AL conductor unless or otherwise specified. The copper cables shall be confirming to IS:1554, PVC insulated and sheathed, stranded copper conductors. The cable shall be laid underground when laid outside the building. It shall be laid in prepared trench / cable tray / wall clamped / duct when laid inside the building. The cable shall be laid with RCC Hume pipe at the entry of the building. The unit rate shall include

350

26250

90000

5220000

Delivery of the cable at site Loading, unloading and delivery of the cable at site store.(If applicable) Shifting of cable from site store to place of installation. Supply & fixing of cable G I clamps(With GI Screw) ,Nylon Tie, brackets, supports, route markers etc. where ever required to fix the cables safely. Earthing the glands and armouring with earthing clamp and jumper and also connecting to common earth bar. Excavation, back filling and leveling of ground along with supply & laying of fine sand, protection bricks and other necessary civil material for laying cables outside the building. Testing of insulation and continuity of cable and submission of reports to the client's representative. 17.2.1 3.5 c x 70 sq. mm. Al. XLPE cable 18.0

19 19.1

MTR

Horizontal Bed Head Panels for ICU/ICCU as per specification , the out let shall comply to out let point summary. The Bed Head Panel should comply to ISO 11197-2004 certification and EN 737 / NFPA 99 C standard. CIVIL WORK

Floating Foundation for MGPS equipment

MGPS TENDER DOCUMENT

BILL OF QUANTITY - VOL I

SET

75 58

PROJECT : L.G. HOSPITAL BY AMC , AHMEDABAD PRINCIPAL CONSULTANT : BHAVESH SHAH AND PRITI SHAH MGPS CONSULTANT : SHETH TECHNO CONSULTANTS PVT. LTD. VOLUME I - MEDICAL GAS PIPELINE SYSTEM BILL OF QUANTITY ESTIMATE SR. NO.

DESCRIPTION

UNIT

QTY

UNIT RATES IN RS.

Total Rs.

Lot

1

21500

21500

Lot

1

21500

21500

providing & laying ordinary cement concrete 1:2:4 (1 cement : 2 coarse sand : 4 graded stone aggregates 20 mm nominal size) and finishing smooth with curing etc.complete including the cost of form work but excluding the cost of reinforcement for R.C.C. work. The same shall be layed on rubber lining of 50mm thickness 19.1.1 Floundation for Air Compressors ( 2 Compressors ) / Receiver Tank / Air Dryer / Related Piping etc 19.1.2 Floundation for Vaccum Pumps ( 3 Pumps ) / Receiver Tank / Related Piping etc 19.2

Core cutting in RCC members of any dia ( Not more then 3") , Complete with cutting , finishing , sealing and painting

Set

36

1250

45000

19.3

Hole cutting in Brick Wall members of any dia ( Not more then 6 ") Complete with cutting , finishing , sealing and painting

Set

48

450

21600

19.4

Hole cutting in Aluminium/glass partition members of any dia ( Not more then 6 ") Complete with cutting , finishing , sealing

Set

36

1250

45000

19.5

Providing and fixing Polycarbonate roof sheets (double layer or two skin) of approved make, on structural roofing / sky light structures in shapes as per Architect’s drawing. The rate shall include cost of scaffolding, screws, nuts, bolts and all necessary fixtures and fastening etc. complete.

Sqm

50

2650

132500

19.6

Providing and fixing M.S.hollow structural steel section like SHR, RHS, tubes etc. or as suggested in contractors's drawing including of all labours and materials for all levels Profile Cutting,threading,drilling, Nut-Bolting, Welding and applying Rust remover and 1-coats of Zinc Chromate / red lead paint and three or more coats of synthetic enamel paint of approved shade and made (“Asian or Tata or" equi.) as directed and specified as directed by Architect / Clerk-Of-Work. For all levels, lift and leads.

Sqm

50

1050

52500

19.7

Cylinder Manifold Area RCC plat form with suitable foundation design required to handle cylinder loading worst case. The heigh of the plat form should be apx. 1.2 Mtr for easy loading / unloading of the cylinders , the scope includes the rainforcement required for the strength and stability of the plat form.

Sqm

50

2250

112500

19.8

MS Fabrication Job - Mainly for working plat form at each floor level in the service shaft

Kgs

1250

65

81250

GRAND TOTAL FOR MGPS SYSTEM INSTALLATION

33,471,620.10

Rs. Three Cror Thirty Four Lacs Seventy One Thousand Six Hundred Twenty only ( For Vol I) Note : 1)The above prices are all inclusive of Design / Supply / Installation / Leak Testing / Comissioning of the Medical Gas Pipe Line System as per tender specification. And the scope coveres the Defact Liability Period of 36 Months , during this period all the routine and break down maintanance shall be carried out by the contractor at his own cost. 2) For L1 Consideration the weitage on Volume I shall be given 75% and on Volume II 25%.

MGPS TENDER DOCUMENT

BILL OF QUANTITY - VOL I

PROJECT : L.G. HOSPITAL BY AMC , AHMEDABAD PRINCIPAL CONSULTANT : BHAVESH SHAH AND PRITI SHAH MGPS CONSULTANT : SHETH TECHNO CONSULTANTS PVT. LTD. VOLUME I - MEDICAL GAS PIPELINE SYSTEM BILL OF QUANTITY ESTIMATE SR. NO.

DESCRIPTION

UNIT

QTY

UNIT RATES IN RS.

Total Rs.

I / We am/are willing to carry out the work at ___________% above / below ( Should be written in figures and words ) the estimated cost mentioned above for Volume 1. The amount of my/our tender works out as under. Estimated Cost Put to Tender : Rs. 3,34,71,620/- ( For Vol I ) Add/Deduct ________ % : Rs. __________ Net Total : Rs. __________ In Words Rs. ( For Vol I ) ____________________________________________________________________________________ Signature of Tenderer :

Additional City Engineer - Bridge Project Ahmedabad Municipal Corporation

Name Company Seal Date

MGPS TENDER DOCUMENT

Date

BILL OF QUANTITY - VOL I