Product Catalogue
If it can be made ... it can be made to last.
www.westconprecast.com
Dealer inquiries welcome. Need a pricelist? Contact us today: Edmonton 1.888.459.6695 Calgary 1.888.279.2537 Or visit us on the web at
two manufacturing locations in Alberta alone Westcon With
can service all of your concrete needs, large or small. In addition, we operate the largest delivery fleet of any precast manufacturer in western Canada. Use these handy maps to find the Westcon location in your sales territory.
My Westcon Location
Edmonton
b
N
Calgary
E
bW
b
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
EdmontonTerritory
b S Calgary Territory
Table of Contents Paving Stones
2
Paving Stones - Tumbled Paving Stones
3
Paving Stones - Special Orders & Accessories
4
Sidewalk Blocks & Stepping Stones
5 6
Alberta Retaining Wall
7
Retaining & Garden Wall
8
Using Westcon Packaged Products
9 9 10
Planters & Bases
11 12 13
Bird Baths
14
Barbeques & Accessories
15
Tables, Benches & Chairs
16 17
Trash Containers & Ashtrays
18
Garden Miscellaneous
19 20
Architectural Precast
21 22
Steps & Brackets
23 24
Building Products
25
Westcon Solid Concrete Footing Block
26
Curbs & Barriers
27 28
Waste Water Management
29 30 31 32
www.westconprecast.com
If it can be made ... it can be made to last.
19 Riel Drive St. Albert Alberta T8N 1N2
Packaged Products
4412 54th Avenue SE Calgary, Alberta T2C 2B9
1
Table of Contents
Paving Stone Installation
1
www.westconprecast.com
Why should I use Westcon Paving Stones instead of asphalt, poured concrete, or other paving solutions?
Paving Stone Installation
• Numerous paving styles
• No cracking
• Unlimited color possibilities
• 3 times stronger than poured concrete
• Create your own design
• Perfect for freeze-thaw conditions
• Low cost, no maintenance
• Pavers move with soil conditions
• 50 year + life expectancy
• Easy installation
How do I install my Westcon paving stones? To begin, remember the five key elements to paving stone installation: (figure a)
Installing My Paving Stones
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
Probably the most compelling answer to this question is in the finished look of a well-done paving stone project. Here are just a few of the advantages of Westcon paving stones:
1. Subgrade – the natural earth material found on site. 2. Sub-base – a layer of gravel. 3. Sand bedding – a layer of graded sand. 4. Paving Stone – the surface wearing course. 5. Edge Restraint – the support used around the perimeter of the paved area.
figure a
To begin:
8. Sweep Westcon Jointing sand into the joints.
1. Excavate to design levels.
9. Re-vibrate the surface and refill the joints until full.
2. Compact the subgrade to the required density. 3. Place and compact the sub-base in layers not exceeding 150mm (6”). The sub-base should be graded to a level so that the thickness of the bedding sand will be not more than 40mm (11/2”) after compaction. 4. Screed the Bedding Sand.
10. Sweep the excess sand from the surface.
Note: The finished surface should not vary by more than 8mm (3/8”) when tested with a 2.5m (8’) straight edge.
5. Place the paving stones in the pattern selected. 6. Where necessary cut pieces to fit the edge. Cut pieces should not be less than ¼ of a full paving stone. 7. Vibrate the surface with two or three passes of a flat plate compactor. (figure b)
0 figure b
Lockpave This unique geometric shape offers proven engineering superiority for any heavy duty application. a. Regular Stone
b. ½ Edge Stone
c. Edge Stone
Thickness
Length
Width
Coverage
Weight
60 mm 80 mm 23/8” 31/8” 60 mm 80 mm 23/8” 31/8” 60 mm 80 mm 23/8” 31/8”
225 mm
112.5 mm
39.5 pieces per m2
87/8”
47/16”
3.7 pieces per ft2
112.5 mm
112.5 mm
79 pieces per m2
47/16”
47/16”
7.4 pieces per ft2
225 mm
112.5 mm
39.5 pieces per m2
8
4
3.7 pieces per ft
140 kg/m2 185 kg/m2 28.5 lb/ft2 38 lb/ft2 140 kg/m2 185 kg/m2 28.5 lb/ft2 38 lb/ft2 140 kg/m2 185 kg/m2 28.5 lb/ft2 38 lb/ft2
”
7/8
”
7/16
2
a b Coverage: Approx. 10.1 m / 109 ft2 per pallet. Stock Colours: Natural, Charcoal, Tan, Red 2
c
Heritage
Photo: Custom Stonescapes
2. Square 3. Small Rectangle 4. Small Circle 5. Large Circle
Thickness 60 mm 23/8” 60 mm 23/8” 60 mm 23/8” 60 mm 23/8” 60 mm 23/8”
Length 172 mm 63/4” 115 mm 41/2” 115 mm 41/2” 112 mm 41/2” 115 mm 41/2”
Width 115 mm 41/2” 115 mm 57 mm 21/4” 86mm 33/8” 112 mm 41/2”
1
5 3
Coverage: Heritage A- (Circle Package) Approx. 8.4 m2 / 91 ft2 per pallet. Heritage B- Approx. 9.4 m2 / 101.1 ft2 per pallet. Heritage C- Approx. 9.4 m2 / 101.1 ft2 per pallet.
Stock Colours: Charcoal Multi-Blend
2
4412 54th Avenue SE Calgary, Alberta T2C 2B9
1. Large Rectangle
Paving Stones
Heritage is an attractive and distinctive paving stone system that presents the timeless beauty of cobblestones, yet is remarkably simple to install.
4
Alberta Rumble Thickness Length 235 mm 91/4” 200 mm 8” 120 mm 43/4” 171 mm 63/4”
Width
Coverage
140 mm 51/2” 140 mm 51/2” 140 mm 51/2” 140 mm 51/2”
30.4 pieces per m2 2.8 pieces per ft2 35.7 pieces per m2 3.3 pieces per ft2 59.5 pieces per m2 5.5 pieces per ft2 40.2 pieces per m2 3.6 pieces per ft2
Alberta Rumble’s textured face and variety of sizes offer a completely unique old world look to any paving application.
19 Riel Drive St. Albert Alberta T8N 1N2
a. Rumble Rectangle 60 mm 23/8” b. Double Rumble 60 mm 23/8” c. Rumble Half 60 mm 23/8” d. Rumble Square 60 mm 23/8”
Coverage: Approx. 10 m2/ 108 ft2 per pallet. Stock Colours: Charcoal Charcoal-Tan Blend
a
b
d
c
Holland
Its simple rectangular geometry makes the Holland paving stone one of the World’s most popular. And with sizing that allows for a wide variety of laying patterns, Holland a preferred alternative to clay-brick paving. a
Thickness 60 mm 80 mm 23/8” 31/8” b. Holland Petite 60 mm 23/8” c. Double Holland Petite 60 mm 23/8” a. Holland
b
b. Cobble Edge
Thickness 60 mm 80 mm 23/8” 31/8” 60 mm 80 mm 23/8” 31/8”
Coverage 39.5 pieces per m2
87/8”
47/16”
3.7 pieces per ft2
203 mm 8” 203 mm 8”
101mm 4” 203 mm 8”
48 pieces per m2 4.5 pieces per ft2 24 pieces per m2 2.2 pieces per ft2
Weight 140 kg/m2 185 kg/m2 28.5 lb/ft2 38 lb/ft2 140 kg/m2 28.5 lb/ft2 140 kg/m2 28.5 lb/ft2
Length 230 mm
Width 140 mm
Coverage 38 pieces per m2
9”
51/2”
3.5 pieces per ft2
230 mm
115 mm
43 pieces per m2
9”
4
4 pieces per ft2
”
1/2
Coverage: Cobble- Approx. 10.2 m2/ 110 ft2 per pallet. Cobble Edge Approx. 4.7 m2/ 50 ft2 per pallet. Stock Colours: Natural, Charcoal, Tan, Red, Multi
Weight 140 kg/m2 185 kg/m2 28.5 lb/ft2 38 lb/ft2 140 kg/m2 185 kg/m2 28.5 lb/ft2 38 lb/ft2
www.westconprecast.com
a. Cobble
Width 112.5 mm
Coverage: Holland- Approx. 10.1 m2/ 109 ft2 per pallet. Holland Petite Approx. 10.1 m2/ 109 ft2 per pallet. Double Holland Petite Approx. 10.1 m2/ 109 ft2 per pallet. Stock Colours: Natural, Charcoal, Tan, Red, Multi
c
Cobble Stone
Length 225 mm
With its classic octagonal looks and its strong interlocking characteristics cobble is a popular choice for residential and commercial paving projects.
2
Turfstone
3
strength and beauty
Turfstone
Thickness
Length
Width
Coverage
Weight
90 mm
600 mm
400 mm
4.2 pieces per m2
130 kg/m2
31/2”
24”
16”
.5 pieces per ft2
26 lb/ft2
Stock Colours: Natural
Plaza 12x12 Plaza
Paving Stones - Tumbled Paving Stones
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
This mix of offers an ideal way to preserve green space in areas host to occasional vehicle traffic.
Thickness
Length
Width
Coverage
Weight
60 mm
305 mm
305 mm
11.1 pieces per m2
140 kg/m2
23/8”
12”
12”
1 pieces per ft2
28.5 lb/ft2
Coverage: Approx. 11.15 m / 120 ft per pallet. 2
Stock Colours: Natural Charcoal
Red
2
Multi-Blend
easy-to-lay
This , large format stone offers the beauty of an exterior tile finish with immense
durability.
Roman Artisan All of our Westcon Artisan paving stones come in a tumbled finish with softened colour to give any landscaping application timeless beauty and elegance. Roman Artisan
Thickness
Length
Width
Coverage
Weight
60 mm
230 mm
185 mm
23 pieces per m2
132 kg/m2
23/8”
9”
71/4”
2.1 pieces per ft2
26.5 lb/ft2
Typical of our Artisan line, Roman Artisan offers a distinctive old-world look from the moment of installation. Each piece is carefully tumbled to enhance the pavers time-worn charm.
Stock Colours: Charcoal Earthtone Sandstone
Artisan Product Name Holland Artisan Holland Petite Artisan
Roman Artisan
Alberta Rumble Artisan Corso Artisan A Corso Artisan B Corso Artisan C
Coverage: Approx. 10.64 m2/ 114 ft2 per pallet.
Colour Natural Charcoal Natural Charcoal Multi Charcoal Earthtone Sandstone Charcoal Charcoal-Tan Charcoal-Tan Charcoal-Tan Charcoal-Tan
Pieces/Pallet 400
Weight kg 1400
Coverage 10.1 m2 / 109 ft2
540
1559
108 m2 / 116 ft2
250
1334
10.64 m2 / 114 ft2
390
1400
10 m2 / 108 ft2
120 240 480
1450 1450 1450
11.15 m2 / 120 ft2 11.15 m2 / 120 ft2 11.15 m2 / 120 ft2
Special Orders Quadro
At Westcon we pride ourselves on having the biggest selection of paving stone molds of any manufacturer in Western Canada.
Bowtie
If your large scale commercial job requires something unique contact one of our sales representatives for more information on our special order paving stones today.
Hexagon
*Westcon offers custom molds and colours where 50 or more pallets (>5,000 ft2) are required. Custom order charges will apply. Contact one of our sales representatives for details.
Square
How to test for a sealed or treated surface... Bric
kSto
p TM
To find out if the concrete you’re working with has been stained or sealed try this simple test: Sprinkle water onto the concrete surface. If the water beads up or doesn’t appear to soak in, the concrete is either sealed or too smooth for staining (very smooth concrete needs to be roughened to take stain).
Alum
inum
kSt
Bri
op TM
Most sealers can be stripped with a methylene chloride based stripper, but if possible determine what sealer was used on the concrete and contact the manufacturer for recommendations about removal.
“Th
eB eas t” 8 ’
ckS
top TM
Home Owners Tip:
Pla
stic
7’ 9 ”
Home Owners Tip:
Granastar
Concrete Cleaner- Removes grease and oil stains from concrete. Clear Concrete Sealer- Gloss or Satin finish. Transparent Concrete StainAssorted colours.
Cement pigments.
www.westconprecast.com
Edge restraints are crucial in preventing lateral movement of paving stones and loss of bedding sand. Westcon offers a number of solutions to hold your paving projects in place for a lifetime.
Mason’s SelectTM Concrete Products
19 Riel Drive St. Albert Alberta T8N 1N2
Bric
8’ 4 ”
4412 54th Avenue SE Calgary, Alberta T2C 2B9
A few of the more than 1,000 possible laying combinations possible with these special order* paving stones.
Paving Stones - Special Orders & Accessories
Accessories
Octagon
Use Granastar products when mixing concrete, mortar, stucco, or grout for colourful finishes.
UniSheen/Websheen 4L Also available: 19L
CurbStone 36” x 9” x 3”
4
5
Sidewalk Blocks
Also available: Charcoal Exposed Weight: 48 kg
Natural Finish
Did you know? Concrete slabs offer an ideal durability for flat
24” x 24” Sidewalk Block
18” x 18” Sidewalk Block
Also available: Natural Charcoal
Also available: Natural Exposed
Weight: 39 kg
Weight: 24 kg
Charcoal Finish
Exposed Finish
New Product! 18” x 18” Slate Sidewalk Block
Slate Finish
roofing applications.
Sidewalk Blocks & Stepping Stones
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
24”x 30” Sidewalk Block
And at just 24 kg Westcon’s 18” x 18” Sidewalk Block offers an easy to handle, easy to install solution to long term roofing requirements.
Available in Natural (shown here) or Charcoal finish. Also available: 18” Round Slate Sidewalk Block
18” x 18” Roof Tile
2” x 4” x 24”
Sidewalk Block Risers 2” x 4” x 24” 11 kg 2” x 4” x 30” 14 kg
Home Owners Tip: Applying simple stains or sealants can change refractive qualities and create a unique and beautiful finish to natural concrete. See page 4 for more information on sealant and stains available from Westcon.
24” x 30” Sundial Block
Natural or Charcoal Weight: 48 kg
24”x 30” Rundle Block
Natural or Charcoal Weight:48 kg
24” x 30” Brick Block
Natural or Charcoal Weight: 48 kg
Sidewalk Blocks 8” x 16” Patio Slab
Natural Finish Also available in red Weight: 6.8 kg
18” Round Sidewalk Block
Natural Finish Also available: Charcoal Exposed Weight: 24 kg
walkways and natural areas.
18” Floral Block Round
A hand-poured stepping stone available in Natural (shown here) or Charcoal finish.
Available in Natural (shown here) or Charcoal finish.
Weight: 18.5 kg
Weight: 19.5 kg
19 Riel Drive St. Albert Alberta T8N 1N2
18” x 18” Floral Block
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Westcon Hand-Crafted Stepping stones are hand-poured and stripped, offering each product a unique appearance that can greatly enhance
Sidewalk Blocks & Stepping Stones
Hand-Crafted Stepping Stones
Home Owners Tip: Put a little fun into a walkway or children’s play area with these unique stepping stones. 14” Log Block
www.westconprecast.com
Natural Weight: 16.3 kg
24” x 12” Big Foot Block
Natural Weight: 11.5 kg
6
Alberta Retaining Wall
Alberta Retaining Wall (ARW) ARW is a mortar-free system that lends itself easily to landscape projects such as terrace gardens and retaining walls. Installation is fast and easy and ARW is available in a number of colours that can compliment most garden applications, so choose one that best suits your landscape.
granular backfill next to block retaining wall
Preparation Before beginning to excavate and construct, prepare a layout for your ARW project. Be sure to consider drainage patterns, soil conditions, and local building codes. Base preparation is dependant on what size and type of project you plan to build. Projects designed with more than three courses require the base course of ARW to be buried below grade.
Retaining & Garden Walls
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
7
top soil
Bottom top soil
Installation 1.
2.
3.
4.
Begin your project by digging a trench of the required depth and width. Place 75mm to 100mm (3”- 4”) of crushed rock in the bottom. Level and compact. Place a row of ARW in the trench, leveling the block from side to side and from front to back. Fill behind ARW with clean, crushed rock and compact the back fill, check level of ARW again.
compacted granular base
Cap
Height
# of rows
Corner Block
Continue assembling additional courses by positioning the units in a staggered relationships with the course below. Backfill each course with crushed rock and compact as you go. Install the last course using cap block. Backfill with top soil if needed.
Home Owners Tip: Sweep clean the top of each course and apply a construction adhesive for extra strength in any mortar-free wall application. Stock Colours: Natural Charcoal Charcoal-Tan
ARW Block Quantity Chart
Top
Corner Detail
1 2 3 4 5 6 7 8 cap blocks
Length
inches 5 10 15 20 25 30 35 40
5’ 9 18 27 36 45 54 63 72 9
10’ 15’ 17 34 51 68 85 102 119 136 17
26 54 78 104 130 156 182 208 26
20’
25’
30’
34 68 102 136 170 204 238 272 34
43 86 129 172 215 258 301 344 43
52 104 156 208 260 312 364 416 52
90 degree corners are made by using the corner block. Split the block in half using a hammer and chisel. This will make two corner blocks or half blocks. Alternate the blocks on the corner. Use construction adhesive to secure the blocks in place.
Curve Detail
Retaining & Garden Wall Split Piece Length
380mm/15”
Width
295mm / 111/2”
Thickness
150mm/6”
Slopestone
Coverage: 23 split pcs./ m2 Packaging: 8 Pieces Un-split – 16 pcs. field Stock Colours: Natural Only
Installation
Wallstone
Curved Wall Laying Pattern
Westcon’s Slopestone is a superior application for heavy duty and industrial retaining wall requirements. Engineered for strength and easy installation, Slopestone is a solid and dependable wall for contractor or homeowner use.
19 Riel Drive St. Albert Alberta T8N 1N2
1. Excavate the area to undisturbed soil. 2. Place and compact a 75100mm (3”- 4”) layer of crushed rock base. 3. Split the Wallstone or Slopestone by striking centre seams with a chisel and heavy sledge (leave Wallstone bottom course un-split for extra footing). 4. Place on prepared base in a runner pattern for straight walls. For curves in Slopestone walls see figure a. 5. Use copping stone for top course of Wallstone (Slopestone does not require a cap). 6. Backfill the wall with a well draining granular material. 7. Maximum recommended height for these walls is 1200mm (48”). Contact your Westcon Representative for details on higher walls.
4412 54th Avenue SE Calgary, Alberta T2C 2B9
figure a
Retaining & Garden Walls
Straight Wall Laying Pattern
Remove Ridges from each corner piece. Break approximately 25mm (1”) from the end of each corner piece to match split face texture.
Full Piece
Split Piece
Length
300mm/12”
300mm/12”
Width
400mm/16”
200mm /8”
Thickness
100mm/4”
100mm/4”
Coverage: 33 split pcs./m Packaging: 40 Pieces Un-split- 24 pcs. field / 16pcs. coping Stock Colours: Red, Charcoal-Tan
www.westconprecast.com
A simple, inexpensive retaining wall easily built by contractors or home owners. The tongue and groove design provides accurate positioning and allows the wall to be built vertically or stepped back. Each piece has one broken and one smooth face to provide a choice of wall finish. Red or Charcoal-Tan
2
8
9
Using Westcon Packaged Products
Empty contents of sack into mortar box, wheel barrow, or onto a smooth surface. Form a crater for adding water. Add clean water as recommended on the bag and mix thoroughly. If mix is too stiff, add more water, a cupful at a time. Avoid a soupy mix. In cold weather use warm water to accelerate the set. Protect from freezing until cured.
Anchoring Posts and Poles Make a master plan before digging. Unless you are using pressure-treated lumber, apply a wood preservative such as creosote to that portion of the post that will be below ground level. 1. In areas subject to freezing, set the posts between 3’ and 4’ deep. The hole diameter for a 4” by 4” post should be 8” to 10”. Fill the bottom with 6” of crushed stone or gravel for drainage. 2. Two bags of Westcon Concrete Mix are required to firmly anchor each post. Using a rod or stick, force the concrete around the post in succeeding 12” to 15” layers. Proceed until the hole is filled. 3. Mound the concrete around the post to about 2” above ground level and slope the top towards the ground. Keep the posts braced for a day or two to allow the concrete to achieve sufficient strength. While doing this, keep the concrete damp.
Using Westcon Packaged Products
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
Mixing Directions
Laying Brick or Concrete Blocks All brick and concrete block work should be placed on a properly constructed slab or footing. First, dig a trench below the frost line. Pour in 3” to 4” of crushed stone or gravel and compact it at the bottom. Place 2” x 4” lumber to form the footings directly on top of the gravel or stone. 1. Pour a 3” to 4” thickness of Westcon Mortar Mix into the forms. Level off and finish smooth. Allow one day for curing before proceeding. If you’re working with bricks, dampen them first. Concrete blocks must always be dry. Mix only enough Westcon Mortar Mix that you can reasonably use in an hour. Lay out the first course (layer) of bricks on the previously constructed footing, allowing 3/8” between each. With a pencil, mark the location of the bricks on the footing. Drive stakes at the corners of project and stretch taut string lines between them at the proper height for the first layer. 2. Start at one corner by laying a 3/4” bed of mortar long enough for 3 or 4 bricks. It should be the full width of the brick. (Joints between subsequent layers should be 3/8” thick). Lay the first corner brick and tap it level. Butter the end of the next brick and press it down into the mortar against the first brick allowing for a 3/8” joint. Do the other corners, then fill in the first course. 3. Once the first layer is complete start building up each corner (up to 4 or 5 layers depending on the job). Use levels and straight edge frequently. 4. With the help of a mason’s string line build up the subsequent layers, cutting off excess mortar with an upward sweep of the trowel. 5. The mortar must set before finishing the joints. When the mortar can take a thumb print, tool all the joints in a V-shaped fashion. Wipe off small drippings with a clean burlap cloth. Working with concrete blocks is similar except that the blocks should not be laid wet. When applying mortar coat the entire top of the block.
Repairing Mortar Joints 1. Dig out the old damaged masonry with a small chisel or screw driver. Remove all loose mortar and unsound material. Go at least 1” deep and use a small brush to clean out completely. Wet the area to be repaired several times with clean water. Mix Westcon Mortar Mix according to the directions on the bag.
Packaged Products 2. Place the prepared mortar on a board and hold it up against the wall against the joint to be repaired. Using a small trowel designed for this purpose, slide some mortar off the board and force it directly into the opening. Use a squared-off piece of wood to tamp the mix into all recessed areas of the cavity at the back. Do not leave gaps between the old and new mortar which could trap water and cause future problems. Once the mortar becomes “thumb print” hard, finish to match the existing joint. Remove small drippings with a clean piece of burlap.
Resurfacing a Masonry Wall
NOTE: if a second coat is required, apply a coarser first coat. Before applying the second coat, let the first one harden a bit and then roughen the surface with a stiff bristle broom. Don’t allow the first coat to dry out. Keep it moist for 24 hours before applying the second coat, which, in turn, should be kept moist for 48 hours.
Helpful Hints: It is best to consult local utilities before digging any deep holes or trenches and local building authorities before erecting any deck or other above-ground structure. The instructions contained in this booklet are intended as a general guide only.
Weight kg 25 25 25 22.68 22.68 25 25 20 40 34 34 40 40 40 40 40 20
www.westconprecast.com
Pieces/Pallet 50 50 50 50 50 50 50 50 40 40 40 40 40 40 40 45 48
19 Riel Drive St. Albert Alberta T8N 1N2
Product Name Concrete Mix #1 Topping Mix #2 Mortar Mix #3 Play Sand Jointing Sand Concrete Mix - Post Haste Chemstar Type S Lime Hydrated Lime Cement - Normal Portland Cement - Mortar Type S Cement - Stucco Cement - Sulphate Resistant Cement - White Cement - Oilwell “G” Cement - High Early Cement - Fondu Safety Marker
4412 54th Avenue SE Calgary, Alberta T2C 2B9
1. For best results, apply a concrete bonder to the wall before applying the Westcon Topping Mix. 2. Apply up to 1/4” thick layer of the Topping Mix with a trowel. Try to obtain even coverage over the entire wall. 3. Finish with wood trowel or float. Keep moist for at least 48 hours.
Packaged Products
Before starting, make sure that the wall surface is clean and sound. Any deteriorated or severely worn areas should be thoroughly repaired. Before applying the parge coat, spray the wall several times with clean water. The blocks should be damp, but not soaked. This will preclude them from draining too much moisture from the finishing mix.
10
11
Planters & Bases
www.westconprecast.com
101SB Champagne fluted Artisan
21”W x 18”H 65kg
89 Hexagon
31”W x 22”H 200kg 89A Hexagon (Not Shown) 31”W x 16”H 145kg
101 Champagne
Planters & Bases
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
69 Hexagon
20”W x 18”H 55kg
24”W x12”H 75kg
99 Hexagon
26”W x 16”H 115kg
101A Champagne
23”W x 18”H 110kg
102 Bowl
103 Dish
26”W x 14”H 90kg
28”W x 11”H 60kg
79 Octagon
36”W x 18”H 135kg
100 Bowl
32”W x 19”H 140kg
101B Champagne (no base)
23”W x 20” H 90kg
104 EggCup
16”W x 18”H 70kg
321F Round Shallow Bowl - Artisan
13”W x 10”H 25kg
111 Dish Low
109 Low Round
110 Square Slanted
28”W x 16”H 105kg
16”W x 10”H 55kg
112 Tulip
113 Bowl
4412 54th Avenue SE Calgary, Alberta T2C 2B9
105 Pot
Planters & Bases
72”W x 23”H 364kg
19 Riel Drive St. Albert Alberta T8N 1N2
21”W x 8”H 25kg 36”W x 22”H 180kg
16” W x 9”H 20kg
130 Basket
114 Tappered Pot 115 Square
www.westconprecast.com
24”W x 15”H 70kg
16”W x 9”H 45kg 24”W x 29”H 140kg
12
Planters & Bases 201A Round Modular Section
www.westconprecast.com
13
60”L x 16”W x 16”H 250kg
48”W x 12”H 415kg
202A Rectangle
48”L x 14”W x 14”H 190kg
201 Round Modular Base 202 Rectangle
19 Riel Drive St. Albert Alberta T8N 1N2
39”L x 12”W x 12”H 100kg
203 Square Modular Base
205 Square
206 Cone 30”W x 12”H 145kg 203A Square Modular Section (Not Shown) 30”W x 12”H 80kg
36”w x 32”H 585kg 26” W x 16”H 80kg
207 Bell
220 Bowl - Flat Edge 208 Bowl
Planters & Bases
4412 54th Avenue SE Calgary, Alberta T2C 2B9
202B Rectangle
48” W x 12” H 245 kg
18”W x 10”H 35kg
22” W x 17”H 85kg 208A Base 45kg
27”W x 11”H 75kg
Bird Baths Imagine waking to chorus of songbirds on a summer morning! Westcon concrete bird baths are a wonderful addition to any garden, backyard, or natural space.
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Bird Baths
117A Sunflower Bird Bath 24”W x 31”H natural finish 100kg
19 Riel Drive St. Albert Alberta T8N 1N2
24”W x 31”H exposed finish 100kg
118 Small Bird Bath 16”W x 24”H natural finish 25kg 118A Small Bird Bath exposed finish (not shown) 16” W x 24” H 25kg
www.westconprecast.com
117B Sunflower Bird Bath
117 Large Bird Bath 24”W x 35”H exposed finish 115kg
14
Barbeques & Accessories
36” Barbeque Base
www.westconprecast.com
15
natural finish (2 pieces) 24kg (each)
19 Riel Drive St. Albert Alberta T8N 1N2
24” Metal Barbeque Grill
(7 per circle, 6 for bottom course) available in red (shown here), natural, and charcoal 14.4kg
3kg
friends and family near the fire year-round with a Westcon Barbeque. Works great for cookouts or as a fire pit. Enjoy gatherings with
Barbeques & Accessories
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Barbeque Block 24”
Complete 24” Barbeque kits available. red (shown here), natural, & charcoal
Also available:
Barbeque Blocks- 48” (not shown) (10 per circle, 9 for bottom course) natural finish only 19kg
48” Metal Barbeque Grill 6kg
Tables, Benches & Chairs Add a touch of elegance to any patio, yard, or garden with hand-poured Westcon furniture.
124 Artisan Italian Bench
A beautiful feature with the 122 Table or on its own. 112kg
Custom Precast Westcon’s skilled craftsman can make almost any concept a reality in precast concrete. Talk to a Westcon representative today about custom molds or commercial applications.
Unisheen finish
19 Riel Drive St. Albert Alberta T8N 1N2
Ground finish
4412 54th Avenue SE Calgary, Alberta T2C 2B9
42”W x 30”H 155kg
Tables, Benches & Chairs
122 ItalianStyle Table
A number of finishing techniques can be used to augment the beauty of natural concrete. Here are just two of the different finishes that are fast and easy for anyone to apply. Custom Golf Course Benches
www.westconprecast.com
The Bern Bench – Artisan
214 Picnic Table Assembled Top is 72” x 36” 825kg
Classic symmetry in the Swiss architectural style. 24”W x 48”L x 16”H 230kg
16
Tables, Benches & Chairs
17
Product Name
Finish
Weight Kg
Natural/Exposed
255
119A - Table Base Only 39” W Exp..
Exposed
160
119B - Table Top Only - 39” W - Nat.
Natural
95
120 - Round Patio Seat 16” W x 18” H - Exp.
Exposed
90
122 - Table - Italian Style - 42” W x 30” H - Nat.
Natural
155
122A - Table Base Swirl - 15” W 27” H - Nat.
Natural
92
122B - Table Top - Italian Style - 42” W - Nat.
Natural
65
123 - Table Top Italian Style - 32” W - Nat.
Natural
45
124 - Bench for 122 Table -
Natural
112
125 - Round Table w/ Bench Attached
Exposed
500
211 - Bench - 55” L x 24” W x 19” H - Exp.
Exposed
230
211A - Bench - 72” L x 24” W x 24” H - Exp.
Exposed
325
211B - Bench - 21” L x 14” W x 14” H - Exp.
Exposed
35
212 - Bench End - 28” W x 41” H x 4” Thick - Exp.
Exposed
85
119 Table
39”W x 35”H exposed bottom, natural top 255kg
Tables, Benches & Chairs Continued
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
119 - Table - 39” W x 35” H - Exp. Bottom, Nat. Top
120 Round Patio Seat
16”W x 18”H exposed finish 90kg
212 Bench End
28”W x 41”H x 4” Thick exposed finish 212 Bench End natural finish (not shown) 85kg
211B Bench
21”L x 14”W x 14”H Exposed finish 35kg
213 Picnic Table End
61”W x 29”H x 4” Thick exposed finish 325kg 213A Picnic Table End natural finish, not shown
211 Bench
55”L x 24”W x 19”H exposed finish 280kg
Trash Containers Product Name 91 - Hexagon - Dice - Trash Container 25” W x 32” H
Exposed
265
209 - Round Trash Container - 22” W x 32” H
Exposed
265
N/A
3
Exposed
395
209 RM - Rubber Maid Lid
N/A
3
209SP - Lid for 209A Metal Liner
N/A
2
Exposed
155
N/A
3
Exposed
250
215A - Metal Liner for 215 Square Trash Container
N/A
3
215B - Metal Lid for 215 Square Trash Container
N/A
3
216 - Ashtray - 14” W x 28” H
Exposed
160
217 - Closed Trash Container - 26” x 24” x 41” H
Exposed
350
209A - Metal Liner for 209 Round Trash Container 209B - Round Ash Tray - 22” W x 32” H
210 - Round Trash Container - 20” W x 28” H 210A - Metal Liner for 210 Round Trash Container 215 - Square Trash Container - 20” W x 28” H
215
19 Riel Drive St. Albert Alberta T8N 1N2
Back
209
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Weight Kg
Trash Containers & Ashtrays
Finish
Front 216
www.westconprecast.com
217 Closed Garbage Can
exposed finish comes with hinged door (not shown) for easy access
18
Garden Miscellaneous
www.westconprecast.com
19
The simple and attractive geometry of the sphere make Pillar Balls an interesting addition to the
modern garden. Pillar Cap
9” Pillar Ball, 20” Pillar ball
Tree Ring Round
natural or custom colour 9” – 12kg 12” – 54kg 20” – 250kg 30” – 845kg
5 pieces per circle 8kg
Garden Miscellaneous
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
12” x 12” natural (shown here) or exposed 17kg also available: 14” x 14” – 23kg 16” x 16” – 29kg 18” x 18” 35kg 20” x 20” 43kg
A Flexible Medium Westcon has over 30 years experience designing and creating custom concrete applications. Pictured here are just two of the many special orders that Westcon creates for our customers each year.
Japanese Style Pagoda Custom Rubber Form
Display Platforms
Custom Wooden Form
Garden Miscellaneous Keep bicycles upright and out of the way with concrete bicycle blocks Control erosion from eaves troughs or drain channels.
Splash Pan
Natural finish (shown here), charcoal & exposed 30kg also Road Bike Bicycle Block (not shown) Natural finish, charcoal & exposed 30kg
Scallop Edge
24” x 8” x 2” Natural finish (shown here), charcoal & exposed 12kg
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Bicycle Block
Garden Miscellaneous
12” x 30” 30kg natural finish 12” x 36” – 36kg 12” x 42” – 40kg 12” x 48” – 50kg 24” x 72” – 175kg
19 Riel Drive St. Albert Alberta T8N 1N2
A classic stand for planters or ornaments. Knauer Garden Edge
24” x 51/2” x 2” natural (shown here) or charcoal.
Artisan Pedestal
24” H x 18” base, 101/2” platform natural finish 58kg
www.westconprecast.com
20
Architectural Precast
Great pillars of stone are central to western and eastern architectural
www.westconprecast.com
21
thought and practice. Admired both for their symbolism and functionality, pillars augment natural and man-made spaces in ways that no other feature can.
Artisan
Garden Pillar
Architectural Precast
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
Ornamental Balustrades
Stock or as a custom application, concrete ornamental balustrades offer a refinement and timeless beauty in landscape applications such as garden terraces, patios, and traditional English gardens.
Artisan Garden Pillar 8” Diameter x 6’ High As placement posts for hanging garden walls, centre posts for courtyard fountains, or simply as a free standing landscape features, Westcon Artisan Garden Pillars are as beautiful as they are versatile.
Artisan Half Entry Pillar 24” Diameter x 8’ High A monumental and striking addition to entrance ways or traditional gardens.
Architectural Precast Pictured here are just a few of the many quality Precast projects that Westcon has supplied for architects, engineers, and general contractors. To look at a complete portfolio or for more information contact your Westcon sales representative today.
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Architectural Precast
Project: SAIT Expansion Project 2001
Architect/Designer: The Cohos Evamy Partners. Architecture, Engineering, Interior Design
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
Project: O’CONNORS Men’s Wear
Architect/Designer: Kasian Kennedy. Architecture, Interior Design & Planning Incorporated
22
Concrete Steps & Brackets
4412 54th Avenue SE Calgary, Alberta T2C 2B9 19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
23
Steps & Brackets
Steps & Brackets
”
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Concrete Steps & Brackets
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
24
Building Products Westcon Infrastructure offers a wide variety of stock and custom concrete pads and bases. Call us today for more information.
Propane Block A support for propane vessels or other tank types. natural finish 61kg each
Hydrant Base 35kg
Building Blocks
great for short mortar walls (or college bookshelves)
Footing Block
machine pressed, natural finish 24kg
Building Products
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
25
20cm Standard Building Block 12.5kg
10cm Half Building Block 6kg
MegaBlock Mega Block is a simple engineering concept that lends great strength to retaining walls, temporary structures, shelter bases, or any structure that requires moveable, interlocking components.
Mega Block natural (shown here) or exposed 1819kg
Half Mega Block natural or exposed 910kg
Westcon Solid Concrete Footing Block
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Building Products
Four-way footing blocks are great for decks, sheds, out-building platforms, or any raised wooden platform. Slots allow room for 2” x 6” through 2” x 12” stringers from each side, and the open centre slot allows you to build even where ground isn’t level by accepting 4” x 4”s on-end, cut to the required height. This means you can use Footing Blocks to build almost any deck shape you design. Your imagination is the only limit!
Fast & Easy
www.westconprecast.com
For simple decks, lay out Footing Blocks according to desired area and run 2” x 6” stringers. Adjust blocks until the top edge of the stringer is level.
19 Riel Drive St. Albert Alberta T8N 1N2
Footing blocks can be used in combination with poured footings for extra support or on their own on well-compacted ground. Be sure to carefully evaluate ground conditions before you build.
4” x 4” Center Slot
Home Owners Tip: Remember to place all surface boards on the deck before nailing. Space surface boards ¼” apart using ¼” dowel, adjust as necessary, and apply construction adhesive to top edge of stringers when ready to nail for extra surface stability. 26
Curbs & Barriers
27
Type “A” Mini Barrier
Type “A” Mini Barrier Transition
Curbs & Barriers
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
Type F Barriers
New Jersey Barrier New Jersey Barrier Transition
Type “25” Barrier
Type “21” Barrier
Curbs & Barriers
8 FT. Parking Curb
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Heavy Duty 8 FT. Parking Curb
Curbs & Barriers
7 FT. Parking Curb
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
28
29
www.westconprecast.com
Waste Water Management
M-1000
M-700
Security in Quality Westcon can meet any Waste Water Management need from the m700 (400 gal) to Alberta’s largest working capacity tank, the M3000 (1,766 gal ). Our Concrete Septic Tanks and cisterns are built to last and are often in service for 25 years or more. Each of our tanks is manufactured with 40MPA concrete, and meets or exceeds CSA specifications. What size tank do I need?
Waste Water Management
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
M-3000
Tank size is generally determined by type of application. A general residential guideline to working capacity is as follows: Number of bedrooms x 1.5 people per bedroom x 75 gallons per person = working capacity
However, extra working capacity may be required depending on the working conditions of your new tank. Contact your Westcon sales representative today for more information on choosing the right Waste Water Management solution for your requirements.
Waste Water Management Product #
Product Description Septic Tanks
M-700
w/c-400 gals. H=65” W=48” L=96” Inlet=56”
M-700S
Regular siphon outlet=32” High siphon outlet=40”
M-1000
w/c-755 gals. H=75” W=68” L=96” Inlet=65”
M-1000S
Regular siphon outlet=40” High siphon outlet=46”
M-3000
w/c 1766 gals. H=6’6” W=8’ L=12’10” Outlet=5’5”
Holding Tanks
M-1400
Capacity-1400 gals. H=75” W=68” L=96” Inlet=65”
M-3000
Capacity-3000 gals. H6’6” W=8’ L=12’10” Inlet=5’5”
M-5000
Capacity-5000 gals. Dia. 11’ H=134”
Water Cisterns M-2000
Capacity-2000 gals. H=6’6” W=8’ L=8’61/2”
M-3000
Capacity-3000 gals. H6’6” W=8’ L=12’10” Inlet=5’5”
M-5000
Capacity-5000 gals. Dia. 11’ H=134”
Water, Soap, Silt Separator M-1400sep
1400 gals. H=75” W=68” L=96” Inlet=65”
Custom Tanks & Vaults CT
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Capacity-700 gals. H=65” W=48” L=96” Inlet=56”
Waste Water Management
M-700
Custom Tanks 19 Riel Drive St. Albert Alberta T8N 1N2
CV
Custom Vaults Garage Sumps
DGS
Double Garage Sump L=5’2” W=2’10” H=3’10”
SGS
Single Garage Sump 2’10”W x 2’6”L x 3’10”H
GSL
Sump Lids (Solid and Drain Holes)
www.westconprecast.com
Single Garage Sump
Double Garage Sump
30
31
Waste Water Management SEAL
Concrete sealant for lids & barrels
RML
Septic tank lid. C/w recessed lifting handles
CML
Cleanout tank lid. C/w 6” pvc insert, cap & handles
6CC
6” PVC Cleanout Cap
EXT1230
Septic tank barrel. 12” high x 30” inside dimensions
EXT1830
Septic tank barrel. 18” high x 30” inside dimensions
EXT2430
Septic tank barrel. 24” high x 30” inside dimensions
EXT3630
Septic tank barrel. 36” high x 30” inside dimensions
SU
Siphon Unit (ABS)
SL24
24” Manhold lid
EXT1224
Septic tank barrel. 12” high x 24” inside dimensions
EXT2424
Septic tank barrel. 24” high x 24” inside dimensions
EXT3624
Septic tank barrel. 36” high x 24’ inside dimensions
36” I.D.
Catchbasins
48” I.D.
Manhole material
Special Orders
1 1/4” Brass Nipple Cast in Tank (Cisterns) Private Sewage Handbook
Link Seals
Waste Water Management
4412 54th Avenue SE Calgary, Alberta T2C 2B9
19 Riel Drive St. Albert Alberta T8N 1N2
www.westconprecast.com
Accessories
4” Hole Link Seal L.S. 300 (10 Links for plastic pipe) Hole coring charge - 6”
6” Hole Link Seal L.S. 475 (10 Links for plastic pipe) Hole coring charge - 10”
8” Hole Link Seal L.S. 475 (10 Links for plastic pipe) Hole coring charge - 12”
Septic Tank Barrels
Waste Water Management Terminator Leachfield Chamber Products
65391
Type A Inlet Cap for Splash Pan, 26”
65380
Type A Splash Pan, 47” Long
65390
Type A End Cap, 26”
65392
Type AG (At Grade) 8” x 96”
65514
Type AG (At Grade) End Cap 8”
65503
Type LP (Low Profile) 26” x 96”
65515
Type LP (Low Profile) End Cap 26”
65510
R-15 Conduit for 21/4” Pipe, 96”
65511
Pipe Support Blocks (11/2” ID Pipe), 11/2” High
Waste Water Management Shipping Price includes delivery within 60 km of our Calgary or Edmonton yard. Shipping charge applies outside delivery radius. Customer must provide map and/or directions to site where required for tank delivery. Excavation must be ready to receive tank, with bottom level and one side clear of obstructions for tank access. We also require precise notification of overhead wires or buried items. Extra charges will apply for waiting time (over 1 hour). It will be at the discretion of Westcon delivery personnel to make judgments on difficult installations.
Leachfield Chamber Products
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Type A (Standard) 26” x 96”
Waste Water Management
65331
19 Riel Drive St. Albert Alberta T8N 1N2
Type LP (Low Profile) - Typical Application - shallow bury
Pipe Support
End Cap
www.westconprecast.com
Type A (Standard) - Typical Application - standard trench
Splash Pad
Type AG (At Grade) - Typical Application - above grade
32
19 Riel Drive St. Albert, Alberta T8N 1N2
Phone: 780.459.6695 Fax: 780.459.6670 Toll Free: 1.888.459.6695
4412 54th Avenue SE Calgary, Alberta T2C 2B9
Phone: 403.279.2534 Fax: 403.279.6583 Toll Free: 1.888.279.2537
www.westconprecast.com