CDX-F7500/F7700 SERVICE MANUAL

AEP Model UK Model

Ver 1.1 2004. 04

CDX-F7500/F7700

E Model CDX-F7700

Photo: CDX-F7700

• The tuner and CD sections have no adjustments.

Model Name Using Similar Mechanism

CDX-F7700/F7705X

CD Drive Mechanism Type

MG-611MA-186//K

Optical Pick-up Name

KSS1000E

SPECIFICATIONS CD player section Signal-to-noise ratio Frequency response Wow and flutter

General 120 dB 10 – 20,000 Hz Below measurable limit

Outputs

Inputs

Tuner section FM Tuning range Aerial terminal Intermediate frequency Usable sensitivity Selectivity Signal-to-noise ratio

87.5 – 108.0 MHz External aerial connector 10.7 MHz/450 kHz 9 dBf 75 dB at 400 kHz 67 dB (stereo), 69 dB (mono) Harmonic distortion at 1 kHz 0.5% (stereo), 0.3% (mono) Separation 35 dB at 1 kHz Frequency response 30 – 15,000 Hz MW/LW Tuning range Aerial terminal Intermediate frequency Sensitivity

Tone controls Loudness Power requirements Dimensions Mounting dimensions Mass Supplied accessories

MW: 531 – 1,620 kHz LW: 153 – 279 kHz External aerial connector 10.7 MHz/450 kHz MW: 30 µV LW: 40 µV

Audio output terminals (front/rear) Subwoofer output terminal (mono) Power aerial relay control terminal Power amplifier control terminal Telephone ATT control terminal Illumination control terminal BUS control input terminal BUS audio input or AUX IN terminal Remote controller input terminal Aerial input terminal Bass ±8 dB at 100 Hz Treble ±8 dB at 10 kHz +8 dB at 100 Hz +2 dB at 10 kHz 12 V DC car battery (negative earth) Approx. 178 × 50 × 178 mm (w/h/d) Approx. 182 × 53 × 161 mm (w/h/d) Approx. 1.3 kg Parts for installation and connections (1 set) Front panel case (1) Card remote commander RM-X140

Design and specifications are subject to change without notice.

Power amplifier section Outputs

Speaker outputs (sure seal connectors) Speaker impedance 4 – 8 ohms Maximum power output CDX-F7700: 52 W × 4 (at 4 ohms) CDX-F7500: 50 W × 4 (at 4 ohms)

FM/MW/LW COMPACT DISC PLAYER 9-877-604-02

Sony Corporation

2004D04-1 © 2004. 04

e Vehicle Company Published by Sony Engineering Corporation

1

CDX-F7500/F7700

SERVICE NOTES NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic breakdown because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic breakdown and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care.

CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. If the optical pick-up block is defective, please replace the whole optical pick-up block. Never turn the semi-fixed resistor located at the side of optical pick-up block. optical pick-up

NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. Notes on Chip Component Replacement • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat.

semi-fixed resistor

TEST DISCS This set can playback CD-R and CD-ROM discs. The following test discs should be used to check the capability: CD-R test disc TCD-R082LMT (Part No. J-2502-063-1) CD-RW test disc TCD-W082L (Part No. J-2502-063-2)

This label is located on the bottom of the chassis.

SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

2

CDX-F7500/F7700

Notes on CD-Rs (recordable CDs)/CD-RWs (rewritable CDs) This unit can play the following discs: Type of discs

Label on the disc

z

UNLEADED SOLDER Boards requiring use of unleaded solder are printed with the lead free mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.)

: LEAD FREE MARK Audio CD

MP3 files

• Some CD-Rs/CD-RWs (depending on the equipment used for its recording or the condition of the disc) may not play on this unit. • You cannot play a CD-R/CD-RW that is not finalized∗. • You can play MP3 files recorded on CD-ROMs, CD-Rs, and CD-RWs. • A CD-R/CD-RW to which a session can be added can be played.

Unleaded solder has the following characteristics. • Unleaded solder melts at a temperature about 40°C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350°C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! • Strong viscosity Unleaded solder is more viscous (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. • Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder.

∗ A process necessary for a recorded CD-R/CD-RW disc to be played on the audio CD player. EXTENSION CABLE AND SERVICE POSITION When repairing or servicing this set, connect the jig (extension cable) as shown below. • Connect the MAIN board (CN751) and the SERVO board (CN2) with the extension cable (Part No. J-2502-076-1).

MAIN BOARD CNP301

J-2502-076-1

SERVO BOARD CN2

3

CDX-F7500/F7700

TABLE OF CONTENTS 1. GENERAL Location of Controls ................................................................ 5 Connections ............................................................................. 6

2. DISASSEMBLY 2-1. Sub Panel Assy (CD) ........................................................... 9 2-2. CD Mechanism Block ......................................................... 9 2-3. Main Board ....................................................................... 10 2-4. Chassis (T) Sub Assy ........................................................ 10 2-5. Roller Arm Assy ................................................................ 11 2-6. Chassis (OP) Assy ............................................................. 11 2-7. Optical Pick-up ................................................................. 12 2-8. SL Motor Assy (M902) ..................................................... 12 2-9. LE Motor Assy (M903) ..................................................... 13 2-10. Servo Board ....................................................................... 13

3. DIAGRAMS 3-1. 3-2. 3-3. 3-4. 3-5.

IC Pin Descriptions ........................................................... 14 Block Diagram –CD Section– ........................................... 20 Block Diagram –Main Section– ........................................ 21 Block Diagram –Display Section– .................................... 22 Note for Printed Wiring Boards and Schematic Diagrams .......................................................... 23 3-6. Waveforms ......................................................................... 23 3-7. Circuit Boards Location .................................................... 23 3-8. Schematic Diagram –CD Mechanism Section (1/2)– ....... 24 3-9. Schematic Diagram –CD Mechanism Section (2/2)– ....... 25 3-10. Printed Wiring Boards –CD Mechanism Section– ............ 26 3-11. Schematic Diagram –Main Section (1/3)– ........................ 27 3-12. Schematic Diagram –Main Section (2/3)– ........................ 28 3-13. Schematic Diagram –Main Section (3/3)– ........................ 29 3-14. Printed Wiring Boards –Main Section– ............................ 30 3-15. Printed Wiring Board –Sub Section– ................................ 32 3-16. Schematic Diagram –Sub Section– ................................... 33 3-17. Printed Wiring Board –Key Section– ................................ 34 3-18. Schematic Diagram –Key Section– ................................... 35 3-19. IC Block Diagrams ............................................................ 36

4. EXPLODED VIEWS 4-1. 4-2. 4-3. 4-4. 4-5. 4-6.

Main Section ..................................................................... 38 Front Panel Section ........................................................... 39 CD Mechanism Section (1) ............................................... 40 CD Mechanism Section (2) ............................................... 41 CD Mechanism Section (3) ............................................... 42 CD Mechanism Section (4) ............................................... 43

5. ELECTRICAL PARTS LIST ......................................... 44

4

CDX-F7500/F7700 SECTION 1 GENERAL Location of controls Card remote commander RM-X140 Refer to the pages listed for details. a DSPL/PTY (display mode change/ programme type) button 13, 16, 19, 22, 25 b Number buttons Radio: To store stations/receive stored stations. CD/MD: (1): REP 14 (2): SHUF 15 (6): PAUSE*1 12 Sound: (5): BBE MP*1 24 c DSO button 27 d MENU button To display the menus. e SOURCE (Power on/Radio/CD/MD*2/ AUX*3) button To select the source. f SEEK/AMS () buttons b Volume control dial/SOUND button Rotate to: – Adjust the volume. – Adjust the sound settings. Press to: – Select the sound items. 3 qs DISC (ALBUM)/PRESET (+/–) buttons 4 MODE button 6 DSO button 7 SCRL (scroll) button 8 Display window 9 Z (eject) button (located on the front side of the unit, behind the front panel) 12, 12 0 OPEN button 10, 12, 12 qa Receptor for the card remote commander

qd OFF (Stop/Power off) button* qf EQ7 button qg RESET button (located on the front side of the unit, behind the front panel) 10 qh SOURCE button qj Number buttons qk AF/TA button 19, 20, 21 ql IMAGE button 28 * Warning when installing in a car without an ACC (accessory) position on the ignition switch After turning off the ignition, be sure to press and hold (OFF) on the unit until the display disappears. Otherwise, the display does not turn off and this causes battery drain.

qd OFF (Stop/Power off) button* qf EQ7 button qg RESET button (located on the front side of the unit, behind the front panel) 10 qh SOURCE button qj Number buttons qk AF/TA button 19, 20, 20, 21, 21 ql IMAGE button 28 * Warning when installing in a car without an ACC (accessory) position on the ignition switch After turning off the ignition, be sure to press and hold (OFF) on the unit until the display disappears. Otherwise, the display does not turn off and this causes battery drain.

6

5

CDX-F7500/F7700

Connections (AEP, UK Model) Auxiliary equipment such as portable DVD player (not supplied) Zusätzliche Geräte wie z. B. der tragbare DVDPlayer (nicht mitgeliefert) Equipement auxiliaire comme un lecteur de DVD portable (non fourni) Apparecchio ausiliario quale un lettore DVD portatile (non in dotazione) Optionele apparatuur zoals de draagbare DVDspeler (niet bijgeleverd)

3 *2

*1 Note for the aerial connecting If your car aerial is an ISO (International Organisation for Standardisation) type, use the supplied adaptor 5 to connect it. First connect the car aerial to the supplied adaptor, then connect it to the aerial jack of the master unit. *2 RCA pin cord (not supplied) 3 * Supplied with XA-C30 *4 Be sure to match the color-coded cord for audio to the appropriate jacks from the unit. If you connect an optional CD/MD unit, you cannot use AUX IN terminal. *5 Supplied with the auxiliary equipment 6 * Insert with the cord upwards *7 Supplied with the CD/MD changer

*5 *2

*1 Hinweis zum Anschließen der Antenne Wenn Ihre Fahrzeugantenne der ISO-Norm (ISO = International Organization for Standardization - Internationale Normungsgemeinschaft) entspricht, schließen Sie sie mithilfe des mitgelieferten Adapters 5 an. Verbinden Sie zuerst die Fahrzeugantenne mit dem mitgelieferten Adapter und verbinden Sie diesen dann mit der Antennenbuchse des Hauptgeräts. *2 Cinchkabel (nicht mitgeliefert) 3 * Mit dem XA-C30 geliefert *4 Achten Sie darauf, das farbcodierte Audiokabel mit den richtigen Buchsenam Gerät zu verbinden. Wenn ein gesondert erhältliches CD/MD-Gerät angeschlossenist, kann der AnschlussAUX IN nicht verwendet werden. *5 mit den Zusatzgeräten mitgeliefert

*3

*2

AUDIO OUT FRONT

L

L

R

R

REMOTE IN

Signalquellenwähler (nicht mitgeliefert) Sélecteur de source (non fourni)

SUB OUT (MONO) from car aerial *1 von Autoantenne *1 de l’antenne de la voiture *1 dall’antenna dell’auto *1 van een auto-antenne *1

*7

Selettore di fonte (non in dotazione)

*6 AUDIO OUT REAR

5

*1 Remarque sur le raccordement de l’antenne Si votre antenne de voiture est de type ISO (Organisation internationale de normalisation), utilisez l’adaptateur fourni 5 pour la raccorder. Raccordez d’abord l’antenne de voiture à l’adaptateur fourni et, ensuite, à la prise d’antenne de l’appareil principal. *2 Cordon à broche RCA (non fourni) *3 Fourni avec le XA-C30

Source selector (not supplied)

*4 Veillez à faire correspondre le code de couleurs audio aux fiches correspondantesde l’appareil. Si vous raccordez un appareil CD ou MD en option, vous ne pouvez pas utiliser la borne AUX IN. *5 fourni avec l’équipement auxiliaire *6 Insérez avec le câble vers le haut

Geluidsbronkiezer (niet bijgeleverd)

Fuse (10 A) Sicherung (10 A) Fusible (10 A) Fusibile (10 A) Zekering (10 A)

BUS CONTROL IN

XA-C30

*4 Assicurarsiche i cavi differenziati in base al colore per l’audio corrispondano alle prese appropriate dell’apparecchio. Se viene collegato un apparecchio CD/MD opzionale, non è possibile utilizzare il terminale AUX IN. *5 in dotazione con l’apparecchio ausiliario *6 Inserire con il cavo rivolto verso l’alto

*7 In dotazione con il cambia CD/MD

*6 Mit dem Kabel nach oben einsetzen *7 Mit dem CD/MD-Wechsler geliefert

BUS AUDIO IN/ AUX IN*4

*1 Nota per il collegamento dell’antenna Se l’antenna dell’auto è di tipo ISO (International Organization for Standardization), utilizzare l’adattatore 5 in dotazione per collegarla. Collegare prima l’antenna della macchina all’adattatore in dotazione, quindi collegarla alla presa dell’antenna dell’apparecchio principale. *2 Cavo a piedini RCA (non in dotazione) *3 In dotazione con il modello XA-C30

*1 Opmerking bij de antenne-aansluiting Indien uw auto is uitgerust met een antenne van het type ISO (International Organisation for Standardization), moet u die aansluiten met behulp van de bijgeleverde adapter 5. Sluit eerst de auto-antenne aan op de bijgeleverde adapter en vervolgens de antennestekker op het hoofdtoestel. *2 Tulpstekkersnoer (niet bijgeleverd) *3 Geleverd met de XA-C30 *4 Zorg ervoor dat de kleurcode voor audio overeenkomt met de betreffende aansluitingen op het toestel. Als u los verkrijgbare CD/MD-apparatuur aansluit, kunt u de AUX IN aansluiting niet gebruiken. *5 Geleverd bij de optionele apparatuur *6 Plaatsen met het snoer naar boven

*7 Geleverd met de CD/MD-wisselaar

*7 Fourni avec le changeur de CD/MD

7 Max. supply current 0.3 A max. Versorgungsstrom 0,3 A Courant d’alimentation maximum 0,3 A Alimentazione massima fornita 0,3 A Max. voedingsstroom 0,3 A

*3

AMP REM

Blue/white striped Blauweiß gestreift Rayé bleu/blanc Rigato blu e bianco Blauw/wit gestreept

ATT

Light blue Hellblau Bleu ciel Azzurro Lichtblauw

A

B

5

7

from the car’s power connector vom Stromanschluss des Fahrzeugs du connecteur d’alimentation de la voiture dal connettore di alimentazione dell’auto van de autovoedingsstekker

1

4 See “Power connection diagram” on the reverse side for details. Näheres dazu finden Sie im „Stromanschlussdiagramm“. Blättern Sie dazu bitte um. Voir le « Schéma de connexion d’alimentation » au verso pour plus de détails. Per ulteriori informazioni, vedere “Schema dei collegamenti di alimentazione” che si trova sul retro. Zie "Voedingsaansluitschema" op de achterkant voor meer details.

1

3

5

7

2

4

6

8

from the car’s speaker connector vom Lautsprecheranschluss des Fahrzeugs du connecteur de haut-parleur de la voiture dal connettore del diffusore dell’auto van de autoluidsprekerstekker

4

Yellow Gelb Jaune Giallo Geel

continuous power supply permanente Stromversorgung alimentation continue alimentazione continua continu voeding

5

Blue Blau Bleu Blu Blauw

power aerial control Motorantennensteuerung antenne électrique comando dell’antenna elettrica elektrische antenne

6

Orange/White switched illumination power supply geschaltete Orangeweiß gestreift Beleuchtungsstromversorgung alimentation de l’éclairage Rayé orange/ blanc commuté alimentazione illuminazione Arancione/ bianco commutata pgeschakelde voeding voor Oranje/wit verlichting

6

7

Red Rot Rouge Rosso Rood

switched power supply geschaltete Stromversorgung alimentation commutée alimentazione commutata geschakelde voeding

8

Black Schwarz Noir Nero Zwart

earth Masse masse terra aarding

8

2

Positions 1, 2 and 3 do not have pins. An Position 1, 2 und 3 befinden sich keine Stifte. Les positions 1, 2 et 3 ne comportent pas de broches. Le posizioni 1, 2 e 3 non hanno piedini. De posities 1, 2 en 3 hebben geen pinnen.

Speaker, Rear, Right Lautsprecher hinten rechts Haut-parleur, arrière, droit Diffusore, posteriore, destro Luidspreker, achter, rechts

5

–

Speaker, Rear, Right Lautsprecher hinten rechts Haut-parleur, arrière, droit Diffusore, posteriore, destro Luidspreker, achter, rechts

6

+

Speaker, Front, Right Lautsprecher vorne rechts Haut-parleur, avant, droit Diffusore, anteriore, destro Luidspreker, voor, rechts

7

–

Speaker, Front, Right Lautsprecher vorne rechts Haut-parleur, avant, droit Diffusore, anteriore, destro Luidspreker, voor, rechts

8

Purple Violett Mauve Viola Paars

3

4

+

Grey Grau Gris Grigio Grijs

+

Speaker, Front, Left Lautsprecher vorne links Haut-parleur, avant, gauche Diffusore, anteriore, sinistro Luidspreker, voor, links

–

Speaker, Front, Left Lautsprecher vorne links Haut-parleur, avant, gauche Diffusore, anteriore, sinistro Luidspreker, voor, links

+

Speaker, Rear, Left Lautsprecher hinten links Haut-parleur, arrière, gauche Diffusore, posteriore, sinistro Luidspreker, achter, links

–

Speaker, Rear, Left Lautsprecher hinten links Haut-parleur, arrière, gauche Diffusore, posteriore, sinistro Luidspreker, achter, links

White Weiß Blanc Bianco Wit

Green Grün Vert Verde Groen

Negative polarity positions 2, 4, 6, and 8 have striped leads. An den negativ gepolten Positionen 2, 4, 6 und 8 befinden sich gestreifte Adern. Les positions de polarité négative 2, 4, 6 et 8 sont dotées de cordons rayés. Le posizioni a polarità negativa 2, 4, 6 e 8 hanno cavi rigati. De posities voor negatieve polariteit (2, 4, 6 en 8) hebben gestreepte kabels.

Connection diagram (3)

Anschlussdiagramm (3)

Schéma de raccordement (3)

Schema di collegamento (3)

Aansluitschema (3)

A To

A An AMP REMOTE IN des gesondert erhältlichen Endverstärkers

A Au niveau du AMP REMOTE IN d’un amplificateur de puissance

A A AMP REMOTE IN di un amplificatore di potenza opzionale

A Naar AMP REMOTE IN van een optionele vermogensversterker

AMP REMOTE IN of an optional power amplifier This connection is only for amplifiers. Connecting any other system may damage the unit.

B To

the interface cable of a car telephone

Warning If you have a power aerial without a relay box, connecting this unit with the supplied power connecting lead 7 may damage the aerial. Notes on the control leads • The power aerial control lead (blue) supplies +12 V DC when you turn on the tuner, or when you activate the AF (Alternative Frequency) or TA (Traffic Announcement) function. • When your car has built-in FM/MW/LW aerial in the rear/side glass, connect the power aerial control lead (blue) or the accessorypower input lead (red) to the power terminal of the existing aerial booster. For details, consult your dealer. • A power aerial without a relay box cannot be used with this unit. Memory hold connection When the yellow power input lead is connected, power will always be supplied to the memory circuit even when the ignition switch is turned off. Notes on speaker connection • Before connecting the speakers, turn the unit off. • Use speakers with an impedance of 4 to 8 ohms, and with adequate power handling capacities to avoid its damage. • Do not connect the speaker terminals to the car chassis,or connect the terminals of the right speakers with those of the left speaker. • Do not connect the earth lead of this unit to the negative (–) terminal of the speaker. • Do not attempt to connect the speakers in parallel. • Connect only passive speakers. Connecting active speakers (with built-in amplifiers) to the speaker terminals may damage the unit. • To avoid a malfunction, do not use the built-in speaker leads installed in your car if the unit shares a common negative (–) lead for the right and left speakers. • Do not connect the unit’s speaker leads to each other. Note on connection If speaker and amplifier are not connected correctly, “Failure” appears in the display. In this case, make sure the speaker and amplifier are connected correctly.

Dieser Anschluss ist ausschließlich für Verstärker gedacht. Schließen Sie nichts anderes daran an. Andernfalls kann das Gerät beschädigt werden.

Questo collegamento è riservato esclusivamente agli amplificatori. Non collegare un tipo di sistema diverso onde evitare di causare danni all’apparecchio.

Deze aansluiting is alleen bedoeld voor versterkers. Door een ander systeem aan te sluiten kan het apparaat worden beschadigd.

B An Schnittstellenkabel eines Autotelefons

B Vers le cordon de liaison d’un téléphone de voiture

B Al cavo di interfaccia di un telefono per auto

B Naar het interface-snoer van een autotelefoon

Warnung

Avertissement

Avvertenza

Opgelet

Wenn Sie eine Motorantenne ohne Relaiskästchenverwenden, kann durch Anschließen dieses Geräts mit dem mitgelieferten Stromversorgungskabel 7 die Antenne beschädigt werden. Hinweise zu den Steuerleitungen • Die Motorantennen-Steuerleitung (blau) liefert + 12 V Gleichstrom, wenn Sie den Tuner einschalten oder die AF(Alternativfrequenzsuche) oder die TA-Funktion (Verkehrsdurchsagen) aktivieren. • Wenn das Fahrzeug mit einer in der Heck-/Seitenfensterscheibe integrierten UKW/MW/LW-Antenne ausgestattet ist, schließen Sie die Motorantennen-Steuerleitung (blau) oder die Zubehörstromversorgungsleitung (rot) an den Stromversorgungsanschluss des vorhandenen Antennenverstärkers an. Näheres dazu erfahren Sie bei Ihrem Händler. • Es kann nur eine Motorantenne mit Relaiskästchen angeschlossen werden. Stromversorgung des Speichers Wenn die gelbe Stromversorgungsleitung angeschlossen ist, wird der Speicher stets (auch bei ausgeschalteter Zündung) mit Strom versorgt. Hinweise zum Lautsprecheranschluss • Schalten Sie das Gerät aus, bevor Sie die Lautsprecher anschließen. • Verwenden Sie Lautsprecher mit einer Impedanz zwischen 4 und 8 Ohm und ausreichender Belastbarkeit. Ansonsten können die Lautsprecher beschädigt werden. • Verbinden Sie die Lautsprecheranschlüsse nicht mit dem Wagenchassis und verbinden Sie auch nicht die Anschlüsse des rechten mit denen des linken Lautsprechers. • Verbinden Sie die Masseleitung dieses Geräts nicht mit dem negativen (–) Lautsprecheranschluss.

Si vous disposez d’une antenne électrique sans boîtier de relais, le branchement de cet appareil au moyen du cordon d’alimentation fourni 7 risque d’endommager l’antenne.

Quando si collega l’apparecchio con il cavo di alimentazione in dotazione 7, si potrebbe danneggiare l’antenna elettrica se questa è priva di scatola a relè. Note sui cavi di controllo • Il cavo (blu) di controllo dell’antenna elettrica fornisce alimentazione pari a +12 V CC quando si attiva il sintonizzatore oppure la funzione TA (notiziario sul traffico) o AF (frequenza alternativa). • Se l’automobile è dotata di antenna FM/MW/LW incorporata nel vetro posteriore/laterale, collegare il cavo (blu) di controllo dell’antenna elettrica o il cavo (rosso) di ingresso dell’alimentazione accessoria al terminale di alimentazione del preamplificatore dell’antenna esistente. Per ulteriori informazioni, consultare il proprio fornitore. • Non è possibile usare un’antenna elettrica senza scatola a relè con questo apparecchio. Collegamento per la conservazione della memoria Quando il cavo di ingresso alimentazione giallo è collegato, viene sempre fornita alimentazione al circuito di memoria anche quando l’interruttore di accensione è spento. Note sul collegamento dei diffusori • Prima di collegare i diffusori spegnere l’apparecchio. • Usare diffusori di impedenza compresa tra 4 e 8 ohm e con capacità di potenza adeguata, altrimenti i diffusori potrebbero venire danneggiati. • Non collegare i terminali del sistema diffusori al telaio dell’auto e non collegare i terminali del diffusore destro a quelli del diffusore sinistro. • Non collegare il cavo di terra di questo apparecchio al terminale negativo (–) del diffusore. • Non collegare i diffusori in parallelo. • Assicurarsi di collegare soltanto diffusori passivi, poiché il collegamento di diffusori attivi, dotati di amplificatori incorporati, ai terminali dei diffusori potrebbe danneggiare l’apparecchio. • Per evitare problemi di funzionamento, non utilizzare i cavi dei diffusori incorporati installati nell’automobile se l’apparecchio condivide un cavo comune negativo (–) per i diffusori destro e sinistro. • Non collegare fra loro i cavi dei diffusori dell’apparecchio. Nota sui collegamenti Se l’amplificatore e il diffusore non sono collegati correttamente, “Failure” viene visualizzato nel display. In tal caso, accertarsi che l’amplificatore e il diffusore siano collegati correttamente.

Indien u een elektrische antenne hebt zonder relaiskast, kan het aansluiten van deze eenheid met het bijgeleverde netsnoer 7 de antenne beschadigen. Opmerkingen betreffende de aansluitsnoeren • De antennevoedingskabel (blauw) levert +12 V gelijkstroom wanneer u de tuner inschakelt of de AF (Alternative Frequency) of TA (Traffic Announcement) functie activeert. • Wanneer uw auto is uitgerust met een FM/MW/LW-antenne in de achterruit/voorruit, moet u de antennevoedingskabel (blauw) of de hulpvoedingskabel (rood) aansluiten op de voedingsingang van de bestaande antenneversterker. Raadpleeg uw dealer voor meer details. • Met dit apparaat is het niet mogelijk een automatische antenne zonder relaiskast te gebruiken. Instandhouden van het geheugen Zolang de gele voedingskabel is aangesloten, blijft de stroomvoorziening van het geheugen intact, ook wanneer het contact van de auto wordt uitgeschakeld. Opmerkingen betreffende het aansluiten van de luidsprekers • Zorg dat het apparaat is uitgeschakeld, alvorens de luidsprekers aan te sluiten. • Gebruik luidsprekers met een impedantie van 4 tot 8 Ohm en let op dat die het vermogen van de versterker kunnen verwerken. Als dit wordt verzuimd, kunnen de luidsprekers ernstig beschadigd raken. • Verbind in geen geval de aansluitingen van de luidsprekers met het chassisvan de auto en sluit de aansluitingen van de rechter en linker luidspreker niet op elkaar aan. • Verbind de aardingskabel van dit apparaat niet met de negatieve (–) aansluiting van de luidspreker. • Probeer nooit de luidsprekers parallel aan te sluiten. • Sluit geen actieve luidsprekers (met ingebouwde versterkers) aan op de luidspreker-aansluiting van dit apparaat. Dit zal leiden tot beschadiging van het apparaat. Sluit dus altijd uitsluitend luidsprekers zonder ingebouwde versterker aan. • Om defecten te vermijden mag u de bestaande luidsprekerbedrading in uw auto niet gebruiken wanneer er een gemeenschappelijke negatieve (–) draad is voor de rechter en linker luidsprekers. • Verbind de luidsprekerdraden niet met elkaar. Opmerking over aansluiten Als de luidspreker en versterker niet correct zijn aangesloten, wordt "Failure" in het display weergegeven. In dit geval moet u zorgen dat de luidspreker en versterker correct zijn aangesloten.

• V ersuchen Sie nicht, Lautsprecher parallel anzuschließen. • An die Lautsprecheranschlüsse dieses Geräts dürfen nur Passivlautsprecher angeschlossen werden. Schließen Sie keine Aktivlautsprecher (Lautsprecher mit eingebauten Verstärkern) an, da das Gerät sonst beschädigt werden könnte. • Um Fehlfunktionen zu vermeiden, verwenden Sie nicht die im Fahrzeug installierten, integrierten Lautsprecherleitungen, wenn eine gemeinsame negative (–) Leitung für den rechten und den linken Lautsprecher verwendet wird. • Verbinden Sie nicht die Lautsprecherkabel des Geräts miteinander.

Hinweis zum Anschließen Wenn Lautsprecher und Verstärker nicht richtig angeschlossen sind, erscheint „ Failure “ im Display. Vergewissern Sie sich in diesem Fall, dass Lautsprecher und Verstärker richtig angeschlossen sind.

6

facultatif Ce raccordement existe seulement pour les amplificateurs. Le raccordement à tout autre système peut endommager l’appareil.

Remarques sur les fils de commande • Le fil de commande (bleu) fournit du courant continu de +12 V lorsque vous mettez le tuner sous tension ou lorsque vous activez la fonction AF (fréquence alternative) ou TA (informations circulation). • Lorsque votre voiture est équipée d’une antenne FM/MW (PO)/LW (GO) intégrée dans la vitre arrière/latérale, raccordez le fil de commande de l’antenne (bleu) ou l’entrée d’alimentation des accessoires (rouge) au bornier de l’amplificateur d’antenne existant. Pour plus de détails, consultez votre revendeur. • Une antenne électrique sans boîtier de relais ne peut pas être utilisée avec cet appareil. Raccordementpour la conservation de la mémoire Lorsque le fil d’entrée d’alimentation jaune est connecté, le circuit de la mémoire est alimenté en permanence même si la clé de contact est en position d’arrêt. Remarques sur le raccordement des haut-parleurs • Avant de raccorder les haut-parleurs, mettre l’appareil hors tension. • Utiliser des haut-parleurs ayant une impédance de 4 à 8 ohms et une capacité adéquate sous peine de les endommager. • Ne pas raccorder les bornes du système de haut-parleurs au châssis de la voiture et ne pas connecter les bornes du haut-parleur droit à celles du haut-parleur gauche. • Ne pas raccorder le câble de masse de cet appareil à la borne négative (–) du haut-parleur. • Ne pas tenter de raccorder les haut-parleurs en parallèle. • Ne pas connecter d’enceintes acoustiques actives (avec amplificateurs intégrés) aux bornes d’enceinte de cet appareil, pour éviter d’endommager l’appareil. Veiller à raccorder des enceintes passives uniquement. • Pour éviter tout dysfonctionnement, n’utilisez pas les fils des hautparleurs intégrés installés dans votre voiture si l’appareil dispose d’un fil négatif commun (–) pour les haut-parleurs droit et gauche. • Ne raccordez pas entre eux les cordons des haut-parleurs de l’appareil. Remarque sur le raccordement Si les enceintes et l’amplificateur ne sont pas raccordés correctement, le message « Failure » s’affiche. Dans ce cas, assurez-vous que les enceintes et l’amplificateur sont raccordés correctement.

CDX-F7500/F7700

Connections (E Model)

7

CDX-F7500/F7700 SECTION 2 DISASSEMBLY Note : This set can be disassemble according to the following sequence.

SET 2-1.

SUB PANEL ASSY (CD) (Page 9)

2-2.

CD MECHANISM BLOCK (Page 9)

2-3.

MAIN BOARD (Page 10)

2-7.

8

2-4.

CHASSIS (T) SUB ASSY (Page 10)

2-5.

ROLLER ARM ASSY (Page 11)

2-10. SERVO BOARD (Page 13)

2-6.

CHASSIS (OP) ASSY (Page 11)

2-8.

SL MOTOR ASSY (M902) (Page 12)

OPTICAL PICK-UP (Page 12)

2-9.

LE MOTOR ASSY (M903) (Page 13)

CDX-F7500/F7700

Note : Follow the disassembly procedure in the numerical order given.

2-1. SUB PANEL ASSY (CD)

3 two claws

4 2 two claws

CN601 1 two screws (+PTT 2.6 x 6) 5 sub panel assy (CD)

2-2. CD MECHANISM BLOCK

7 bracket (CD) 5 CD mechanism block 6 two screws (+PTT 2.6 x 6)

2 screw (+PTT 2.6 x 6)

3

1 screw (+PTT 2.6 x 6)

4 CNP301

9

CDX-F7500/F7700

2-3. MAIN BOARD 6 cord 2 two screws (+PTT 2.6 x 8)

1 three ground point screws (+PTT 2.6 x 6)

5 screw (+PTT 2.6 x 8) 4 CN401

3 MAIN board

4 insulating sheet

2-4. CHASSIS (T) SUB ASSY

4 claw 2 two screws (+P 1.7 x 2.2) 1 two screws (+P 1.7 x 2.2)

6 chassis (T) sub assy

5 SENSOR board

3 claw

10

CDX-F7500/F7700

2-5. ROLLER ARM ASSY

3 washer (1.1 – 2.5)

5 roller arm assy

4 worm wheel (RA)

2 spring (RAR)

1 spring (RAL)

2-6. CHASSIS (OP) ASSY

8 qa chassis (OP) assy

0 compression spring (damper)

lever (D) 4 washer 1 CN1 6 9 two compression springs (damper)

5 gear (LE1)

7

slider (R) 3 tension coil spring (KF) 2 Remove the six solderings.

11

CDX-F7500/F7700

2-7. OPTICAL PICK-UP

2 chucking arm sub assy

5 claw

1 tension coil spring (CHKG)

7 optical pick-up

6 main shaft

4 rack (SL) 3 screw (+B 1.4 x 5)

2-8. SL MOTOR ASSY (M902)

1 screw (+P 1.4 x 1.8)

2 SL motor assy (M902)

12

CDX-F7500/F7700

2-9. LE MOTOR ASSY (M903)

8 screw (+M 1.7 x 2.5)

0 worm (LEB) assy

9 bearing (LEB)

qf two toothed lock screws (+M 1.4 )

2 washer

qa screw (+M 1.7 x 2.5)

3 gear (LE1)

lever (D)

4

bracket (LEM) qs screw (+M 1.7 x 2.5)

qd

qg LE motor assy (M903)

5

6 screw (+P 1.7 x 2.2)

slider (R) 7 leaf spring (LE) 1 Remove the soldering.

2-10. SERVO BOARD

1 Remove the eight solderings.

6 SERVO board

2 Remove the three solderings. 4 toothed lock screw (M 1.7)

5 claw

3 CN1

13

CDX-F7500/F7700 SECTION 3 DIAGRAMS 3-1. IC PIN DESCRIPTIONS • IC3 CXD3059BR (DIGITAL SERVO/DIGITAL SIGNAL PROCESSOR) (SERVO BOARD (1/2)) Pin No. Pin Name I/O Pin Description 1 MIRR I/O Mirrer signal input/output

14

2 3

DFCT FOK

I/O I/O

Defect signal input/output Focus OK signal input/output

4 5

VSS LOCK

— I/O

Ground pin Not used in this set. (Open)

6 7

MDP SSTP

O I

Spindle motor servo control signal output Disc most inner detection signal input

8 9

IOVSS1 SFDR

— O

Digital ground pin for I/O Sled drive signal output

10 11

SRDR TFDR

O O

Sled drive signal output Tracking drive signal output

12 13

TRDR FFDR

O O

Tracking drive signal output Focus drive signal output

14 15

FRDR IOVDD1

O —

Focus drive signal output Digital power supply pin for I/O

16 17

AVDD0 AVSS0

— —

Analog power supply pin for I/O Analog ground pin

18 19

NC E

— I

Not used. (Open) E signal input

20 21

F TEI

I I

F signal input Tracking error signal input from the DSSP block

22 23 24

TEO FEI FEO

O I O

Tracking error signal output to the RF amp block Focus error signal input from the DSSP block Focus error signal output form the RF amp block

25

VC

I/O

26 27

A B

I I

A signal input B signal input

28 29

C D

I I

C signal input D signal input

30 31

NC AVDD4

— —

Not used. (Open) Analog power supply pin

32

RFDCO

I/O

RFDC signal output RFDC signal input from the DSSP block by command select

33 34

PDSENS AC SUM

I O

Reference voltage input for PD RFAC suming amp signal output

35 36

EQ IN LD

I O

Equalizer circuit signal input APC amp signal output

37 38

PD NC

I —

APC amp signal input Not used. (Open)

39 40

RFC AVSS4

I —

EQ cut off frequency adjustment input Analog ground pin

41 42

RFACO RFACI

O I

RFAC signal output RFAC signal input or EFM signal input

43 44

AVDD3 BIAS

— I

Analog power supply pin Asymmetry circuit constant current input

45 46

ASYI ASYO

I O

Asymmetry comparate voltage input EFM full swing signal output

47 48

VPCO VCTL

O I

Charge pomp output for wideband EFM PLL VCO2 control voltage input for wideband EFM PLL

49

AVSS3

—

Analog ground pin

VC voltage output to the RF amp block Center voltage input from the DSSP block by command select

CDX-F7500/F7700

Pin No. 50

Pin Name CLTV

I/O I

Pin Description

51 52

FILO FILI

O I

Filter signal output for master PLL Filter signal input for master PLL

53 54

PCO AVDD5

O —

Charge pomp output for master PLL Analog power supply pin

55 56

DDVROUT DDVRSEN

O I

DC/DC converter output DC/DC converter output voltage monitor signal input

57 58

AVSS5 DDCR

— I

Analog ground pin Reset signal input for DC/DC converter

59 60

NC BCKI

— I

Not used. (Open) D/A interface bit clock signal input

61 62

PCMDI LRCKI

I I

D/A interface serial data signal input D/A interface LR clock signal input

63 64

LRCK VSS

O —

D/A interface LR clock signal output Digital ground pin for internal

65 66

PCMD BCK

O O

D/A interface serial data signal output D/A interface bit clock signal output

67 68

VDD EMPH

— O

Digital power supply pin for internal Not used in this set. (Open)

69 70

EMPHI IOVDD2

I —

Not used in this set. (Fixed at “L”.) Digital power supply pin for I/O

71 72, 73

DOUT TEST

O I

Digital out signal output Test pin Normally “L”.

74 75 76

IOVSS2 NC XVSS

— — —

Digital ground pin for I/O Not used in this set. (Open) Ground pin for master clock

77 78

XTAO XTAI

O I

Crystal oscillation circuit output (16.9344 MHz) Crystal oscillation circuit input (16.9344 MHz)

79 80

XVDD AVDD1

— —

Power supply pin for master clock Analog power supply pin

81 82

AOUT1 VREFL

O O

L channel analog signal output L channel reference voltage output

83 84

AVSS1 AVSS2

— —

Analog ground pin Analog ground pin

85 86

VREFR AOUT2

O O

R channel reference voltage output R channel analog signal output

87 88

AVDD2 NC

— —

Analog power supply pin Not used. (Open)

89 90

IOVDD0 RMUT

— O

Digital power supply pin for I/O R channel “O” detection flug output

91 92

LMUT NC

O —

L channel “O” detection flug output Not used. (Open)

93 94

XTSL IOVSS0

I —

X’tal select signal input 16.9344 MHz: “L”, 33.8688 MHz: “H” Digital ground pin for I/O

95 96

XTACN SQSO

I O

Oscillation circuit control input “H”: Oscillation start, “L”: Oscillation stop Sub 80 bit and PCM peak, level data signal output CD text data signal output

97 98

SQCK SBSO

I O

Clock signal input for SQSO read out Sub P-W serial data signal output Not used in this set. (Open)

99 100

EXCK XRST

I I

Clock signal input for SBSO read out Not used in this set. (Open) System reset signal input “L”: reset

101 102

SYSM DATA

I I

Mute signal input “H”: mute Serial data signal input

103

VSS

—

Digital ground pin for internal

VCO1 control voltage input

Not used in this set. (Fixed at “L”.)

15

CDX-F7500/F7700

Pin No. 104

Pin Name XLAT

I/O I

Latch signal input

105 106

CLOK VDD

I —

Serial data transfer clock signal input Digital power supply pin for internal

107 108

SENS SCLK

O I

SENS signal output Clock signal input for SENS serial data read out

109 110

ATSK WFCK

I/O O

111 112

XUGF XPCK

O O

XUGF signal output XPCK signal output

113 114

GFS C2PO

O O

GFS signal output C2PO signal output

115 116

SCOR VDD

O —

Sub cord sync signal output Digital power supply pin for internal

117 118

C4M WDCK

O O

4.2336 MHz signal output Not used in this set. (Open) Word clock signal output Not used in this set. (Open)

119 120

COUT NC

I/O —

16

Pin Description

Input/output for anti-shock WFCK signal output Not used in this set. (Open) Not used in this set. (Open) Not used in this set. (Open)

Track count signal input/output Not used. (Open)

Not used in this set. (Open)

CDX-F7500/F7700

• IC303 M30624MGP-123GP (SYSTEM CONTROL) (MAIN BOARD (3/3)) Pin No. Pin Name I/O 1 SIRCS I Remocon data input

Pin Description

2 3

(NCO) CD SO/TSO

O O

Not used CD servo serial data output

4 5

CD SI/TSI CD CKO/TCKO

I O

CD servo serial data input CD servo serial clock output

6 7

BYTE CNVSS

I I

Connecting to ground. Flash write-in signal input

8 9

XCIN XCOUT

I O

Sub clock signal input (32.768kHz) Sub clock signal output (32.768kHz)

10 11

RESET XOUT

I O

CPU reset input Main clock signal output (6MHz)

12 13

VSS XIN

— I

Ground Main clock signal input (6MHz)

14 15

VCC1 NMI

— I

Ground Non maskable interrupt signal input

16 17

CD INTQ DAVN

I I

CD-TEXT sync. signal input RDS data block sync. detection signal input

18 19

BU IN NS MASK

I O

Back-up power detection signal input NS-MASK signal output

20 21

BEEP FSW IN

O I

Beep signal output DD converter OSC frequency count input

22 23

FSW OUT SA CLK

O O

DD converter OSC frequency change output Spectrum analyzer clock output

24 25 26

TEL ATT ATT VOL ATT

I O O

Telephone mute signal input Mute signal output Electronic volume mute signal output

27 28

I2C CKO I2C SIO

O O

I2C bus serial clock output I2C bus serial data output

29 30

UNI SO UNI SI

O I

SONY bus serial data output SONY bus serial data input

31 32

UNI CKO TUNER ATT

O O

SONY bus serial clock output Tuner mute signal output

33 34

EE SIO EE CKO

I/O O

35 36

RE IN0 RE IN1

I I

Rotary encoder signal input 0 Rotary encoder signal input 1

37 38

NOSE SW DOOR SW

I I

Front panel detection signal input Panel open detection signal input

39 40

HOLD AMP DIAG

I I

External bus data input (HOLD) AMP self-diagnosis function control signal input

41 42

AMP STB (NCO)

O O

AMP standby signal output Not used

43 44

(NCO) WRI/WR

O I

Not used External bus data input (WRI/WR)

45 46

CD LIMIT CD D SW

I I

CD LIMIT switch detection signal input CD D switch detection signal input

47 48

CD IN SW 4V SEL

I I

CD IN switch detection signal input 4V PRE-OUT select signal input

49 50

MP3 SEL DST SEL1

I I

Deck mechanism select signal input Destination select setting pin 1

51 52

DST SEL2 CD LM LOAD

I O

Destination select setting pin 2 CD loading signal output

Tuner pack EEPROM serial data input/output Tuner pack EEPROM serial clock output

17

CDX-F7500/F7700

Pin No. 53

Pin Name CD LM EJECT

I/O O

CD eject signal output

54 55

CD RESET CD AO

O O

CD reset signal output CD AO signal output

56 57

CD STB (NCO)

O O

CD strobe signal output Not used

58 59

CD RF OK CD ON

I I

CD RF OK signal input CD ON signal input

60 61

VCC2 DISP RESET

— O

Power supply pin (+5V) Display CPU reset signal output

62 63

VSS TEST IN

— I

Ground Test mode signal input

64 65

BUS ON SYS RST

O O

BUS ON signal output System reset signal output

66 67

BUS/AUX (NCO)

O O

BUS AUDIO/AUX-IN select signal output Not used

68 69

ACC IN ILL IN

I I

ACC power supply check signal input ILL check signal input

70 71

RC IN1 CDM ON

I I

Rotary commander signal input CD power supply ON signal input

72 73

CD SELF SW TU ATT IN

I I

CD SELF switch detection signal input Tuner attenuator zero cross signal input

74 75

ZERO DET1 ZERO DET2

I I

ZERO detection signal input 1 ZERO detection signal input 2

76 77 78

Z ATT (NCO) (NCO)

I O O

Z mute signal input Not used Not used

79 80

ROMC EN QUALITY

O I

Connecting to ground. Tuner noise detection signal input

81 82

MPTH VSM

O I

Not used S-meter signal input

83 84

SA IN KEY IN1

I I

Spectrum analyzer data input Key signal input

85 86

KEY IN0 RC IN0

I I

Key signal input Rotary commander signal input

87 88

KEY ACK2 KEY ACK0

I I

Rotary commander ACK signal input Key ACK signal input

89 90

KEY ACK1 DOORING

I O

Key ACK signal input Sub panel LED power supply control signal output

91 92

RAM BU FLD ON

I O

RAM back-up input FL driver power supply control signal output

93 94

FL ON AVSS

O —

FL power supply control signal output Ground

95 96

DISP CE VREF

O —

Display CPU chip enable output AD converter reference voltage (+5V)

97 98

AVCC DISP SI/RX

— I

Power supply pin (+5V) Display CPU serial data input

99 100

DISP SO/TX DISP CKO

O O

Display CPU serial data output Display CPU serial clock output

18

Pin Description

CDX-F7500/F7700

• IC901 M30823MH-080GP (DISPLAY CONTROL) (KEY BOARD) Pin No. Pin Name I/O 1 SYS CE I Main chip enable input

Pin Description

2 3

(NCO) FL DAT3

O O

Not used FL serial data output 3

4 5

(NCO) FL CLK IN

O I

Not used FL serial clock input

6 7

BYTE CNVSS

I I

Connecting to ground. Flash write-in signal input

8 9

PLL LPF PLL GND

O I

PLL low pass filter connection pin Ground

10 11

RESET XOUT

I O

CPU reset input Main clock signal output (8MHz)

12 13

VSS XIN

— I

Ground Main clock signal input (8MHz)

14 15

VCC NMI

— I

Power supply pin (+5V) Non maskable interrupt signal input

16 17

(NCO) GCP IN

O I

Not used GCP pulse interrupt signal input

18, 19 20

(NCO) GCP OUT

O O

Not used GCP pulse signal output

21 22

LAT BK

O O

FL data LAT output FL BK signal output

23 24

GCP2 (NCO)

O O

FL GCP signal output 2 Not used

25 26 27

GCP1 (NCO) GCP4

O O O

FL GCP signal output 1 Not used FL GCP signal output 4

28 29

GCP3 SYS SO

O O

FL GCP signal output 3 Main bus serial data output

30 31

SYS SI SYS CLK

I O

Main bus serial data input Main bus serial clock output

32 33

(NCO) FL DAT1

O O

Not used FL serial data output 1

34 35

(NCO) FL CLK

O O

Not used FL serial clock output

36 to 38 39

(NCO) HOLD

O I

Not used External bus data input (HOLD)

40 to 43 44

(NCO) WRI/WR

O I

Not used External bus data input (WRI/WR)

45 to 59 60

(NCO) VCC

O —

Not used Power supply pin (+5V)

61 62

(NCO) VSS

O —

Not used Ground

63 to 93 94

(NCO) AVSS

O —

Not used Ground

95 96

(NCO) VREF

O —

Not used Reference voltage (+5V)

97 98

AVCC (NCO)

— —

Power supply pin (+5V) Not used

99 100

FL DAT2 FL CLK IN

O I

FL serial data output 2 FL serial clock input

19

19

CDX-F7500/F7700

3-2. BLOCK DIAGRAM — CD SECTION —

• R-ch is omitted due to same as L-ch. • Siganal Path : CD PLAY

DETECTOR PD1

PD2

PD2

26 A

PD1

42 RFACI

RFACO 41

ASYO 46

45 ASYI

CD-L

AOUT1 81 AOUT2 86

27 B

A

MAIN SECTION

(Page 21)

R-CH

28 C

I-V AMP

29 D

E

E

F

19 E

F

20 F

RF AMP,DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR IC3

PD

LD

AUTOMATIC POWER CONTROL Q1

36 LD

TEO 22

2-AXIS DEVICE

23 CD RMUT

21 TEI FOK SQSO SQCK XRST DATA XLAT CLOK SENS SCLK GFS C2PO SCOR

PD 37

PD

OPTICAL PICK-UP BLOCK (KSS1000E)

22 CD LMUT

RMUT 90

23 FEI

FEO 24

LASER DIODE

LD

LMUT 91

19 16 18 15 14 13 12 11 10 8 7 52

3 96 97 100 102 104 105 107 108 113 114 115

CD FOK CD SQSO CD SQCK CD XRST CD DATA CD XLAT CD CLOK CD SENS CD SCLK CD GFS CD C2PO CD SCOR

FCS–

11 VO2–

VIN2+ 22

10 VO2+

VIN2– 21

14 FRDR

13 VO1–

VIN1+B 19

11 TFDR

12 VO1+

VIN1–B 18

12 TRDR

IC273 (1/3) 7

1

IC252 (1/3) 6

2

IC273 (2/3) 2

6 3 IC273 (3/3)

UNI SCK BUS ON

EJECT OK 61 MECON 63

71 CDM ON

IC252 (3/3) 2 5 Q267

59 CD ON 76 Z ATT

C D+6V

CD+3.3V +1.5V REG IC7

80 X0

SW1 (DOWN)

+1.5V

+1.5V CONTROL Q2,3

5 VOUT

VDD 1 CE 3

46 MEC_DSW

+3.3V

M902 (SLED)

M

M901 (SPINDLE)

M

M903 (LOADING)

M

6 VO4+

VIN4+ 31

9 SFDR

7 VO4–

VIN4– 32

10 SRDR

8 VO3+

VIN3+ 25

6 MDP

BCK BCKI PCMDI LRCK LRCKI PCMD

SW2 (SELF)

66 60 61 63 62 65

4 VLO–

45 MEC_INSW

SW4 (LIMIT)

42 MEC_LIMIT

MUTE 34

41 DRON

FWD 1

43 MEC LOAD

REV 2

44 MEC EJECT

20

+3.3V CONTROL Q5,6

DECON 65

9 VO3–

5 VLO+

53 MEC_SELFSW

SW3 (DISC IN)

20

(Page 21)

38 DOOR SW

IC252 (2/3) 1 7

(TRACKING) TRK–

MAIN SECTION

SYSTEM CONTROL IC303 (1/3)

(FOCUS) TRK+

B

SYS RST ATT BU CHK

X2 18.43MHz

XTAO 77

UNI SO

RSTX 75 A ATT 60 BU IN 51

81 X1 X1 16.9344MHz

LINK OFF UNI SI

5

CDON CHK 68

XTAI 78 13 FFDR

20 56 25 57 26 58 50

CDON 64 ZMUT 66 CD SYSTEM CONTROL IC4 MECON CHK 67

FOCUS/TRACKING COIL DRIVE, SLED/SPINDLE/LOADING MOTOR DRIVE IC1 FCS+

LINK OFF UNISI RXD UNISO TXD UNICLK BUS ON

AUDIO INTERFACE IC8 DEC XMUTE DEC SSTBY DEC XRST DEC STBY DEC INT DEC SCL DEC SDA EMPH

37 27 28 29 30 31 32 69

22 41 2 3 36 7 6 28

CLCK SRMSTB RESET STANDBY BUCK I2C SCL I2C SDA BUSO

15 18 11 16 19 14

BCK1A BCK1B SD0O LRCK1A LRCK1B SD1O

BU+3.3V

CDX-F7500/F7700

3-3. BLOCK DIAGRAM — MAIN SECTION —

F7500

AMP IC470 2

F7700 CN401 SUB OUT(MONO)

1 MUTE Q470

F7500 ELECTRONIC VOLUME IC401

CD SECTION

A

PB LCH 4 PB RCH 7 OUTSW 17

CD-L R-CH

(Page 20)

GROUND SW Q408 L

AMP IC402

R-CH

42 CD LCH 43 CD RCH

8

14

L

11

J601 (ANTENNA)

1 ANT

OUT RF 22 OUT RR 21

L 4 R 3

13

L

R-CH

MUTE Q171

AMP IC431

40 TUNER LCH 41 TUNER RCH OUT LF 25

3

1

OUT LR 24

5

7

AU+8V

MUTE 15

TU+5V BU+5V

SCL 13 SDA 12

MUTE Q181

D401

MUTE CONTROL Q401,402

R-CH BATT

82 VSM VOL ATT 26 32 TUNER ATT ATT 25 34 EECKO BEEP 20 33 EESIO AMP STB 41 73 TU ATTIN AMP DIAG 40 SA IN 83 80 QUALITY SA CLK 23 BUS/AUX 66 19 NS MASK ACC IN 68

QUALITY 5 Q380

RDS DEMODULATOR IC550 RDS 9

16 MPX

SDA SCL

SCL SDA

SCL 9 SDA 10

5 AMP-REM 6 ANT-REM F901

2 SDA 4 SCL

BATT

16

BATT

D904 REG1 REG2 REG3 REG4 REG5

16 ACGND 22 STB 25 DIAG BATT

30 37 31 33 34

AU+8V BU+5V CD+3.3V CD+6V ILL+B

35 VP

TEL ATT 24

ACC CHECK Q102

7

TEL ATT Q103

13 15

TEST IN 63

SCL SDA

RL+ RL-

4 FR+ 12 FR3 RR+ 11 RR-

F7700

SW1 29 SW2 27

IIC CKO 27 IIC SIO 28

E2P SCL 16 E2P SDA 17 MUTE CONDITION 8

10

F7700 SCL SDA

SYSTEM CONTROL IC303 (2/3)

S-METER 6 TU MUTE 7

2

RL+ 9 RL- 7

MUTE Q450

SCL SDA

TU-SCL 13 TU-SDA 14

CNP101 1 FL+ 9 FL-

FL+ 5 FL- 3

11 INRL MUTE Q451

PJ401

FRONT AUDIO OUT

R

R-CH

CONTROLLED POWER AMP/ MULTIPLE VOLTAGE REGULATOR IC201 12 INFL

SA IN 14 SA OUT 16 VCC 10 TU VDD 11 E2P VDD 15

REAR AUDIO OUT

R

R-CH TUX501 (TUNER UNIT)

BUS AUDIO IN

R

R-CH

14

ILL CHECK Q907

ILL IN 69

ACC

ATT TEST ILL

4 OSCO X550 4.332MHz

DAVN 8

5 OSCI

BUS INTERFACE IC110

17 DAVN

BU+3.3V

BATT DET Q101

BATT 3 • R-CH is omitted due to same as L-CH. • Signal Path

BU IN UNI SI UNI SO UNI CKO BUS ON SYS RST

: CD PLAY : FM : MW/LW

18 30 29 31 64 65

10 8 9 11 12 13 D301

B CHK DATA OUT DATA IN CLK IN BUSON RST

(Page 20)

B

TU+5V REG Q501

AU+8V

21

CNP102 8

D105 BATT

6

3

5

2

4 BUS ON SWITCH Q110,112

BUS ON 1 RST 2

C

DISPLAY SECTION

TH100 LINK ON/OFF SWITCH Q111

1 7

(Page 22)

BU CHECK DET Q270,273

21

TU+5V

CLK 4

RESET

LINK OFF BUS ON UNI SCK UNI SO UNI SI ATT BU CHK

BU+5V

DATA I/O 6

D302

SYS RST

CD SECTION

+3.3V REG IC271

BATT

BUS CONTROL IN

CDX-F7500/F7700

3-4. BLOCK DIAGRAM — DISPLAY SECTION —

SYSTEM CONTROL IC303 (3/3) ROTARY ENCODER ENC901(1/2)

DISPLAY CONTROL IC901 FL DAT1 33 FL DAT2 99 FL DAT3 3 LAT 21 BK 22 FL CLK 35

35 REIN0 36 REIN1

KEY MATRIX S901-910,912 LSW901-908 ENC901(2/2)

85 KEYIN0 84 KEYIN1

DISP CE 95 DISP SI 98 DISP SO 99 DISP CKO 100

1 30 29 31

CNVSS 7

CE SI SO CLK

7 CNVSS GCP1 GCP2 GCP3 GCP4

88 KEY ACKO 89 KEY ACK1

6 5 4 12 13 7

DISP RESET 61

10 RESET

25 23 28 27

4 5 1 2

11

GCP

FL900 FLUORESCENT INDICATOR TUBE 11

GCP BUFFER IC902

87 KEY ACK2 RESET IC904

1 70 RCIN1 86 RCIN0

CNJ101 (REMOTE IN)

ILL+B LED901,910-924 LSW901-908

POWER CONTROL Q601,602

BATT

DOOR IND 90

BU+5V

2 IN

OUT 1

10 RESET

SIRCS 1

C

(Page 21)

+5V REG D911

ILL+B

1 VCC

S301 RESET MAIN SECTION

LED931,932

REMOTE CONTROL RECEIVER IC903

RESET IC302

2 OUT

IR

RESET 37 NOSE SW S300 (NOSE DET)

XOUT 11 XIN 13

X301 32.768kHz

8 XCIN 9 XCOUT

X302 6MHz

POWER CONTROL Q914,916

ILL+B

+5V REG Q915

FL VDD+5V

FLD ON 92 FL ON 93 T620 BATT

FSW OUT 22

POWER CONTROL Q623,Q624

DC-DC CONVERTER CONTROL Q621,622

D623,624

5 VCC 7 CT

OUT 4

IN 1

FSW IN 21

22

22

FL+4.3V

DC-DC CONVERTER IC620

D620,621 FL+1V ON/OFF DRIVE Q620

FL+55V D622

CDX-F7500/F7700

3-5. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS

3-6. WAVEFORMS

THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) For schematic diagrams.

For printed wiring boards.

Note: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. f : internal component. • • C : panel designation.

Note: • X : parts extracted from the component side. • Y : parts extracted from the conductor side. a : Through hole. • • : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.)

Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.

• • • • • •

•

•

• •

A : B+ Line. B : B– Line. H : adjustment for repair. Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. CD mechanism section no mark : CD PLAY Main (1/3), (2/3), (3/3) and Key sections no mark : FM ( ) : AM < > : CD PLAY ∗ : Impossible to measure Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. J : CD PLAY F : FM f : MW/LW

— Servo Board — (MODE: CD PLAY)

— Main Board —

1

1

5 Approx. 0.8Vp-p

0V

2.9Vp-p

32.768kHz

Approx. 100mVp-p

IC3

wa

ra

IC3

(TEI)

2

9

IC303

(RFACO)

6

(XCOUT)

2 2Vp-p

Caution: Pattern face side: (Side B) Parts face side: (Side A)

Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.

Approx. 100mVp-p

IC3

wd

6MHz

16.9344MHz

(FEI)

IC3

3

uj

IC303

(XTAO)

7

5Vp-p 4.332MHz

18.43MHz

IC3

wh

(XOUT)

1Vp-p

These are omitted

B E

qa

3

Approx. 150mVp-p

C Q

5Vp-p

0V

IC4

(A), wk (C)

ia

IC550

(X1)

4

(OSCO)

4 Approx. 150mVp-p

BE C These are omitted

IC3

wj

(B), wl (D)

ECB These are omitted

3-7. CIRCUIT BOARDS LOCATION

SERVO board SENSOR board

tuner unit (TUX501) MAIN board KEY board SUB board

23

23

CDX-F7500/F7700

R60

R67

R59 TP148

R56

C45

TP141 TP145

TP137

TP127

TP120

R52 C41 TP116

TP109

TP106

TP98

TP97

R40

R48

R50

TP344

TP343

TP65

TP63

TP62

C33

TP94 TP96

3-8. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 23 for Waveforms.

R71 C54 TP59 R64

TP57

TP60

TP61 C52

C58

C53

C59

R29

TP180

TP181

C60

R97

R98 CN2

C29 TP129 TP72 TP123 TP128

IC3

R77

R70

C28

TP139

X1 TP56

TP140 R13 R6 C22 C23

R22

C25 TP21

BP2

FB2

TP48

R24

FB5

TP49 TP47

TP71

BP3

C24 CN1

TP175

C57

R25

R114 R78

TP50

R23 C27

R76

TP22

R79

TP24 TP25

R68

TP26

TP41 TP132 TP46 TP36

R72

C6

TP33

C50

R54

R45

R43 C39

R41

C49 C48

R55

R49

R12

C35

C47 R53

C44

C38

C43

C30 C10

R46

R7

R38

C34

C42

C37

TP45

C40

TP44

R44

Q1

R96

TP99

C5 TP35

C46 C64

(Page 25)

24

TP39 TP38 TP43

R42

R1

TP32

TP34

TP42 TP51 TP37

TP136

C4

TP28 TP29 TP30

TP133 TP135

R133 R124

TP23

TP27

TP55 TP54

C55

TP167

TP53 R65

24

C65

R61

TP40

(Page 29)

CDX-F7500/F7700

• Refer to page 23 for Waveforms. 3-9. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 36 for IC Block Diagram. (Page 24)

FB1

R47

R146

R73

R69

C56

R57

R39

R148

C36

R147

R136

C67

R91

R81 R92

TP7 SW4

C63

TP8

R15

R14

R117 X2

TP9

SW3

TP70

R85

IC B/D

R86

C1

TP11 IC1

C32

R37

R87

C2

SW2

TP12 C21

C3

IC4

TP19 SW1

TP20

R140

C11 R18

C19

R20 C66 R19 TP17

R17

C18

M903

R145

R123

TP18

R141 R142

TP58

R143 R21

TP13 M901

R26 R27

C26

TP14 TP15

R16 C7

M902

R28

R4 R2

TP16

TP52

R74

R80

R62

R129

R128

R5

R11 C14

R127

R122

R3

R9

R126

C16

C8

R115

TP31

R119 C51 C13

R10

R8

C115

C86

C92

R111 R110

C77 C75

C109 R102

R144

R108

C79 TP226

BP1

IC8 C110

R109

IC B/D

TP230

IC7

TP231 Q5

Q3

C83 R101

C85 R106

R107

R139 Q6

TP249

R99

C91

25

Q2 C74

R116

25

CDX-F7500/F7700

3-11. SCHEMATIC DIAGRAM — MAIN SECTION (1/3) — • Refer to page 36 for IC Block Diagram.

C555

IC B/D

C554 C557

R553

L501

R478

C556 R477 R473 R472

C470

TUX501

C475 IC550 R402

R552 R550

J601

L503

R502

C503

C508

C507

FB442 C443

C552

X550

R471

R551

C550 C551

C509

IC470 C553 R402

FB441

Q470

R407

C558

R430

R432

R504

C510

IC B/D

R431

IC402

R429

C278 C273 R274

R272

C178 R275

Q271 R282 Q501

C441

C272 C440

L502

R380

C282

Q380

C436

C288

Q281 C283

C438

C400

R285

R284

R410

C437 R427 R172

C182

C173 R174

D501 C420 C419

R175

Q171

R424

R182

Q181 R433

C418 R436

C309

C183

R435

R434

D122

R185

R184

R446 R444

C511

R143 R142

R443

R501

Q408 R408 C199 R445

C417

C308

C242 C142

C172 C501

PJ401

C188 R243 R242

C439 C502

CN401

C442

R456 R455

R454

C416

C451 R460

IC B/D

C447 C452

C421 C433

R426

C450

IC451 C422

Q453

R461

Q452

R463

R459

L401 C446

C434

C424 R414 R415

C449 R458

C423

C435

R465 C425

IC401

R416

R453

R452 R451 R450 R449

R448

R417

C448

C427

C426

C428

C429

Q451

R462

Q450

R464

R457

C445 Q402

C453

R418

(Page 28) D401

R401

R419 IC431

D403

C432

R421

Q401 R420

C444

C430

C403

R403

R447 C401

R422

C431 R437

R438

(Page 29)

27

27

CDX-F7500/F7700 3-12. SCHEMATIC DIAGRAM — MAIN SECTION (2/3) — • Refer to page 36 for IC Block Diagram.

C210

C215

C205

IC B/D D111 D110

CNP101

D113 C206

R203

C218

R205

D112

CN103 C208

C216

C209

C217

C219

R206

C207

R204

CN102

D114 IC201

D116

D115 D117

D118

D120

D119

D121 C203

R202

C202

F901

R103 C211 C212 C221

C204

R111

Q103

Q907 R921

C223 R110

R922

R112

D106

R201 C201

D909

C214 R929

D108

R109

C903

R920

C226 R107

C225 R105

Q102 C227

R104

C106

C103

D123

R106

C102 R108

D109

L101

(Page 27) R643

R642 Q915

R634 L901

Q914 R950

Q624 R635 Q623

D911

R949

C901

C928 Q916

D910

R116 CNJ101

C930

C623 Q621 R627 R628

R626

D624

T620

L620

CN601 C620

C624 D623

R625 D625

R629

D622

R621

R622

C621

R620

C622 C628

C629

D620 D621

Q622 IC620 R623

IC B/D R630

R631

Q601 C626

C627

R601

R602

R603 D606

Q602

D605

D602

R632

D601

D626

D604

D627

R624

D603

R633

(Page 33)

Q620 R636

C625

R600

(Page 29)

28

28

CDX-F7500/F7700 • Refer to page 23 for Waveforms. 3-13. SCHEMATIC DIAGRAM — MAIN SECTION (3/3) — • Refer to page 37 for IC Block Diagram.

(Page 28)

(Page 27)

(Page 24)

D275

CNP301

FB329 C336

FB325

D904 L303 C335 C342

FB326 R240 FB328

FB327

R241 FB330

C341

R369

R371

R910

R370

R323

R361

C325 R385 C306 C333 C334 C307

R322

R345

R344

R343

R341

R365

R346

R366

R302

C324

R381

R314

FB324

C303

C304

R363 L301

L302

R271

R391 C319

IC273 R270

C321

R312 R364

R377

R273

D306

R342

C322

Q273

IC303 C317

Q270

X302 C332

C323 C315

X301

R393 D301

C316 R311

D302 IC252

R304 IC271

C271

L320 R267

JR302 JR301

C320

R330 C318

R333

R351

C330 R335

R350

Q267

R332

R319 R357

R102

D105

R101

D104

Q101

D907

D305 R326

R356 Q111

R118

IC B/D

TH100

D103

D101

D102

Q112 D271 Q110

C101 R115

R113

IC110

C111

R367

R301

C110

C313

S301 R117 R300

R114

S300

IC302 C312

CNP102

29

29

C311

CDX-F7500/F7700

3-16. SCHEMATIC DIAGRAM — SUB SECTION —

CNP501

(Page 35) (Page 28)

S901

33

D991

D990

LED932

LED931

33

R990

R991

CDX-F7500/F7700

3-18. SCHEMATIC DIAGRAM — KEY SECTION —

ENC901(1/2)

R979

CN901 C901

R981

R918

R919

R920

R921

R922

R923

R924

R925

R926

R927

R980

D901

LED901

LSW902(2/2)

FB912

R985

R984

LED923

D902

R983

LSW903(2/2)

LSW904(2/2)

LSW905(2/2)

LSW907(2/2)

LSW901(2/2)

LSW906(2/2)

LSW908(2/2)

LED910

LED924

D903 D904

C912

(Page 33)

R928

D913

R929

R930

R931

R932

R933

R934

R935

R936

R937 R938

LED913

LED918

LED912

LED914

LED915

D917

LED911

LED916

D918

LED917

D915

D909 D910

D916

R955 LED919

LED921

C903

D914

R953

R954

IC901

FB911 R977

IC903

R901

FB910

D912

R987

S902

S910

ENC901(2/2)

LSW901(1/2)

S903

S912

S904

LSW902(1/2)

S905

LSW903(1/2)

S906

LSW904(1/2)

S907

LSW905(1/2)

S908

LSW906(1/2)

S909

LSW907(1/2)

FB909 FB913

FB906 FB905

R947

R903

R972

R913

FB920

FB903

FB902

R906

FB901

C905

D919

C906

X901

R905

R912

R975

R973

C915

R970 R982 C916

R971

FB919

FB918

FB904 FB917

R911

R946 R904

FB915 FB916

C917

D911

IC904

R910

FB907 FB914

C904

R902

FB908

R976

R907

R914

R915

IC902 R908

C913

R916

R960

C907

R909 R959

R917

R958 LSW908(1/2) C909 R961 L901

FL900

35

35

R978

LED920

LED922

R939

CDX-F7500/F7700

VDD 1 FWD 1

AC2IN-L AC2OUT-L FILOL

OUT-LF

OUT-LR

33

32

31

30 29

28 27 26

25

24 23

5 VOUT

36 S-GND

THERMAL SHUTDOWN

HIGH PASS FILTER2

MIXER

NC

VREFOUT VDD

IC1 LA6560-TE-L-E (SERVO Board (2/2))

ACIN-L

IC401 TDA7416 (MAIN Board (1/3)) ACOUT-L

IC7 R1114N151D-TR-FA (SERVO Board (2/2))

ACIN-R

3-19. IC BLOCK DIAGRAMS

INPUT REV 2

35 VCONT

VCC2 3 OUTPUT CONTROL

VLO- 4

BTL-AMP OUTPUT ON/OFF

MUTE

NC ACOUT-R ACIN-SW ACOUT-SW

34 MUTE

GND 2 33 VIN4

VLO+ 5

VREF

CURRENT LIMIT

SOFT STEP FADER

34 35 36 37

SOFT STEP FADER HIGH PASS FILTER

32 VIN4-

CE 3

LEVEL SHIFT

VO4+ 6

SUB WOOFER FILTER

4 NC

31 VIN4+

VO4- 7

LEVEL SHIFT

VO3- 9

VIN1/VREF-SW

22 OUT-RF

SOFT STEP FADER

21 OUT-RR

7 BAND EQUALIXER

30 VREF-IN

VO3+ 8

MIXER

SOFT STEP FADER

MAIN VOLUME

HIGH PASS FILTER2

SOFT STEP FADER

29 VIN1-SW SOFT MUTE

20 AC2IN-R 19 AC2OUT-R 18 FILOR

17 OUTSW 16 SAOUT 15 MUTE

ZERO CROSS

28 VREF-OUT LOUDNESS

GND

SPECTRUM ANALIZER

GND

14 SAIN

IC402 LA2901V-TL (MAIN Board (1/3))

IN-GAIN

27 REG-OUT LEVEL SHIFT

VO2+ 10

SIGNAL AMP

FR- 1

26 REG-IN

CREF 38 NC 39

FR+ 2 TUNER-LCH TUNER-RCH CD-LCH CD-RCH AUX-L

VO2- 11 25 VIN3+ LEVEL SHIFT

VO1+ 12

24 VIN3-

MAIN SOURCE SELECTOR

24 OUT(FR)

N.C 3

VREF

VCC SIGNAL AMP

RR- 4

40 41 42 43 44

REAR SELECTOR

FADER

INPUT MULTIPLEXER

II2CBUS

POWER SUPPLY

23 OUT(RR)

20 LIFTR OUT

VREF

20 VIN2

19 VCC(R) 18 VCC(L)

L

VIN1+A 17

DC(L) 7

H

9 10 11

VREF

IC620 NJM2377M(TE2) (MAIN Board (2/3))

8

7

VCC

DC(R) 6

AMP-A VIN1-A 16

8

NC GND NC

21 VIN2-

21 LIFTR VD

6 7

CS

VIN1 15

LIFT AMP

1 2 3 4 5

MIC

22 VIN2+

VCC

NC PD-RCH+

VCC1 14

22 GND(R) VREF

CT

23 VIN3

REF

VO1- 13

NC NC AUXR PD-LCH+ PD-

RR+ 5

6

5

30µA VREF LIFT AMP

VIN1-B 18 AMP-B

VREF

19 VIN1+B

17 LIFTL OUT OSC

16 LIFTL VD

L.O

VCC

15 GND(L)

U.VLO

FL+ 8 SIGNAL AMP

FL- 9 N.C 10

VREF

14 OUT(FL) S.C.P ER.AMP

VCC

0.52V

PWM

RL+ 11 13 OUT(RL) RL- 12

36

36

1

2

3

4

IN

F.B

GND

OUT

SIGNAL AMP

13 SCL 12 SDA

CDX-F7500/F7700 IC201 TDA8588AJ/N2 (MAIN Board (2/3)) TAB 1 2 SDA OUT FL- 3

I2C BUS 4 SCL

FL OUT FL+ 5

6 VP2 OUT RL- 7 RL

8 PGND3

OUT RL+ 9 10 SVR

MUTE

INRL 11 SGND 13

12 INFL 14 INFR

MUTE

PROTECTION DIAGNOSTIC

INRR 15

16 AC GND

VP

OUT RR+ 17 RR

18 PGND2

OUT RR- 19

20 VP1

OUT FR+ 21 STANDBY MUTE

FR OUT FR- 23

22 STB

CHIP DETECT DIAGNOSTIC

24 PGND1 TEMPERATURE PROTECTION

DIAG 25

ENABLE LOGIC 26 RST

SW2(ANT REM) 27

SWITCH

SW1(ANT REM) 29

SWITCH

28 CRES

REGULATOR

30 REG1(AUDIO +B) REG3(SERVO) 31 REG4(DR+B) 33

32 GND(REG) 34 REG5(ILL)

VP(REG) 35

REFERENCE VOLTAGE REG2(BU 5V) 37

36 CBU LOADDUMP PROTECTION

REGULATOR

CIN

SCOUT

VREF

MPX

VSSA

VDDA

AFIN

MAD PSWN

IC110 MM1175XFF (MAIN Board (3/3))

LVIN

IC550 SAA6588T/V (MAIN Board (1/3))

20

19

18

17

16

15

14

13

12 11 PAUSE DETECTOR

POWER SUPPLY & RESET

MULTI PATH DETECTOR

57kHz 8th ORDER BAND-PASS FILTER

CLOCKED COMPARATOR

BUSON 1

5

CLOCK RDS/RDBS DEMODULATOR

RDS/RDBS DECODER

RESET SWITCH

13 RST

BATT 3

BATT SWITCH

12 BUSON

CLK 4

11 CLK-IN

VREF 5

10 B-CHK

4 CLOCK

INTERFACE REGISTER

DATA

I/O DATA 6

DATA OSCILLATOR & CLOCK

14 VCC

RST 2

SIGNAL QUALITY DECODER 4

1 2

3

4

5

6

7

8

9

10

TCON

OSCO

OSCI

VSSD

VDDD

DAVN

SDA

SCL

IIC BUS SLAVE TRANSCEIVER

MRO MPTH

TEST CONTROL

BACK-UP SWITCH

GND 7

9 IN DATA 8 OUT DATA

37

CDX-F7500/F7700 SECTION 4 EXPLODED VIEWS NOTE: • The mechanical parts with no reference number in the exploded views are not supplied. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • -XX and -X mean standardized parts, so they may have some difference from the original one.

• Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet’s Color • Accessories are given in the last of this parts list.

The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.

4-1. MAIN SECTION not supplied

A

MG-611MA-186//K

10

#1

#1 #2 B

A

12 F901

9 #2

8

TUX501

7

6

11

#1 not supplied

not supplied

not supplied

B

5 3

4

#1

1

#1

2 4

Ref. No.

Part No.

Description

1 2 3 4 5

X-3384-273-1 1-828-511-11 3-246-030-01 3-261-903-01 X-3384-490-1

LOCK ASSY CABLE, FLAT (FFC) 22P BUTTON (EJECT) SCREW (+BTT 2X5) PANEL ASSY (CD), SUB

6 7 * 8 9 10

X-3384-271-1 3-713-786-51 3-246-006-31 3-376-464-11 1-790-375-12

GEAR ASSY SCREW +P 2X3 COVER SCREW (+PTT 2.6X6), GROUND POINT CORD (WITH CONNECTOR) (SUB OUT (MONO))

38

Remark

Ref. No. 11 11 12 12 F901

not supplied (SUB board)

Part No.

Description

Remark

A-3283-454-A MAIN BOARD, COMPLETE (F7500) A-3283-460-A MAIN BOARD, COMPLETE (F7700) 1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER) (AEP,UK) 1-776-207-72 CORD (WITH CONNECTOR) (E) 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A

TUX501 A-3220-961-A TUNER UNIT (TUX-032//Q3) #1 7-685-792-09 SCREW +PTT 2.6X6 (S) #2 7-685-793-09 SCREW +PTT 2.6X8 (S)

CDX-F7500/F7700

4-2. FRONT PANEL SECTION

58 57 #3

#3 #3

FL900

56

55

not supplied (KEY board)

not supplied

not supplied

54 51 52 53

Ref. No.

not supplied

Part No.

Description

51 52 53 54 54

X-3384-508-1 3-265-937-01 X-3384-635-1 X-3385-024-1 X-3385-025-1

BUTTON KIT ASSY (S) SPRING (OPEN) KNOB ASSY (S) PANEL ASSY (S), FRONT (E) PANEL ASSY (S), FRONT (F7500)

Remark

54 55 56

X-3385-026-1 PANEL ASSY (S), FRONT (F7700:AEP,UK) 3-260-341-01 SHEET (FL) X-3384-495-1 PANEL ASSY, FRONT BACK

Ref. No. 57 58 58 58

Part No.

Description

Remark

X-3378-390-3 A-3372-637-A A-3372-685-A A-3372-688-A

FL900

CASE ASSY (for FRONT PANEL) COMPLETE ASSY, FRONT PANEL (F7500) COMPLETE ASSY, FRONT PANEL (E) COMPLETE ASSY, FRONT PANEL (F7700:AEP,UK) 1-518-953-11 INDICATOR TUBE, FLUORESCENT

#3

7-685-105-19 SCREW +P 2X8 TYPE2 NON-SLIT

39

CDX-F7500/F7700

4-3. CD MECHANISM SECTION (1) (MG-611MA-186//K)

not supplied

102

not supplied (SENSOR board)

101

#4

not supplied

not supplied

103

104 106

105 108 107

Ref. No. 101 102 103 104 105

40

Part No.

Description

A-3372-455-A 3-253-729-01 3-253-746-13 3-253-746-03 3-253-695-01

CHASSIS (T) SUB ASSY SPRING (LTR), TENSION COIL SPRING (DAMPER), COMPRESSION SPRING (DAMPER), COMPRESSION SPRING (KF), TENSION COIL

Remark

Ref. No. 106 107 108 #4

Part No.

Description

3-253-748-01 3-352-758-31 A-3283-359-A 7-627-552-87

DAMPER (S) SCREW (M1.7), TOOTHED LOCK SERVO BOARD, COMPLETE SCREW, PRECISION +P 1.7X2.2

Remark

CDX-F7500/F7700

4-4. CD MECHANISM SECTION (2) (MG-611MA-186//K)

155 156

157 154 (including M901)

#5 M902

SW4

159 not supplied

158

not supplied

153

not supplied

151

152

The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified.

Ref. No.

Part No.

Description

151 152 0 153 154 155

A-3337-637-A 3-316-938-91 8-820-207-02 A-3337-640-A A-3337-641-A

CHASSIS (OP) COMPLETE ASSY SCREW (B1.4X5), TAPPING OPTICAL PICK-UP (KSS1000E/K1RP) CHASSIS (OP) SUB ASSY (including M901) ARM SUB ASSY, CHUCKING

156

A-3337-639-A LEVER (SL) SUB ASSY

Remark

Ref. No.

Part No.

Description

157 158 159 M902 SW4

X-3383-454-3 3-261-959-02 3-264-165-02 A-3337-638-A 1-571-099-11

LEVER (SL) ASSY SPRING (SL), TORSION SCREW MOTOR ASSY, SL (SLED) SWITCH (1 KEY) (LIMIT)

#5

7-627-850-77 SCREW, PRECISION +P 1.4X1.8

Remark

41

CDX-F7500/F7700

4-5. CD MECHANISM SECTION (3) (MG-611MA-186//K)

203

201 202

207 211

204

209 208

210

205

207 207 M903

#4

206

Ref. No.

Part No.

Description

201 202 203 204 205

3-262-755-01 3-259-024-01 A-3337-633-A 3-259-455-02 3-253-713-01

WASHER (1.1-2.5) WHEEL (RA), WORM ARM ASSY, ROLLER SPRING (RAL) SPRING (RAR)

206 207

3-259-469-01 SPRING (LE), LEAF 2-134-636-31 SCREW (M1.7X2.5)

42

Remark

Ref. No.

Part No.

Description

208 209 210 211 M903

3-259-467-01 3-345-648-91 A-3372-456-A 3-259-468-01 A-3372-454-A

BRACKET (LEM) SCREW (M1.4), TOOTHED LOCK WORM (LEB) ASSY BEARING (LEB) MOTOR ASSY, LE (LOADING)

#4

7-627-552-87 SCREW, PRECISION +P 1.7X2.2

Remark

CDX-F7500/F7700

4-6. CD MECHANISM SECTION (4) (MG-611MA-186//K)

254 252

255 252 256 251

253

257

Ref. No. 251 252 253 254

Part No.

Description

3-259-429-01 3-344-223-01 3-259-470-01 3-253-755-02

WHEEL (LE), WORM WASHER GEAR (LE1) LEVER (D)

Remark

Ref. No. 255 256 257

Part No.

Description

Remark

3-899-829-01 WASHER (SLIT) 3-259-032-01 GEAR (LE2) A-3372-453-A CHASSIS (M) BLOCK ASSY

43

CDX-F7500/F7700 SECTION 5 ELECTRICAL PARTS LIST

KEY NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable

Ref. No.

Part No.

• Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. • CAPACITORS uF : µF • COILS uH : µH

Description

Remark

KEY BOARD ********** 3-260-341-01 SHEET (FL)

Ref. No.

The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified. When indicating parts by reference number, please include the board.

Part No.

Description

FB902 FB903 FB904 FB905 FB906

1-414-760-21 1-414-760-21 1-414-760-21 1-414-760-21 1-414-760-21

INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD

Remark

FB907 FB908 FB909 FB910 FB911

1-414-760-21 1-414-760-21 1-414-760-21 1-414-760-21 1-414-760-21

INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD

FB912 FB913 FB914 FB915 FB916

1-414-760-21 1-414-760-21 1-414-760-21 1-414-760-21 1-414-760-21

INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD

FB917 FB918 FB919 FB920

1-414-760-21 1-414-760-21 1-414-760-21 1-414-760-21

INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD

< CAPACITOR > C901 C903 C904 C905 C906

1-107-826-11 1-107-826-11 1-164-227-11 1-162-915-11 1-162-915-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 0.1uF 0.022uF 10PF 10PF

10% 10% 10% 0.5PF 0.5PF

16V 16V 25V 50V 50V

C907 C909 C912 C913 C915

1-107-826-11 1-107-826-11 1-216-864-11 1-107-826-11 1-164-230-11

CERAMIC CHIP CERAMIC CHIP SHORT CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 0.1uF 0 0.1uF 220PF

10% 10%

16V 16V

10% 5%

16V 50V

C916 C917

1-107-826-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP

0.1uF 0.1uF

10% 10%

16V 16V

< CONNECTOR > < FLUORESCENT INDICATOR > CN901

1-818-141-11 PLUG, CONNECTOR 20P FL900

1-518-953-11 INDICATOR TUBE, FLUORESCENT

< DIODE > < IC > D901 D902 D903 D904 D909

8-719-978-33 8-719-978-33 8-719-978-33 8-719-978-33 8-719-978-33

DIODE DIODE DIODE DIODE DIODE

DTZ-TT11-6.8B DTZ-TT11-6.8B DTZ-TT11-6.8B DTZ-TT11-6.8B DTZ-TT11-6.8B

D910 D911 D912 D913 D914

8-719-978-33 8-719-069-54 8-719-404-50 6-500-886-01 8-719-978-33

DIODE DIODE DIODE DIODE DIODE

DTZ-TT11-6.8B UDZS-TE17-5.1B MA111-TX RSA6.1ENTR DTZ-TT11-6.8B

D915 D916 D917 D918 D919

8-719-978-33 8-719-978-33 8-719-978-33 8-719-978-33 1-216-864-11

DIODE DTZ-TT11-6.8B (F7700) DIODE DTZ-TT11-6.8B (F7700) DIODE DTZ-TT11-6.8B (F7700) DIODE DTZ-TT11-6.8B (F7700) SHORT CHIP 0

LED901 LED901 LED910 LED910 LED911

6-500-204-01 6-500-450-01 6-500-204-01 6-500-450-01 6-500-204-01

LED LED LED LED LED

< ROTARY ENCODER >

LED911 LED912 LED912 LED913

6-500-450-01 6-500-204-01 6-500-450-01 6-500-204-01

LED LED LED LED

ENC901 1-478-474-11 ENCODER, ROTARY (SOUND,VOLUME) < FERRITE BEAD > FB901

44

1-414-760-21 INDUCTOR, FERRITE BEAD

IC901 IC902 IC903 IC904

6-803-991-01 8-759-523-94 6-600-321-01 8-759-658-25

IC IC IC IC

M30823MH-080GP TC74VHC32FT(EL) KSM-401Y (IR) PST3432UL

< COIL > L901

1-469-847-11 INDUCTOR

100uH

< DIODE > CL-190UB2-X-T (IMAGE) (F7700) CL-195SR-CD-T (IMAGE) (F7500) CL-190UB2-X-T (OFF) (F7700) CL-195SR-CD-T (OFF) (F7500) CL-190UB2-X-T (SCRL) (F7700)

CL-195SR-CD-T (SCRL) (F7500) CL-190UB2-X-T (EQ7) (F7700) CL-195SR-CD-T (EQ7) (F7500) CL-190UB2-X-T (SEEK +/>/M) (F7700) LED913 6-500-450-01 LED CL-195SR-CD-T (SEEK +/>/M) (F7500)

CDX-F7500/F7700 KEY Ref. No.

Part No.

Description

Remark

Part No.

Description

R905 R906 R907 R908 R909

1-218-851-11 1-218-851-11 1-218-855-11 1-218-859-11 1-218-863-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

1.5K 1.5K 2.2K 3.3K 4.7K

0.5% 0.5% 0.5% 0.5% 0.5%

1/10W 1/10W 1/10W 1/10W 1/10W

R910 R911 R912 R913 R914

1-219-286-11 1-219-286-11 1-219-286-11 1-218-847-11 1-218-851-11

RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP

680 680 680 1K 1.5K

2% 2% 2% 0.5% 0.5%

1/16W 1/16W 1/16W 1/10W 1/10W

R915 R916 R917 R918

1-218-851-11 1-218-855-11 1-218-859-11 1-216-811-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP

1.5K 2.2K 3.3K 150

0.5% 0.5% 0.5% 5%

R918

1-216-820-11 METAL CHIP

820

5%

1/10W 1/10W 1/10W 1/10W (F7700) 1/10W (F7500)

R919

1-216-820-11 METAL CHIP

820

5%

R920

1-216-811-11 METAL CHIP

150

5%

R920

1-216-820-11 METAL CHIP

820

5%

R921

1-216-820-11 METAL CHIP

820

5%

R922

1-216-811-11 METAL CHIP

150

5%

R922

1-216-820-11 METAL CHIP

820

5%

R923

1-216-820-11 METAL CHIP

820

5%

LSW901 1-771-883-31 SWITCH, TACTILE (WITH LED) (SOURCE) (F7500) LSW901 1-786-711-11 SWITCH, TACTILE (WITH LED) (SOURCE) (F7700) LSW902 1-771-883-31 SWITCH, TACTILE (WITH LED) (AF/TA) (F7500) LSW902 1-786-711-11 SWITCH, TACTILE (WITH LED) (AF/TA) (F7700) LSW903 1-771-883-31 SWITCH, TACTILE (WITH LED) (6/PAUSE) (F7500)

R924

1-216-811-11 METAL CHIP

150

5%

R924

1-216-820-11 METAL CHIP

820

5%

R925

1-216-820-11 METAL CHIP

820

5%

R926

1-216-811-11 METAL CHIP

150

5%

LSW903 1-786-711-11 SWITCH, TACTILE (WITH LED) (6/PAUSE) (F7700) LSW904 1-771-883-31 SWITCH, TACTILE (WITH LED) (5/BBE MP) (F7500) LSW904 1-786-711-11 SWITCH, TACTILE (WITH LED) (5/BBE MP) (F7700) LSW905 1-771-883-31 SWITCH, TACTILE (WITH LED) (4) (F7500) LSW905 1-786-711-11 SWITCH, TACTILE (WITH LED) (4) (F7700)

R926

1-216-820-11 METAL CHIP

820

5%

R927

1-216-820-11 METAL CHIP

820

5%

R928

1-216-811-11 METAL CHIP

150

5%

R928

1-216-820-11 METAL CHIP

820

5%

LSW906 1-771-883-31 SWITCH, TACTILE (WITH LED) (3) (F7500) LSW906 1-786-711-11 SWITCH, TACTILE (WITH LED) (3) (F7700) LSW907 1-771-883-31 SWITCH, TACTILE (WITH LED) (2/SHUF) (F7500) LSW907 1-786-711-11 SWITCH, TACTILE (WITH LED) (2/SHUF) (F7700) LSW908 1-771-883-31 SWITCH, TACTILE (WITH LED) (1/REP) (F7500)

R929

1-216-820-11 METAL CHIP

820

5%

R930

1-216-811-11 METAL CHIP

150

5%

R930

1-216-820-11 METAL CHIP

820

5%

R931

1-216-820-11 METAL CHIP

820

5%

LSW908 1-786-711-11 SWITCH, TACTILE (WITH LED) (1/REP) (F7700)

R932

1-216-811-11 METAL CHIP

150

5%

R932

1-216-820-11 METAL CHIP

820

5%

R933

1-216-820-11 METAL CHIP

820

5%

LED914 6-500-204-01 LED CL-190UB2-X-T (DISC/PRESET +) (F7700) LED914 6-500-450-01 LED CL-195SR-CD-T (DISC/PRESET +) (F7500) LED915 6-500-204-01 LED CL-190UB2-X-T (SEEK –/./m) (F7700) LED915 6-500-450-01 LED CL-195SR-CD-T (SEEK –/./m) (F7500) LED916 6-500-204-01 LED CL-190UB2-X-T (DISC/PRESET –) (F7700)

Ref. No.

Remark

LED916 6-500-450-01 LED CL-195SR-CD-T (DISC/PRESET –) (F7500) LED917 LED917 LED918 LED918

6-500-204-01 6-500-450-01 6-500-204-01 6-500-450-01

LED LED LED LED

CL-190UB2-X-T (DSO) (F7700) CL-195SR-CD-T (DSO) (F7500) CL-190UB2-X-T (MODE) (F7700) CL-195SR-CD-T (MODE) (F7500)

LED919 LED919 LED920 LED920 LED921

6-500-204-01 6-500-450-01 6-500-204-01 6-500-450-01 6-500-204-01

LED LED LED LED LED

CL-190UB2-X-T (VOL1) (F7700) CL-195SR-CD-T (VOL1) (F7500) CL-190UB2-X-T (VOL2) (F7700) CL-195SR-CD-T (VOL2) (F7500) CL-190UB2-X-T (VOL3) (F7700)

LED921 LED922 LED922 LED923 LED923

6-500-450-01 6-500-204-01 6-500-450-01 6-500-204-01 6-500-450-01

LED LED LED LED LED

CL-195SR-CD-T (VOL3) (F7500) CL-190UB2-X-T (VOL4) (F7700) CL-195SR-CD-T (VOL4) (F7500) CL-190UB2-X-T (OPEN) (F7700) CL-195SR-CD-T (OPEN) (F7500)

LED924 6-500-204-01 LED CL-190UB2-X-T (SOURCE) (F7700) LED924 6-500-450-01 LED CL-195SR-CD-T (SOURCE) (F7500) < SWITCH >

1/10W (F7500) 1/10W (F7700) 1/10W (F7500) 1/10W (F7500) 1/10W (F7700) 1/10W (F7500) 1/10W (F7500) 1/10W (F7700) 1/10W (F7500) 1/10W (F7500) 1/10W (F7700) 1/10W (F7500) 1/10W (F7500) 1/10W (F7700) 1/10W (F7500) 1/10W (F7500) 1/10W (F7700) 1/10W (F7500) 1/10W (F7500) 1/10W (F7700)

< RESISTOR > R901 R902 R903 R904

1-219-286-11 1-219-286-11 1-219-286-11 1-218-847-11

RES-CHIP RES-CHIP RES-CHIP METAL CHIP

680 680 680 1K

2% 2% 2% 0.5%

1/16W 1/16W 1/16W 1/10W

1/10W (F7500) 1/10W (F7500)

45

CDX-F7500/F7700 KEY Ref. No.

MAIN Part No.

Description

Remark

R934

1-216-811-11 METAL CHIP

150

5%

1/10W (F7700) 1/10W (F7500) 1/10W (F7500) 1/10W (F7700) 1/10W (F7500)

R934

1-216-820-11 METAL CHIP

820

5%

R935

1-216-820-11 METAL CHIP

820

5%

R936

1-216-811-11 METAL CHIP

150

5%

R936

1-216-820-11 METAL CHIP

820

5%

R937

1-216-820-11 METAL CHIP

820

5%

R938

1-216-811-11 METAL CHIP

150

5%

R938

1-216-820-11 METAL CHIP

820

5%

R939

1-216-820-11 METAL CHIP

820

5%

R946

1-218-855-11 METAL CHIP

2.2K

0.5%

1/10W (F7500) 1/10W (F7700) 1/10W (F7500) 1/10W (F7500) 1/10W

R947 R953 R954 R955 R958

1-218-855-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

2.2K 100K 100K 100K 100K

0.5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R959 R960 R961 R970 R971

1-216-845-11 1-216-845-11 1-216-005-00 1-216-833-11 1-216-833-11

METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP

100K 100K 15 10K 10K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R972 R973 R975 R976 R977

1-216-809-11 1-216-831-11 1-216-845-11 1-216-819-11 1-216-821-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

100 6.8K 100K 680 1K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R978 R979

1-218-863-11 METAL CHIP 1-216-821-11 METAL CHIP

4.7K 1K

0.5% 5%

R979

1-216-823-11 METAL CHIP

1.5K

5%

R980

1-216-821-11 METAL CHIP

1K

5%

R980

1-216-823-11 METAL CHIP

1.5K

5%

1/10W 1/10W (F7700) 1/10W (F7500) 1/10W (F7700) 1/10W (F7500)

Ref. No.

Part No.

Description

S904 S905 S906 S907 S908

1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31 1-771-884-31

SWITCH, TACTILE (SEEK –/./m) SWITCH, TACTILE (DISC/PRESET +) SWITCH, TACTILE (DISC/PRESET –) SWITCH, TACTILE (MODE) SWITCH, TACTILE (DSO)

Remark

S909 S910 S912

1-771-884-31 SWITCH, TACTILE (SCRL) 1-771-884-31 SWITCH, TACTILE (EQ7) 1-771-884-31 SWITCH, TACTILE (IMAGE) < VIBRATOR >

R981

1-216-823-11 METAL CHIP

1.5K

5%

R982 R983

1-216-821-11 METAL CHIP 1-216-821-11 METAL CHIP

1K 1K

5% 5%

R983

1-216-823-11 METAL CHIP

1.5K

5%

R984

1-216-821-11 METAL CHIP

1K

5%

R984

1-216-823-11 METAL CHIP

1.5K

5%

R985

1-216-823-11 METAL CHIP

1.5K

5%

R987

1-216-845-11 METAL CHIP

100K

5%

< SWITCH > S902 S903

46

1-771-884-31 SWITCH, TACTILE (OFF) 1-771-884-31 SWITCH, TACTILE (SEEK +/ >/M)

1/10W (F7500) 1/10W 1/10W (F7700) 1/10W (F7500) 1/10W (F7700) 1/10W (F7500) 1/10W (F7500) 1/10W

X901 1-813-250-11 VIBRATOR, CRYSTAL (SMD) (8MHz) ************************************************************* A-3283-454-A MAIN BOARD, COMPLETE (F7500) A-3283-460-A MAIN BOARD, COMPLETE (F7700) ********************* 7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT 7-685-793-09 SCREW +PTT 2.6X8 (S) 7-685-795-09 SCREW +PTT 2.6X12 (S) < CAPACITOR > C101 C102 C103 C106 C110

1-126-940-11 1-126-960-11 1-131-868-81 1-115-340-11 1-107-826-11

C111 C142 C172

ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP

330uF 1uF 3300uF 0.22uF 0.1uF

20% 20% 20% 10% 10%

25V 50V 16V 25V 16V

1-107-826-11 CERAMIC CHIP 1-162-927-11 CERAMIC CHIP 1-126-044-11 ELECT

0.1uF 100PF 1uF

10% 5% 20%

C173

1-124-721-11 ELECT

10uF

20%

C173

1-126-964-11 ELECT

10uF

20%

16V 50V 50V (F7700) 50V (F7700) 50V (F7500)

C178 C182

1-162-927-11 CERAMIC CHIP 1-126-044-11 ELECT

100PF 1uF

5% 20%

C183

1-124-721-11 ELECT

10uF

20%

C183

1-126-964-11 ELECT

10uF

20%

C188

1-162-927-11 CERAMIC CHIP

100PF

5%

C199 C201 C202 C203 C204

1-162-964-11 1-115-467-11 1-162-923-11 1-126-961-11 1-124-695-11

0.001uF 0.22uF 47PF 2.2uF 22uF

10% 10% 5% 20% 20%

50V 10V 50V 50V 25V (F7700)

C204

1-126-965-11 ELECT

22uF

20%

C205 C206 C207 C208

1-115-340-11 1-125-891-11 1-125-891-11 1-162-927-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.22uF 0.47uF 0.47uF 100PF

10% 10% 10% 5%

25V (F7500) 25V 10V 10V 50V

C209 C210 C211 C212 C214

1-162-927-11 1-115-340-11 1-165-908-11 1-126-964-11 1-126-964-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT

100PF 0.22uF 1uF 10uF 10uF

5% 10% 10% 20% 20%

50V 25V 10V 50V 50V

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT

50V 50V (F7700) 50V (F7700) 50V (F7500) 50V

CDX-F7500/F7700 MAIN Ref. No.

Part No.

Description

C215 C216 C217 C218 C219

1-115-340-11 1-162-927-11 1-162-927-11 1-125-891-11 1-125-891-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.22uF 100PF 100PF 0.47uF 0.47uF

10% 5% 5% 10% 10%

25V 50V 50V 10V 10V

Remark

C221 C223 C225 C226 C227

1-126-933-11 1-126-964-11 1-125-837-11 1-126-964-11 1-115-340-11

ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP

100uF 10uF 1uF 10uF 0.22uF

20% 20% 10% 20% 10%

16V 50V 6.3V 50V 25V

C242 C271 C272

1-162-927-11 CERAMIC CHIP 1-126-964-11 ELECT 1-126-044-11 ELECT

100PF 10uF 1uF

5% 20% 20%

C273

1-124-721-11 ELECT

10uF

20%

C273

1-126-964-11 ELECT

10uF

20%

50V 50V 50V (F7700) 50V (F7700) 50V (F7500)

C278 C282

1-162-927-11 CERAMIC CHIP 1-126-044-11 ELECT

100PF 1uF

5% 20%

C283

1-124-721-11 ELECT

10uF

20%

C283

1-126-964-11 ELECT

10uF

20%

C288

1-162-927-11 CERAMIC CHIP

100PF

5%

C303 C304 C306 C307 C308

1-126-933-11 1-107-826-11 1-126-933-11 1-107-826-11 1-126-044-11

100uF 0.1uF 100uF 0.1uF 1uF

20% 10% 20% 10% 20%

ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT

50V 50V (F7700) 50V (F7700) 50V (F7500) 50V 16V 16V 16V 16V 50V (F7700)

Ref. No.

Part No.

Description

Remark

C400

1-124-721-11 ELECT

10uF

20%

C401 C403 C416 C417

1-126-947-11 1-125-891-11 1-125-837-11 1-125-837-11

47uF 0.47uF 1uF 1uF

20% 10% 10% 10%

C418

1-124-721-11 ELECT

10uF

20%

C418

1-126-964-11 ELECT

10uF

20%

C419 C420 C421

1-126-959-11 ELECT 1-126-959-11 ELECT 1-125-837-11 CERAMIC CHIP

0.47uF 0.47uF 1uF

20% 20% 10%

C422

1-124-673-11 ELECT

100uF

20%

C422

1-126-933-11 ELECT

100uF

20%

C423 C424 C425

1-162-970-11 CERAMIC CHIP 1-162-965-11 CERAMIC CHIP 1-136-154-00 FILM

0.01uF 10% 0.0015uF 10% 0.012uF 5%

10V (F7700) 16V (F7500) 25V 50V 50V

C426 C427 C428 C429 C430

1-162-927-11 1-162-927-11 1-162-927-11 1-162-927-11 1-162-965-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

100PF 100PF 100PF 100PF 0.0015uF

5% 5% 5% 5% 10%

50V 50V 50V 50V 50V

C431 C432 C433 C434 C435

1-162-927-11 1-136-154-00 1-126-960-11 1-126-960-11 1-126-960-11

CERAMIC CHIP FILM ELECT ELECT ELECT

100PF 0.012uF 1uF 1uF 1uF

5% 5% 20% 20% 20%

50V 50V 50V 50V 50V

C436

1-164-156-11 CERAMIC CHIP

0.1uF

C437

1-124-673-11 ELECT

100uF

C438

1-162-965-11 CERAMIC CHIP

0.0015uF 10%

C439

1-162-965-11 CERAMIC CHIP

0.0015uF 10%

C440

1-124-673-11 ELECT

100uF

20%

ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

C308

1-126-960-11 ELECT

1uF

20%

C309

1-126-044-11 ELECT

1uF

20%

C309

1-126-960-11 ELECT

1uF

20%

C311 C312

1-125-710-11 DOUBLE LAYERS 0.1F 1-126-933-11 ELECT 100uF

20%

50V (F7500) 50V (F7700) 50V (F7500) 5.5V 16V

C313 C315 C316 C317 C318

1-164-156-11 1-162-919-11 1-162-918-11 1-162-970-11 1-165-176-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 22PF 18PF 0.01uF 0.047uF

25V 50V 50V 25V 16V

C441

1-124-721-11 ELECT

10uF

20%

5% 5% 10% 10%

C442 C443 C444

1-162-927-11 CERAMIC CHIP 1-126-964-11 ELECT 1-124-721-11 ELECT

100PF 10uF 10uF

5% 20% 20%

C319 C320 C321 C322 C323

1-162-970-11 1-126-961-11 1-126-964-11 1-162-920-11 1-162-920-11

CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP

0.01uF 2.2uF 10uF 27PF 27PF

10% 20% 20% 5% 5%

25V 50V 50V 50V 50V

C445

1-124-721-11 ELECT

10uF

20%

C446

1-124-721-11 ELECT

10uF

20%

C447

1-124-721-11 ELECT

10uF

20%

C324 C325 C330 C332 C333

1-126-964-11 1-162-970-11 1-162-964-11 1-164-156-11 1-126-933-11

ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT

10uF 0.01uF 0.001uF 0.1uF 100uF

20% 10% 10%

C448

1-124-721-11 ELECT

10uF

20%

C449

1-124-721-11 ELECT

10uF

20%

20%

50V 25V 50V 25V 16V

C450

1-124-721-11 ELECT

10uF

20%

C334 C335 C336 C341 C342

1-107-826-11 1-126-933-11 1-107-826-11 1-162-966-11 1-162-966-11

CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 100uF 0.1uF 0.0022uF 0.0022uF

10% 20% 10% 10% 10%

16V 16V 16V 50V 50V

C451

1-124-721-11 ELECT

10uF

20%

20%

50V (F7700) 35V 10V 6.3V 6.3V 50V (F7700) 50V (F7500) 50V 50V 6.3V

25V (F7700) 10V (F7700) 50V (F7700) 50V (F7700) 10V (F7700) 50V (F7700) 50V 50V 50V (F7700) 50V (F7700) 50V (F7700) 50V (F7700) 50V (F7700) 50V (F7700) 50V (F7700) 50V (F7700)

47

CDX-F7500/F7700 MAIN Ref. No.

Part No.

Description

Remark

Part No.

Description

D109 D110 D111 D112 D113

8-719-200-82 8-719-053-18 8-719-053-18 8-719-053-18 8-719-053-18

DIODE DIODE DIODE DIODE DIODE

11ES2 1SR154-400TE-25 1SR154-400TE-25 1SR154-400TE-25 1SR154-400TE-25

D114 D115 D116 D117 D118

8-719-053-18 8-719-053-18 8-719-053-18 8-719-053-18 6-500-508-01

DIODE DIODE DIODE DIODE DIODE

1SR154-400TE-25 1SR154-400TE-25 1SR154-400TE-25 1SR154-400TE-25 RR263M-400FTR

D119 D120 D121 D122 D123

6-500-508-01 6-500-508-01 6-500-508-01 8-719-978-33 8-719-200-82

DIODE DIODE DIODE DIODE DIODE

RR263M-400FTR RR263M-400FTR RR263M-400FTR DTZ-TT11-6.8B 11ES2

D271 D275 D301 D302 D305

8-719-801-78 8-719-420-51 8-719-420-51 8-719-420-51 8-719-988-61

DIODE DIODE DIODE DIODE DIODE

1SS184 MA729 MA729 MA729 1SS355TE-17

D306 D401 D403 D501 D601

8-719-988-61 8-719-404-50 8-719-069-55 8-719-069-55 8-719-978-33

DIODE DIODE DIODE DIODE DIODE

1SS355TE-17 MA111-TX UDZS-TE17-5.6B UDZS-TE17-5.6B DTZ-TT11-6.8B

D602 D603 D604 D605 D606

8-719-978-33 8-719-978-33 8-719-978-33 6-500-886-01 6-500-886-01

DIODE DIODE DIODE DIODE DIODE

DTZ-TT11-6.8B DTZ-TT11-6.8B DTZ-TT11-6.8B RSA6.1ENTR RSA6.1ENTR

D620 D621 D622 D623 D624

8-719-053-18 8-719-053-18 8-719-055-33 8-719-055-30 8-719-055-30

DIODE DIODE DIODE DIODE DIODE

1SR154-400TE-25 1SR154-400TE-25 D1FL40 D1FS4A-TA D1FS4A-TA

D625 D626 D627 D904 D907

8-719-083-66 8-719-069-54 8-719-420-51 8-719-801-78 8-719-988-61

DIODE DIODE DIODE DIODE DIODE

UDZS-TE17-18B UDZS-TE17-5.1B MA729 1SS184 1SS355TE-17

PIN, CONNECTOR (PC BOARD) 3P SOCKET, CONNECTOR 22P PIN, CONNECTOR 16P PLUG, CONNECTOR (BUS CONTROL IN) CONNECTOR, BOARD TO BOARD 28P

D909 D910 D911

8-719-988-61 DIODE 1SS355TE-17 8-719-069-55 DIODE UDZS-TE17-5.6B 8-719-420-51 DIODE MA729

< JACK >

FB324 FB325 FB326 FB327 FB328

1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11 1-414-813-11

FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD)

FB329 FB330 FB441 FB442

1-216-295-11 1-216-295-11 1-414-813-11 1-414-813-11

SHORT CHIP 0 SHORT CHIP 0 FERRITE, EMI (SMD) FERRITE, EMI (SMD)

C452

1-164-156-11 CERAMIC CHIP

0.1uF

C453

1-164-156-11 CERAMIC CHIP

0.1uF

C470

1-126-960-11 ELECT

1uF

20%

C475

1-107-826-11 CERAMIC CHIP

0.1uF

10%

C501

1-162-970-11 CERAMIC CHIP

0.01uF

10%

25V (F7700) 25V (F7700) 50V (F7700) 16V (F7700) 25V

C502 C503 C507 C508 C509

1-126-964-11 1-126-963-11 1-126-933-11 1-125-837-11 1-125-837-11

ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP

10uF 4.7uF 100uF 1uF 1uF

20% 20% 20% 10% 10%

50V 50V 16V 6.3V 6.3V

C510 C511 C550 C551 C552

1-135-834-11 1-162-970-11 1-162-926-11 1-162-923-11 1-162-970-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

2.2uF 0.01uF 82PF 47PF 0.01uF

10% 5% 5% 10%

6.3V 25V 50V 50V 25V

C553 C554 C555 C556 C557

1-126-947-11 1-162-970-11 1-135-834-11 1-164-739-11 1-162-959-11

ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

47uF 0.01uF 2.2uF 560PF 330PF

20% 10% 5% 5%

35V 25V 6.3V 50V 50V

C558 C620 C621 C622 C623

1-162-965-11 1-104-665-11 1-128-552-11 1-126-934-11 1-126-964-11

CERAMIC CHIP ELECT ELECT ELECT ELECT

0.0015uF 100uF 47uF 220uF 10uF

10% 20% 20% 20% 20%

50V 25V 63V 16V 50V

C624 C625 C626 C627 C628

1-164-315-11 1-162-966-11 1-107-826-11 1-162-923-11 1-107-826-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

470PF 0.0022uF 0.1uF 47PF 0.1uF

5% 10% 10% 5% 10%

50V 50V 16V 50V 16V

C629 C901 C903 C928 C930

1-126-933-11 1-126-965-11 1-126-963-11 1-164-156-11 1-126-965-11

ELECT ELECT ELECT CERAMIC CHIP ELECT

100uF 22uF 4.7uF 0.1uF 22uF

20% 20% 20%

16V 50V 50V 25V 50V

20%

< CONNECTOR > * CN401 CN601 CNP101 CNP102 CNP301

1-506-985-11 1-569-915-11 1-774-701-21 1-580-907-41 1-817-536-11

CNJ101 1-764-270-21 JACK, STEREO MINIATURE (DIA.3.5) (REMOTE IN)

Ref. No.

< FERRITE BEAD >

< DIODE > D101 D102 D103 D104 D105

8-719-083-66 8-719-083-66 8-719-420-51 8-719-069-56 8-719-083-66

D106 D108

8-719-978-33 DIODE DTZ-TT11-6.8B 8-719-083-66 DIODE UDZS-TE17-18B

48

DIODE DIODE DIODE DIODE DIODE

UDZS-TE17-18B UDZS-TE17-18B MA729 UDZS-TE17-6.2B UDZS-TE17-18B

< IC > IC110 IC201

8-759-096-16 IC MM1175XFF 6-705-359-01 IC TDA8588AJ/N2

Remark

CDX-F7500/F7700 Ver 1.1

MAIN Ref. No.

Part No.

Description

Part No.

Description

IC252 IC271 IC273 IC302 IC303

8-759-679-05 6-705-373-01 8-759-679-05 8-759-658-25 6-803-990-01

IC IC IC IC IC

TC7WH34FU(TE12R) MM3123DPLE TC7WH34FU(TE12R) PST3432UL M30624MGP-123GP

Remark

Q452 Q453 Q470 Q501 Q601

6-550-752-01 6-550-752-01 6-550-752-01 8-729-920-85 8-729-055-91

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

DTC614TKT146 (F7700) DTC614TKT146 (F7700) DTC614TKT146 2SD1664-QR SRA2202SF

IC401 IC402 IC431 IC451 IC470

6-703-303-01 6-703-419-01 6-705-720-01 6-705-720-01 6-705-720-01

IC IC IC IC IC

TDA7416 LA2901V-TLM-E (F7700) RC4580IDR (F7700) RC4580IDR (F7700) RC4580IDR (F7700)

Q602 Q620 Q621 Q622 Q623

8-729-055-95 8-729-048-72 8-729-055-91 8-729-055-95 8-729-055-95

TRANSISTOR FET 2SK2615 TRANSISTOR TRANSISTOR TRANSISTOR

SRC1204SF

IC550 IC620

6-703-809-01 IC SAA6588T/V2-518 6-705-542-01 IC NJM2377M(TE2)

Q624 Q907 Q914 Q915 Q916

6-550-828-01 8-729-120-28 8-729-055-91 8-729-015-11 8-729-055-94

FET RSQ035P03TR TRANSISTOR 2SC1623-L5L6 TRANSISTOR SRA2202SF TRANSISTOR 2SD1802FAST-TL TRANSISTOR SRC1202SF

< JACK > J601

Ref. No.

Remark

SRA2202SF SRC1204SF SRC1204SF

1-793-598-11 JACK (ANTENNA) < RESISTOR > < JUMPER RESISTOR >

JR301 JR302

1-216-864-11 SHORT CHIP 1-162-927-11 CERAMIC CHIP

0 100PF

5%

50V

< COIL >

R101 R102 R103 R104 R105

1-216-077-11 1-216-049-11 1-216-821-11 1-216-829-11 1-216-841-11

RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP

15K 1K 1K 4.7K 47K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

L101 L301 L302 L303 L320

1-456-617-11 1-414-394-41 1-414-394-41 1-414-398-11 1-414-394-41

COIL, CHOKE INDUCTOR INDUCTOR INDUCTOR INDUCTOR

250uH 2.2uH 2.2uH 10uH 2.2uH

R106 R107 R108 R109 R110

1-216-841-11 1-216-073-00 1-216-073-00 1-216-833-11 1-216-833-11

METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP

47K 10K 10K 10K 10K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

L401 L501 L502 L503 L620

1-414-394-41 1-216-296-11 1-414-394-41 1-414-394-41 1-456-729-11

INDUCTOR SHORT CHIP INDUCTOR INDUCTOR COIL, POWER

2.2uH 0 2.2uH 2.2uH

R111 R112 R114 R115 R116

1-216-841-11 1-216-821-11 1-216-809-11 1-216-809-11 1-216-809-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

47K 1K 100 100 100

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

L901

1-414-394-41 INDUCTOR

2.2uH

R117 R118 R142 R143 R172

1-216-797-11 1-216-829-11 1-216-825-11 1-216-833-11 1-216-295-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP

10 4.7K 2.2K 10K 0 (F7500)

5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W

R174

1-216-809-11 METAL CHIP

100

5%

R174

1-216-813-11 METAL CHIP

220

5%

R175 R182 R184

1-216-841-11 METAL CHIP 1-216-295-11 SHORT CHIP 1-216-809-11 METAL CHIP

47K 5% 0 (F7500) 100 5%

1/10W (F7500) 1/10W (F7700) 1/10W

R184

1-216-813-11 METAL CHIP

220

5%

R185 R201 R202 R203

1-216-841-11 1-216-841-11 1-216-809-11 1-216-821-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP

47K 47K 100 1K

5% 5% 5% 5%

1/10W (F7700) 1/10W 1/10W 1/10W 1/10W

R204 R205 R206 R240 R241

1-216-821-11 1-216-821-11 1-216-821-11 1-216-049-11 1-216-049-11

METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP

1K 1K 1K 1K 1K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R242 R243 R267

1-216-825-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-845-11 METAL CHIP

2.2K 10K 100K

5% 5% 5%

1/10W 1/10W 1/10W

< JACK > PJ401

1-774-700-11 JACK, PIN 6P (BUS AUDIO IN, AUDIO OUT REAR/FRONT) < TRANSISTOR >

Q101 Q102 Q103 Q110 Q111

8-729-055-94 8-729-120-28 8-729-120-28 8-729-055-91 8-729-055-94

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

SRC1202SF 2SC1623-L5L6 2SC1623-L5L6 SRA2202SF SRC1202SF

Q112 Q171 Q181 Q267 Q270

8-729-055-91 6-550-752-01 6-550-752-01 8-729-055-94 8-729-053-84

TRANSISTOR SRA2202SF TRANSISTOR DTC614TKT146 TRANSISTOR DTC614TKT146 TRANSISTOR SRC1202SF FET SSM3KO9FU(T5LSONY1)

Q271 Q273 Q281 Q380 Q401

6-550-752-01 8-729-053-84 6-550-752-01 8-729-055-95 8-729-055-95

TRANSISTOR DTC614TKT146 FET SSM3KO9FU(T5LSONY1) TRANSISTOR DTC614TKT146 TRANSISTOR SRC1204SF TRANSISTOR SRC1204SF

Q402 Q408 Q450 Q451

8-729-055-91 8-729-053-84 6-550-752-01 6-550-752-01

TRANSISTOR SRA2202SF FET SSM3KO9FU(T5LSONY1) TRANSISTOR DTC614TKT146 (F7700) TRANSISTOR DTC614TKT146 (F7700)

1/10W (F7500)

49

CDX-F7500/F7700 MAIN Ref. No.

Part No.

Description

R270 R271 R272 R273 R274

1-216-837-11 1-216-845-11 1-216-295-11 1-216-837-11 1-216-809-11

METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP

R274

Remark 22K 100K 0 (F7500) 22K 100

5% 5%

1/10W 1/10W

5% 5%

1/10W 1/10W (F7500)

1-216-813-11 METAL CHIP

220

5%

R275 R282 R284

1-216-841-11 METAL CHIP 1-216-295-11 SHORT CHIP 1-216-809-11 METAL CHIP

47K 5% 0 (F7500) 100 5%

1/10W (F7700) 1/10W

R284

1-216-813-11 METAL CHIP

220

5%

R285 R300 R301 R302 R304

1-216-841-11 1-216-864-11 1-216-864-11 1-216-845-11 1-216-845-11

METAL CHIP SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP

47K 0 0 100K 100K

5%

1/10W

5% 5%

1/10W 1/10W

R311 R312 R314 R319 R322

1-216-845-11 1-216-845-11 1-216-845-11 1-216-821-11 1-216-827-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

100K 100K 100K 1K 3.3K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R323 R326 R330 R332 R333

1-216-827-11 1-216-853-11 1-216-845-11 1-218-871-11 1-216-809-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

3.3K 470K 100K 10K 100

5% 5% 5% 0.5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R335 R341 R342 R343 R344

1-216-837-11 1-216-845-11 1-216-833-11 1-216-845-11 1-216-833-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

22K 100K 10K 100K 10K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R345 R346 R350 R351 R356

1-216-833-11 1-216-833-11 1-216-809-11 1-216-809-11 1-218-871-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

10K 10K 100 100 10K

5% 5% 5% 5% 0.5%

1/10W 1/10W 1/10W 1/10W 1/10W

R357 R361 R363 R364 R365

1-218-871-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

10K 100K 100K 100K 100K

0.5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R366 R367 R369 R370

1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP

100K 100K 100K 100K

5% 5% 5% 5%

R371

1-216-845-11 METAL CHIP

100K

5%

1/10W 1/10W 1/10W 1/10W (F7500) 1/10W (F7700)

1/10W (F7500) 1/10W (F7700)

R377 R380 R381 R385 R391

1-216-845-11 1-216-809-11 1-216-845-11 1-216-864-11 1-216-845-11

METAL CHIP METAL CHIP METAL CHIP SHORT CHIP METAL CHIP

100K 100 100K 0 100K

5% 5% 5%

1/10W 1/10W 1/10W

5%

1/10W

R393 R401

1-216-845-11 METAL CHIP 1-216-017-11 RES-CHIP

100K 47

5% 5%

1/10W 1/10W

50

Ref. No.

Part No.

Description

Remark

R402

1-216-813-11 METAL CHIP

220

5%

R402 R403 R407 R408

1-216-864-11 1-216-295-11 1-216-841-11 1-216-809-11

SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP

0 (F7500) 0 47K 5% 100 5%

1/10W 1/10W

R410 R414 R415 R416 R417

1-216-295-11 1-216-833-11 1-216-833-11 1-216-809-11 1-216-809-11

SHORT CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

0 10K 10K 100 100

5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W

R418 R419 R420 R421 R422

1-216-809-11 1-216-809-11 1-216-833-11 1-216-833-11 1-216-813-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

100 100 10K 10K 220

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R424 R426 R427 R429

1-216-825-11 1-216-864-11 1-216-864-11 1-216-086-00

METAL CHIP SHORT CHIP SHORT CHIP RES-CHIP

2.2K 0 0 36K

5%

1/10W

5%

1/10W (F7700)

R429

1-216-295-11 SHORT CHIP

0 (F7500)

R430

1-216-082-00 RES-CHIP

24K

5%

R431

1-216-086-00 RES-CHIP

36K

5%

1/10W (F7700) 1/10W (F7700)

R431 R432

1-216-295-11 SHORT CHIP 1-216-082-00 RES-CHIP

0 (F7500) 24K 5%

R433

1-216-086-00 RES-CHIP

36K

R433 R434

1-216-295-11 SHORT CHIP 1-216-082-00 RES-CHIP

0 (F7500) 24K 5%

R435

1-216-086-00 RES-CHIP

36K

R435 R436

1-216-295-11 SHORT CHIP 1-216-082-00 RES-CHIP

0 (F7500) 24K 5%

R437

1-216-833-11 METAL CHIP

10K

5%

R438

1-216-835-11 METAL CHIP

15K

5%

R443 R444 R445

1-216-864-11 SHORT CHIP 1-216-864-11 SHORT CHIP 1-216-864-11 SHORT CHIP

0 (F7500) 0 (F7500) 0 (F7500)

R446 R447

1-216-864-11 SHORT CHIP 1-216-845-11 METAL CHIP

0 (F7500) 100K 5%

R448

1-216-845-11 METAL CHIP

100K

5%

R449

1-216-835-11 METAL CHIP

15K

5%

R450

1-216-833-11 METAL CHIP

10K

5%

R451

1-216-835-11 METAL CHIP

15K

5%

R452

1-216-833-11 METAL CHIP

10K

5%

R453

1-216-845-11 METAL CHIP

100K

5%

5%

5%

1/10W (F7700)

1/10W (F7700) 1/10W (F7700)

1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700)

1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700)

CDX-F7500/F7700 MAIN Ref. No.

Part No.

Description

Remark

R454

1-216-845-11 METAL CHIP

100K

5%

R455

1-216-835-11 METAL CHIP

15K

5%

R456

1-216-833-11 METAL CHIP

10K

5%

R457

1-216-813-11 METAL CHIP

220

5%

R458

1-216-813-11 METAL CHIP

220

5%

R459

1-216-813-11 METAL CHIP

220

5%

R460

1-216-813-11 METAL CHIP

220

5%

R461

1-216-841-11 METAL CHIP

47K

5%

R462

1-216-841-11 METAL CHIP

47K

5%

R463

1-216-841-11 METAL CHIP

47K

5%

R464

1-216-841-11 METAL CHIP

47K

5%

R465 R471 R472

1-216-864-11 SHORT CHIP 1-216-864-11 SHORT CHIP 1-216-835-11 METAL CHIP

0 (F7700) 0 (F7700) 15K 5%

R473

1-216-833-11 METAL CHIP

10K

1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700)

Ref. No.

SENSOR

SERVO

Part No.

Description

R643 R910 R920 R921 R922

1-216-296-11 1-216-845-11 1-216-073-00 1-216-073-00 1-216-845-11

SHORT CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP

0 100K 10K 10K 100K

Remark 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W

R929 R949 R950

1-216-837-11 METAL CHIP 1-216-057-00 RES-CHIP 1-216-057-00 RES-CHIP

22K 2.2K 2.2K

5% 5% 5%

1/10W 1/10W 1/10W

< SWITCH > 1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700) 1/10W (F7700)

S300 S301

< TRANSFORMER > T620

5%

1-443-212-11 TRANSFORMER, DC-DC CONVERTER < THERMISTOR (POSITIVE) >

TH100

5%

1-786-458-11 SWITCH, PUSH (1 KEY) (NOSE DET) 1-762-638-21 SWITCH, TACTILE (RESET)

1-801-792-21 THERMISTOR, POSITIVE

1/10W (F7700)

< TUNER > TUX501 A-3220-961-A TUNER UNIT (TUX-032//Q3)

1/10W (F7700) 1/10W (F7700)

R477

1-216-841-11 METAL CHIP

47K

1/10W (F7700)

R478 R501 R502 R504

1-216-864-11 1-216-821-11 1-216-864-11 1-216-864-11

SHORT CHIP METAL CHIP SHORT CHIP SHORT CHIP

0 (F7500) 1K 5% 0 0

R550 R551 R552 R553 R600

1-216-827-11 1-216-817-11 1-216-797-11 1-216-797-11 1-216-295-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP

3.3K 470 10 10 0

5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W

R601 R602 R603 R620 R621

1-216-029-00 1-216-029-00 1-216-029-00 1-216-230-00 1-216-230-00

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

150 150 150 22K 22K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/8W 1/8W

R622 R623 R624 R625 R626

1-218-863-11 1-218-895-11 1-218-847-11 1-216-025-11 1-216-848-11

METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP

4.7K 100K 1K 100 180K

0.5% 0.5% 0.5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R627 R628 R629 R630 R631

1-216-846-11 1-216-841-11 1-216-833-11 1-216-837-11 1-216-833-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

120K 47K 10K 22K 10K

5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W

R632 R633 R634 R635 R636

1-216-841-11 1-216-809-11 1-216-833-11 1-216-864-11 1-216-839-11

METAL CHIP METAL CHIP METAL CHIP SHORT CHIP METAL CHIP

47K 100 10K 0 33K

5% 5% 5%

1/10W 1/10W 1/10W

5%

1/10W

R642

1-216-296-11 SHORT CHIP

< VIBRATOR > X301 1-813-202-11 VIBRATOR, CRYSTAL (32.768kHz) X302 1-813-254-11 VIBRATOR, CRYSTAL (6MHz) X550 1-579-900-21 VIBRATOR, CRYSTAL (4.332MHz) ************************************************************* SENSOR BOARD **************

1/10W

< SWITCH >

0

SW2 1-529-566-61 SWITCH, PUSH (1 KEY) (SELF) SW3 1-529-566-61 SWITCH, PUSH (1 KEY) (DISC IN) ************************************************************* A-3283-359-A SERVO BOARD, COMPLETE ********************** < CAPACITOR > C1 C2 C3 C4 C5

1-162-970-11 1-162-970-11 1-162-970-11 1-162-970-11 1-107-826-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.01uF 0.01uF 0.01uF 0.01uF 0.1uF

10% 10% 10% 10% 10%

25V 25V 25V 25V 16V

C6 C7 C8 C10 C11

1-162-970-11 1-162-962-11 1-162-962-11 1-104-609-11 1-107-826-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP

0.01uF 470PF 470PF 100uF 0.1uF

10% 10% 10% 20% 10%

25V 50V 50V 4V 16V

C13 C14 C16 C18 C19

1-162-965-11 1-162-965-11 1-107-826-11 1-164-227-11 1-164-227-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.0015uF 0.0015uF 0.1uF 0.022uF 0.022uF

10% 10% 10% 10% 10%

50V 50V 16V 25V 25V

C21 C22 C23

1-107-826-11 CERAMIC CHIP 1-162-962-11 CERAMIC CHIP 1-162-967-11 CERAMIC CHIP

0.1uF 10% 470PF 10% 0.0033uF 10%

16V 50V 50V

51

CDX-F7500/F7700 SERVO Ref. No.

Part No.

Description

C24 C25 C26 C27 C28

1-162-962-11 1-162-967-11 1-162-970-11 1-126-208-21 1-107-826-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP

470PF 0.0033uF 0.01uF 47uF 0.1uF

Remark

C29 C30 C32 C33 C34

1-164-156-11 1-107-826-11 1-164-156-11 1-164-156-11 1-107-826-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

C35 C36 C37 C38 C39

1-107-826-11 1-162-970-11 1-164-677-11 1-107-826-11 1-162-927-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

C40 C41 C42 C43 C44

1-162-969-11 1-164-156-11 1-162-970-11 1-125-837-11 1-162-970-11

C45 C46 C47 C48 C49

10% 10% 10% 20% 10%

50V 50V 25V 4V 16V

Ref. No.

Part No.

Description

Remark

< JUMPER RESISTOR > FB1 FB2 FB5

1-216-864-11 SHORT CHIP 1-216-864-11 SHORT CHIP 1-216-864-11 SHORT CHIP

0 0 0

< IC >

10%

25V 16V 25V 25V 16V

0.1uF 0.01uF 0.033uF 0.1uF 100PF

10% 10% 10% 10% 5%

16V 25V 16V 16V 50V

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.0068uF 0.1uF 0.01uF 1uF 0.01uF

10% 10% 10% 10%

25V 25V 25V 6.3V 25V

1-162-970-11 1-162-965-11 1-107-826-11 1-104-609-11 1-125-837-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP

0.01uF 0.0015uF 0.1uF 100uF 1uF

10% 10% 10% 20% 10%

25V 50V 16V 4V 6.3V

R1 R2 R3 R4 R5

1-218-941-81 1-218-971-11 1-218-971-11 1-218-965-11 1-218-965-11

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

100 33K 33K 10K 10K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

C50 C51 C52 C53 C54

1-125-837-11 1-164-156-11 1-100-381-11 1-100-381-11 1-164-156-11

CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT CHIP CERAMIC CHIP

1uF 0.1uF 10uF 10uF 0.1uF

10%

6.3V 25V 16V 16V 25V

R6 R7 R8 R9 R10

1-218-965-11 1-208-635-11 1-218-971-11 1-218-971-11 1-218-965-11

RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP

10K 10 33K 33K 10K

5% 0.5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

C55 C56 C57 C58 C59

1-164-156-11 1-162-970-11 1-164-156-11 1-107-826-11 1-107-826-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 0.01uF 0.1uF 0.1uF 0.1uF

25V 25V 25V 16V 16V

R11 R12 R13 R14 R15

1-218-965-11 1-208-635-11 1-218-965-11 1-218-990-11 1-218-990-11

RES-CHIP METAL CHIP RES-CHIP SHORT CHIP SHORT CHIP

10K 10 10K 0 0

5% 0.5% 5%

1/16W 1/16W 1/16W

C60 C63 C64 C65 C66

1-100-381-11 1-162-970-11 1-107-826-11 1-126-208-21 1-164-156-11

ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP

10uF 0.01uF 0.1uF 47uF 0.1uF

20% 10% 10% 20%

16V 25V 16V 4V 25V

R16 R17 R18 R19 R20

1-218-990-11 1-218-965-11 1-218-965-11 1-218-969-11 1-218-969-11

SHORT CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

0 10K 10K 22K 22K

5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W

C67 C74 C75 C77 C79

1-107-826-11 1-126-208-21 1-162-970-11 1-107-826-11 1-107-826-11

CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 47uF 0.01uF 0.1uF 0.1uF

10% 20% 10% 10% 10%

16V 4V 25V 16V 16V

R21 R22 R23 R24 R25

1-218-990-11 1-218-967-11 1-218-967-11 1-218-953-11 1-218-953-11

SHORT CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

0 15K 15K 1K 1K

5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W

C83 C85 C86 C91 C92

1-107-826-11 1-125-837-11 1-107-826-11 1-107-826-11 1-107-826-11

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

16V 6.3V 16V 16V 16V

R26 R27 R28 R29 R37

1-218-981-11 1-218-965-11 1-218-990-11 1-218-977-11 1-218-990-11

RES-CHIP RES-CHIP SHORT CHIP RES-CHIP SHORT CHIP

220K 10K 0 100K 0

5% 5%

1/16W 1/16W

5%

1/16W

C109 C110 C115

1-107-826-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP 1-162-966-11 CERAMIC CHIP

0.1uF 10% 0.1uF 10% 0.0022uF 10%

16V 16V 50V

R38 R39 R40 R41 R42

1-218-967-11 1-218-941-81 1-218-990-11 1-218-985-11 1-218-965-11

RES-CHIP RES-CHIP SHORT CHIP RES-CHIP RES-CHIP

15K 100 0 470K 10K

5% 5%

1/16W 1/16W

5% 5%

1/16W 1/16W

R43 R44 R45

1-218-977-11 RES-CHIP 1-218-957-11 RES-CHIP 1-218-971-11 RES-CHIP

100K 2.2K 33K

5% 5% 5%

1/16W 1/16W 1/16W

10%

20% 20%

10% 10% 10%

< CONNECTOR > CN1 CN2

52

1-794-153-21 CONNECTOR, FPC (ZIF) 16P 1-817-275-21 CONNECTOR, BOARD TO BOARD 28P

IC1 IC3 IC4 IC7 IC8

6-705-366-01 8-753-216-86 6-804-028-02 6-705-364-01 6-705-365-01

IC IC IC IC IC

LA6560-TE-L-E CXD3059BR MB90487PFV-G-107-BNDE1 R1114N151D-TR-FA TC94A34FG-002

< TRANSISTOR > Q1 Q2 Q3 Q5 Q6

8-729-904-87 8-729-928-90 8-729-904-87 8-729-904-87 8-729-928-90

TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR

2SB1197K-R DTC114EE 2SB1197K-R 2SB1197K-R DTC114EE

< RESISTOR >

CDX-F7500/F7700 SERVO Ref. No.

Remark

Ref. No.

SUB

Part No.

Description

Part No.

Description

R46 R47 R48 R49 R50

1-218-957-11 1-218-977-11 1-218-941-81 1-218-953-11 1-218-941-81

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

2.2K 100K 100 1K 100

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

R128 R129 R133 R136 R139

1-218-965-11 1-218-965-11 1-216-864-11 1-218-977-11 1-218-957-11

RES-CHIP RES-CHIP SHORT CHIP RES-CHIP RES-CHIP

10K 10K 0 100K 2.2K

5% 5%

Remark 1/16W 1/16W

5% 5%

1/16W 1/16W

R52 R53 R54 R55 R56

1-218-941-81 1-218-959-11 1-218-961-11 1-218-953-11 1-218-973-11

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

100 3.3K 4.7K 1K 47K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

R140 R141 R142 R143 R144

1-218-941-81 1-218-941-81 1-218-941-81 1-218-941-81 1-218-965-11

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

100 100 100 100 10K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

R57 R59 R60 R61 R62

1-218-941-81 1-218-941-81 1-218-990-11 1-218-985-11 1-218-965-11

RES-CHIP RES-CHIP SHORT CHIP RES-CHIP RES-CHIP

100 100 0 470K 10K

5% 5%

1/16W 1/16W

5% 5%

1/16W 1/16W

R145 R146 R147 R148

1-218-977-11 1-218-941-81 1-218-941-81 1-218-941-81

RES-CHIP RES-CHIP RES-CHIP RES-CHIP

100K 100 100 100

5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W

R64 R65 R67 R68 R69

1-218-941-81 1-218-941-81 1-218-941-81 1-218-990-11 1-218-973-11

RES-CHIP RES-CHIP RES-CHIP SHORT CHIP RES-CHIP

100 100 100 0 47K

5% 5% 5%

1/16W 1/16W 1/16W

5%

1/16W

R70 R71 R72 R73 R74

1-218-945-11 1-218-941-81 1-218-990-11 1-218-941-81 1-218-941-81

RES-CHIP RES-CHIP SHORT CHIP RES-CHIP RES-CHIP

220 100 0 100 100

5% 5%

1/16W 1/16W

5% 5%

1/16W 1/16W

R76 R77 R78 R79 R80

1-218-941-81 1-218-947-11 1-218-941-81 1-218-941-81 1-218-977-11

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

100 330 100 100 100K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

R81 R85 R86 R87 R91

1-218-941-81 1-218-973-11 1-218-973-11 1-218-973-11 1-220-200-81

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

100 47K 47K 47K 30K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

R92 R96 R97 R98 R99

1-218-971-11 1-218-990-11 1-218-941-81 1-218-941-81 1-218-965-11

RES-CHIP SHORT CHIP RES-CHIP RES-CHIP RES-CHIP

33K 0 100 100 10K

5%

1/16W

5% 5% 5%

1/16W 1/16W 1/16W

R101 R102 R106 R107 R108

1-218-969-11 1-218-990-11 1-218-969-11 1-218-965-11 1-218-941-81

RES-CHIP SHORT CHIP RES-CHIP RES-CHIP RES-CHIP

22K 0 22K 10K 100

5%

1/16W

5% 5% 5%

1/16W 1/16W 1/16W

R109 R110 R111 R114 R115

1-218-953-11 1-218-945-11 1-218-990-11 1-218-941-81 1-218-941-81

RES-CHIP RES-CHIP SHORT CHIP RES-CHIP RES-CHIP

1K 220 0 100 100

5% 5%

1/16W 1/16W

5% 5%

1/16W 1/16W

R116 R117 R119 R122 R123

1-218-941-81 1-218-990-11 1-218-941-81 1-218-965-11 1-218-990-11

RES-CHIP SHORT CHIP RES-CHIP RES-CHIP SHORT CHIP

100 0 100 10K 0

5%

1/16W

5% 5%

1/16W 1/16W

R124 R126 R127

1-216-864-11 SHORT CHIP 1-218-965-11 RES-CHIP 1-218-965-11 RES-CHIP

0 10K 10K

5% 5%

1/16W 1/16W

< SWITCH > SW1

1-529-565-61 SWITCH, PUSH (1 KEY) (DOWN) < VIBRATOR >

X1 1-795-561-21 VIBRATOR, CERAMIC (16.9344MHz) X2 1-795-822-21 VIBRATOR, CERAMIC (18.43MHz) ************************************************************* SUB BOARD ********** 1-828-511-11 CABLE, FLAT (FFC) 22P < CONNECTOR > CNP501 1-818-142-11 SOCKET, CONNECTOR 20P < DIODE > D990 D991 LED931 LED931 LED932 LED932

8-719-978-33 8-719-978-33 6-500-895-01 8-719-082-38 6-500-204-01 6-500-450-01

DIODE DTZ-TT11-6.8B (F7700) DIODE DTZ-TT11-6.8B (F7700) LED CL-270UB2-X-TS (WINDOW) (F7700) LED CL-270SR-C-TS (WINDOW) (F7500) LED CL-190UB2-X-T (Z) (F7700) LED CL-195SR-CD-T (Z) (F7500) < RESISTOR >

R990

1-216-809-11 METAL CHIP

100

5%

R990

1-216-817-11 METAL CHIP

470

5%

R991

1-216-817-11 METAL CHIP

470

5%

1/10W (F7700) 1/10W (F7500) 1/10W (F7500)

< SWITCH > S901 1-771-884-31 SWITCH, TACTILE (Z) *************************************************************

53

CDX-F7500/F7700

Ref. No.

Part No.

Description

Remark

Ref. No.

MISCELLANEOUS *************** 10 12 12 0 153 154

1-790-375-12 CORD (WITH CONNECTOR) (SUB OUT (MONO)) 1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER) (AEP,UK) 1-776-207-72 CORD (WITH CONNECTOR) (E) 8-820-207-02 OPTICAL PICK-UP (KSS1000E/K1RP) A-3337-640-A CHASSIS (OP) SUB ASSY (including M901)

F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A M902 A-3337-638-A MOTOR ASSY, SL (SLED) M903 A-3372-454-A MOTOR ASSY, LE (LOADING) SW4 1-571-099-11 SWITCH (1 KEY) (LIMIT) *************************************************************

Part No.

Description

Remark

PARTS FOR INSTALLATION AND CONNCTIONS ************************************** 301 302 303 304 305

X-3382-647-1 X-3366-405-1 3-934-325-01 3-264-055-01 1-465-459-21

FRAME ASSY, FITTING SCREW ASSY (EXP), FITTING SCREW (+K 5X8 TP) (E) COLLAR ADAPTOR, ANTENNA (AEP,UK)

306 307 308

3-246-471-01 KEY (FRAME) 1-776-207-72 CORD (WITH CONNECTOR) (E) 1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER) (AEP,UK)

301

302

303

304

305

307

308

ACCESSORIES ************ 1-477-110-51 REMOTE COMMANDER (RM-X140) 3-230-047-01 LID, BATTERY CASE (for RM-X140) 3-263-381-21 MANUAL, INSTRUCTION (ENGLISH, TRADITIONAL CHINESE) (E) 3-263-381-31 MANUAL, INSTRUCTION (ENGLISH,GERMAN, FRENCH,ITALIAN,DUTCH) (AEP,UK) 3-263-425-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH, TRADITIONAL CHINESE) (E) 3-263-425-31 MANUAL, INSTRUCTION, INSTALL (ENGLISH, GERMAN,FRENCH,ITALIAN,DUTCH) (AEP,UK) *************************************************************

54

×4

306

×2

The components identified by mark 0 or dotted line with mark. 0 are critical for safety. Replace only with part number specified.

CDX-F7500/F7700

MEMO

55

CDX-F7500/F7700

REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. 1.0 1.1

56

Date 2004. 02 2004. 04

Description of Revision New Addition of Q620.

(SPM-04005)

www.s-manuals.com