PGF / PGC SERIES CONVERTIBLE SINGLE PACKAGE GAS/ELECTRIC UNIT PGF = Standard Models PGC = California Models with NOX baffles
3 THRU 5 TON, THREE PHASE
· Combination gas heating and electric cooling, self-contained for year-round comfort. Systems install on rooftop or at ground level. Units are shipped complete in one carton; with only the flue gas vent requiring mounting at time of installation.
CONSTRUCTION
· Triple--coated steel, consisting of a Polyester top coat, a urethane primer coat preceeded by an oxide pretreatment. One piece weather resistant top. Access panels for easy service. Side by side supply and return. Heavy gauge base with rails.
10 SEER Three Phase Models
COIL PROTECTION · The condenser coil has a sturdy wire inlet grille and UV rated vinyl mesh installed on the surface of the coil for additional protection. ACCESS PANELS
· Located to provide easy serviceability. The gas and electrical controls are behind the same exterior panel.
CONVERTIBLE DISCHARGE
· Units have side-by-side supply and return air openings for either horizontal or downflow applications. Simply relocate duct cover panels.
COMPRESSOR
· The high efficiency compressor has external rubber mounts to help minimize system noise and features an automatic reset current / temperature sensing overload protection system. 3 to 4 ton uses reciprocating compressors, 5 ton uses a scroll.
COILS
· Both the condenser and evaporator coils have aluminum fins and copper tubes to promote efficient heat transfer. The refrigerant flow is controlled with capillary tubes. The refrigerant circuit is sealed, tested, and fully charged at the factory.
EXTERNALLY-MOUNTED GAUGE PORTS
· Provides easier servicing and allows for more accurate reading of operating conditions.
INDUCED DRAFT COMBUSTION
· An induced draft combustion blower is used to provide air for combustion. A safety switch is used to prove that air for combustion is being delivered to the main burners before ignition takes place.
HOT SURFACE PILOT (HSP) ELECTRONIC INTERMITTENT IGNITION DEVICE
· The hot surface pilot ignition (HSP) is more energy efficient and provides added safety of operation.
ELECTRONIC FAN CONTROL
· Adjustable electronic fan control with optional low speed contiuous fan feature responds quickly to circulate heated air and provide maximum comfort.
IN-SHOT BURNERS
· New design delivers more complete, efficient combustion.
HEAT EXCHANGER
· Aluminized serpentine clamshell heat exchanger provides corrosion resistance for longer life and efficient heat transfer.
EVAPORATOR BLOWER
· All model sizes are equipped with multiple speed direct drive blower motors to provide proper air flow for both heating and cooling requirements.
AIR FILTERS
· Air filters are supplied with these units.
TRANSFORMER · 65VA · Resettable circuit breaker. ECONIMIZER · Factory wired to accept economizer. WARRANTY
· Standard one (1) year limited warranty on parts. · Five (5) year limited warranty on the compressor. · Ten (10) year limited warranty on the gas fired heat exchanger.
RESIDENTIAL AND COMMERCIAL SYSTEMS · SPLIT SYSTEMS · PACKAGED AIR CONDITIONERS · COMBINATION GAS / ELECTRIC UNITS · HEAT PUMPS · AIR HANDLERS · MANUFACTURED HOME AIR CONDITIONERS · GAS, OIL AND ELECTRIC FURNACES International Comfort Products 650 Heil--Quaker Avenue, Lewisburg, TN 37091
509 21 1403 01 4/18/05
UNIT SPECIFICATIONS Electrical Data MODEL NUMBER PG*036H080(F) PG*036H100(F) PG*036L080(F) PG*036L100(F) PG*036S080(F) PG*036S100(F) PG*048H080(F) PG*048H120(F) PG*048L080(F) PG*048L120(F) PG*048S080(F) PG*048S120(F) PG*060H100(F) PGF060H140(E) PGC060H140(F) PG*060L100(F) PGF060L140(E) PGC060L140(F) PG*060S100(F) PGF060S140(E) PGC060S140(F)
Condenser Data Fan Motor
Coil
HACR
Voltage Breaker / Max. Fuse Ampacity Phase - Hz 208/230--3--60 20 amps 17.1 208/230--3--60 20 amps 17.1 460--3--60 15 amps 9.0 460--3--60 15 amps 9.0 575--3--60 15 amps 7.0 575--3--60 15 amps 7.0 208/230--3--60 30 amps 21.1 208/230--3--60 30 amps 21.1 460--3--60 15 amps 10.2 460--3--60 15 amps 10.2 575--3--60 15 amps 8.4 575--3--60 15 amps 8.4 208/230--3--60 45 amps 30.3 208/230--3--60 45 amps 30.3 208/230--3--60 45 amps 30.3 460--3--60 20 amps 13.9 460--3--60 20 amps 13.9 460--3--60 20 amps 13.9 575--3--60 15 amps 11.9 575--3--60 15 amps 11.9 575--3--60 15 amps 11.9
Total Face Area (Sq. Ft.)
Fins Per In. / Rows
Tube Diameter (In.)
8.0 8.0 8.0 8.0 8.0 8.0 10.5 10.5 10.5 10.5 10.5 10.5 14.9 14.9 14.9 14.9 14.9 14.9 14.9 14.9 14.9
20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2 20 / 2
3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8
HP
Full Load Amps
1/3
1.9
1/3
1.9
1/3
.74
1/3
.74
1/3
.60
1/3
.60
1/3
1.9
1/3
1.9
1/3
.75
1/3
.75
1/3
.60
1/3
.60
1/3
1.9
1/3
1.9
1/3
1.9
1/3
.75
1/3
.75
1/3
.75
1/3
.60
1/3
.60
1/3
.60
Fan Size Diameter (In.) 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3 20.3
RPM (Max)
1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140 1140
No. Blades Pitch ° 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27 3 --27
CFM (Max.)
3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000 3000
BELS 7.8 7.8 7.8 7.8 7.8 7.8 7.8 7.8 7.8 7.8 7.8 7.8 8.0 8.0 8.0 8.0 8.0 8.0 8.0 8.0 8.0
* F = PGF Standard Models, C = PGC models with Nox baffles and meet California emission requirements.
Evaporator Coil Motor
Coil
MODEL NUMBER PG*036H080(F) PG*036H100(F) PG*036L080(F) PG*036L100(F) PG*036S080(F) PG*036S100(F) PG*048H080(F)+ PG*048H120(F)+ PG*048L080(F)+ PG*048L120(F)+ PG*048S080(F) PG*048S120(F) PG*060H100(F) PGF060H140(E) PGC060H140(F) PG*060L100(F) PGF060L140(E) PGC060L140(F) PG*060S100(F) PGF060S140(E) PGC060S140(F)
Total Face Area (Sq. Ft.)
3.66 3.66 3.66 3.66 3.66 3.66 5.33 5.33 5.33 5.33 5.33 5.33 5.33 5.33 5.33 5.33 5.33 5.33 5.33 5.33 5.33
Fins Per In. / Rows
Tube Diam. (In.)
Blower H.P. / Type / Speeds
14 / 3 14 / 3 14 / 3 14 / 3 14 / 3 14 / 3 14 / 3 14 / 3 14 / 3 14 / 3 14 / 3 14 / 3 14 / 4 14 / 4 14 / 4 14 / 4 14 / 4 14 / 4 14 / 4 14 / 4 14 / 4
3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8 3/8
1/2 / PSC / 3 1/2 / PSC / 3 1/2 / PSC / 3 1/2 / PSC / 4 1/2 / PSC / 1 1/2 / PSC / 1 1/2 / PSC / 3 1/2 / PSC / 4 1/2 / PSC / 3 1/2 / PSC / 3 1/2 / PSC / 1 1/2 / PSC / 1 1 / PSC / 4 1 / PSC / 4 1 / PSC / 4 1 / PSC / 4 1 / PSC / 4 1 / PSC / 4 1 / PSC / 1 1 / PSC / 1 1 / PSC / 1
Compressor Blower
Full Locked Load Rotor Type & Size Amps Amps DD11--9A 3.6 7.50 DD11--9A 3.6 7.50 DD11--9A 2.0 4.15 DD11--9A 2.0 4.15 DD11--9A 1.5 3.60 DD11--9A 1.5 3.60 DD11-9A 3.6 7.50 DD11-9A 3.6 7.50 DD11-9A 2.0 4.50 DD11-9A 2.0 4.50 DD11-11A 1.5 3.60 DD11-11A 1.5 3.60 DD12-12A 6.0 15.0 DD12-12A 6.0 15.0 DD12-12A 6.0 15.0 DD12-12A 2.5 7.2 DD12-12A 2.5 7.2 DD12-12A 2.5 7.2 DD12-12A 2.4 5.80 DD12-12A 2.4 5.80 DD12-12A 2.4 5.80
* F = PGF Standard Models, C = PGC models with Nox baffles and meet California emission requirements. + PG*048*120 have DD11--11 blower. Air Filters are supplied with these units, 3 to 5 ton use 14 x 25 x 1 (2) SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE
2
RPM (Max)
CFM Rated
Type
Rated Load Amps
1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000 1000
1250 1250 1250 1250 1250 1250 1600 1600 1600 1600 1600 1600 1900 1900 1900 1900 1900 1900 1900 1900 1900
Recip Recip Recip Recip Recip Recip Recip Recip Recip Recip Recip Recip Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll
9.7 9.7 5.0 5.0 3.9 3.9 12.5 12.5 6.0 6.0 5.0 5.0 17.9 17.9 17.9 8.9 8.9 8.9 7.1 7.1 7.1
Locked Rotor Amps
Factory Refrigerant Charge R-22 (Oz.)
Ship Weight ( Lbs. )
72 72 33 33 27 27 91 91 42 42 39 39 124 124 124 59.6 59.6 59.6 49.4 49.4 49.4
89 89 89 89 89 89 102 102 102 102 102 102 136 136 136 136 136 136 136 136 136
410 410 410 410 410 410 490 490 490 490 490 490 510 510 510 510 510 510 510 510 510
PERFORMANCE DATA: HEATING Input (MBTUH) MODEL NUMBER
Output (MBTUH)
Efficiency ** DOE (AFUE) Calif. (CSE) Std. Std.
Temperature Rise o F
Gas Piping Size (In.)
Transformer Size Va.
Standard
Standard
PG*036(H,L,S)080(F) PG*036(H,L,S)100(F)
80 100
64 80
80.0 80.0
76.0 76.0
35--65 35--65
1/2 1/2
65 65
PG*048(H,L,S)080(F) PG*048(H,L,S)120(F)
80 120
64 96
80.0 80.0
76.0 76.0
35--65 40--70
1/2 1/2
65 65
PG*060(H,L,S)100(F) PGF060(H,L,S)140(E) PGC060(H,L,S)140(F)
100 140 140
80 112 112
80.0 80.0 80.0
76.0 76.0 76.0
30--60 35--65 35--65
1/2 1/2 1/2
65 65 65
* F = PGF Standard Models, C = PGC models with Nox baffles and meet California emission requirements. ** As determined by D.O.E. Annual Fuel Utilization Efficiency (A.F.U.E.) Rating Test. Heating capacity valid for elevations up to 2,000 feet above sea level. For elevations above 2,000 feet, rated capacity should be reduced by 4% for each 1,000 feet above sea level. All models meet California C.S.E. and NOx standards.
PERFORMANCE DATA: COOLING Rated Capacity 1 BTUH
S/T Ratio
S.E.E.R.
PG*036(H,L,S)080(F) PG*036(H,L,S)100(F)
33,400
.75
PG*048(H,L,S)080(F) PG*048(H,L,S)120(F)
45,500
.79
MODEL NUMBER
E.E.R. 3
Power Input Watts
Evaporator Rated Airflow (SCFM)
Ext. Static Pressure Drop 2 Wet
10.0
8.5
4000
1100
.15
10.0
9.0
5115
1600
.15
6480
1900
.15
PG*060(H,L,S)100(F) 58,000 .75 10.0 8.8 PGF060(H,L,S)140(E) PGC060(H,L,S)140(F) * F = PGF Standard Models, C = PGC models with Nox baffles and meet California emission requirements. 1 2 3
Rated Capacity @ ARI standard conditions, 95° Amb, 80° DB/67° WB, 230 Volts. For applications at 208 volts deduct 1000 BTU. Includes a .08 drop for a filter For reference only
BLOWER PERFORMANCE DATA MODEL * NUMBER
MOTOR SPEED
Air Delivery in CFM at ESP** 0.20
0.30
HI
1649
1621
1595
1562
MD
1284
1281
1255
1239
LO
1091
1073
1072
1059
HI
1949
1881
1818
1741
MD HI
1637
1589
1540
1487
MD
1383
1353
1319
1280
LO
1289
1267
1236
1208
PG*036S
HI
1733
1695
1655
1587
PG*048S
HI
1840
1781
1722
1659
HI
1983
1910
1837
1750
MD HI
1915
1852
1783
1710
MD
1805
1748
1693
1634
LO
1700
1666
1578
1531
HI
2108
2039
1856
1759
PG*036H PG*048H
PG 036L PG*036L PG*048L
PG*060(H L) PG*060(H,L)
PG*060(S)
0.40
0.50
* F = PGF Standard Models, C = PGC models with Nox baffles and meet California emission requirements. **Air delivery against shown external static pressures taken with 230V to unit and dry coil. For wet coil subtract approximately 25 CFM. Add .08 static for internal filters.
3
SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE
EXPANDED PERFORMANCE DATA (COOLING) -- 3 TON (NET DATA) 65
Airflow IDB* CFM 1400 70
1250 1100 1400
75
1250 1100 1400
80
1250 1100 1400
85
1250 1100
MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW
59
32.6 0.74 3.24 32.8 0.73 3.11 32.7 0.72 3.01 32.6 0.89 3.25 32.8 0.87 3.13 32.7 0.86 3.02 33.1 1.02 3.04 32.9 1.02 3.01 33 0.97 2.95 32.9 1.22 3.05 34 1.02 2.93 33.7 1.02 2.83
63
75 67
33.3 0.58 3.21 33.6 0.58 3.08 33.4 0.55 2.99 33.6 0.71 3.23 33.8 0.7 3.09 34 0.69 2.97 33.6 0.81 3.29 34.1 0.82 3.13 34.2 0.81 2.99 33.9 1.02 3.21 34.4 0.92 3.09 34.3 0.91 2.97
34 0.44 3.18 34.1 0.45 3.08 34.3 0.44 2.96 34.1 0.55 3.22 34.4 0.55 3.09 34.7 0.55 2.98 34.4 0.67 3.24 34.8 0.66 3.1 34.5 0.63 2.99 34.8 0.79 3.27 35.1 0.77 3.12 35.4 0.76 3
71
---------35.3 0.44 2.95 35 0.44 3.09 35.1 0.44 2.98 35 0.54 3.21 35.4 0.54 3.1 35.6 0.53 2.99 35.3 0.64 3.26 35.5 0.63 3.13 35.9 0.63 3.01
59
31.3 0.76 3.5 31.3 0.75 3.34 31.2 0.74 3.21 31.5 0.92 3.45 31.4 0.9 3.32 31.2 0.88 3.2 32.5 1.02 3.27 32.1 1.02 3.2 31.6 1 3.12 33.8 1.02 3.3 33.5 1.02 3.18 32.9 1.02 3.07
63
32.8 0.58 3.51 33 0.58 3.36 32.8 0.57 3.24 33 0.73 3.52 33.1 0.72 3.37 33.1 0.71 3.23 33 0.86 3.53 33.3 0.85 3.37 33.2 0.83 3.24 33.6 1.02 3.41 33.7 0.97 3.3 33.4 0.95 3.19
Outdoor Ambient Temperature - Degrees F. Dry Bulb 85 95 Entering Indoor Temperature - Degrees F. Wet Bulb 67 71 59 63 67 71 59 63 67 33.9 0.44 3.5 34.1 0.44 3.36 34.3 0.44 3.24 34.1 0.56 3.52 34.4 0.56 3.38 34.5 0.56 3.25 34.3 0.69 3.53 34.6 0.68 3.39 34.4 0.66 3.26 34.6 0.82 3.55 34.8 0.8 3.4 34.9 0.79 3.27
---------35.4 0.43 3.38 35.4 0.43 3.38 35.5 0.44 3.26 35.3 0.54 3.53 35.6 0.54 3.39 35.8 0.54 3.27 35.6 0.66 3.56 35.8 0.65 3.41 36 0.64 3.29
30 0.78 3.77 29.9 0.77 3.58 29.7 0.75 3.41 30.3 0.95 3.66 30.1 0.93 3.51 29.7 0.9 3.38 31.8 1.02 3.51 31.2 1.02 3.38 30.3 1.02 3.28 34.6 0.82 3.55 32.9 1.02 3.43 32.2 1.02 3.31
32.4 0.59 3.8 32.4 0.59 3.63 32.3 0.58 3.5 32.4 0.75 3.8 32.4 0.74 3.64 32.3 0.72 3.5 32.5 0.91 3.76 32.5 0.89 3.62 32.2 0.86 3.49 33.4 1.02 3.6 32.9 1.02 3.51 32.6 0.98 3.42
33.9 0.43 3.82 34.2 0.44 3.65 34.2 0.44 3.52 34.2 0.57 3.81 34.3 0.57 3.66 34.3 0.56 3.52 34.3 0.71 3.82 34.4 0.7 3.67 34.4 0.69 3.53 34.4 0.85 3.84 34.5 0.83 3.68 34.4 0.81 3.53
---------35.4 0.43 3.81 35.7 0.43 3.67 35.8 0.43 3.54 35.7 0.55 3.85 35.9 0.55 3.68 36 0.54 3.55 35.9 0.68 3.85 36.1 0.67 3.7 36.2 0.65 3.56
28 0.81 3.91 27.9 0.79 3.72 27.7 0.77 3.55 28.5 0.98 3.77 28.2 0.96 3.64 27.8 0.93 3.5 30.4 1.02 3.7 35.9 0.55 3.68 36 0.54 3.55 32.4 1.02 3.8 36.1 0.67 3.7 30.8 1.02 3.5
30.8 0.6 4.06 30.8 0.59 3.86 30.5 0.59 3.69 30.7 0.78 4.06 30.7 0.76 3.86 30.4 0.74 3.69 31 0.94 3.96 30.8 0.91 3.8 30.4 0.89 3.66 32.4 1.02 3.81 31.7 1.02 3.69 30.8 1.02 3.58
33.3 0.43 4.1 33.4 0.43 3.94 33.3 0.44 3.8 33.3 0.58 4.11 33.3 0.58 3.95 33.2 0.57 3.8 33.2 0.74 4.12 33.4 0.75 3.95 33.1 0.71 3.8 33.4 0.89 4.07 33.3 0.86 3.93 33.1 0.84 3.8
105 71
---------34.9 0.42 4.14 35.3 0.43 3.96 35.3 0.43 3.83 35 0.55 4.15 35.4 0.56 3.97 35.4 0.55 3.83 35.3 0.7 4.15 35.5 0.69 3.99 35.3 0.66 3.86
59
25.9 0.83 4.05 25.9 0.81 3.87 25.7 0.79 3.7 26.5 1.02 3.86 26.3 0.98 3.74 26 0.96 3.63 28.7 1.02 3.88 28.1 1.02 3.72 27.3 1.02 3.58 30.7 1.02 4 30 1.02 3.83 29.2 1.02 3.68
63
115 67
28.6 0.61 4.21 28.6 0.61 4.01 28.4 0.6 3.84 28 0.81 4.16 28.5 0.78 4.02 28.3 0.76 3.84 29 0.97 4.07 28.7 0.94 3.93 28.4 0.92 3.79 30.8 1.02 4 30.1 1.02 3.84 29.2 1.02 3.7
31.5 0.42 4.39 31.5 0.43 4.18 31.3 0.43 4 31.4 0.6 4.39 31.4 0.59 4.18 31.2 0.58 4 31.2 0.77 4.39 31.2 0.75 4.18 31.1 0.73 4 31.5 0.93 4.29 31.3 0.9 4.13 31.1 0.87 3.97
71
---------34 0.42 4.43 34.1 0.43 4.26 34 0.43 4.12 34 0.58 4.44 34.1 0.57 4.27 33.9 0.56 4.12 33.9 0.73 4.44 34 0.71 4.27 33.9 0.69 4.12
59
23.7 0.87 4.15 23.7 0.84 3.99 23.6 0.82 3.83 24.8 1.02 3.93 24.3 1.02 3.84 24 0.99 3.74 26.9 1.02 4.06 26.3 1.02 3.9 25.6 1.02 3.74 29 1.02 4.19 28.3 1.02 4.02 33.9 0.69 4.13
63
26.2 0.63 4.36 26.3 0.63 4.16 26.2 0.61 3.99 26.2 0.83 4.34 26.2 0.81 4.17 26.1 0.79 3.99 26.9 1 4.18 26.6 0.98 4.05 26.3 0.95 3.93 29 1.02 4.19 28.3 1.02 4.03 27.6 1.02 3.87
67
29.1 0.42 4.54 29.1 0.43 4.34 29 0.44 4.16 29 0.61 4.54 29 0.6 4.34 28.9 0.59 4.16 28.9 0.8 4.53 28.9 0.77 4.34 28.2 0.76 4.1 29.4 0.96 4.4 29.1 0.94 4.25 28.8 0.91 4.11
71
---------32 0.42 4.74 32 0.43 4.54 31.9 0.43 4.35 31.8 0.59 4.74 31.9 0.58 4.54 31.8 0.57 4.35 31.6 0.76 4.75 31.7 0.74 4.54 31.7 0.71 4.36
EXPANDED PERFORMANCE DATA (COOLING) -- 4 TON (GROSS DATA) 65
Airflow IDB* CFM 1792 70
1600 1408 1792
75
1600 1408 1792
80
1600 1408 1792
85
1600 1408
MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW
59
47.4 0.79 3.98 46.0 0.76 3.95 43.7 0.72 3.89 48.2 0.90 4.00 46.8 0.86 3.98 44.5 0.82 3.92 49.1 1.00 4.03 47.7 0.94 4.01 45.3 0.90 3.95 49.9 1.00 4.06 48.5 0.99 4.03 46.1 0.95 3.98
63
49.2 0.66 4.05 47.7 0.63 4.02 45.3 0.61 3.96 49.7 0.81 4.08 48.2 0.77 4.05 45.8 0.74 3.99 50.2 0.93 4.11 48.7 0.88 4.08 46.3 0.85 4.02 50.9 1.00 4.14 49.4 0.95 4.11 47.0 0.91 4.05
75 67
53.9 0.46 4.17 52.3 0.44 4.14 49.7 0.42 4.08 53.8 0.61 4.20 52.2 0.58 4.17 49.6 0.56 4.11 53.6 0.76 4.23 52.0 0.72 4.20 49.4 0.69 4.14 53.3 0.90 4.26 51.8 0.86 4.23 49.2 0.83 4.17
71
---------57.7 0.39 4.32 56.0 0.37 4.29 53.2 0.36 4.23 57.3 0.56 4.36 55.6 0.54 4.32 52.8 0.52 4.26 56.9 0.73 4.39 55.2 0.70 4.36 52.5 0.67 4.29
59
46.3 0.82 4.25 45.0 0.78 4.22 42.7 0.75 4.16 47.1 0.93 4.29 45.7 0.89 4.25 43.5 0.85 4.19 47.9 1.00 4.32 46.6 0.98 4.29 44.2 0.94 4.22 48.8 1.00 4.35 47.4 1.00 4.32 45.0 0.98 4.25
63
48.0 0.69 4.34 46.6 0.66 4.31 44.3 0.63 4.24 48.5 0.84 4.37 47.1 0.80 4.34 44.7 0.76 4.27 49.0 0.96 4.40 47.6 0.92 4.37 45.2 0.88 4.31 49.7 1.00 4.44 48.3 0.99 4.40 45.9 0.95 4.34
* Entering Indoor Temperature -- Degrees F. Dry Bulb SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE
Outdoor Ambient Temperature - Degrees F. Dry Bulb 85 95 Entering Indoor Temperature - Degrees F. Wet Bulb 67 71 59 63 67 71 59 63 67
52.6 0.48 4.47 51.1 0.45 4.43 48.5 0.43 4.37 52.5 0.63 4.50 51.0 0.60 4.47 48.4 0.58 4.40 52.3 0.78 4.53 50.8 0.75 4.50 48.3 0.71 4.43 52.1 0.94 4.57 50.6 0.89 4.53 48.0 0.86 4.47
---------56.3 0.41 4.64 54.7 0.39 4.60 52.0 0.37 4.53 56.0 0.58 4.67 54.3 0.56 4.64 51.6 0.53 4.57 55.6 0.76 4.71 53.9 0.72 4.67 51.2 0.69 4.60
45.2 0.84 4.50 43.9 0.80 4.47 41.7 0.77 4.40 46.0 0.96 4.53 44.6 0.91 4.50 42.4 0.88 4.43 46.8 1.00 4.57 45.4 1.00 4.54 43.2 0.96 4.47 47.6 1.00 4.60 46.2 1.00 4.57 43.9 1.00 4.50
46.9 0.70 4.59 45.5 0.67 4.56 43.2 0.64 4.49 47.3 0.86 4.63 46.0 0.82 4.59 43.7 0.78 4.52 47.8 1.00 4.66 46.4 0.94 4.63 44.1 0.90 4.56 48.5 1.00 4.70 47.1 1.00 4.66 44.8 0.97 4.59
51.4 0.49 4.73 49.9 0.47 4.69 47.4 0.45 4.62 51.3 0.65 4.77 49.8 0.62 4.73 47.3 0.59 4.66 51.1 0.80 4.80 49.6 0.77 4.77 47.1 0.73 4.69 50.8 0.96 4.84 49.4 0.92 4.80 46.9 0.88 4.73
Standard Rating
4
---------55.0 0.42 4.91 53.4 0.40 4.87 50.7 0.38 4.80 54.6 0.60 4.95 53.0 0.57 4.91 50.4 0.55 4.84 54.2 0.78 4.99 52.7 0.74 4.95 50.0 0.71 4.87
44.1 0.87 4.72 42.8 0.83 4.68 40.7 0.80 4.61 44.9 0.99 4.75 43.6 0.94 4.72 41.4 0.90 4.65 45.7 1.00 4.79 44.3 1.00 4.75 42.1 0.99 4.68 46.5 1.00 4.83 45.1 1.00 4.79 42.9 1.00 4.72
45.7 0.73 4.81 44.4 0.69 4.78 42.2 0.66 4.70 46.2 0.88 4.85 44.8 0.84 4.81 42.6 0.81 4.74 46.7 1.00 4.89 45.3 0.97 4.85 43.0 0.93 4.78 47.4 1.00 4.93 46.0 1.00 4.89 43.7 1.00 4.81
50.1 0.50 4.96 48.6 0.48 4.92 46.2 0.46 4.85 50.0 0.67 5.00 48.5 0.64 4.96 46.1 0.61 4.88 49.9 0.83 5.04 48.4 0.79 5.00 46.0 0.76 4.92 49.6 0.99 5.08 48.2 0.94 5.04 45.8 0.91 4.96
105 71
---------53.7 0.43 5.16 52.1 0.41 5.12 49.5 0.39 5.04 53.3 0.62 5.20 51.7 0.59 5.16 49.2 0.57 5.07 52.9 0.80 5.24 51.4 0.77 5.20 48.8 0.73 5.11
59
41.9 0.90 4.90 40.7 0.86 4.86 38.7 0.83 4.79 42.6 1.00 4.94 41.4 0.98 4.90 39.3 0.94 4.83 43.4 1.00 4.98 42.1 1.00 4.94 40.0 1.03 4.86 44.1 1.00 5.02 42.9 1.00 4.98 40.7 1.00 4.90
63
43.4 0.75 5.00 42.2 0.72 4.96 40.1 0.69 4.89 43.9 0.92 5.04 42.6 0.88 5.00 40.5 0.84 4.93 44.3 1.00 5.08 43.0 1.00 5.04 40.9 0.96 4.96 45.0 1.00 5.12 43.7 1.00 5.08 41.5 1.00 5.00
115 67
47.6 0.52 5.16 46.2 0.50 5.12 43.9 0.48 5.04 47.5 0.70 5.20 46.1 0.66 5.16 43.8 0.64 5.08 47.4 0.86 5.24 46.0 0.82 5.20 43.7 0.79 5.12 47.1 1.00 5.28 45.8 0.98 5.24 43.5 0.94 5.16
71
---------51.0 0.45 5.36 49.5 0.43 5.32 47.0 0.41 5.24 50.6 0.64 5.41 49.2 0.61 5.36 46.7 0.59 5.28 50.3 0.83 5.45 48.8 0.80 5.41 46.4 0.76 5.32
59
38.8 0.91 5.06 37.7 0.87 5.02 35.8 0.83 4.94 39.5 1.00 5.10 38.3 0.99 5.06 36.4 0.95 4.98 40.2 1.00 5.14 39.0 1.00 5.10 37.1 1.04 5.02 40.9 1.00 5.18 39.7 1.00 5.14 37.7 1.00 5.06
63
40.2 0.76 5.17 39.1 0.73 5.13 37.1 0.70 5.05 40.7 0.93 5.21 39.5 0.88 5.17 37.5 0.85 5.09 41.1 1.00 5.25 39.9 1.00 5.21 37.9 0.97 5.13 41.7 1.00 5.29 40.5 1.00 5.25 38.4 1.00 5.17
67
44.1 0.53 5.33 42.8 0.50 5.29 40.7 0.48 5.20 44.0 0.70 5.37 42.7 0.67 5.33 40.6 0.64 5.24 43.9 0.87 5.41 42.6 0.83 5.37 40.5 0.79 5.29 43.7 1.00 5.46 42.4 0.99 5.41 40.3 0.95 5.33
71
---------47.2 0.45 5.54 45.8 0.43 5.50 43.6 0.41 5.41 46.9 0.65 5.59 45.5 0.62 5.54 43.3 0.59 5.45 46.6 0.84 5.63 45.2 0.80 5.59 43.0 0.77 5.50
EXPANDED PERFORMANCE DATA (COOLING) -- 5 TON (GROSS DATA) 65
Airflow IDB* CFM 2128 70
1900 1672 2128
75
1900 1672 2128
80
1900 1672 2128
85
1900 1672
MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW MBh S/T KW
59
60.5 0.75 5.23 58.7 0.72 5.20 55.8 0.69 5.12 61.5 0.86 5.27 59.7 0.82 5.23 56.7 0.78 5.16 62.6 0.94 5.31 60.8 0.90 5.27 57.7 0.86 5.20 63.7 0.98 5.35 61.8 0.94 5.31 58.7 0.90 5.23
63
62.7 0.63 5.34 60.8 0.60 5.30 57.8 0.57 5.22 63.3 0.77 5.38 61.5 0.73 5.34 58.4 0.70 5.26 63.9 0.88 5.42 62.1 0.84 5.38 59.0 0.80 5.30 64.9 0.95 5.46 63.0 0.91 5.42 59.9 0.87 5.34
75 67
68.7 0.44 5.49 66.7 0.42 5.45 63.3 0.40 5.37 68.5 0.58 5.53 66.5 0.55 5.49 63.2 0.53 5.41 68.3 0.72 5.58 66.3 0.68 5.53 63.0 0.65 5.45 68.0 0.86 5.62 66.0 0.82 5.58 62.7 0.78 5.49
71
---------73.5 0.37 5.70 71.4 0.36 5.66 67.8 0.34 5.57 73.0 0.54 5.74 70.9 0.51 5.70 67.4 0.49 5.61 72.5 0.70 5.79 70.4 0.66 5.74 66.9 0.64 5.66
59
59.1 0.78 5.61 57.3 0.74 5.56 54.5 0.71 5.48 60.1 0.89 5.65 58.3 0.85 5.61 55.4 0.81 5.52 61.1 1.00 5.69 59.3 0.93 5.65 56.4 0.89 5.56 62.2 1.00 5.73 60.4 0.97 5.69 57.4 0.93 5.61
63
61.2 0.65 5.72 59.4 0.62 5.67 56.5 0.60 5.59 61.8 0.79 5.76 60.0 0.76 5.72 57.0 0.73 5.63 62.5 0.91 5.81 60.6 0.87 5.76 57.6 0.83 5.67 63.4 0.98 5.85 61.5 0.94 5.81 58.5 0.90 5.72
* Entering Indoor Temperature -- Degrees F. Dry Bulb
Outdoor Ambient Temperature - Degrees F. Dry Bulb 85 95 Entering Indoor Temperature - Degrees F. Wet Bulb 67 71 59 63 67 71 59 63 67 67.1 0.45 5.89 65.1 0.43 5.84 61.9 0.41 5.75 66.9 0.60 5.93 65.0 0.57 5.89 61.7 0.55 5.80 66.7 0.74 5.98 64.8 0.71 5.93 61.5 0.68 5.84 66.4 0.89 6.03 64.5 0.85 5.98 61.2 0.81 5.89
---------71.8 0.39 6.12 69.7 0.37 6.07 66.3 0.35 5.98 71.3 0.56 6.16 69.3 0.53 6.12 65.8 0.51 6.02 70.8 0.72 6.21 68.8 0.69 6.16 65.3 0.66 6.07
57.6 0.80 5.93 56.0 0.76 5.89 53.2 0.73 5.80 58.6 0.91 5.98 56.9 0.87 5.93 54.1 0.83 5.84 59.7 1.00 6.03 57.9 0.95 5.98 55.0 0.91 5.89 60.7 1.00 6.07 58.9 1.00 6.03 56.0 0.96 5.93
59.8 0.67 6.05 58.0 0.64 6.01 55.1 0.61 5.92 60.4 0.81 6.10 58.6 0.78 6.06 55.7 0.74 5.96 61.0 0.94 6.15 59.2 0.89 6.10 56.2 0.86 6.01 61.9 1.00 6.20 60.1 0.96 6.15 57.1 0.92 6.05
65.5 0.46 6.24 63.6 0.44 6.19 60.4 0.42 6.09 65.3 0.62 6.29 63.4 0.59 6.24 60.3 0.56 6.14 65.1 0.76 6.34 63.2 0.73 6.29 60.1 0.70 6.19 64.8 0.91 6.39 62.9 0.87 6.34 59.8 0.83 6.24
---------70.1 0.40 6.48 68.1 0.38 6.43 64.7 0.36 6.33 69.6 0.57 6.53 67.6 0.54 6.48 64.2 0.52 6.38 69.1 0.74 6.59 67.1 0.71 6.53 63.8 0.68 6.43
56.2 0.83 6.22 54.6 0.79 6.17 51.9 0.75 6.08 57.2 0.94 6.27 55.5 0.90 6.22 52.8 0.86 6.13 58.2 1.00 6.32 56.5 0.98 6.27 53.7 0.94 6.17 59.2 1.00 6.37 57.5 1.00 6.32 54.6 0.99 6.22
58.3 0.69 6.35 56.6 0.66 6.30 53.8 0.63 6.20 58.9 0.84 6.40 57.2 0.80 6.35 54.3 0.77 6.25 59.5 0.97 6.45 57.8 0.92 6.40 54.9 0.88 6.30 60.4 1.00 6.50 58.6 0.99 6.45 55.7 0.95 6.35
63.9 0.48 6.55 62.0 0.46 6.50 58.9 0.44 6.39 63.7 0.64 6.60 61.9 0.61 6.55 58.8 0.58 6.45 63.6 0.79 6.65 61.7 0.75 6.60 58.6 0.72 6.50 63.2 0.94 6.70 61.4 0.90 6.65 58.3 0.86 6.55
105 71
---------68.4 0.41 6.81 66.4 0.39 6.75 63.1 0.37 6.65 67.9 0.59 6.86 66.0 0.56 6.81 62.7 0.54 6.70 67.5 0.76 6.92 65.5 0.73 6.86 62.2 0.70 6.75
59
53.4 0.86 6.47 51.9 0.82 6.42 49.3 0.78 6.32 54.3 0.97 6.52 52.8 0.93 6.47 50.1 0.89 6.37 55.3 1.00 6.57 53.7 1.00 6.52 51.0 0.98 6.42 56.3 1.00 6.62 54.6 1.00 6.57 51.9 1.00 6.47
63
55.4 0.72 6.60 53.8 0.68 6.55 51.1 0.65 6.45 55.9 0.87 6.66 54.3 0.83 6.60 51.6 0.80 6.50 56.5 1.00 6.71 54.9 0.96 6.66 52.1 0.92 6.55 57.4 1.00 6.76 55.7 1.00 6.71 52.9 0.99 6.60
115 67
60.7 0.50 6.81 58.9 0.47 6.76 56.0 0.45 6.65 60.6 0.66 6.86 58.8 0.63 6.81 55.9 0.60 6.70 60.4 0.82 6.92 58.6 0.78 6.87 55.7 0.75 6.76 60.1 0.98 6.98 58.3 0.93 6.92 55.4 0.89 6.81
71
---------65.0 0.42 7.08 63.1 0.40 7.03 59.9 0.39 6.91 64.5 0.61 7.14 62.7 0.58 7.08 59.5 0.56 6.97 64.1 0.79 7.20 62.2 0.76 7.14 59.1 0.72 7.03
59
49.5 0.86 6.68 48.1 0.82 6.63 45.6 0.79 6.52 50.3 0.98 6.73 48.9 0.94 6.68 46.4 0.90 6.58 51.2 1.00 6.79 49.7 1.00 6.74 47.2 0.99 6.63 52.1 1.00 6.84 50.6 1.00 6.79 48.1 1.00 6.68
63
51.3 0.72 6.82 49.8 0.69 6.77 47.3 0.66 6.66 51.8 0.88 6.88 50.3 0.84 6.82 47.8 0.80 6.71 52.3 1.00 6.93 50.8 0.96 6.88 48.3 0.92 6.77 53.1 1.00 6.99 51.6 1.00 6.93 49.0 1.00 6.82
67
56.2 0.50 7.04 54.6 0.48 6.98 51.8 0.46 6.87 56.1 0.67 7.09 54.5 0.63 7.04 51.7 0.61 6.92 55.9 0.82 7.15 54.3 0.78 7.09 51.6 0.75 6.98 55.6 0.98 7.21 54.0 0.94 7.15 51.3 0.90 7.04
71
---------60.2 0.43 7.32 58.4 0.41 7.26 55.5 0.39 7.15 59.8 0.62 7.38 58.0 0.59 7.32 55.1 0.56 7.20 59.4 0.80 7.44 57.6 0.76 7.38 54.8 0.73 7.26
Standard Rating
5
SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE
ACCESSORIES ROOF CURBS, TRANSITION AND DUCT KITS Used on (Unit Size) 3 Ton 4 -- 5 Ton
8” Curb
14” Curb
24” Curb
ACL01FB0A * AXB020CLA ** ACL02FB0A * AXB020CLA **
ACM01FB0A * AXB020CMA ** ACM02FB0A * AXB020CMA **
ACH01FB0A * AXB020CHA ** ACH02FB0A * AXB020CHA **
Square to Round Transition Kit ACT01FB0A AXB020CTA ACT02FB0A ACT22FB0A
Round Duct Size (Inches) 16 16 18 18
Concentric Grill Flush Mount AXB020CFA AXB020CFA AXB030CFA AXB030CFA
Concentric Grill Step Down AXB020CSA AXB020CSA AXB030CSA AXB030CSA
ROOF CURB DIMENSIONS (AC SERIES) Model No.
A
B
C
D
E
F
G
H
K (ACL)
K (ACM)
K (ACH)
AC(L,M,H)01FB0A
42--1/2
39--1/2
16
21--1/2
2
45--3/4
42--3/4
20
8
14
24
AC(L,M,H)02FB0A
44--3/4
41--3/4
18--7/8
20--7/8
2
45--3/4
42--3/4
22
8
14
24
D
E
F
G
H
K (CLA)
K (CMA)
K (CHA)
14
24
ROOF CURB DIMENSIONS (AX SERIES) Model No.
A
B
C
AXB020C(L,M,H)A** 42-3/4 39-3/4 18 18 3-3/4 42-3/4 39-3/4 18 8 * Full Perimeter Curbs ** AXB curbs are not full perimenter curbs. Three ton units have a 3 inch overhang on the control access panel end of the unit . The 4 & 5 ton units have a 3 to 4 inch overhang on the back and sides. There will be some supply air blockage, but this does not affect the performance of the unit.
ECONOMIZERS Mainline Model Number
Description
Used on
Fully Modulating Horizontal
AHE01FB0A
3 Ton
Fully Modulating Horizontal
AHE02FB0A
4 to 5 Ton
Fully Modulating Downflow
AEM01FB0A
3 Ton
3 Position Horizontal
AHP01FB0A
3Ton
3 Position Horizontal
AHP02FB0A
4 to 5 Ton
3 Position Downflow
AEP01FB0A
3 Ton
H
C E
FRESH AIR DAMPERS Description
Mainline Model Number
35% Manual Fresh Air Damper 35% Manual Fresh Air Damper 35% Motorized Fresh Air Damper 35% Motorized Fresh Air Damper
AFA01FB0A AFA02FB0A AFM01FB0A AFM02FB0A
A Used on 4 to 5 Ton 3 Ton
AKF12FBOA
Used on ALL
HAIL GUARD Mainline Model Number
Hail Guard
Used on
AGH01FB0A
3 Ton
AGH02FB0A
4 to 5 Ton
FOSSIL FUEL CONVERSION (0’ to 2000’) Service Parts Number *
Used on Heat Input
Natural to LP Gas
1172663
80 MBTUH
Natural to LP Gas
1172662
100, 120, 140 MBTUH
LP to Natural Gas
1172664
80 MBTUH
LP to Natural Gas
1098575
100, 120, 140 MBTUH
Description
* Available through Service Parts only. For High Altitude conversions, see installation instructions. SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE
K*
Roof Curbs available in 8’’, 14” and 24‘‘ Heights (K Dimensions)
Filters not included in kit, small chassis uses 12 x 25 x 1 (2 ea), large chassis uses 14 x 25 x 1 (2 ea)
Description
D
Curb Dimensions
4 to 5 Ton
Mainline Model Number
Return Air Filter Kit
B
3 Ton
RETURN AIR FILTER KIT Description
BACK
F G
6
UNIT DIMENSIONS
4 TO 5 TON
3 TON
K
SUPPLY
RETURN
See Detail
N
N
BASE PAN ALL DIMENSIONS IN INCHES
L**
Connections Detail
BASE RAIL
GAS CONNECTION 1/2‘‘ PIPE LOW VOLTAGE 1/2‘‘ CONDUIT
BASE RAIL 27
K
ELECTRICAL POWER CONDUIT
Condensate Drain
12--1/4
SUPPLY 2--1/4
46--1/8**
19 12--1/4 1--3/4
RETURN
19
5--3/16 2--3/16
6
2--3/16 3--3/4
A
B
C
D
E
F
G
H
I
J
K
L
M
N
3 Ton
UNIT SIZE
29--1/2
47--1/2
47--1/2
3
9--1/2
12
14
12
14
4--1/2
16
42--3/4
1--9/16
46--1/2
4 TO 5 Ton
37--1/2
47--1/2
51--1/2
7--1/2
6--1/2
19
12
12
19
4--1/2
22
46--1/4
5--3/16
49--3/4
** Measured from inside to inside on base rails.
SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE
7
MODEL NUMBER IDENTIFICATION GUIDE MODEL NUMBER
P
G
F
036
H
F
100
P = Single Package GAS ELECTRIC
Engineering Cole
GAS HEAT INPUT 100 = 100,000 080 = 80,000
120 = 120,000 140 = 140,000
ELECTRICAL CHARACTERISTICS H = 208 / 230--3--60 L = 460--3--60 S = 575--3--60 F = Standard Series
COOLING CAPACITY (NOMINAL BTUH)
C = Models with Nox baffles and meet California emission requirements.
36 = 3 ton 48 = 4 Ton
60 = 5 Ton
GUIDE SPECIFICATION CABINET The cabinet is made of triple--coated steel, consisting of a Polyester top coat, a urethane primercoat preceeded byan oxide pretreatment. One piece weatherresistanttop. The base rails are 16 gauge steel with fork lift slots and holes provided for lifting shackles. The unit is designed with convertible airflow for either horizontal or downflow applications with conversion accomplished by relocating two panels. Indoor blower compartment interior cabinet surfaces are insulated with a minimum 1/2’’ thick, flexible glass insulation, coated on the air side. Aluminum foil faced glass fiber insulation is used in the furnace compartment. COOLING SECTION The unit is factory charged and operationally ready upon delivery. The unit refrigerant circuit has a high efficiency fully hermetic compressor (5 ton has scroll compressor) with internal overload protection, and copper tube / aluminum fin evaporator and condenser coils. The unit is designed for cooling operation to 40o F and will be capable of being wired for field installed economizer type accessories.
COILS The evaporator and condenser coils are fabricated with aluminum fins mechanically bonded to copper tubing. Both coils are pressure tested prior to assembly into the unit and electronically leak tested after assembly into the unit. CONDENSER FAN The unit has a single direct-drive propeller-fan / motor assembly. The assembly is mounted directly to a vertical-discharge grille that is easily removed for service. Motors are 1100 RPM with sleeve or ball bearings and internal overload protection. EVAPORATOR BLOWER All units have a direct-drive evaporator blower motor as a standard. The direct-drive evaporator blower motor has sleeve bearings and internal overload protection. HEATING SECTION The gas-fired heating section features an induced draft blower for combustion air. The unit has an aluminized steel serpentine clamshell heat exchanger located on the discharge air side of the blower. The system uses in-shot burners ignited by a hot surface pilot ignition system, protected by both a high heat limit switch and flame roll-out switch. The induced draft blower motor is interlocked with a proven air pressure safety device.
INSTALLATION CLEARANCES
RECOMMENDED FOR SERVICE
RIGGING DETAILS
CORNER WEIGHTS (LBS) UNIT SIZE
3 TON 4 TON 5 TON
SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE
8
A
B
C
D
OPERATING WEIGHT TOTAL
82 98 100
103 123 125
143 171 175
82 98 100
410 490 500