HCD-MX500i/MX550i
SERVICE MANUAL
Canadian Model Chinese Model Singapore Model
Ver. 1.0 2010.05
HCD-MX500i
AEP Model
HCD-MX500i/MX550i
UK Model
HCD-MX550i
Photo: HCD-MX550i • HCD-MX500i is the amplifier, CD player, tuner, USB (Except Canadian) and iPod/iPhone section in CMT-MX500i. • HCD-MX550i is the amplifier, CD player, tuner, USB and iPod/iPhone section in CMT-MX550i.
• • • • • •
iPod is a trademark of Apple Inc. iPhone is a trademark of Apple Inc. MPEG Layer-3 audio coding technology and patents licensed from Fraunhofer IIS and Thomson. Windows Media is either a registered trademark or trademark of Microsoft Corporation in the United States and/or other countries. This product is protected by certain intellectual property rights of Microsoft Corporation. Use or distribution of such technology outside of this product is prohibited without a license from Microsoft or an authorized Microsoft subsidiary. All other trademarks and registered trademarks are of their respective holders. In this manual, ™ and ® marks are not specified.
Model Name Using Similar Mechanism
NEW
CD Mechanism Type
CDM85CD-DVBU102
Optical Pick-up Block Name
KHM-313CAA
SPECIFICATIONS DAB/DAB+ frequency table (Band-III)
Main unit AUDIO POWER SPECIFICATIONS With 6 ohm loads, both channels driven, from 120 10,000 Hz; rated 30 watts per channel minimum RMS power, with no more than 10% total harmonic distortion from 250 milliwatts to rated output.
Amplifier section European model: DIN power output (rated): 25 watts + 25 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 30 watts + 30 watts (6 ohms at 1 kHz, 10% THD) Music power output (reference): 30 watts + 30 watts (6 ohms at 1 kHz, 10% THD) Other models: DIN power output (rated): 25 watts + 25 watts (6 ohms at 1 kHz, DIN) Continuous RMS power output (reference): 30 watts + 30 watts (6 ohms at 1 kHz, 10% THD)
Input AUDIO IN (stereo mini jack): Sensitivity 700 mV, impedance 47 kilohms
Outputs SPEAKERS: Accepts impedance of 6 ohms
CD player section System: Compact disc and digital audio system Laser Diode Properties Emission Duration: Continuous Laser Output*: Less than 44.6μW * This output is the value measurement at a distance of 200mm from the objective lens surface on the Optical Pick-up Block with 7mm aperture. Frequency response: 20 Hz 20 kHz Signal-to-noise ratio: More than 90 dB Dynamic range: More than 90 dB
iPod/iPhone section
Frequency
Label
174.928 MHz
5A
209.936 MHz
10A
176.640 MHz
5B
211.648 MHz
10B
178.352 MHz
5C
213.360 MHz
10C
180.064 MHz
5D
215.072 MHz
10D
181.936 MHz
6A
216.928 MHz
11A
183.648 MHz
6B
218.640 MHz
11B
185.360 MHz
6C
220.352 MHz
11C
187.072 MHz
6D
222.064 MHz
11D
188.928 MHz
7A
223.936 MHz
12A
190.640 MHz
7B
225.648 MHz
12B
192.352 MHz
7C
227.360 MHz
12C
194.064 MHz
7D
229.072 MHz
12D
195.936 MHz
8A
230.784 MHz
13A
Compatible iPod/iPhone models: iPod touch 2nd generation iPod touch 1st generation iPod classic 120 GB, 160 GB (2009) iPod classic 160 GB (2007) iPod classic 80 GB iPod nano 5th generation (video camera) iPod nano 4th generation (video) iPod nano 3rd generation (video) iPod nano 2nd generation (aluminum) iPod nano 1st generation iPod 5th generation (video) iPod 4th generation (color display) iPod 4th generation iPod mini iPhone iPhone 3G iPhone 3GS
197.648 MHz
8B
232.496 MHz
13B
USB section (except for North American model)
199.360 MHz
8C
234.208 MHz
13C
201.072 MHz
8D
235.776 MHz
13D
202.928 MHz
9A
237.488 MHz
13E
204.640 MHz
9B
239.200 MHz
13F
206.352 MHz
9C
208.064 MHz
9D
Frequency
* Frequencies are displayed to two decimal places on this system.
Tuner section FM tuner section: FM stereo, FM superheterodyne tuner Tuning range: North American model: 87.5 MHz 108.0 MHz (100 kHz step) Other models: 87.5 MHz 108.0 MHz (50 kHz step) Antenna: FM lead antenna Antenna terminals: 75 ohms unbalanced Intermediate frequency: 10.7 MHz DAB/DAB+ tuner section (MX550i only): FM stereo, DAB/FM superheterodyne tuner Frequency range* Band-III: 174.928 (5A) MHz 239.200 (13F) MHz * For details, see “DAB/DAB+ frequency table” below. Antenna: DAB/FM lead antenna Antenna terminal: 75 ohms, F female
Label
Supported bit rate: MP3 (MPEG 1 Audio Layer-3): 32 kbps 320 kbps, VBR WMA: 48 kbps 192 kbps, VBR AAC: 48 kbps 320 kbps Sampling frequencies: MP3 (MPEG 1 Audio Layer-3): 32/44.1/48 kHz WMA: 44.1 kHz AAC: 44.1 kHz (USB) port: Type A, maximum current 500 mA
General Power requirements: North American model: AC 120 V, 60 Hz Other models: AC 220 V 240 V, 50/60 Hz Power consumption: 33 watts Dimensions (W/H/D) (excl. speakers): Approx. 309 mm × 122 mm × 247 mm Mass (excl. speakers): Approx. 2.9 kg Design and specifications are subject to change without notice.
Standby power consumption: 0.5 W Halogenated flame retardants are not used in the certain printed wiring boards.
COMPACT DISC RECEIVER 9-889-872-01
Sony Corporation
2010E05-1 © 2010.05
Audio&Video Business Group Published by Sony Techno Create Corporation
HCD-MX500i/MX550i
NOTES ON CHIP COMPONENT REPLACEMENT • Never reuse a disconnected chip component. • Notice that the minus side of a tantalum capacitor may be damaged by heat. FLEXIBLE CIRCUIT BOARD REPAIRING • Keep the temperature of soldering iron around 270 °C during repairing. • Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). • Be careful not to apply force on the conductor when soldering or unsoldering. Laser component in this product is capable of emitting radiation exceeding the limit for Class 1.
This appliance is classified as a CLASS 1 LASER product. This marking is located on the rear or bottom exterior.
SAFETY-RELATED COMPONENT WARNING! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
TABLE OF CONTENTS 1.
SERVICING NOTES .............................................
2.
DISASSEMBLY
2-1. 2-2. 2-3. 2-4. 2-5. 2-6. 2-7. 2-8. 2-9. 2-10. 2-11. 2-11.
Disassembly Flow ........................................................... Case ................................................................................. Front Panel Block ........................................................... Knob (VOL) .................................................................... MAIN Board ................................................................... SP Board ......................................................................... POWER Board ................................................................ CD Block ........................................................................ BD96/BD96U Board....................................................... Belt .................................................................................. FFC Holder ..................................................................... Optical Pick-up Block (KHM-313CAA) ........................
3.
TEST MODE ............................................................ 15
4.
ELECTRICAL CHECK ......................................... 18
5.
DIAGRAMS
5-1. Block Diagram - CD, USB Section - .............................. 5-2. Block Diagram - TUNER, iPod/iPhone, AUDIO IN Section - ................ 5-3. Block Diagram - OUTPUT, PANEL Section - ............... 5-4. Block Diagram - POWER SUPPLY Section - ................ 5-5. Printed Wiring Board - BD96/BD96U Board (Side A) - ................................... 5-6. Printed Wiring Board - BD96/BD96U Board (Side B) - ................................... 5-7. Schematic Diagram - BD96/BD96U Board (1/2) - ........ 5-8. Schematic Diagram - BD96/BD96U Board (2/2) - ........ 5-9. Printed Wiring Board - DAB Board (MX550i) - ............ 5-10. Schematic Diagram - DAB Board (MX550i) - ............... 5-11. Printed Wiring Board - MAIN Board (1/2) - .................. 5-12. Printed Wiring Boards - MAIN Board (2/2) -................. 5-13. Schematic Diagram - MAIN Section (1/4) - ................... 5-14. Schematic Diagram - MAIN Section (2/4) - ................... 5-15. Schematic Diagram - MAIN Section (3/4) - ................... 5-16. Schematic Diagram - MAIN Section (4/4) - ................... 5-17. Printed Wiring Boards - IP/JACK/SP/USB Boards - ..... 5-18. Schematic Diagram - IP/JACK/SP/USB Boards - .......... 5-19. Printed Wiring Boards - PANEL Section - ..................... 5-20. Schematic Diagram - PANEL Section - .......................... 5-21. Printed Wiring Board - POWER Board -........................ 5-22. Schematic Diagram - POWER Board - ..........................
6.
EXPLODED VIEWS
6-1. 6-2. 6-3. 6-4. 6-5. 6-6.
Case Section .................................................................... Front Panel Section ......................................................... iPod Dock Section .......................................................... MAIN Board Section ...................................................... Chassis Section ............................................................... CD Mechanism Deck Section (CDM85CD-DVBU102) ................................................
7.
3
8 8 9 10 10 11 11 12 13 13 14 14
19 20 21 22 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41
54 55 56 57 58 59
ELECTRICAL PARTS LIST .............................. 60
HCD-MX500i/MX550i SECTION 1 SERVICING NOTES NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR BASE UNIT The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by the charged electrostatic load, etc. on clothing and the human body. During repair, pay attention to electrostatic break-down and also use the procedure in the printed matter which is included in the repair parts. The flexible board is easily damaged and should be handled with care. NOTES ON LASER DIODE EMISSION CHECK The laser beam on this model is concentrated so as to be focused on the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens. UNLEADED SOLDER Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size)
NOTE OF REPLACING THE MS-203 BOARD When the MS-203 board is damaged, exchange the entire CDM85 (CD) ASSY. MODEL IDENTIFICATION – Back Panel –
PART No.
Model
Part No.
HCD-MX500i: AEP model
4-175-955-0[]
HCD-MX500i: Canadian model
4-175-955-2[]
HCD-MX500i: Singapore model
4-175-955-3[]
HCD-MX500i: Chinese model
4-175-955-4[]
HCD-MX550i: AEP, UK models
4-175-955-5[]
: LEAD FREE MARK Unleaded solder has the following characteristics. • Unleaded solder melts at a temperature about 40 °C higher than ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350 °C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful! • Strong viscosity Unleaded solder is more viscous (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc. • Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder. RELEASING THE ANTITHEFT LOCK The disc tray lock function for the antitheft of an demonstration disc in the store is equipped. Releasing Procedure: 1. Press the [?/1] button to turn the power on. 2. While pressing the [x] button, press the [Z] button unit “UNLOCKED” displayed on the fluorescent indicator tube (around 5 seconds) . Note: When “LOCKED”is displayed, the disc tray lock is not released by turning power on/off with the [?/1] button.
3
HCD-MX500i/MX550i
CAPACITOR ELECTRICAL DISCHARGE PROCESSING When checking the board, the electrical discharge is necessary for the electric shock prevention. Connect the resistors referring to the figure below. • POWER board (C11, C12) (Canadian model) Both ends of respective capacitors. – POWER Board (Conductor Side) –
C12
800 :/2 W
C11
800 :/2 W
• POWER board (C10) (Except Canadian model) Both ends of respective capacitors. – POWER Board (Conductor Side) –
C10
4
800 :/2 W
HCD-MX500i/MX550i
HOW TO OPEN THE TRAY WHEN POWER SWITCH TURN OFF
bottom side 1 Insert the hard metal fittings of L character type in the hole of the chassis, and push the lever in the direction of the arrow.
MAIN, BD96/BD96U AND SP BOARDS SERVICE POSITION SP board
MAIN board
BD96 board (Canadian) BD96U board (Except Canadian)
5
HCD-MX500i/MX550i
FL, KEY, JACK AND USB BOARDS SERVICE POSITION
JACK board
MAIN board
FL board
KEY board
BD96 board (Canadian) BD96U board (Except Canadian) USB board (Except Canadian)
CD MECHANISM DECK, MAIN AND BD96/BD96U BOARDS SERVICE POSITION
MAIN board BD96 board (Canadian) BD96U board (Except Canadian)
POWER board
DAB board (MX550i)
CD mechanism deck
6
HCD-MX500i/MX550i
POWER BOARD SERVICE POSITION
POWER board
MAIN board
FL board
7
HCD-MX500i/MX550i SECTION 2 DISASSEMBLY •
This set can be disassembled in the order shown below.
2-1.
DISASSEMBLY FLOW SET
2-2. CASE (Page 8)
2-3. FRONT PANEL BLOCK (Page 9)
2-5. MAIN BOARD (Page10)
2-6. SP BOARD (Page 11)
2-4. KNOB (VOL) (Page 10)
2-8. CD BLOCK (Page 12)
2-7. POWER BOARD (Page 11)
2-9. BD96/BD96U BOARD (Page 13)
2-10. BELT (Page 13)
2-11. FFC HOLDER (Page 14)
2-12. OPTICAL PICK-UP BLOCK (KHM-313CAA) (Page 14)
Note: Follow the disassembly procedure in the numerical order given.
2-2.
CASE
5 case
1 two screws (BV/RING)
2 three screws (BV/RING)
3
4
3
– Bottom view –
8
HCD-MX500i/MX550i
2-3.
FRONT PANEL BLOCK qd screw (BV3) qf lead wire (from HP board) 7 ferrite core
5 Lift up the coating clip.
9 connector (CN402) 8 flexible flat cable (13 core) (CN404) qs two screws (BV3) 6 flexible flat cable (13 core) (CN409) qg two claws
2 Draw out the tray.
qh front panel block
0 connector (CN402)
qg two claws 3 two claws 4 panel (CD) block
qs three screws (BV3)
qa screw (BV3) (EXCEPT Canadian)
bottom side 1 Insert the hard metal fittings of L character type in the hole of the chassis, and push the lever in the direction of the arrow.
9
HCD-MX500i/MX550i
2-4.
KNOB (VOL)
Note: The illustration sees the front panel block from FL board side.
2 knob (VOL)
FL board
front panel block
hole 1 Push the knob (VOL) by flat-head screwdriver.
2-5.
MAIN BOARD qg two screws (BV3)
qh two coating clips
ql heatsink (AMP)
w; radiation sheet qg three screws (BV3)
wa cushion (ferrite)
ws MAIN board 2 ferrite core 1 flexible flat cable (13 core) (CN409) 3 connector (CN704) 4 connector (CN412) 5 flexible flat cable (13 core) (CN404) 6 connector (CN402) 7 connector (CN417)
qk two screws (BV3) qs connector (CN401) qj
qd connector (CN703) qf connector (CN702) qg screw (BV3) (MX550i) qa flexible flat cable (9 core) (CN407)
8 flexible flat cable (5 core) (CN410)
9 flexible flat cable (19 core) (CN408) (Canadian)/ flexible flat cable (27 core) (CN415) (Except Canadian)
0 flexible flat cable (9 core) (CN405) (CND, CH, SP)/ flexible flat cable (11 core) (CN406) (AEP, UK)
• Abbreviation CH : Chinese model CND : Canadian model SP : Singapore model
10
HCD-MX500i/MX550i
2-6.
SP BOARD 2 connector (CN703) 1 connector (CN702) 6 SP board
5 clamp filter
3 screw (BV3)
4
2-7.
POWER BOARD 6 two screws (BV3) 2 two screws (BV3) 6 two screws (BV3)
7 POWER board
6 two screws (BV3) 1 power cord connector (CN1) 2 screw (BV3) 3 lead wire (from HP board)
5
4 claw
11
HCD-MX500i/MX550i
2-8.
CD BLOCK 2 four screws (BV3)
Note 1: Do not remove this connector (CN201) at this point. It is necessary to process electrostatic measures of optical pick-up. 1 connector (CN301)
6 bracket (center)
4 screw (BV3)
7 two claws
7 two claws
bracket (front) 7 two claws
8 screw (BV3)
3
flexible flat cable (5 core)
9 claw
– Front side view –
5 two claws qa filament tape 0 bracket (front)
8 screw (BV3) 9 claw
qs three screws (BV3)
8 screw (BV3)
wire (flat type) (24 core) filament tape qf CD block guard board
Note 2: When you install CD block, fix the wire (flat type) (24 core) with the filament tape firmly as shown in figure.
12
qd
HCD-MX500i/MX550i
2-9.
BD96/BD96U BOARD
Note 1: When disconnection the wire (flat type) (24 core) of optical pick-up block, solder the short-land.
1 Solder the short-land.
2 wire (flat type) (24 core) (CN201) Note 2: When assembling the optical pick-up block, remove the solder of short-land after connecting the wire (flat type) (24 core). – CD mechanism deck block bottom view –
• Abbreviation CH : Chinese model CND : Canadian model SP : Singapore model
3 BD96 board (MX500i: CND)/ BD96U board (MX500i: AEP, CH, SP/MX550i)
2-10. BELT 7 chuck cam
8 belt 6 shaft
3 claw
4 tray 5 two hooks 3 claw bottom side
2
1 Push the lever in the direction of the arrow.
13
HCD-MX500i/MX550i
2-11. FFC HOLDER Note 1: The illustration sees the CD mechanism deck block from optical pick-up block side. 3 FFC holder Note 2: Remove the FFC holder from the original set and install it again.
2 two claws
1 two claws
1 two claws CD mechanism deck block
2-12. OPTICAL PICK-UP BLOCK (KHM-313CAA) +RZWREHQGWKHwire (flat type) (24 core)
to optical pick-up block (KHM-313CAA)
40 mm to BD96/BD96U board (CN201)
The lower side is contact side. The upper side is contact side.
1 two screws 6 optical pick-up block (PTPWH M2.6) insulator 3 (KHM-313CAA) two screws 1 (PTPWH M2.6)
4 wire (flat type) (24 core)
3 insulator
3 insulator 3 insulator 5 connector
2 mechanism deck (CDM85 (CD))
– CD mechanism deck block bottom view –
14
40 mm
50 mm
HCD-MX500i/MX550i SECTION 3 TEST MODE COLD RESET The cold reset clears all data including preset data stored in the memory to initial conditions. Execute this mode when returning the set to the customer. Procedure: 1. In the standby status, press the [?/1] button to turn the power on. 2. Press two buttons of [ENTER] and [?/1] simultaneously. 3. When “RESET” appears, the set enters. AUTO STANDBY MODE This mode is used to change the automatic standby function. With this function, the system enters standby mode automatically in about 30 minutes when there is no operation or audio signal output. By default, the automatic standby function is turned on. Procedure: 1. Press the [?/1] button to turn the power on. 2. Press the [?/1] button for 2 seconds. 3. The message “AUTO STBY” → “OFF” is displayed on the fluorescent indicator tube and the automatic standby OFF mode is set. 4. To turn this function on, press the [?/1] button again for 2 seconds. The message “AUTO STBY” → “ON” is displayed on the fluorescent indicator tube and the automatic standby ON mode is set. COMMON TEST MODE This mode is used to check operations of amplifier. Procedure: 1. Press the [?/1] button to turn the power on. 2. Press two buttons of [ENTER] and [FUNCTION] simultaneously. 3. When the COMMON test mode is activated, “AUDIO IN” is displayed on the fluorescent indicator tube and “c PLAY SLEEP” blink on the fluorescent indicator tube. 4. Each time [EQ] button on the remote commander is pressed, the display changes starting “TONE MAX”, “TONE MIN” and “TONE FLAT” this order. 5. Turn the [VOLUME] knob counterclockwise, “VOLUME MIN” is displayed on the fluorescent indicator tube. Turn the [VOLUME] knob clockwise, “VOLUME MAX” is displayed on the fluorescent indicator tube. 6. To release this mode, press the [?/1] button. PANEL TEST MODE This mode is used to check the fluorescent indicator tube, LED, model, destination, software version and key. Procedure: 1. Press the [?/1] button to turn the power on. 2. Press three buttons of [ENTER] and [x] simultaneously. 3. All segments on the fluorescent indicator tube, [STANDBY] LED light up. 4. Press the [ENTER] button, the model and destination are displayed on the fluorescent indicator tube. 5. Press the [ENTER] button again, MC version is displayed on the fluorescent indicator tube. 6. Each time [ENTER] button is pressed, the display changes starting from MC version, GC version, USBL version , USBM version, IPL version, CD version, CDD version, CDMA version, CDMB version, BDA version, BDB version, ST version, TA version and TM version this order, and returns to the MC version display. 7. When [x] button is pressed while the MC version is displayed, year, month and day of the software creation is displayed. When [x] button is pressed again, the display returns to the MC version display.
8. Press the [TOOL MENU] button, the key test mode is activated and “K 0 V0” is displayed on the fluorescent indicator tube. 9. Each time a button is pressed, “K” value increases. However, once a button is pressed, it is no longer taken into account. All keys are pressed, display becomes “K9” . 10. “V” value increases 2, 4, 6 ... if turn the [VOLUME] knob clockwise, or it decreases 8, 6, 4 ... if turn the knob counterclockwise. 11. To release this mode, press three buttons in the same manner as step 2, or disconnect the power cord. CD SHIP MODE This mode moves the optical pick-up to the position durable to vibration. Use this mode when returning the set to the customer after repair. Procedure: 1. Press the [?/1] button to turn the power on. 2. Press the [FUNCTION] button to select “CD”. 3. Press two buttons of [TOOL MENU] and [?/1] simultaneously. 4. After blink “STANDBY”, “LOOK” is displayed, disconnect the AC plug. CD SHIP MODE & MEMORY CLEAR This mode is used to perform CD ship mode and cold reset simultaneously. Procedure: 1. Press the [?/1] button to turn the power on. 2. Press three buttons of [x] and [DSGX] simultaneously. 3. After blink “STANDBY”, “LOOK” is displayed disconnect the AC plug. ANTITHEFT LOCK MODE This mode is used to unable to take sample disc out of disc tray in the shop. Procedure: 1. Press the [?/1] button to turn the power on. 2. Press the [Z] button to open the disc tray and set the CD disc. 3. Press the [Z] button to close the disc tray. 4. Press two buttons of [x] and [Z] for 5 seconds. 5. The message “LOCKED” is displayed on the fluorescent indicator tube and the disc tray is locked. (Even if pressing the [Z] button, the message “LOCKED” is displayed on the fluorescent indicator tube and the disc tray is locked) 6. To release from this mode, press two buttons of [x] and [Z] for 5 seconds. 7. The message “UNLOCKED” is displayed on the fluorescent indicator tube and the disc tray is unlocked. CD POWER MANAGE This mode is used to changed over CD power on/off for decreasing of reception noise in the tuner mode. Procedure: 1. Press the [?/1] button to turn the power on. 2. Press the [FUNCTION] button to select “CD”. 3. Press the [?/1] button again to turn the power off. 4. Press two buttons of [ + v] and [?/1] simultaneously. 5. The message “CD POWER ON” or “CD POWER OFF” is displayed on the fluorescent indicator tube, and CD power on/off is changed over in the tuner mode.
15
HCD-MX500i/MX550i
CD SERVICE MODE This mode can run the CD sled motor freely. Use this mode, for instance, when cleaning the optical pick-up. Procedure: 1. Press the [?/1] button to turn the power on. 2. Press the [FUNCTION] button to select “CD”. 3. Press three buttons of [x] and [ + v] simultaneously, the message “SERVICE MO” is displayed on the fluorescent indicator tube. 4. Press the [l m TUNE –] button to move the optical pickup to inside track and the message “SLED IN” is displayed on the fluorescent indicator tube, or press the [M L TUNE +] button to outside track and the message “SLED OUT” is displayed on the fluorescent indicator tube. 5. Press the [u] button, “LD ON” or “LD OFF” is displayed on the fluorescent indicator tube. Each time [u] button is pressed, laser diode on/off is changed over. 6. To release this mode, press the [?/1] button. CD SERVO TEST MODE This mode can check the servo system operations of the optical pick-up system (= optical unit + BD96/BD96U board). Note 1: Do not enter the [CD SERVO TEST MODE] while any other test mode is in progress. Note 2: Do not enter any other test mode while the [CD SERVO TEST MODE] is in progress. Note 3: In RAM Read, “SBADrough”, “SBBTrough”, “DT-GI roug”, “SBAD fine”, “SBBT fine”, “DT-GI fine”, “DSPcomcnt”, and “EDCcomcnt” are displayed but are not used in the service.
How to Enter the CD Servo Test Mode Procedure: 1. Press the [?/1] button to turn the power on. 2. Press the [FUNCTION] button to select CD function. 3. Press three buttons of [x], and [V ‒] simultaneously. 4. It enters the CD servo test mode and displays “bdt S CURV”. How to Exit from the CD Servo Test Mode Procedure: 1. To release this mode, press the [?/1] button. Key Operation: –]: [ + v], [V Use these keys to move between the seven modes contained in the CD Servo Test Mode, that are the S-Curve Mode, the RAM Read Mode, the RAM Write Mode, the Command Out Mode, the Error Rate Mode the LOG Initialize Mode and the LOG Read Mode as described below. Also, use these keys to move between the menus within the respective seven modes. When [ + v] is pressed, the screen advances to the next menu or to the next mode. When [V –] is pressed, the screen returns back to the previous menu or to the previous mode. Use these keys also to increase or decrease the numeric value when changing the numeric value. Pressing [ + v] increases the value and pressing [V –] decreases the value. [ENTER], [x]: Use these keys to move between the different layers of the hierarchy of the CD Servo Test Mode shown below. Press [ENTER] to move down to the lower layer, and press [x] to move up to the higher layer. [M L TUNE +], [l m TUNE –]: Use these keys to move the cursor to the right digit or to the left digit in the six-digit number, when changing the numeric value. Press [M L TUNE +] to move the cursor to the right, and press [l m TUNE –] to return the cursor to the left.
16
[u]: Use this key to execute Command Out in the Command Out Mode. CD Servo Test Mode Tree: S Curve Mode (bdt S CURV) RAM Read Mode (bdtRAM REA)
Higher layer LD ON (LD ON) Disc Type (DiscType) Gain Index (GainIndx) RFO GAIN (RFO_GAIN) FEO GAIN (FEO_GAIN) SBAD GAIN (SBAD_GAIN) TEO GAIN (TEO_GAIN) Disc Size (DiscSize)
Lower layer of menu hierarchy
value indication (AL: 0000, RW: 0001) value indication (0001) value indication (0008) value indication (0005) value indication (0008) value indication (0008) value indication (0000: Non disc, 0001: 8cm, 0002: 12cm) Op ABRAKE Error value indication (OpAbrkErr) (0000) SBBT Data value indication (SBBT Data) (0053) TE Peak value indication (TE P-P) (0097) FEOOCD value indication (FEOOCD) (00C0) The following items are not used (Note 3) RAM Write Mode SPG Mask value edit (bdtRAM WRI) (00 SPG_M) (Non mask:00, Mask:01) Fix RF Gain value edit (00 FixRF) (Non Fix:00, AL Fix:01, RW Fix:02) TMAX ON value edit (00 tmaxo) Driver Mute OFF value edit (00 d_mut) (Normal:00, Forced OFF:01) Command Out Mode COMOUT6X value edit command out (bdt COMOUT) (COMOUT6X) (000000) (OK) READ2X value edit command out (READ2X) (60) (50) REG READ value edit command out (REG_READ) (00) (0000) FEBC? command out (FEBC?) (00) FGADD? command out (FGADD?) (FA) TEBC? command out (TEBC?) (02) TGADD? command out (TGADD?) (0D) RFGC? command out (RFGC?) (3F) FEOF? command out (FEOF?) (0000) TEOF? command out (TEOF?) (FFC0) TEIOCD1? command out (TEIOCD1?) (FEC0) TEIOCD2? command out (TEIOCD2?) (FEC0) TEIOCD3? command out (TEIOCD3?) (0080) TEOOCD? command out (TEOOCD?) (FB80) FEOOCD? command out (FEOOCD?) (00C0) MONITOR value edit command out (MONITOR) (570A00) (OK) Error Rate Mode Error rate indication (bdt ERR RA) (0000000000) LOG Read Mode value indication (bdtLOG REA) (XX: YYYYYY: ZZZZ) XX: LOG Number YYYYYY: Communication LOG ZZZZ: LOG Number LOG Initialize Mode Initializetion Initialization execution (bdtLOG INI) confirmation (INIT done) indication
HCD-MX500i/MX550i
CD ERROR CODE The past errors of the CD mechanism (CDM) are displayed as the CDM Errors, and those of the optical pick-up system (= optical unit + BD96/BD96U board) are displayed as the BD Errors as shown below. Procedure: 1. Press the [?/1] button to turn the power on. 2. Press the [FUNCTION] button to select CD function. 3. Press three buttons of [TOOL MENU] and [u] simultaneously. 4. BD and CDM error counts are displayed on the fluoresent indicator tube as shown below.
08: The disc chucking-release completion operation is in progress. 4 It indicates the operation during which the trouble has occurred. 00 : Waiting for the operation. 10 to 13 : The disc EJECT operation is in progress. 20 : The disc pulling-in operation is in progress. 30 : The disc chucking-release operation is in progress. 40 to 43 : The disc EJECT operation due to error is in progress. 5 Reserve 00: Fix
Em**Ed** X Mode-in count BD error count CDM error count 5. Press the [ + v] button. 6. Then, the CDM error code is displayed as “M0xxxxxxxx” (x means hexadecimal number) on the fluorescent indicator tube as shown below. 7. Every pressing of the [M L TUNE +] button in this mode increments the number after “M” starting from “M0” up to “M9”, and then returns to “M0”. Every pressing of the [l m TUNE –] button in this mode decrements the number after “M”. The smaller the error code number is, the newer the error content is. Press the [V –] button to return to the previous display. 8. When the [ + v] button is pressed then, the BD error code is displayed as “D0xxxxxxxx” (x means hexadecimal number) on the fluoresent indicator tube as shown below. In the same way as the CDM error code, use of the [M L TUNE +] and the [l m TUNE –] buttons in this mode enables tracing of the error history. Press the [V –] button to return to the previous display. 9. To release from this mode, press the [?/1] button to turn the power off. Contents of “CDM Errors” Error display example M 0 FF 11 42 00 1 2 3 4 5 1 It indicates the error history number 0 to 9: The error code number 0 indicates the newest error. 2 It indicates whether the CDM error occurs in the normal operations or during the initialization operation. FF : The error has occurred in the normal operations. Other than FF : The error has occurred during the initialization operation. 3 It indicates the processing during which the trouble has occurred. 01: The disc EJECT processing is in progress. 02: The disc INSERTION-WAITING processing is in progress. 03: Processing of the disc INSERTION-REQUEST for the upper CD tray is in progress. 04: Processing of the disc EJECTION-REQUEST for the upper CD tray is in progress. 05: The disc pulling-in operation is in progress. 06: The disc chucking processing is in progress. 07: The disc re-chucking processing is in progress.
Contents of “BD Errors” Error display example D 0 02 09 01 01 1 2 3 4 5 1 It indicates the error history number 0 to 9: The error code number 0 indicates the newest error. 2 It indicates the error content 01: The focus servo cannot lock-in. 02: GFS is no good (NG). 03: The startup time exceeds the specified period of time (time over) 04: The focus servo is unlocked continuously. 05: Q code cannot be obtained within the specified period of time. 06: The tracking servo cannot lock-in. 07: Blank disc 3 It indicates the on-going processing of optical pick-up system (= optical unit + BD96/BD96U board) when the trouble has occurred. 01: The CD SHIP mode processing is in progress. 02: The POWER OFF processing is in progress. 03: The INITIALIZE processing is in progress. 04: The optical pick-up system (= optical unit + BD96/ BD96U) is in the stop state. 05: The STOP operation is in progress. 06: The startup processing is in progress. 07: The TOC read-in processing is in progress. 08: The SEARCH operation is in progress. 09: The PLAY operation is in progress. 0A: The PAUSE operation is in progress. 0B: The PLAY – MANUAL SEARCH operation is in progress. 0C: The PAUSE – MANUAL SEARCH operation is in progress. 4 It indicates the disc speed when the trouble has occurred. It indicates the step number of each processing specified by 3. Because the numbers of steps are different in each processing, this number is different in each processing. 5 It indicates the disc speed when the trouble has occurred. 01: 1x (normal)
17
HCD-MX500i/MX550i SECTION 4 ELECTRICAL CHECK FM TUNE LEVEL CHECK signal generator set
Procedure: 1. Turn on the set. 2. Input the following signal from signal generator to FM antenna input directly. Carrier frequency : A = 87.5 MHz, B = 98 MHz, C = 108 MHz Deviation : 75 kHz Modulation : 1 kHz ANT input : 35 dBu (EMF) Note: Use 75 ohm coaxial cable to connect signal generator and the set. You cannot use video cable for checking. Use signal generator whose output impedance is 75 ohm.
3. Set to FM tuner function and tune A, B and C signals. 4. Confirm “TUNED” is lit on the display for A, B and C signals. When the selected station signal is received in good condition, “TUNED” is displayed.
18
HCD-MX500i/MX550i SECTION 5 DIAGRAMS 5-1.
BLOCK DIAGRAM - CD, USB Section E[FHSW&DQDGLDQ &16 86%&O175O//E5 ,&4
&'03352&(6625 ,& /O87 5O87 2
$O872 %&.O $,1 %&., /5&., *$7E 3,O67B5E4
$ (Page 20)
&'/
9%86
9%863O:E5 O1OFF6:,7&+ ,&46
9 % 96 '
92%% 92''
%8FFE5 ,&2
95 $ 94 &
92((* 92)))
%8FFE5 ,&2
E 9 F
/'
$8720$7,& 32:(5 &21752/ 4
9 /'2
,O±,O5
5&+
86%O& 86%3O1
4 6 65 66 6 5 49
$±$6
$±$5
65$0&6 5' 65:5 65//% 65/8%
64 65 66 6
6 4 9 4
&DQDGLDQ
5 6 9 92 94 9
'$7$ &/. $,1 %&. /5&. *$7E 675E4
55 56 5 5 59 6 96
%868 %868 %8628 %868 %8&.8 &&E8 5E48
X4 90+] 2 2 2 %86 %86 %862 %86
9 4 4
9 95 94 9
%86 6:,7&+ ,&44
&'%86 &'%86 &'%862 &'%86
44
062%O$5'
%86 6:,7&+ ,&4
24 XO X 6940+]
/,0,7
2 X,
X&&E 4
5E4 4
4
63,1'/E
0
0
63 63 6/ 6/
2 2
92 92 922 922
6/E'
,12¶ 9
2 F02
%,$6 2
4 952
,1¶ 2
752
&/O6E6: O3E16:
6 : TUNER DAB * : Impossible to measure • Voltages are taken with VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. • Circled numbers refer to waveforms. • Signal path. F : TUNER J : CD PLAY d : USB i : iPod/iPhone f : AUDIO IN • Abbreviation CH : Chinese model CND : Canadian model SP : Singapore model
BD96 board (Canadian) BD96U board (Except Canadian)
KEY board USB board (Except Canadian)
23
23
MS-203 board
HCD-MX500i/MX550i
PRINTED WIRING BOARD - BD96/BD96U Board (Side A) - • See page 23 for Circuit Boards Location. •
1
2
BD96 BOARD
A
3
4 (SPINDLE)
OPTICAL PICK-UP BLOCK (KHM-313CAA)
(CND)
BD96U BOARD
: Uses unleaded solder.
5
M
1
(Page 31) MAIN BOARD CN413
A
(EXCEPT CND)
(SIDE A)
7
(SLED)
(LIMIT)
M
6
6
(CHASSIS) CL208
IC201
R206 CL209 7 R207 C216 1 CL216 R209
14 C213
C436 CL405 CL404
CN301 1 CL301
CL104 C214
R311
R308 SL301
SL304
R314
CL303
R437R435 R431 R439
SL303
R458 1
7 R122
CL106 CL124 CL105 C104 C103 R101 C110 C101
C124 C108
C127
C105 CL102
C119 CL103
8
14
CL107
C208
SL201
D
CL108
C129
C157 C133
CL402
C137
C160 C158
C159 C139 R131
R125 C134 R130 C135 R148 (CND) C123 CL113
R147 R146 R145 R144 R143 R150 R149 CL123
R403
CL115
C505
R504 C507 C508
C506
R505 C501 CL501
CL117 CL114
C502
IC403
IC402 R470 R466 R464 R469 C423 R465 R463
CL503
R514 CL410
CL505 CL506 CL509 CL512 CL504 CL507 CL508
C503
1
2
18 19
CN502
C521 CL515
MAIN BOARD CN415 (Page 31)
E
(CND)
24
24
D
C
MAIN BOARD CN408 (Page 31)
(EXCEPT CND)
CL408
R404
R410 R409
R412 R411 C405 R407 R415 C411
C408 R418
C414
C415
(NC)
CN403
C410 CL413
CL416 CL415
C513
CL513
CL516 CL518
CL511 CL514 C504 R501 R503
4
R441 R440
R516
CL502
HCD-MX500i/MX550i
R420 44
R468 R467 R513
USB BOARD CN315 (Page 36)
1
CL411
CL125
B
D401 R401 D403 R402
C404
23
CL122
C536
CN402 1
C422 R445
R136
C145
CL406
CL407
C424
C141
CL409
R430
R457 R447
R506 R507 R508 R509 R510 R511 R512
C
C125 C126
R433 R448 R446
5 C437 4 CL417
22
CL118
C128
R203 R204
C309
CL305 CL306
1 3
C529 C528
CL403R479 R419 R408R480 R425 R422 CL412
6
CL302 CL304
C203
IC406
5
6
R202
R201
8
C207
CN401
2
C202 R215 Q201 R218 R219 C204 R210
R205
1
1
CL210
CL207 CL212
C302 C303 C305
SL302
CL401
R305
CN501
26 27
CL521
CL414
CL519 R519 CL520 CL522
CL202
CL201
CL211
CL205
R208
C515 (CHASSIS)
23 24
CN201
2
CL215 CL214 CL204
E B
B
1
CL203
R302
CL510
CL213
CL206 ET501
R525 C518
ET504
7
5-5.
R518 R520
R521
11 1-882-088-
(11)
HCD-MX500i/MX550i
5-6.
PRINTED WIRING BOARD - BD96/BD96U Board (Side B) - • See page 23 for Circuit Boards Location. •
1
2
BD96 BOARD
A
: Uses unleaded solder.
3
4
5
6
7
(CND)
BD96U BOARD
(EXCEPT CND)
(SIDE B)
R306 R316 (EXCEPT CND) X401
28
7
22
29
30
8
21
14 C406
R413 R414
C
C434
75
C435
51 C420
IC405
IC401
R478 R477
R474 R472
8
7
1 Q401
R444 R443
1 C409 R421
25 R455 C413 R453 R451 R449
R471
IC404
9 R475
26 C421
R138 8
16 R476
R142
14 R473
C143
R502
C514 R515
C148 3 4
C512
2 1
C149
IC102
D
C142 26
R159 R158 R157 R156 R155 R154 R151
IC101
R140
R126
R127 (EXCEPT CND)
25
25
51 R153
R117 R124 R120 R121
C122
1
C116 R107 R105 R103
R106 100
R102 C113 C107 C109 C112 C111 C114 76 C106 C115 75 R109 R108 C118
50 R141
R152
R459
HCD-MX500i/MX550i
C138 R135
R137 R139
(CND)
R454 R452 R450
R133 C130 C132 C136 R128 C131 R134 25
X101
1 C425
C426
R442 100
IC203
IC202
(CND)
50
76
R438
R214
R104
R481 C438
R436
R456
C403
R432
C412
15
IC301
R434
E B
R416 C407
R229 R224 R222 R213 R228 R220 5 4 5 4 R211 C210 1 R212 8 8 1 R223 R230 R226 C212 C211 R231 R217 R216 R225 R227 R221
R112 R113 R116
B
1
R119 R118 11 (CND)
1-882-088-
(11)
HCD-MX500i/MX550i
SCHEMATIC DIAGRAM - BD96/BD96U Board (1/2) - • See page 28 for Waveforms. • See page 42 for IC Block Diagrams. • See page 47 for IC Pin Function Description. 4
5
6
7
8
9
BD96 BOARD (1/2) (CND) BD96U BOARD (1/2) (EXCEPT CND)
12
R120 0
GATE CL117
0
3.3
0
CL114
CL113
CL115
GATE DVSS3
31
D
97
B
98
F
99
TNPC
LOUT 30 DVR 29 DVDD3
ROUT 27
100 E
C126 470p
28
7
8
9
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
100k
R155
100
BUCK-Z
0
R143
100k
R156
100
BUS3-Z
0
R144
100k
R157
100
BUS2-Z
0
R145
100k
R158
100
BUS1-Z
0
R146
100k
R159
100
BUS0-Z
3.3
C143
0.1
R151
100
0
R139
100
1.5
R147
10k
CCE-Z
RST-Z M-MUTE
CL122
CL123
1.5 1.5
3.3
1.6
R142 47
1.6 3.3
C141 22 6.3V
1.6
26
C148 1
R137 1M
3.3 3
4
2
1
IC B/D
IC102 +1.5V REGULATOR IC102 MM3404A15URE 3.3 DVDD-Z DGND L-OUT
R138 1M
1
3.3
1.5
1.5
100k
R150
DACGND R-OUT
R136 0
13
R134 1M
C128 0.047
C132 2200p
SL301
XO
6
XI
5
XVSS3
4
/DFCT
3
VSS1
2
VDD1
1
C129 0.047
R149
3.3
XVDD3
VDDP3
DVSS3
R154 100
3.3
VDD
A
96
0
R148 10k
Vout
95
34
VSS1 33
R141 100
CE
32
35
VDD1
REQ-Z DATA
0
VSS
VSS1
VDDT3
FOK
SBSY
IPF
ZDET
MS
VDDT3
VDDM1
RVSS3
R122 0
R308 39k
GPIN
C
38
MDI
C122 0.033 C125 470p
DOUT
94
BUS0
LDO
C116 0.033
SL302
BCKO
93
39
36
C131 0.1
C302 0.1
AOUT1
92
40
BUS1
SRAMSTB
8
R302 10k
0
3.3
0
0
0
0
91
C124 0.1
10k
AIN
BCKI
VSS1
VDD1
LRCKI
RVDD3
R231 10k
R229
0
1.5
3.3
90
41
BUS2
XRST 37
BD96/BD96U BOARD (2/2)
R135 1k
X101 16.934MHz
220
R230 10k
AWRC
RFO
0.1
R220 10k
I
R228 10k
1.6
89
IC101 TC94A70FG-101
C127 0.1
R223 10k
PDO
AGCI
R107 0
2
PVDD3
88
CD-MP3 PROCESSOR
BUS3
ST_REQ
0
CL118
BUFFER IC203 NJM2740V
TESTR
1.5
1.2
87
IC101
3.3
C104 0.1
5
7 1.8
R222 10k
2.1
R225 10k
2.1
H
1000p
VMDIR
R128
6
1.8
1.8
IC203
5
1.8
R106 0
RESIN
86
R140 100
0
(Page 27) 0.1
8
R105 0
85
C133
C108
1.8
1
V+
1.8
7
2
R104 0
BUCK 42
R133 10k
C130
6 2.1
2.1
5
3
1.8
VRO
VCOI
2.1 4
V+
BUFFER IC202 NJM2740V
1.8
R103 0
84
VSSP3
1
R102 0
XCCE 43
DMO
R227 10k
R226 10k
RFEQ0
1.3
2.3
83
IRQ 45
VREF
2
C212 0.1
2.3
V-
3
3.3
C107 68p
TEST 44
ST_REQ/CKO 46
TRO
4
IC202
2.1
2.1
R217 10k
1.6
RFRPI
1.6
FCS- 24
CL105
C211 0.1
CL205
1.6
RFI
82
1.6
R224 10k
0.1
C113
SLCO
81
1.7
R221 10k
1.6
80
FOO
CL206
0.015
AOUT2 47
AVDD3
R216 10k
C109
C103 0.1
C213 0.1
PVSS3
TEZI
1.6
79
49
REQ 48
3.3
CL104
0
CL207
1.6
1.6 1.6
0
CL208
G
CL103
VCOF
PIO2 50
1.6
F
1.6
78
R125 100
PIO1/ST_REQ
TEO
FCS+ 23
1.6
PVREF
FEO
TRK+ 22
CL211
CL102
0.1
LPFO
77
CL106
TRK- 21
R210 10k
R214 10k
2200p
C112
1.8
VOC/C 20
R213 10k
C111
1.7
R101 22k
2.1
VOD/D 19
CL213
R219 10k
C110 0.01
R218 10k
0.01
76
SBAD
C207 1
CL215
C106
1
1.6
CL212
RF 17 (LO:DVD.HI:CD)MSW 18
R211 1k
0.01
CL107
CL214
R212 1k
C114
CL108
C210 1
V-
VOA/A 16
CL209
1.8
VOB/B 15
E
1.6
C216 10
5
VOF/F+H 14
1.4
C101 1 CL216
VC 12 GND (PDIC) 13
C159 1000p
75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 TMAXS
CL210
VCC 11
C139 0.1
(EXCEPT CND)
C105 100 10V
R215 10k
VOE/E+G 10
OPTICAL PICK-UP BLOCK (KHM-313CAA)
C149 1
C158 1000p
C123
2.1
2.1
5
2.5
2.5
1.8
C214 10
14
RFRP
9
13
12
LPFN
NC
IC201 NJM13403V(TE2)
11
TMAX
8
R205 100
10
9
RFZI
VR (780)
8
R208 10k
C145 0.1
C135 0.1 R131 10k
AVSS3
7
CL204
R130 100k
C119 0.1
BUFFER CL203
SBSY
R112 330k
IC201
2.4
6
11 BD96/BD96U BOARD (2/2)
(Page 27)
R153 10k
C134 0.1 R116 5.6k
1
1.8
LD (780) VR (650)
2
3
2.1
5
4
2.1
4
PD
5
V+
NC
6
R109 0
C115 0.015
GND
3
7
2.5
NC
AUTOMATIC POWER CONTROL
2.5
2
2.5
LD (650)
19
(CND)
R119 0
1.6
D
1
R108 15k
C202 1000p
R118 0
R113 47k
R203 0
2.5
CN201 24P GND (LD)
10k
0.1
R209
C
18
R152 0
R126 100
R117 0
B
2.3 Q201 2SA2119K
CLK
C118 47p
/LOCK
SL201
R207 10k
CL202
1.9
17
(EXCEPT CND)
R127 0
IN_SW
R206 10k
R124 0
R121 0
FGIN
R204 100k
R202 3.3
3
16
2
0
C204 1
AIN
BCK
C160 1000p
1.7
C203 100 10V
15
1 C208 10
CL201 R201 1
14
13
1.9
A
11
10
LRCK
3
2
LRCKO
1
FMO
5-7.
C136 5p
C138 5p
C137 0.1
C157 1000p
C142 0.1 CL124 CL125
J
AGND AVDD3.3V AVDD5V
VM
IC301 BA5826HFP-E2
1.6
3.1
3.1
IC301
R314 0
L
R316 47k
R306 0 (SPINDLE)
M (LIMIT)
M
(SLED)
M
R305 15k
CN301 6P
6
R311 10k
CL301
1
SP-
1
SP+
2
LIMIT
3
LIMIT
4
SL-
5
SL+
6
HCD-MX500i/MX550i
SL304
FOCUS/TRACKING COIL DRIVE, SLED/SPINDLE MORTOR DRIVE
OPOUT
10 11 12 13 14
GND
9
SL303
IC B/D
OPIN
RESETt
VO3-
VO3+
8
VO2-
IN2
29
VO2+
IN2’
IN3
GND
7
12 BD96/BD96U BOARD (2/2)
(Page 27)
1.6
3.1
3.1
1.6
6.9
VCC
GND
6
1.6
MUTE
IN3’
GND
6.9
1.6
REGOUT
5
3.3
4
6.9
REGB
BIAS
VCC
1.6 RESET
IN4
IN1 3
1.6
VO1+ 2
3.5
1 2.9
VO1-
IN4’
21 20 19 18 17 16 15
VO4+
30
GND
28 27 26 25 24 23 22 VO4-
K
3.1
3.1
MGND
CL302 CL303 CL304 CL305 CL306
26
26
C303 0.1
C305 0.1
C309 220 10V
HCD-MX500i/MX550i
SCHEMATIC DIAGRAM - BD96/BD96U Board (2/2) - • See page 28 for Waveforms. • See page 42 for IC Block Diagrams. • See page 47 for IC Pin Function Description. 4
5
6
7
8
9
BD96 BOARD (2/2) (CND) BD96U BOARD (2/2) (EXCEPT CND)
11
13
14
15
16
17
BUS0-B
BUS1-B 100 R457 100k
100k
R436
R438
BUCK-Z
D11
31
96
REQ-U
D10 30
97
ST-REQ
D9 29
98
PG1
D8 28
99
PG0
DVCC3A 27
A0
0.2
D15
0.2
D14
0.2
D13
0.2
D12
0.1
D11
0.1
D10
0.1
D9
0.1
D8
3.3
C435 1000p
3.3
A10
0
A9
0
A8
0
A7
0
2
3
4
5
6
7
8
9
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
18 19 20 21
I/O7 WE A10 A9 A8 A7 NC
I/O10
31
I/O9
30
I/O8
29
D11
R468 47
D10
0.1
R469 47
D9
0.1
R470 47
D8
A3
27
A4
26
A5
25
A6
24
0
A3
0
A4
0
A5
0
A6
RXD
4
RESET
5
GND
6
VCC
7
0
3.3
0
VCC
1A
SELECT
3.3
ST
1B
3.3
0
4A
1Y 4B
2A 0
4Y
2Y
3A
9
8
1
2
3
4
5
6
7
BUS1-Z
BUS3-Z
R473 0
BUS2
R476
0
BUS2-Z
BUS3
C404 0.1
GND
1
2
3
4
5
6
7
R471 10k
C405 0.1
3.3 R415 10k
BUS_SEL
R421 4.7k
C411 0.1
C410 10 16V
C414 0.1
C415 10 16V
C409 0.1
C413 0.1
C425 0.1
R515 0
BUS1-Z
R472 0
R474
0
BUS0-Z
0 (CND)
Q401 RT1N141C-TP-1 INVERTER
C521 0.1
BUS1
C512 0.1
DI-B
RST-B
C504 0.1
BUS0
DGND C501 100 10V
DVDD-Z R502 0
CL501 CL502
AVDD3.3V
K
13 BD96/BD96U BOARD (1/2)
(Page 26)
C505 0.1
CL503 CL504
AGND C503 100 10V
C506 0.1
CL505
RST-Z R503 0
AVDD5V R504 100 L-OUT
L
R-OUT
CL506
R506
BUS1
R507
100
CL507
BUS2
R508
100
CL508
BUS3
R509
100
CL509
BUCK
R510
100
CCE
R511
100
CL511
REQ
R512
100
CL512
SBSY
R513
100
CL513
M-MUTE
R514
100
CL514
DACGND C508 2200p
100
BUS0
CL510
C507 2200p
R505 100
CL515
M
BUS_SEL
R516
N
27
CL516
CL518
DI-B
R519
100
CL519
TXD-B
R520
100
CL520
RXD-B
R521
100
CL521
RST-B
27
100 R518 100
DO-B
HCD-MX500i/MX550i
AVDD5V
2
AVDD3.3V
3
R-ch
4
DACGND
5
L-ch
6
AGND
7
RST-Z
8
BUS0
9
BUS1
10
BUS2
11
BUS3
12
BUSCK
13
CCE
14
REQ
15
SBSY
16
M-MUTE
17
DVDD-Z
18
DGND
19
DVDD-EVER3.3V
CL522
D MAIN BOARD (2/4) CN415
(Page 33)
(EXCEPT CND)
CN501 27P
R501 0
C502 100 10V
1 0
3C
4O/I
8 3I/O
0
0 9
10
3O/I
0 11 4I/O
4C
3.3 12
1C
3.3 13
3.3
BUS SWITCH
14 VCC
3.3
D7
D5
D6
D7
D6
D5
D4
D3
D2
D1
IC404
C434 1000p
R418 100
(CND)
CN502 19P
2C
RST-B
10
BUS0-Z
2I/O
RXD-B
CL416
11
NC 23
3.3
CL415
12
C424 0.1
0
TXD-B
13
BUS1-B
2O/I
CL414
14
BUS0-B
0
3
BUS SWITCH IC403 TC74HC4066AFT(EL)
NC 28
1O/I
2
TXD
AM0
IC B/D
IC403
0
R467 47
0.1
0.1
0
32
0
I/O11
1I/O
AM0
BOOT
CL413
BUS2-Z
BUS3-Z
0
1
BUS3-B
3.3
0
BOOT
(CND)
BUS2-B
0
VCC 33
IC404 TC74HC4066AFT(EL) CL412
0
3.3 D12
IC B/D
C408 0.1
J
R466 47
(CND)
D0 (NC)
D13
0.2
R475 0
GND 34
CN403 7P
I
R465 47
REQ-Z
REQ
CL411
DVSS 26
1
17
22
C513 100 10V
C514 0.1
16
D14
0.2
REQ-B
3I/O
A1
0
0.3
0.2
R464 47
D15
GND
0
D7 WR
I/O6
R463 47
3O/I
A2
R456 47
15
I/O5
0.2
3C
A3
0
0.3
14
I/O4
LB
3.3
0
0
D6
R455 47
13
16
4O/I
A4
0.3
15
2C
0
0.3
R454 47
I/O12
35
14
0
A5
R453 47
D5
GND
36
13
4I/O
0
D4
VCC
37
I/O13
12
2I/O
A6
11 12
I/O3
I/O14
11
0
C423 0.1
10
I/O2
10
0
3.3
3.3
0
0.2
I/O1
9
4C
A7
R452 47
9
I/O15
38
UB
1
2
2O/I
A8
0
D3
8
39
RD
3.3
DATA SELECTOR IC405 TC74VHC157FT(EKJ)
0
0
0.2
LB
3.3
0.3
R412 4.7k
A9
R451 47
I/O0
UB 40
A2
0
A13
A14
A15
A16
DVCC3A
0
C422 0.1
0.2
D2
7
CE
OE 41
A1
0
3
1C
0
0
0
0
BUS0-U
95
A10
D1
R450 47
0.2
6
A11
0
4
1O/I
4.7k R439 BUS1-U
BUS2-U
32
A11
0
D0
5
A12
42
0
4.7k R437
0
0
0
0
BUS3-U
A23
CCE-U
BUCK-U
RD
DVSS
DVCC3A
SRWR
SRLLB
BOOT
TA0IN
SRLUB
33
D12
35
0
3.3
R449 47
4
43
A2
5
3B
4.7k R435
0
A1
6
3Y
4.7k
0
A11
A13
7
GND
8
IC405
0
A14
A0
0
4.7k
R433
A12
3
0
3.3
4.7k
R431 0
0
3.3
3.3
3.3
3.3
3.3
0
SRAM-CS
D13
GATE
R402 0
2
44
2B
IC B/D
A0
VCC
0
A15
0
3.3
0
3.3
A-IN
94
0.3
CL409
LRCK
93
CL408
(Page 37)
X2
D14 34
D4
4
D15
BCK
0.3
3
SI0
92
D3
DVBUS_VCC
CL407
A0 36
SO0
91
0.3
2
A1 37
D2
D+
A2 38
90
100 DVSS R401 0
USB CONTROLLER IC401 92CD28AFG-7FU8 (M
3.3
USB BOARD CN315
1
SPCLK
A3 39
D1
CL406 VBUS_GND
3.1
R411 4.7k
C403 0.1
I-USB-SI
89
A4 40
0.2
CN402 4P
D403 DZ2J036M0L
D401 DZ2J036M0L
3.1
88
IC401
0.2
0
ST_REQ
O-USB-SO
0.2
0
CLK
87
D0
3.3
R444 100
DATA
86
0.2
0
A5 41
85
DVSS1A
10k
A6 42
DVCC1A
0
A7 43
O-USB-D0
RVOUT2
0
DVSS
84
0
100
48
83
0
REQ-B
0 R442
49
DVSS 44
RVIN
10k
A11
DVCC3A 45
RVIN
CL417 C437 1
R440
0
100 R407
GATE
G
10k
X1USB
RVOUT1
R443
AIN
10k
R441
AM0
82
3.3
R459 0
BCK
R409
D-
81
3.3
3.3
RXD-B
50
A8 46
80
DVCC1B
OC 4
A12
A9 47
0
0 3.3
C421 0.1
A10
DVSS1B
CLK TXD-B
5 5.1
0
DATA
D+
0
EN
3.3 3
VIN
5.1 VBUS POWER ON/OFF SWITCH IC406 BD2220G-TR
F
2 GND
IC406
1
VOUT
IC B/D
3.3
DO-B
USBPON
79
PWE
3.3
78
XT2
0
XT1
0
R410 0
B
10k
R419
27 27
AM0
(EXCEPT CND)
H
R413 R414
USBOC
AM1
X1
R479 1k
77
DVCC3B
5
3.3
DVCC3A
INT3
4
DGND
R408 100k
76
3.3
DGND
CL403
CL405
3.3
INT2
3
3.3
C436 0.1
CL404
INT1
USB5V
CL402
3.3
2
DVSS
75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 R480 10k
I-USB-DI
MGND
C420 0.1
USB-RST
(Page 33)
1
1.6
1.4 C536 1
CN401 5P VM7V
3.3
E
0
A13
SRAM-CS
VM
CL401
MAIN BOARD (2/4) CN413
C412 0.1
MGND
(Page 26)
A
C407 33p
3.3
D
A14
1
1I/O
R425 100k
X401 9MHz
C406 22p
0
0
A15
3.3
IC402 S-RAM
R416 100
CCE-Z
A12
A13
A15
A14
100 R448 100k R434
100
100 R447 100k R432
LB
RD
UB
R478 0
C426 0.1
R430
C438 0.1
BOOT
12
11 BD96/BD96U BOARD (1/2)
CCE
CL410
IC402 IS61LV6416-10TLT
R422
R481 100k
21
(Page 26)
R477 0
BUCK
R420 100
(CHASSIS)
BD96/BD96U BOARD (1/2)
20
(CND)
CCE-B
E
R403 15k
E
C
R404 15k
C518 0.1
ET504
19
BUCK-B R458 100
R446
3
C515 0.1
WR
SRAM-CS
B
(CHASSIS)
18
2
R445 100
ET501
12
1 BUS2-B
A
10
CCE-B
3
BUS3-B
2
BUCK-B
1
LRCK
5-8.
1
AVDD5V
2
AVDD3.3V
3
R-ch
4
DACGND
5
L-ch
6
AGND
7
RST-Z
8
BUS0
9
BUS1
10
BUS2
11
BUS3
12
BUSCK
13
CCE
14
REQ
15
SBSY
16
M-MUTE
17
DVDD-Z
18
DGND
19
DVDD-EVER3.3V
20
DVDD-B
21
BUS_SEL
22
DGND
23
DO
24
DI
25
USB-SO
26
USB-SI
27
USB-RST
C MAIN BOARD (2/4) CN408
(Page 33)
HCD-MX500i/MX550i
5-9.
• Waveforms
IC101 wf (XO) (CD play mode)
qa
•
: Uses unleaded solder.
1
IC401 qa (Xcout)
2
3 DAB1 DAB TUNER MODULE
1.9 Vp-p
4.6 Vp-p
qs
IC101 il (RFO) (CD play mode)
(Page 31)
H
DAB BOARD
IC401 qd (Xout)
JL672
C684 C685 JL671 C686
C683 R673
C675 1
3.2 Vp-p 0.9 Vp-p
B
1 V/DIV, 100 ns/DIV
500 mV/DIV, 1 Ps/DIV
IC401 ud (X2) (CD play mode)
C681
200 ns
qd
R676 JW655
IC705 rk (XFSOIN)
C674 R681 R672
3.6 Vp-p
3.1 Vp-p
111 ns
R678
R677 R679
C673 3 1 C672 4 5
IC671
5
JL675
JL679 JL678
8 9
JL677 JL676 JW652
JL674
R680 C679
1
CN671
2
C678 C677 1
IC672
R675 FB671 JW656
C689
C688
1 V/DIV, 10 ns/DIV
qf
11, 12 1-882-122-
IC711 0 (LRCK)
4.7 Vp-p 20.8 Ps 1 V/DIV, 10 Ps/DIV
qg
IC711 qa (MCLK)
4.7 Vp-p 81 ns 1 V/DIV, 50 ns/DIV
qh
IC711 qs (SCLK)
4.9 Vp-p 324 ns 1 V/DIV, 200 ns/DIV
HCD-MX500i/MX550i
MAIN BOARD CN407
C
20.6 ns
1 V/DIV, 50 ns/DIV
JW654
JL673
30
C682
C691 C690
29
CN672
2
3
ANTENNA DAB 75:
1 V/DIV, 20 Ps/DIV
2 V/DIV, 50 ns/DIV
2
A
30.8 Ps
59.1 ns
CN01
4
JW653
1
• See page 23 for Circuit Boards Location.
– MAIN Board –
JW651
– BD96/BD96U Board –
PRINTED WIRING BOARD - DAB Board (MX550i) -
28
28
(11, 12)
HCD-MX500i/MX550i
5-10. SCHEMATIC DIAGRAM - DAB Board (MX550i) - • See page 42 for IC Block Diagrams.
1
3
2
4
5
6
7
8
9
DAB BOARD
A
ANTENNA DAB 75: CN01
DAB1 DAB TUNER MODULE
B
CN672 30P 29
AUDR
27
A_GND
AUDL
30
AUD_SDOUTO
25
28
AUD_SCLK
AUD_SFR
JL672
26
23
AUD_MCLK
AUD_SFR
24
JL673
21
SPI_MOSI
SPI_MOSO
22
JL674
19
SP/PDIFOUT
SYS_RESET
20
17
GPIOA14
SPICS2
18
JL676
15
S1_DOUT
S1_DIN
16
JL677
13
SCP2CLK
SCP2DATA
14
11
GPIOB10
GPIOB4
12
9
GPIOA12
GPIOB1
10
7
GPIOC15
GPIOA5
8
5
GPIOB11
GPIOC14
6
3
GND
GND
4
1
3.3V
1.2V
2
CN671 9P JL671
C
H MAIN BOARD (2/4) CN407
(Page 33)
DAB_R
1
AGND
2
DAB_L
3
DAB_1.2V_ON
4
DAB_3.3V_ON
5
DGND
6
EVER4.0V
7
SIDO
8
SIDI
9
C683 10p
C684 47p
C685 10p
C686 47p
R673 100
JL675
JL678 JL679
FB671 0
D
R680 100
R681 0
F C689 47p
C672 0.22
VO
F.B.
4
5
IC672 SI-3010KM-TLS
GND 3
2
C673 0.01
29
R677 10k
R676 1k R675 47k
29
C682 100 6.3V
C681 0.1
C691 47p
G
HCD-MX500i/MX550i
1
C690 10p
R672 10k C688 10p
VI
3
CONT
NOISE
2
C674 1
IC672 +1.2V REGULATOR
VO GND
1
C675 0.1
VI
+3.3V REGULATOR IC671 TK11133CSCL-G
CONT
4
IC671
E
5
IC B/D
IC B/D
C677 1
C678 1
C679 1
R678 1k
R679 10k
HCD-MX500i/MX550i
5-11. PRINTED WIRING BOARD - MAIN Section (1/2) - • See page 23 for Circuit Boards Location. •
1
2
3
4
MAIN BOARD (COMPONENT SIDE)
: Uses unleaded solder.
5
(CHASSIS)
6
7
8
9
10
11
(CHASSIS)
A IC515
C420 R597
IC711
C794 R793 Q701 C703
R792
B
IC704
R726
R426
R524 R522
C501
R424
1
FB535
5
R440 C571
IC510 1
C572 5
R561 C575
C574
C599
E
Q505
B E
FB509
B
B
R516 R515
R574 R519
C143 (MX550i)
C130 C181 C182
R542
C140
C185 C186 C184
R137
C183
FB101
R553
C240
R555
80
R453
R459 R456 R455 (MX500i: AEP/MX550i)
R374
Q509
R478 R480
CL473
CL481 R473
CL707
C547 CL507
C487
E
B
C521 B
E Q517
IC509
FB502
IC405
5
R250
4
5
4
1 C570
3
3 C403
R590
C524 C545 R585
R496 R586
R581
R591
C543
R587
C402
C401
C551
R251 R532
C494
C493
C474
C473
C520 FB519
C476 C475
C546
C544
(EXCEPT CND)
C470 C488
R414
R391 Q504
FB534 C467
R588
R464
1
C468
R462 R469
R408
R483
CL479
4 C522
R125 R127
C406
CL467
CL400
C565
R589
R487 R486 CL468 R484
IC505
5
3 C477 C486 C485
C566
1
B E Q512
C577
R572 R489
C519
1
FB513
C481 C482
5 CL506
FB512
R538 R539
R537
CL421
CL483
81
R472 R476
IC504
C479
CL484
R520
C193 C194 C294 C293
C146 R145
C106 C191
CL505
E
R517
5
R506
CL405
IC401
51 (CND, CH, SP) R457 R458 R466 R452 R454 C529 R556 R451 Q516 R460 CL469
E
8
4
C530
50
C500 C579
R400
1
R362
C242
C252
C189 C192
C129
C495
C206 R248
100
CL439
R579
C230 C281 C282
C246
IC503 R121
C516
R505
(MX550i) R449 R450
C480 C598
C285 C286 C284 C283
1
R352 R350
C291 C292
C141 8
C1875 C188 R144 C105
C517
C229
1
IC511
C590
C515
FB521
Q506
FB508
C721
C591
C597 C596
R410
R443 CL441 CL446
C144 C595
R111
C205 C2874
C288
C126
C594
CL425
R497
R444 R445
C416
CL434
R442
R211
C247
R213 C226
C172 R101
CL407
CL430 31
R437 R439
Q508
C262 R103
R203 C171
R221 CL423
30
R432 R433 R434 R438
1
B2 C1
C201 C101
R243 C290
C164 R113
C108
C264 C263
CL406
C511
B
IC506
5
Q507
B
C489 C490 C491 C492
C525
E
CL420
R431
3
C207
C161
R411
CL429
CL412
4
E
R354
C483
C484
C261
C751
C271 C2 B1 C272 R201 E1
R364
R115
C162
C701
B E
C168 C167
C109
C107
C502
1 20 16 15 5 6 1011
C510 (EXCEPT CND)
L701
C771
FB704
IC402
C563
CL710
D
G
C727
R727
C518
F
ET701
R765
E
C166
1
R356
C265
C266
C208
E2 Q106
CL482
E
C726
B
Q702
E B
Q703
R215
C503
FB701 R728
32
R353
R371
C209 C204 C104
C584 C504 R163
R355 R357 R358
(MX500i: AEP/MX550i)
C267 C268
C506
C731
C809 C808
C505
C736
1
16 C733 R736
C170 C169
C241
C
R262 C863
C586 C587
16
C585
8
9
R746
C807 C806
C787
CL720
R601 C738
C734
17
C273 C173
C289
1
44
TP723
CL700
C759
C124
C592
R706 R713
R747
2425
C224
CL717
C593
C764
1213
CL702
C274
C190
CL721
CL713
C746 C745
IC705
R714
C765
37 36
8
3
C163
R778
148
CL705
C766
R780 CL701
IC702 4
1 2
CL704
22
CL724 C778
CL723 R754 R756 R752 CL722
7 R733 R731
CL706
23
R783 C780
14 C739
R745
R777
B
Q753
C767
C784
R776
E Q752 E B
B
IC707
CL711
4
R781
R594
C165
IC703
1 5 CL709
IC502
R782 3 1
C421 C419
8 5
C270 C269
C737 C744
C174
C785
1 4
C117
C217
R600
X703
ET702
CL708
IC709
C425
R582
C569
4
3
5
1
IC508
(EXCEPT CND) 11 1-882-114-
HCD-MX500i/MX550i
30
30
(11)
HCD-MX500i/MX550i
5-12. PRINTED WIRING BOARDS - MAIN Section (2/2) - • See page 23 for Circuit Boards Location. •
1
2
3
4
: Uses unleaded solder.
5
6
7
8
9
10
11
12
MAIN BOARD (CONDUCTOR SIDE)
2
JL544
H DAB BOARD CN671
9
JL432
C761 R711
C798
CL714
R209
C795 R142
R143
M
POWER BOARD CN904
(Page 40)
1
JL725 CN702
C822 C722
C792
3
C845
1
C844
K
C769
C723
JL727
C740
R513
FB524
4
JL728
R724
C720
SP BOARD CN321
(Page 36)
CN704
2
C741
FB706
JL433
L721
C707
C823
L
C846
C821 C820
3
C724
CL715
C706
1
1 C729
C728
C725
C712
C847 C856
2
IC710
C708
D705
C797
R784
R531
C826 C824 L712
C713
1
R785 R530
R758
R786
C747
C827 C825
C718
C789
C773 JL729
CL716
3 4
IC712 2
R787
R769
R162
R788 R751
R241
C753
C776
R743
8 CN407
JL434
FB523
R789
R242 R147
JL431
FB504
(Page 28)
R249
CL719
D706
C793
C796
C788 R701
R102
R112 R212 R202
C709
C763
R718
C804
FB703
FB702
R502
1
C469 JL584 JL583 JL582 JL581 JL580 JL587
JL543
JL430
R104
R753 D755
CN703
C772
C768
C752 C754
R774
JL726
JL429
FB516
R363
R501
C466
C770
(CHASSIS)
JL730
C719
CL718
C756
C704
C779
C829
D765
R725
1
R114
TP745
C799
R204
CN414
9
R349
2
C762
TP739
R351
JL586 JL585
C758
C781
C735
EP702
R775
C828
TP741 TP743
JL542
C775
L762
C857 L704
C801
R373 R372
R214
JL541
CN405 C533 R399
1
C786
C118
C774
C710
L702
JL540
JL535 R398
C777
L703 C757
C218
R768
JL533
8
JL428
C120
R258
R521
(NC)
JL538
C121
R389
10
JL536
(CND, CH, SP)
C
R257
C220
R767
JL534
R157
R259
R359
JL588
ANTENNA FM 75: COAXIAL
TU1 TUNER (FM) SUPPLIED WITH THE ASSEMBLED BLOCK
R503
R766
11 9
R592
R523
(MX500i: AEP/MX550i) JL539 CN406 JL537 JL532
C422
R593
C534
C221
R596
C423
EP501
B
R598 C523
C471
(CHASSIS)
R595
R161
C424
C509
R108
A
SP BOARD CN321
(Page 36)
R514 FB705
C254
D
(MX500i: AEP/MX550i)
(MX550i)
JL569
FB201
JL403
JL401
E
JL402 1
(CND)
(Page 24)
F
C BD96U BOARD CN501
(Page 24) (EXCEPT CND)
JL411
CN415
D
19
18
R366
R367
R365
JL509
CN402
1
26
27 CN408
JL548
(EXCEPT CND) C581 5
C408
CN413
FB522 1
2 1
C580
CN410
R388
4
R535
IC507 C532
9
5
JL546
(EXCEPT CND)
FB520 (EXCEPT CND)
R447 R448
R441
R565
R446
R548
R576
JL518 JL522
JL503
C535 R253
JL501
JL556
R583
JL524 R252 CN403
1
JL521 JL519
JL550
JL563
2 R255
JL553 JL526
JL525
JL561 JL558
C498
R584
R254
12 13
JL502
1
R498
R234 R233
R134
C478 R232 JL557
CN409
1
12
13
JL559 JL554 JL555
W501
FB506
JL564 JL562
FB507 FB505
11 1-882-114-
BD96/BD96U BOARD CN401
A
(Page 24)
POWER BOARD CN905
J
(Page 40)
JACK BOARD CN301
F
G
MS-203 BOARD
(Page 38)
(Page 36)
Note: When the MS-203 board is damaged, exchange the entire CDM85 (CD) ASSY.
HCD-MX500i/MX550i
FL BOARD CN621
31
31
E
IP BOARD CN331
(Page 36)
POWER BOARD CN902
(Page 40)
JL504
R463
JL517 R247
I
JL523
R577
R477 JL520
R557
JL505
C499 D503
R470 R558
JL510
JL507
R547
(CND, CH, SP)
9
C526
R436 R435
R533
JL529
JL527
R245
2
1 C564
R404
JL511
R499 JL512
R534
R546
R541
R461
JL516
JL514
JL528 JL530 JL531
JL545
C578 JL547
G
C582
R430 R465
C409 CN412
R559
R560 R562
R536
R471
C536
FB515
R417 R429
JL515
R246
EP701
R360
(EXCEPT CND)
(MX500i: CND, AEP/MX550i)
C528
R416 JL426
R420 C540 C412
C472
C527
FB517
R428 R427
D502 R570 R571 JL513
R482 R599 C418
JL420 JL422 JL424
JL425
R474 R475
4
JL506
FB514
R492 R493
R490 R495
JL508
3 CN417 1
JL416 JL418
R494 R488 R491 R485
JL410 C568
R403 R402 R401
JL579
D501
2
(CHASSIS)
R419
(EXCEPT CND)
JL577
JL589
JL414 FB511
JL415 JL417
JL427
FB518 JL406 JL408
JL412
JL413
JL419 JL421 JL423
JL574
FB510 JL404
JL407
BD96 BOARD CN502
JL572
JL573 JL575
2
JL405
JL409
JL571
JL578
1
CN401
8
R529
JL570
C225
9
R412
R413
R237 C567
R518 (CND, CH, SP) R409
X402
X401 R120 C125
(NC)
R422
R418
(11)
HCD-MX500i/MX550i
5-13. SCHEMATIC DIAGRAM - MAIN Section (1/4) - • See page 28 for Waveforms. • See page 42 for IC Block Diagrams. • See page 47 for IC Pin Function Description. 1
A
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
MAIN BOARD (1/4)
3
(Page MAIN 34) BOARD (3/4)
R565 4.7k (MX500i: CND) 0 (MX500i: CH, SP)
Q512 RT1N141C-TP-1 iPod WAKE UP DETECT
MC[66] CN410 5P
Q516 2SC3052EF-T1-LEF PROTECT DETECT
R465 1k (MX500i: CND) 4.7k (MX500i: AEP/MX550i)
3.3
3.2
JL527
12
VSS
11
10
MC[56]
MC[51]
MC[52]
/SD MC[53]
MC[54]
MC[57]
MC[58]
MC[55] 100
100
100
100
R455
R454
R453
R452
100 R459
10k
10k
R558
R557 R457 1k
100 R460
R458 1k
100 R461
MC[24]
3.3
MC[22]
C502 10p
C501 10p
0
10k
10k
4.7k
R534
R546
R547
R448 100
3.3 3.3
R447 100
3.3
CL446
MC[48] R446
100
R445 100
INIT
3.3
R444 100
NSPMUTE
3.3
R443 100
SCLATCH
3.3
R442 100 R441
3.3 CL439
R440
100
100
SCDT
R439
100
/RST
R438
100
SOFTMUTE
3.3
R437
100
PGMUTE
R435
100
3.3 3.3
R436
100
R434
100
MC[36] MC[35]
CL434
3.3
(Page 34)
MC[41]
3.3
3.3
X402 5MHz
/DCP
R433
100
MC[33]
R432
100
MC[32] MC[31]
3.3 10k R536 47k
R541
no use
R431 100
CN401 9P
CL430
CL429
R430 4.7k
MC[9] MC[12]
R524 4.7k
9
GND
8
RXD
7
BUSY
6
VDD
5
SCLK
4
TXD
3
PGM
2
RST
1
GND
(NC)
R522 4.7k
(CND, CH, SP) R518 47k
2 MAIN BOARD (3/4)
SCSHIFT
CL441
0
MC[47]
MC[46]
3.3
3.3
no use
R429 4.7k
MC[26]
4
11
R401 100 R413 0
USB_TxD_OUT 31
3.3
USB_CTS
3.3
3.3
3.3
USB_RESET
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
iPod CP RESET
9
BCo_RESET
8
CL420
3.3
ST_CE
ST_DO
ST_CLK
ST_DI/STEREO
RDS_DATA
CDM_OPEN_SW
CDM_CLOSE_SW
CDM_LOAD_IN
Vcc
POWER ON
Vss
SPEC_IN
7
IC402 MFI341S2164
2 3
0
0
0
0
0
0
0
0
0
3.3
3.3
3.3
3.3
0
0
BCo_SPI_REQ
6
0
5
47k
I2C_SCL
VCC
9
4
100
RESET
5
8
3
USB_RxD_IN 32
R411
4
7
2
100
13
NC
6
1
R402
NC
NC
NC I2C_SDA
MODE1
3
NC
VOUT 4
MODE0
14
iPod CP IIC SDA
100 LCD DI
3.3
VIN 5 3.9
1
FB502 0
IC405 TK11133CSCL-G
15
NC
3.3
NC
NC
AC_DET
Avcc
USB_RTS 33
EEPROM
2
NC
3.3
NC
NC
IC405 +3.3V REGULATOR
1
NC
3
3.3
IC B/D
NC
1.3 2 GND
CONT
1
NOISE
3.9
I
J
MC[59]
MC[70]
MC[61]
MC[71]
99
S-MASTER_DCP 34
12
IC402
20 19 18 17 16
D503 DA2J10100L
R427 100 (EXCEPT CND)
CL400
5 6
FB534 0
R591 0
R409 10k
8
C510 18p
9
R422 100
R418 100
7 CL412
(Page 33)
AC-DET
VREF
AC-DET
K
10k
98
R400 10k
C530 0.1
KEY_1
CD BUS0
BCo_SPI_CS
C518 1
97
DAB RxD_IN 36 DAB TxD_OUT 35
R420
C536 1
C563 0.01
Avss
R419
C402 1
3.3
S-MASTER_PG_MUTE 37
CD BUS1
96
10k
C403 0.01
C401 1
3.3
R583 10k
CD BUS2
95
R417
C535 0.1
3.3
R497 100
R520 1k
JL517
0
94
3.3
MC[97]
S-MASTER_SOFT_MUTE 38
iPod CP IIC SCL
0
CD BUS3
3.3
100
CDM_LOAD_OUT
R495
93
S-MASTER_RESET 39
BCo_POWER
MC[95]
DEC BUS SEL
R410 10M
R246 0
R519 10k
MC[49] R449 100
220k
R245 0
FL/LCD RESET
0
92
AC-CUT
100
S-MASTER_DATA 40
SBSY
R494
CD CLK
RDS-INT
MC[94]
91
S-MASTER_SHIFT 42
0
0
LCD BACKLIGHT 41
IC401 R5F364AEDFA
IC401
0
100
SYSTEM CONTROLLER
0.4
R493
CD CCE
S-MASTER_LATCH 43
NMI
Q509 ISA1235AC1TP-1EF OVER CURRENT PROTECT
MP3_IREQ
90
Vcc
MC[93]
0 C489 15p
89
3.3
3.3
CD_DRIVER_MUTE
3.3
3.3
100
BCo_SPI_READY
100
R491
AUDIO_LEVEL_INPUT
R490
MC[91]
88
S-MASTER_NSP_MUTE 44
Xin
0
MC[90]
0
CD_XRST
VOL IIC_SDA/E2P-SDA 47 STBY_LED 46
Vss
MC[89]
100
87
VOL IIC_CLK/E2P-CLK 48
S-MASTER_INIT 45
Xout
100
R489
ZIPANG_ON
1.5
R488
BOLERO/iPod_ON
86
RESET
MC[88]
85
1.7
3.3
Xcout
3.3
100
SINGER_ON
1
3.3
100
R487
84
3.3
100
R486
MC[87]
NC
HP_DET
R485
MC[86]
POWER_PROTECT
Xcin
C564 1
MC[85]
83
DAB-POWER_3.3 49
CNVss
C494 68p
0
DAB-POWER_1.2 50
BYTE
R533 1.2k
CL484
100
TA_LINE_MUTE
BCo_SPI_CLK
C492 68p
R484
HP_MUTE
82
BCo_SPI_DIN
C491 15p
MC[84]
81
BCo_SPI_DOUT
C490 68p
0
SIRCS
C468 100p
C467 100p
C488 68p
C470 1
C487 15p
G
C493 15p
0
FL/LCD CS
R532 1k
CL481
CL483
FL/LCD SCL
R388 4.7k R250 0
MC[50]
ST_TUNED
FL/LCD DO
MC[60]
CL482
R483 1k
3.2
6.9
6.9
0
R482 100
R535 4.7k
MC[59]
R450 100
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
MC[82]
F
R451 100
(MX550i)
C532 0.1
1
R570 R470
RIN 9
2.5
GND 8
3.3
FIN 7
CL469
R478
100
VCC 6
0
VM 5
MX500i: AEP/ MX550i
MX500i: AEP, CH, SP/ MX550i
R492 100
MC[92]
0
OUT1 4
0
RNF 3
0
OUT2 2 0
1 3.5
E
VREF
R480 1k
MAIN BOARD (2/4)
MC[72]
IC507 LOADING MOTOR DRIVE IC507 BA6956AN
H
10k
D502 DA2J10100L
IC B/D
MC[2]
JL526
C416 0.1
100
MC[1]
MC[41]
100
100
R471
100
R255
3.3
R254
JL525
KEY_2
JL524
R251 0
C527 470 10V
C528 0.1
R548 4.7k
R456 100
R466 100
0.8
13
R474 1M
MC[3]
CL473
12
100
R472 1k
FL/LCD_DA FL/LCD_SCLK
C529 0.1
MC[61] R253
JL523
2.2
D
JL522
3.3
11
VOLUME_JOG
10
FL/LCD_CS
3
FL/LCD_RESET
R252 100
BYPASS
(Page 39)
JL521
R556 47k
R465
JL520
0
9
iPod_WAKE
8
FL/LCD +7V
I_KEY WAKE UP_POWER & DISPLAY
FL/LCD_GND
100
FL BOARD CN621
R584 10k
MC[4] MC[46]
R477
7
JL519
3.3
STBY_ LED_R
R247 100
JL518
(CND, CH, SP)
3.3 Q504 RT1P144C-TP-1
iPod_RxD_IN
6
MC[71]
3.3
5
G
MC[70]
JL516
100
4
DGND SIRCS
3.2
R463 1k
R565
R404
KEY_2
C
JL515
3.1
3
100
2
KEY_1
0
R403
EVER 3.3V
Q504, 517 AUDIO LEVEL DETECT
MC[72]
JL514
MC[77]
3.3 JL513
1
MC[78]
0 CN403 13P VOLUME_JOG
R579 220k
MC[60]
R473 10k
R577 10k
R571
C472 0.01
IPOD_WAKE
MC[57]
R374 10k
MC[76]
JL531
R391 1k
10k
5
Q517 RT1N237C-TP-1
R475
OPEN SW
MC[58]
3.3
B
3.3
0
JL530
iPod_DET
4
R599 100k
JL529
10k
CLOSE SW
C418 1
JL528
R576
3
100
2
DGND
R476
CLOSE MS-203 BOARD
R574 1k
3.3
1
iPod_TxD_OUT
OPEN
X401 32.768kHz
R424 100
R426 100
R412 10k
R428 100
MX500i: AEP/ MX550i
R529 10k
C540 0.1
MC[27]
MC[28]
MC[26]
MC[24]
MC[22]
MC[19]
MC[18]
MC[9]
MC[4]
MC[3]
L
MC[2]
MC[1]
C511 18p
MC[12]
10 C412 0.1
Note: When the MS-203 board is damaged, exchange the entire CDM85 (CD) ASSY.
HCD-MX500i/MX550i
32
32
HCD-MX500i/MX550i 5-14. SCHEMATIC DIAGRAM - MAIN Section (2/4) - • See page 42 for IC Block Diagrams. 9
JL434
R398 0
JL541
R399 0
PGMUTE
SOFTMUTE
/RST
/SD
SCDT
SCSHIFT
SCLATCH
NSPMUTE
INIT
/DCP
0 FB516
0
0
C534 100 16V
R351 0 CN417 3P
C533 0.1
C484 68p
C483 15p
A+5V
iPodR
iPod_A.G
iPodL
A.GND
MC[50]
MC[49]
MC[36]
MC[35]
MC[18]
JL542
R349 0
R350 0
JL539
R359 0
JL508 A+5V
2
AGND
3
EVER 4V
1
POW-ON
2
GND-SUB
3
AC-DET
4
P-MONI
5
+11V
6
DGND
7
M+7V
8
MGND
9
JL509 JL506
MC[86]
MC[82]
MC[86]
1
MC[85]
A+9V
JL501
(Page 41)
A.GND
FB523
0 R363
0 R356 MC[55]
R365 0
JL540
R364 0
2
CN412 9P
POWER BOARD CN902
EVER3.3V
1 C495
FB524 0 FB504
0 R355 MC[54]
R560 100k
(Page 41)
I
MC[82]
A.GND
CD/USB_R
CD/USB_L
Tuner_L
Tuner_R
DAB_A.G
DAB_R
AIN-L
AIN_R
AGND
1
AIN_L
AIN-R
2
CL479
(AIN-DET)
INIT
/DCP
DAB_R
DGND
AGND
9
EVER4.0V
DAB_L
8
A+5V
DAB_1.2V_ON
7
JL433
DAB_3.3V_ON
6
JL432
DGND
5
JL431
EVER4.0V
4
JL430
SIDO
3
JL543
SIDI
2
RDS DATA
1
JL544
JL429
RDS INT
0 R354 MC[53]
C521 1
3
1
F
MAIN BOARD (3/4)
(EXCEPT CND)
4
(Page 32)
0
C500 0.1
R353
5
6
MC[52]
MAIN BOARD (1/4)
0
7
R352
1
MC[51]
8
POWER BOARD CN905
CN402 4P
5
R366 0
R362 0
9
E
R358
R562 100k
10
J
7
(Page 34)
MAIN BOARD (3/4)
0
0 R357
(Page 35)
D
19
18
R367 0
MC[56]
C
JL428
D0/STEREO
11
MAIN BOARD (4/4)
CN407 9P
JL532
CLK
10
JL533
DI
9
JL534
CE
8
JL535
TUNED
7
JL536
GND
6
POW-ON
JL537
D0/STEREO
R-OUT
CLK
9
5
DI
8
VCC
CE
7
4
TUNED
6
L-OUT
GND
5
3
R-OUT
4
2
VCC
1
L-OUT
3
CN406 11P
JL538
9
CN405 9P
2
9V
MAIN BOARD (2/4)
(Page 34)
MAIN BOARD (4/4)
4
1
6
B
JACK BOARD CN301
F
(Page 35)
(Page 34) MAIN BOARD (3/4)
17
(Page 37)
DAB BOARD CN671
H
DAB_L
(Page 29)
SUPPLIED WITH THE ASSEMBLED BLOCK
TU1 TUNER (FM)
16
15
(MX550i)
ANTENNA FM 75: COAXIAL
SUPPLIED WITH THE ASSEMBLED BLOCK
TU1 TUNER (FM)
14
3
A
13
4
MX500i: AEP/ MX550i
ANTENNA FM 75: COAXIAL
12
11
PGMUTE
(CND, CH, SP)
10
SOFTMUTE
8
/RST
7
/SD
6
SCDT
5
SCSHIFT
4
3
SCLATCH
2
NSPMUTE
1
JL502 JL503 JL504 JL505 JL507
JL580
C466 1
JL510
JL581
JL511 JL512
EP701
JL587
C469 1
R360 0.1
JL588
E
G
C409 0.1
C408 0.1
(CHASSIS)
D501 DA2J10100L
C520 1
C499 0.1 CN415 19P
N
HCD-MX500i/MX550i
Vin
GND
Vout
ADJ
1
3.3
5
Vc 3.3
MC[76]
C572 1
MC[78]
1.3
MC[77]
NOISE
IPOD_WAKE
GND
VOUT
3.3
3.9 VIN 3.3
CONT
3.3
3.9
0
0
FB520
FB519
(EXCEPT CND)
MC[32]
JL425
R582
100
MC[31]
JL426
R581
100
MC[27]
JL427
R587
100
C546
100p
C545
100p
C544
100p
C543
100p
A
BU96/BU96U BOARD (2/2) CN401
(Page 27)
33
33
FB507
FB506
FB505
JL562
JL563
JL564
0
100 R234 JL561
0
100
R517
0
100
22
R134
13
MC[33]
100
12
MC[28]
100
R585
AGND
0
R586
JL424
iPod R+
R416
JL423
11
JL422
MC[92]
10
100
iPod L+
R496
iPod DET
FB514
JL421
W501
9
JL420
CN409 13P
CN413 5P
ACC DET
0
C478 0.1
R233
0
C574 2.2
JL559
0
FB517
R561 4.7k
C571 2.2
JL558
FB511
JL419
R559 0
C579 100 10V
JL557
JL418
C551 0.1
C498 0.1
100
MC[88]
0
C578 100 16V
R232
100
FB515
C580 100 16V
JL556
R464
JL417
R498 0
330k
JL416
R499 0
R515
MC[19]
JL589
C599 68p
JL555
MC[89]
100
5
C581 0.1
JL554
MC[90]
100
R590
4
C582 0.1
8
27
100
R408
JL415
3
IC510 BD8410FPS-E2
7
26
R414
JL414
2
5
6
USB-SI USB-RST
JL413
1
4
TXD
25
MC[91]
3
RXD
USB-SO
MC[93]
100
2
iPod WAKE
24
100
R127
+5V REGULATOR
1
5
23
DI
R588
JL412
IC506 BD8410FPS-E2
ACC ID
DO
JL411
IC506 +5V REGULATOR
C598 15p
4
22
MC[94]
C476 68p
VBUS 5V
21
MC[95]
100
C474 68p
IC B/D
IC510
3
20
DGND
MC[97]
100
R589
IC B/D
VBUS 5V
DVDD-B BUS_SEL
100
R469
JL410
C240 0.01
C294 68p
2
19
R125
JL409
C140 0.01
C194 68p
DGND
18
JL408
C125 1 50V
C479 0.1
C293 15p
1
17
DGND
MC[87]
C193 15p
DGND
DVDD-Z
DVDD-EVER3.3V
0
R516 220k
FB508 0
JL553
16
100
5
15
R462
DGND
SBSY M-MUTE
FB518
JL407
C475 15p
4
14
6
JL406
C473 15p
DGND
13
6
JL548
CCE REQ
FB522 0
R137 100
0
FB509 0
3
12
FB101
0
0
FB521 0
R237 100
USB5V
11
FB201 FB510
C225 1 50V
0
JL547
10
BUS3
FB512
JL403
JL405
0
FB513 0
JL402
JL404
C482 68p
2
BUS2
BUSCK
Q506 RT1N141C-TP-1
Q505 RT1N141C-TP-1 C481 15p
C567 100 10V
MGND
9
C480 0.1
JL546
8
BUS1
R537 10k
C565 0.1
C568 100 16V
OCOUT
BUS0
C570 0.01
VOUT
7
C524 1
3.3
6
C569 0.01
C425 1
FIN
5
RST-Z
C486 68p
STBY
L-ch AGND
C485 15p
1
M
4
Q505, 506 iPod POWER DETECT
VM7V
(Page 27)
3
C525 0
JL545
C BD96U BOARD (2/2) CN501
2
R-ch DACGND
5.1 C575 1
C526 0.1
R539 22k
5.1
L
AVDD3.3V
5
0
3.3
K
C522 1
C566 0.1
JL401 1
4
5.1
CN408 27P AVDD5V
3
3
VIN
(EXCEPT CND)
2
2
OCP
19
1
1
MX500i: AEP, CH, SP/MX550i
0
DVDD-EVER3.3V
+3.3V REGULATOR IC505 SI-3010KM-TLS
MC[85]
18
4
OCOUT
17
DGND
C477 0.01
VOUT
DVDD-Z
C519 1
3.3
16
5
FIN
15
FB535 0
R538 1k
STBY
14
3
5.1
REQ SBSY M-MUTE
2
6.9
13
1
VIN
CCE
3
6.9
12
2
VOUT
BUSCK
1
NOISE
11
GND
10
BUS3
IC509 +3.3V REGULATOR IC509 TK11133CSCL-G
1.3
9
BUS2
VIN
BUS1
IC508 +3.3V REGULATOR IC508 TK11133CSCL-G
IC B/D
4
CONT
IC504 +5V REGULATOR IC504 TK11150CSCL-G
5
3.3
8
5
7
BUS0
VOUT
6
RST-Z
IC B/D
4
NOISE
AGND
9
5
5 VIN
L-ch
IC B/D
GND
4
OCP
J
3
0
(Page 27)
2
R-ch DACGND
CONT
BD96 BOARD (2/2) CN502
AVDD3.3V
IC B/D
IC505
(EXCEPT CND)
1.3
D I
1
3.3
H
AVDD5V
6.9
(CND)
E
IP BOARD CN331
(Page 37)
HCD-MX500i/MX550i 5-15. SCHEMATIC DIAGRAM - MAIN Section (3/4) - • See page 42 for IC Block Diagrams. 1
3
2
4
5
6
7
8
MAIN BOARD (3/4)
2
(Page MAIN 32) BOARD
MC[48]
C173 15p
R600 22k
C274 68p
C273 15p
R601 22k
13
14
15
Q507, 508 MUTING CONTROL SWITCH
R163 220
C174 68p
12
MC[47] R502 0
C224 10 16V
9V
MAIN BOARD (2/4)
C586 15p
EP501
C587 68p
C506 220 16V
C505 0.1
C584 15p
C471 0.1
C585 68p
C504 0.1
C503 47 10V
R211 1k
R530 47k
C121 0.12
0
AIN_R
R111 1k
R201 220k
C271 15p
C272 68p
R101 220k
C171 15p
C172 68p
C220 0.12
C201 1
R209 4.7k
-1
0
-2
A.GND
(Page 35)
MUTING
0
C424 1000p
3
C419 1
C421 2200p
MC[66]
C101 1
BCA L
BCA R
BCB R TC L
7
6
2
3
5
BUFFER IC515 NJM4558V-TE2
16
1 4.5
C107 10 16V
R112 10k
(Page 32)
V-
TC R 4.5
15
8
IC515
4.5
VOL L 4.5
14
R594 10k R503 10
R257 220k
MAIN BOARD (1/4)
4.5
BCB L
SEL L
13 4.5
12
R596 10k
9
OUT R
11 4.5
10
4.5
IN-R6
IN-L6 9 0.8
8
0.8
IN-L5 7
4.5
6
4.5
IN-L4 5
4.5
4
4.5
IN-L3 3
4.5
2 4.5
4.5
1
4.5
ELECTRICAL VOLUME, INPUT SELECTOR IC502 BD3491FS-SE2
R598 470k
4.5
4.5
SR
4.5
17
SB R
4.5
18
VOL R
19
SB L
4.5 20
OUT L
4.5 21
VCC
4.5 22
SEL R
23
SCL
4.5
24
SDA
4.5
4.5 25
IN-R5
26
GND
9
3.3 27
IN-R4
28
FIL
3.3 29
IN-R3
30
IN-R1
4.5
31
IN-R2
32
IN-L2
IC502
R157 220k
IN-L1
IC B/D
4.5
4.5
C422 1
D
MAIN BOARD (4/4)
Q106 IMX9T110
R531 47k
Q508 RT1N141C-TP-1
0
C221 0.12
AIN_L
E
SP_R
0
3.3
C
8
SP_L
3.3
4.5
(CHASSIS)
0
R108 4.7k R262 220
E
(Page 33)
C120 0.12
4
4.5
6
Q507 RT1P141C-TP-1 3.3
V+
(1/4)
B
C124 10 16V
R501 0
11
10
4.5
A
9
CD/USB_L R102 330k
R202 330k
R212 10k
C162 68p
C262 68p
C161 15p
C118 3900p C207 10 16V
C261 15p
R372 10k
R373 10k
C420 100p R597 100k
C218 3900p
CD/USB_R
F
R593 1k
C104 1
R114 4.7k
C523 1
Tuner_L R104 100k
7
C265 15p
R113 10k
R213 10k
R103 100k
C164 68p
C163 15p
R203 100k
C264 68p
C263 15p
C170 68p
MC[82]
C423 1
C509 1
EVER3.3V
R521 2.2k
R523 2.2k A.GND
5
R371 0 A+5V R258 100k
CL507
C406 10 16V
R259 100k
CL505
C577 10 16V
CL506
C547 10 16V
iPod_A.G
C208 10 16V
iPodL
iPodR C168 68p
C167 15p
C268 68p
C267 15p
C182 68p
C109 1 50V
R241 22k
C592 15p
R147 22k
C593 68p
C254 1
IC511 NJM4558V-TE2 9 4.5 R142 22k
C191 15p
C192 68p C190 68p
DAB_L C146 1 50V
R215 1k
LINE AMP
C144 1 50V
C143 1 50V
R143 22k C189 15p
C591 68p
R120 22k
IC511
R144 100
C181 15p
C106 220p
4.5
C105 220p
4.5
8 7
2
6 5
3 VEE
C184 68p
C252 0.1
C141 220p
R121 22k
R248 22k
C288 68p
C287 15p
C241 220p
C246 1 50V
R249 22k
C597 68p
C596 15p
4.5
C206 220p
4.5
C205 220p
C291 15p
C292 68p
R242 22k
C516 0.1
C515 220 16V
C595 68p
C594 15p
R513 4.7k
C286 68p
C185 15p
LINE AMP IC503 NJM4558V-TE2 9 4.5
4
4.5
DAB_R C290 68p
C186 68p
R514 4.7k
C283 15p
C284 68p
IC503
C129 220p
DAB_A.G C242 1 50V
C183 15p
4.5
4.5 C187 15p
C517 220 10V
C247 1 50V R243 100
1
VCC
C130 220p
R145 22k C188 68p
C590 15p
C209 1 50V
C126 1 50V
J
R592 10k
A.GND R389 10k
R161 0
(MX550i)
R115 1k
C289 15p
L
HCD-MX500i/MX550i
C270 68p
C117 10 16V
R162 0
I
K
C269 15p
C169 15p
C204 1 C108 10 16V
(Page 33)
H
C266 68p
C217 10 16V
C165 15p
Tuner_R
MAIN BOARD (2/4)
G
R204 100k
R214 4.7k
C166 68p
R595 10k
34
34
8
1
V+
7
2
6
3
5
V-
4
4.5
C226 1 50V
4.5
C229 220p
4.5
C230 220p
R221 22k C285 15p
C281 15p
C282 68p
R542 22k
R572 0
R553 22k
R555 0
R505 22k
R506 0
MAIN BOARD (2/4)
(Page 33)
HCD-MX500i/MX550i
5-16. SCHEMATIC DIAGRAM - MAIN Section (4/4) - • See page 42 for IC Block Diagrams. 1
2
3
4
5
6
7
8
11
12
15
16
17
18
19
C704 1000p
100p
DIF 14
AVDD
7
DVDD
8
VSS2
CL704
3.3
1.8
3.3
3.3
3.3
3.3
CL700 1.8
CL706
1.6
1.6
LRCK 10
XOVSS
XFSoOUT
DVDD
XOVDD
DVSS
NSPMUTE
SOFTMUTE
PGMUTE
SCDT
SCSHIFT
SCLATCH
8
VSSR
7
OUTR1
6
VDDR
5
OUTR2
4
34 TEST
VSSR
3
35 DVDD
VSUBC
2
XVSS
1
IC705
30 BCK
STREAM PROCESSOR
31 DATA
IC705 CXD9788AR
32 BFVDD
36 XFSIIN
CL705 1.2
9
11
9
33 BFVSS
1.6
OUTL1
10
3.3
3.3
CL720
CL721
R714 100
3.3 1.6
3.3 1.6
1.6
CL722
R752 100
CL723
R754 100
3.3 1.6
R758 22k
1.1
C793 1
0 R718 0
SCLATCH SCSHIFT SCDT /SD /RST SOFTMUTE PGMUTE
SCSHIFT
L702 10uH
C795 1
1.6
R756 100
IC B/D
2
3.3
IC712 3.3
3
C776 1
/SD
1.8
C771 0.01
4
VDD
CE
1
3
Vout
VSS
2
CL708 1.6
C757 220 10V
C727 1
5
R733 47
3.3 1.6
IC702 +3.3V REGULATOR IC702 MM3404A33URE
1.6 3.3 CL702
1 5
2
4 VDD
VSS
Vout
3
R731 47
CE
3.3
3.3
C759 1
NC
1.6
C758 0.1
NC
41
SD
6
PWM_A
7
RESET_AB GND_A
38
8
PWM_B GND_B
37
9
OC_ADJ OUT_B
36
OUT_A
12 VREG 13 M3
PVDD_B BST_B BST_C PVDD_C OUT_C GND_C
40 39
35 34 33 32 31
29
17 RESET_CD OUT_D
28
18 PWM_D PVDD_D
27
19 NC
26
21 VDD
NC BST_D
22 GVDD_C GVDD_D
C762 0.1
C756 0.1
C728 1
R725 3.3
C845 1000p
C744 0.47
D705 RSA39LTE25
C726 2.2
20.3
RST-1
1
DAT-1
2
12 DAT-2
CLK-1
3
11 CLK-2
SET-1
4
10 SET-2
Q1
5
9
Q2
Q1_
6
8
Q2_
GND
7
NC
K SP BOARD CN321
R726 100k
10.1 R766 22
R767 22
10.1
C822 2200p
10.1
C823 2200p
10.1 10.1
10.1
Q702 ISA1235AC1TP-1EF
0 C824 2200p
R728 100k
R727 100k
Q703 ISA1235AC1TP-1EF
0
C825 2200p Q702, 703 OVER LOAD DETECT
20.3 C718 0.033
21.3
D706 RSA39LTE25
C763 0.033
21.3
D755 RSA39LTE25
20.3
Q701 2SC3052EF-T1-LEF PROTECT DETECT
3.3
R792 0
0
10.1 R768 22
C826 2200p
R793 47k
C703 0.01
C827 2200p
R769 22
10.1 20.3
C828 2200p
C829 2200p
CN704 4P
C794 1
JL725
D765 RSA39LTE25
G
I
20.3
C719 2200 35V
C856 0.1
1
3
C741 0.1
C729 220 35V
C706 0.1
O
2
C768 0.033
12
C712 0.1
JL726
P-GND
2
P-GND
3
+27V
4
+27V
M POWER BOARD CN904
(Page 41)
IC710 KIA7812API-U/PF
20.3
21.3
L721 10uH
IC710
1
+12V REGULATOR
C821 0.1
EP702
C820 10 50V
(CHASSIS)
Q752, 753 OVER LOAD DETECT
C764 0.1
Q752 ISA1235AC1TP-1EF
0
0
1
NC
VCC
5
2 3
4
GND
CL714
C707 100 50V
ET702
Q753 ISA1235AC1TP-1EF
10.1
(CHASSIS)
10.1
3.3 C708 100 50V
1.6
10.1
ET701
10.1
R778 100k
C778 2.2
R777 100k
C785 5p
JL729
C766 0.1 C773 2200p
3.3
C709 100 50V
R781 470
C737 4700p
2
1.6 CL709 1.6
C767 0.1
R780 22
CL718 C710 100 50V
3.3 1.6
C769 2200 35V
C784 6p
1.6
35
35
L762 10uH 1
2
3
4
C770 1
R774 3.3
C777 1
R775 3.3
C846 1000p
C847 1000p
C774 2200p
C775 2200p C792 0.1
C739 1
(CHASSIS)
C772 2200p
R782 1M
X703 49.152MHz 1
13 RST-2
L-
3
JL728 20.3
12
23
L+
2
(Page 37)
C725 2200p
C713 0.033
25 24
1
C724 2200p
C765 0.1
14 Vcc
CN702 3P
C844 1000p
30
16 PWM_C GND_D
PVDD_D
4
R724 3.3
21.3
42
5
PVDD_A
3
C720 1
12
CL713
IC B/D
CLOCK SHIFT IC703 MC74VHC74DTR2
IC B/D
R753 0
IC709 MC74VHC1GU04DFT1
3.3
IC703
I
4
PVDD_A
2
CLOCK BUFFER
L703 10uH
C721 1
12
IC709
IC712 MM3404A18URE
/RST
FB705 0
L704 10uH
C780 1
C781 220 10V
C857 1
SOFTMUTE PGMUTE
C779 1
C786 1
+1.8V REGULATOR
CL717
HCD-MX500i/MX550i
C799 1
12 R783 22
IC B/D
DGND
J
C789 1
C745 0.1
C753 100 10V
C740 220 10V
3.3 VOUT
1
SCDT
C798 100 10V
NOISE
SCLATCH
4
VIN
3.9 +3.3V REGULATOR IC704 TK11133CSCL-G
NSPMUTE
5
CONT
NSPMUTE
C734 0.1
C761 1
1.3
(Page 33)
INIT
IC704
/DCP
3.2
MAIN BOARD (2/4)
IC B/D
GND
C735 10 50V
INIT
43
NC
20 NC FB706 0
/DCP
DTW
3
14 M2
EVER4.0V
4
2
11 AGND 3.2
13
CL701
44
10 GND
1.6
TP745
TP743
3.3 TP739
FB704 0
TP741
1.6
1.6
15
14
1.6
R713 100
R706 100
GVDD_B GVDD_A BST_A
1
CL724
1
15 M1
37 38 39 40 41 42 43 44 45 46 47 48
R736 100
A+5V
3.3
3.3 3.3
R747 470
CL707
11
SDTO
R745 100
1.6
SCLK 12 MCLK
1.2 R746 100
12
XFSOIN
6
C733 0.1
3.3
RESET 13
VssL
VSSL
XVDD
5
C752 0.1
1.6
VDDL
29 LRCK
HPVDDL
VCOM VSS1
C754 1000p
3.3
OUTL2
SFLAG
28 MCKSEL
HPOUTL1
4
1.6
27 INIT
HPVSSL
3
CKS1
1.6
HPOUTL2
3.3
CKS2 15
OVFFLAGL
HPVDDR
C863 0.1
CKS0 16
AINL
26
HPOUTR1
5
AINR
2
3.3
HPVSSR
2.5
1
TP723
HPOUTR2
3.3
C736 2.2 50V
16
R743 100
FSOI
2.5
C806 0.1
25
FSOCKO
IC711 AK5358BET-E2 2.5
OVFFLAGR
C747 100 10V
A/D CONVERTER
C738 10 16V
C796 0.1
IC707 CXD9965TN 12
24 23 22 21 20 19 18 17 16 15 14 13
IC711
POW-ON
C797 0.1
C787 0.1
100p
C746 0.1
IC B/D
F
CL715
IC707
CL711
C
E
IC B/D
100p
C788 0.1
(Page 33)
R711 100
R784 100
E
C807
C801 0.01
FB702 0
MAIN BOARD (2/4)
L712 10uH
E
NSPMUTE
SCDT
PGMUTE
SOFTMUTE
SCLATCH
SCSHIFT
100
/RST
CL719
C808
C723 2200p
CL710
/SD
DIGITAL POWER AMP
SP_L
9
R765 0
/DCP
E
C809
C722 2200p
1.6
(Page 34)
H
14
CL716
SP_R
R785
R751 0
R789 100
C804 1000p
100
C751 1 50V
FB703 0
R786
R701 0
100
C701 1 50V
100
8 MAIN BOARD (3/4)
R787
C731 100 10V
L701 10uH
R788
INIT
A.GND
G
13
JL727
FB701 0
D
10
MAIN BOARD (4/4)
A
B
9
R776 100k JL730
CN703 2P 1
R+
2
R-
L SP BOARD CN321
(Page 37)
HCD-MX500i/MX550i
5-17. PRINTED WIRING BOARDS - IP/JACK/SP/USB Boards -
1
A
• See page 23 for Circuit Boards Location.
2
3
•
: Uses unleaded solder.
4
5
6
7
IP BOARD (COMPONENT SIDE) BOARD E MAINCN409 (Page 31)
CN331
1
13
R392
C332
R395 R398
C343
IP BOARD (CONDUCTOR SIDE)
R394
R391 C331
(iPod/iPhone Dock)
B
CN332 30 R399 R338 R337
C340 C339 R339
1 R397 R396 C342
R390 R393
C333 R332 R335 C334 R333 R336 C335 R334 C336 R331
C
1-882-123-
1-882-123-
11 (11)
(11)
(Page 31)
(Page 31)
F
(EXCEPT CND)
USB BOARD
11
JACK BOARD
K
MAIN BOARD CN402
(Page 31)
L
MAIN BOARD CN702
MAIN BOARD CN703
SP BOARD
CN315 JL318
JL314
4
C317 1 4
D
7
A321 JL317
4
JL316 JL315
1 C315 5 6
1 11, 12 1-882-118-
B
JL309
JL308
JR301
(USB)
L
C302
TB322
W301 11, 12
R303
1-882-119(CHASSIS)
F
HCD-MX500i/MX550i
J302 AUDIO IN
36
36
11, 12 C326 C323
R
SPEAKERS
D302
E
C328
C321 C325
C255 C256
C155 C156
(Page 24)
C327
R260
R160
BD96/BD96U BOARD CN402
C324
C322
JL306
(11, 12)
R302 CN316
4 CN301
JL307
C316
1 CN321
(11, 12)
1-882-120-
(11, 12)
HCD-MX500i/MX550i
5-18. SCHEMATIC DIAGRAM - IP/JACK/SP/USB Boards -
1
2
4
5
7
8
9
DGND
1
DGND
2
TPA+(1394DATA)
3
USB D+
4
TPA-(1394DATA)
5
USB D-
6
TPB+(1394DATA
7
VBUS(USB5V)
8
TPB-(1394DATA
9
C334 15p
CN301 4P
R390 0 C333 68p
C342 10
R336 100k
R335 100k
R333 100k
R332 100k
C332 15p
F
C331 68p
MAIN BOARD (2/4) CN402
R334 75k
R393 0
R392
R391
DGND DGND
11
VBUS 5V
DGND 15
10
VBUS 5V
DGND 16
9
ACC ID
Reserved 17
8
iPod POWER
R395 0
TXD 19 Acc DET 20 S-VIDEO-Y 21 S-VIDEO-C 22 VIDEO-OUT 23
R396
0
R397
0
R398
0
R399
0
R337
0
R339
0
R338
0
Remote Sense 24
7
RXD
6
TXD
5
ACC DET
4
iPod DET
3
iPod L+
2
AGND
1
iPod R+
E
(Page 35)
MAIN BOARD (2/4) CN409
MAIN BOARD (4/4) CN703
(Page 33)
MAIN BOARD (4/4) CN702
(Page 35)
LINE-IN-L 25 LINE-IN-R 26 LINE-OUT-L 27
C340 15p
LINE-OUT-R 28
C339 68p
A-GND 29 DGND 30
(EXCEPT CND)
USB BOARD CN315 4P
BD96U BOARD (2/2) CN402
G
JL315 VBUS_VCC
1
D-
2
D+
3
VBUS_GND
4
1
JL316
CN316 (USB)
2
JL317
3
JL318
C315 10
4
(Page 27) C317 0.1
C316 0.1 JL314
HCD-MX500i/MX550i
AIN-R
3
AGND
2
AIN-L
1
JL308
J302 C256 10p
C255 47p
C156 10p
C155 47p
R303 0
AUDIO IN
JL307 JL306
R302
C302 0.1
W301
(CHASSIS)
12
B
4
CN331 13P 13
RXD 18
F
(AIN-DET)
D302 MC2840-T112-1
C335 68p
Reserved 14
E
R260 1k
R160 1k
Acc PWR(3.3V) 13
C
12
(Page 33)
C343 330 6.3V
R331 75k
Acc ID 10
FireWire PWR+(12V) 12
11
JL309
R394 0
C336 15p
10
JACK BOARD
CN332 30P (iPod/iPhone Dock)
FireWire PWR+(12V) 11
D
6
IP BOARD
A
B
3
37
37
SP BOARD
L K
TB322
CN321 4P R-
1
+
R+
2
-
L-
3
+
L+
4
C324 0.01
C323 0.01
C322 0.01
C321 0.01
C325 1000p
C326 1000p
C327 1000p
C328 1000p
R SPEAKERS L
HCD-MX500i/MX550i
5-19. PRINTED WIRING BOARDS - PANEL Section - • See page 23 for Circuit Boards Location. •
1
2
3
: Uses unleaded solder.
4
5
6
7
8
9
KEY BOARD
A
1
4
CN624
+
S631 S621
S622
S623
R642
R644
FUNCTION
R645
S630
x
u
lm TUNE –
D624
B
S625
R646
S632
R651
R650
S624
R643 R637
v
ENTER
Z
ML TUNE +
S626
R649
S621 – 632
STANDBY S627
DSGX
R647
S628
R648 S629
V
TOOL MENU
–
11, 12 1-882-116-
(11, 12)
(Page 31)
C
G
MAIN BOARD CN403
FL BOARD JL627
1
CN622
4
1
12
2 JL628 JL626 JL624
JL631
JL630
CN621
JL629 13 JL633
C641
JL622 JL623 JW616
D
C632 R629
Q623 B E JL635
JW604 C634 R632
C633 R628
C637 49
JW609
JW611
R638
JL621
1
C626
R630
JW610
R639
3
R641 RV621 ROTARY ENCODER VOLUME
JW612 C645
C646
48 JL636
JW619
D622
JW615
R631 64 C635 1
IC621
33
JW602
C625 JW601
R634 C640 R633 16
L621
D621
32
ND621 FLUORESCENT INDICATOR TUBE
54 53
JW608
C631
JW607
C636
JW606
JW603
JW613
JL632
JW605
2
JL625
R640
R625
D623
C629
17
51
4
E
2
1
C628
1
JL634
C627 JW614
B E Q622
R627 R626
R621
9
T621
2
C623 C621 C2
DC/DC CONVERTER TRANSFORMER
C642 1
FB621 R635
C1 Q621
B2 E B1
3
R622
IC622 11, 12 1-882-115-
T621
F
1 9
HCD-MX500i/MX550i
38
38
(11, 12)
HCD-MX500i/MX550i 5-20. SCHEMATIC DIAGRAM - PANEL Section - • See page 42 for IC Block Diagrams.
1
A
2
3
4
5
6
7
8
9
FL BOARD
10
R645 4.7k
S626
ND621
R644 2.2k S623
S624
S625
R643 2.2k
FLUORESCENT INDICATOR TUBE TUNE +
13
S622
S621
/
TUNE -
53 54
P1
P2
P3
P4
P5
P6
P7
P8
P9
P10
P11
P12
P13
P14
P15
P16
P17
P18
P19
P20
P21
P22
P23
P24
P25
P26
P27
P28
R642 1k
FUNCTION
D624 SLR-325VCT31P
1G
2G
3G
4G
5G
6G
7G
8G
9G
10G
11G
P37
B
P29
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51
P30
9
P31
8
P32
7
P33
6
P34
5
P35
4
P36
2
12
KEY BOARD R646 10k
1
11
1G
2G
3G
4G
5G
6G
7G
8G
9G
10G
11G
STANDBY R637 470 R651 10k
C
S632
JL636
S631
ENTER
+
SG27
23
59
AD2
SG26
22
60
AD1
SG25
21
61
SG1
SG24
20 19
63
SG3
SG22
18
64
SG4
SG21
17
3
4
5
6
7
8
9
10 11 12 13 14 15 16
P36
P35
P34
P33
P32
P31
P30
P29
P28
P27
P26
P25
P24
P23
IC622
2
1
2
3
3
C641 0.1
Q623 RT1P441C-TP-1 LED DRIVE
R640 10k R638 2.2k
R641 4.7k
0
3.3
JL632
JL630
P22
P21
P20
P19
P18
P17
P16
P15
P14
P13
P12
P11
P10
P9
P8
P7
JL627 JL626 JL625 JL624
53
JL623
55
JL622
54
JL621
H
C628 0.01
I
C629 0.01
R627 100
JL634
R626 100
R625 10k
C626 22 50V
C625 0.01
L621 100uH
2 C623 0.022
9
4
8
5
7
6
6.4
C621 22 16V
-1 -2
6.4 0
D622 MC2838-T112-1
39
R621 2.2
R622 2.2k
0
T621 DC/DC CONVERTER TRANSFORMER
HCD-MX500i/MX550i
GND
JL633
C642 1
3
KEY2
4
CN621 13P
3.3
JL631
D621 MC2836-T112-1
KEY1
3
CN622 4P
R639 1k
52
D623 DZ2J062M0L
STBY_LED
2
1
REMOTE CONTROL RECEIVER IC622 PNA4823M02S0
JL628
C627 0.01
1
ROTARY ENCODER
R635 47
1
GND
RV621
JL629
G
KEY2
4
VOLUME
2
1
IC B/D
P37
SG20
SG23
SG19
SG2
SG18
62
GND
P2
KEY1
3
-22.9
OUT
58
C640 0.01
VCC
24
DSGX
TOOL MENU
STBY_LED
2
3.3
3.2
GR2
GR3
GR4
GR5
GR6
GR7
GR8
GR9
SG28
-22.7
R634 22k
S627
1
-22.7
3.3
-22.7
-22.7
-22.7
-22.7
-22.7
-22.7
-22.7
-22.7
-22.7
GR10
GR11
GR12
GR13
GR14
GR15
P1
57
SG17
P6
25
SG16
26
SG29
IC621 FLUORESCENT INDICATOR TUBE DRIVER IC621 PT6302LQ-010
P5
SG30
VDD
SG15
DIN
56
P4
55
27
SG14
P3
SG31
SG13
CLKB
P2
54
F
P1
28
SG12
C635 100p
29
SG32
SG11
C634 100p
SG33
CSB
JL635
RSTB
53
3.3
52
SG10
R632 0
30
SG9
0
SG34
R631 0
OSCO
SG8
3.2
55
31
51
54
R630 0
3.1
32
SG35
3.3
R629 1k
GR1
OSCI
SG7
3.3k
53
VSS
50
SG6
R628
52
49
1.5
1.5
GR16
VEE
C632 1000p
C631 47p
E
R633 22k
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
SG5
D
-22.7
-25.1
C633 100p C636 22 16V
Q622 2SC3052EF-T1-LEF GRID DRIVE
R647 1k
S628
S629
S630 -
C637 22 50V
R648 2.2k
R649 2.2k
R650 4.7k
CN624 4P
39
Q621 CPH5504-TL-E OSC
FB621 0
C645 100 16V
C646 1
13
VOLUME JOG
12
EVER+3.3V
11
KEY_1
10
KEY_2
9
DGND
8
SIRCS
7
STBY_LED_R
6
FL/LCD_GND
5
FL/LCD +7V
4
FL/LCD_RESET
3
FL/LCD_CS
2
FL/LCD_DA
1
FL/LCD_SCLK
G MAIN BOARD (1/4) CN403
(Page 32)
HCD-MX500i/MX550i
5-21. PRINTED WIRING BOARD - POWER Board - • See page 23 for Circuit Boards Location. •
1
2
3
: Uses unleaded solder.
4
5
6
7
8
PH11, 601, 602 C
POWER BOARD
E
R24 R608
R14 C13 E B
R609
R4 JW5
C4
B
C606
JW6
C15
C18
C16
C14
Q601
R610
R15
TH2
R16
1
R12
IC11
18
R22
(EXCEPT CND)
C17
9 C19
R10
R905 R903
R17
JW10
R11
C20
10
EP901
D905 C25
R13
C5
JW13
C21
JW7
(CHASSIS)
C909 4
PH11
D14
C908
CN904 1 JW17
PH602
C945 C907
D15
D11
D16
D17
JW4
-
JW8
JW9
C
C12
EP1
E
(CHASSIS)
K
MAIN BOARD CN704
C
(CND) D3
M
E
A
(Page 31)
A
R904
JW12 C2 D1
C10
C11
R29 R18 R25
C
VR001
JW23
HT1 +
G
S
Q011
C920
JW20
D904
C916 1
HT906
D2
5
C23 JW1
JW2
D
(CND)
R23
R3 (CND)
JW11
1 C602 8
IC601
L904
HT905
HT2 D603
C604
Q012
S D903
5
E
IC909 R906 R908 C904
R915 Q901 Q902 E B E B C913
JW15
F FH1
B E Q903
C956
R925
R924
IC905
1
2 HT903
4
C905
C902 C960
C959
R914
D906
1
40
D927
D923 R948
R933 R930 R962 R927
IC908 D910
R966 R960
JW21 JW22 D914
I MAIN BOARD CN412
(Page 31)
1
R961 11, 12 1-882-117-
JW19 C918
EP902
C919
MAIN BOARD CN417
(Page 31)
40
Q904 R934 B E R964 R929
3
3 2
J
(AC IN)
R928 R963
C914 C915
1
R916
C917 L901
R926
5
R910
R907 D901
C958 CN905
1 2 R909
C957
C950
R955
C910 R912 R911 R913
T603 SUB POWER TRANSFORMER
4 3
C952 JW26
C954
R902
FH2
CN902 9
D913 R953
PH601
R901
C906
JW18
R965
C
R2
C944
JW907
D902
D602
C930
D922 R932 JW29 JW16
C22
1
C929 R931
R604
4
R918 D907
JW28
C1
F1
R921
R20
G
R606
4
D911
R27
C603 R603
HCD-MX500i/MX550i
HT902
FB11 R605
3
R968
R952
C24
T1 LINE FILTER
CN1
R951
JW14
TH1
E
2 R920 R922
JW27 JW30 R969
T031 MAIN POWER TRANSFORMER
JW3
C923
IC904
(CHASSIS)
(11, 12)
HCD-MX500i/MX550i
5-22. SCHEMATIC DIAGRAM - POWER Board - • See page 42 for IC Block Diagrams. • See page 47 for IC Pin Function Description. 1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
POWER BOARD
C5 470p 250V
EP1
5 D1 D3SB60F3
SOURCE
DRAIN CL
VCC 4
5.9 R605 15k
R3 1M 1/2W
PH601 PS2561AL1-1-V-W ISOLATOR
3.9
1.8
R901 1k
2.9
R906 47
IC11
4 2.4 2.6 47k 0 2.6
C18 0.1
21 0
H
1
VSENSE
2
F/B
VD
1
C21 0.22
18
3
CT
VG-H
16
4
RT
VS
15
5
GND
VB
14
6
PROTECT VG-L
12
7
SS
8
VC1
P-GND
11
9
OCP
VC2
10
304
C956 0.1
6
+11V
7
DGND
8
M+7V
9
MGND
R933 10k
1
A+9V
2
A+5V
3
AGND
CN905 3P
I MAIN BOARD (2/4) CN412
(Page 33)
I
G
O
J MAIN BOARD (2/4) CN417
(Page 33)
R927 1k D927 DZ2J062M0L 5
2
R962 1k
R964 1k
3
D913 MC2836-T112-1
C952 470 16V
C954 0.22
R928 4.7k
R909 47k
R969 6.8k
13
C957 10 50V
C914 0.22
C915 0.22
C958 220 10V
D922 DA2J10100L
IC B/D
R965 1k
D902 10ERB20-TB5
T031 MAIN POWER TRANSFORMER
1
R929 4.7k
R925 10k
C950 0.22
161
C22 220p 1kV
IC908 +5V REGULATOR IC908 KIA7805API-U/PF
R963 4.7k
R930 1k
IC904 SS
R20 10k
P-MONI
1
2
3
4
5
+7V REGULATOR IC904 SI-8001FFEK
D914 DZ2J091M0L
12
3 C24 0.033 800V
156.5
R25 33
152 D11 UF4005/23
C944 0.22
L904 47uH
R968 10k
D911 MC2836-T112-1
9
5 C23 220p 1kV
156.1
C906 2200 16V
R922 10k
R921 22k
R920 82k
R931 3.3k
10
4
161
D903 SBT80-06LS-S
11
C916 0.22
JW907
R23 0.22 2W
C920 1000 35V
C923 0.1
D907 SJPJ-L3VL
R918 820
C929 0.22
C930 2200 10V
R932 4.7k
8
303.5
7
C909 0
C17 1000p
EP901 6 R17 68
R16 100
R11 0
D904 FMEN-210A
D14 10ERB20-TB5
C907 2200 35V
C908 0
C945 0.22
E
R15
2 S
D16 UDZW-TE17-15B
2.3
Q012 2SK3563(LB2SONY) SWITCHING
1
POWER CONTROL IC11 CXD9841P
C14 1000p
5
VOS
D17 RB751V-40TE-17
Q601 2SC3052EF-T1-LEF INVERTER
C13 0.01
G
IC909 SHUNT REGULATOR IC909 MM1431CURE
304
R27 10
2.3
R10 27k
4
R955 1k
156.5
R14 470k
3
GND
FB11 1.1uH
4 VREF
R22 1k
3
NC
R12 4.7M
0
F
2
R926 47k
2.5 R13 4.7M
R610 330k
Q904 2SC3052EF-T1-LEF PROTECT DETECT
D923 DZ2J100M0L
+9V REGULATOR IC905 SI-3010KFEK
9
R609 150k
C606 0.01
R966 3.3k
C917 0.1
IC905
1
R902 470
K
R608 1k
C913 10 50V
C904 0.1
A
E
R915 10k
R912 47k
IC B/D
D2 S2V60-TA
D3 S2V60-TA
C910 0.01
D603 10ERB20-TB5
C603 2200p
AC-DET
5
3.3
R604 47
C602 0.1
GND-SUB
4
3.8
FB
3
POW-ON
3
0
6
0.8
VDD
2
R603 470k
C11 390 250V
R4 1M 1/2W
1
EVER 4V
2
R961 1k
R924 33k
C12 390 250V
R960 2.2k
R907 4.7k
1
2.5
(CND)
R916 470
0
R908 22k
IC601 MIP2F20MS1SO
R953 1k
R934 1k
7
IC601
13.8
C10 100 450V
JW5
D
TH1
R948 10k
0 Q902 2SC3052EF-T1-LEF
POWER CONTROL
0
JW4
JW6
5
5.9
(EXCEPT CND)
~
7
1
JW3
C
8 SOURCE
~
TH2
1.1
C905 1000 6.3V
D901 10ERB20-TB5
C604 1 50V
R913 10k
3
12.2
(CHASSIS)
D910 DZ2J043M0L
1.8
C959 0.1
(CND)
R911 10k
1.2 3
ADJ
C2 0.22 250V
9
3
3
Vout
3
Q901 2SC3052EF-T1-LEF
E
B
4
D602 ST02D-200TA
SW-OUT
C1 0.22 250V
R2 2.2M 1/2W
R606 1
R914 1k
1
VDR001
D906 DZ2J160M0L
Q903 ISA1235AC1TP-1EF
6.9
2
R910 1k
GND
1
(AC IN)
1
C4 470p 250V
L901 10uH
C902 220 10V
9
3
C960 0.1
V-IN
AC_NEYTRAL
T1 LINE FILTER
12.2
1
CN902 9P
Q901-903 POWER ON/OFF CONTROL
T603 SUB POWER TRANSFORMER
Vin
AC_LIVE
F1 T5AH 250V
Vc
CN1 3P
12.3
A
(CHASSIS)
C919 0
R24 1k
3.6
I Q011 2SK3563(LB2SONY) SWITCHING
161
156.1
HCD-MX500i/MX550i
R905 470
1
C15 10 50V
C16 4.7 50V
D15 UDZW-TE17-15B
C20 47 25V
C19 0.1
R18 10k
0
S
C918 0
D905 MTZJ-T-77-20A
(CHASSIS) R951 10k
R903 1k
R29 10
J
PH11 PS2561AL1-1-V-W ISOLATOR
E
EP902
CN904 4P 1
P-GND
PH602 PS2561AL1-1-V-W
2
P-GND
ISOLATOR
3
+27V
4
+27V
1.1 R952 4.7k
R904 100k
C25 330 35V
41
41
M MAIN BOARD (4/4) CN704
(Page 35)
HCD-MX500i/MX550i
• IC Block Diagrams
BIAS
– +
VO1(+)
2
IN1
3
28 GND D.BUFF D.BUFF
LEVEL SHIFT
2I/O 4
10 4O/I
2C 5
9 3O/I
REF
7
GND
8
IN2'
9
MUTE
3
VCC
22 VCC
VCC
21 VCC
19 IN3
D.BUFF
LEVEL SHIFT
LEVEL SHIFT
D.BUFF
GND
NP
– MAIN Board – IC405, 508, 509, 704 TK11133CSCL-G IC504 TK11150CSCL-G
18 VO3(+)
VO2(+) 11 D.BUFF
D.BUFF
17 VO3(–)
5
4
16 RESETt
OPOUT 14
OVER HEAT & OVER CURRENT PROTECTION
15 OPIN
CONTROL CIRCUIT
8 3I/O
– +
16 VCC
1 SELECT 11 S
15 STROBE
1B
4A
14 4A
OUTPUT 1Y 4
1Y
4B
13 4B
2A 5
2A
4Y
12 4Y OUTPUT 11
2B 6
2B
3A
11 3A
OUTPUT 2Y 7
2Y
3B
10 3B
INPUT
INPUT
1A
1B 3
GND 8
3Y
INPUT
2
3
GND
NP
IC406 BD2220G-TR VIN 1
G
1A 2
1 VCONT
BANDGAP REFERENCE
IC405 TC74VHC157FT (EKJ)
REGULATOR
5 VOUT
B1 B2 C1 C2 D1 D2 E1 E2 F1 F2
1 2 3 4 5 6 7 8 9 10
32 SDA 31 SCL
INPUT SELECTOR
I2C BUS LOGIC
SEL2 11 SEL1 12
BUFFER
VOL1 13 VOL2 14
VOLUME
TC2 15 TC1 16
30 FIL 29 GND
INPUT GAIN
28 SDA 27 SCL
26 VCC
25 OUT1 SURROUND TREBLE/ BASS
21 OUT2 20 19 18 17
4 /OC
INPUT
9 3Y OUTPUT
HCD-MX500i/MX550i
IC502 BD3491FS-SE2
24 SB1 23 SR 22 SB2
GND 2 EN (/EN) 3
ADJ 5
20 IN3'
IN2 10
VO2(–) 12 GND 13
2
23 BIAS
5
MUTE
1
3C 6 GND 7
TSD – +
VOUT
11 4I/O
– +
VOUT 4
REGULATOR 2O/I 3
GND 3
BANDGAP REFERENCE
24 IN4'
14 VCC
12 4C
CONTROL CIRCUIT
25 IN4
REGOUT 6
13 1C
OVER HEAT & OVER CURRENT PROTECTION
26 VO4(+)
3 VOUT
REGB
1O/I 2
VC 1 VIN 2
D.BUFF
RESET 4
GND 2
1I/O 1
4
D.BUFF
LEVEL SHIFT
THERMAL SHUT-DOWN REGULATOR BIAS TRAP
IC403, 404 TC74HC4066AFT (EL)
5
27 VO4(–)
VIN
CURRENT LIMIT
1
VCONT
VOLTAGE REFERENCE
VO1(–)
IC672 SI-3010KM-TLS VOUT
4 VDD CE 1
– DAB Board – IC671 TK11133CSCL-G
IC301 BA5826HFP-E2
VIN
– BD96/BD96U Board – IC102 MM3404A15URE
42
42
BCB1 BCA1 BCA2 BCB2
HCD-MX500i/MX550i
IC506, 510 BD8410FPS-E2
IC505 SI-3010KM-TLS VC 1
OCP 1
OVER CURRENT PROTECTION
VIN 2 VIN 2 GND 3
VOLTAGE REFERENCE STBY 3
TSD
– +
STANDBY FIN GND
– +
THERMAL SHUTDOWN DISCHARGE VOUT 4
REF
OCOUT 5
VOUT 4 ADJ 5
IC702 MM3404A33URE IC712 MM3404A18URE
IC507 BA6956AN TSD
4 VDD CE 1 CONTROL LOGIC
BIAS
1
2
3
4
5
6
7
8
9
VREF
OUT2
RNF
OUT1
VM
VCC
FIN
GND
RIN
VOLTAGE REFERENCE
– +
CURRENT LIMIT
3 VOUT
GND 2
IC703 MC74VHC74DTR2 14 13 12 11 VCC
10 PR D CK
D
PR
CLR
9
8
Q Q
Q Q
CK CLR 1
2 3
4
5 6
GND 7
43
HCD-MX500i/MX550i
XFSOIN
XVDD
HPVDDL
HPOUTL1
HPVSSL
HPOUTL2
HPVDDR
HPOUTR1
HPVSSR
HPOUTR2
FSOI FSOCKO
IC705 CXD9788AR
48
47
46
45
44
43
42
41
40
39
38 37
CLOCK GENERATOR (SECONDARY)
CLOCK GENERATOR (PRIMARY)
36
XFSIIN
35
DVDD
VSUBC 2
34
TEST
VSSR 3
33
BFVSS
OUTR2 4
32
BFVDD
31 30 29
DATA BCK LRCK
28
MCKSEL
27
INIT
26
SFLAG
25
OVFFLAGL
XVSS 1
VDDR 5
PWM
OUTR1 6
LINER INTERPOLATOR
'6
VSSR 7
FILTER & LOW CUT FILTER
GAIN CONTROL
SAMPLING RATE CONVERTER
SgP
VSSL 8 OUTL2 9 VDDL 10 INIT/ MUTE
OUTL1 11
SERIAL CONTROLLER
20
21
22
23
24
SCSHIFT
OVFFLAGR
DVDD
19
SCLATCH
XOVDD
18
SCDT
XFSOOUT
17
PGMUTE
16
SOFTMUTE
15
NSPMUTE
14
DVSS
13 XOVSS
VSSL 12
IC707 CXD9965TN GVDD_B
1
/OTW
2
NC NC
3 4
/SD
5
PWM_A
6
/RESET_AB
INTERNAL PULLUP RESISTORS TO VREG
8
OC_ADJ
9
44 GVDD_A
4
43 BST_A 42 NC
PROTECTION AND I/O LOGIC
POWER ON RESET
VREG
41 PVDD_A 40 PVDD_A
TEMP. SENSE OVERLOAD PROTECTION
7
PWM_B
4
UNDER VOLTAGE PROTECTION
39 OUT_A
ISENSE
BTL/P BTL-CONFIGURATION PULLDOWN RESISTORS 38 GND_A 37 GND_B BTL/P BTL-CONFIGURATION PULLDOWN RESISTORS 36 OUT_B
GND 10
PWM RCV.
AGND 11
CTRT.
TIMING
35 PVDD_B
GATE DRIVE
34 BST_B 33 BST_C
VREG 12
32 PVDD_C
M3 13 M2
PWM RCV.
14
31 OUT_C CTRT.
TIMING
GATE DRIVE
BTL/P BTL-CONFIGURATION PULLDOWN RESISTORS 30 GND_C
M1 15 29 GND_D PWM_C
16
PWM RCV.
/RESET_CD 17 PWM_D
18
NC NC
19 20
VDD
21
44
TIMING
GATE DRIVE
28 OUT_D 27 PVDD_D 26 PVDD_D
VREG
VREG
GVDD_C 22
CTRT.
BTL/P BTL-CONFIGURATION PULLDOWN RESISTORS
PWM RCV.
CTRT.
TIMING
GATE DRIVE
25 NC 24 BST_D 23 GVDD_D
HCD-MX500i/MX550i
IC711 AK5358BET-E2 AINR 1
MODULATOR
DECIMATION FILTER
16 CKS0
AINL 2
MODULATOR
DECIMATION FILTER
15 CKS2
CKS1 3 VCOM 4
14 DIF SERIAL I/O INTERFACE
VOLTAGE REFERENCE
13 PDN
AGND 5 12 SCLK VA 6
CLOCK DIVIDER
11 MCLK
VD 7 10 LRCK DGND 8
9 SDTO
VEE
GR16 GR15 GR14 GR13 GR12 GR11 GR10 GR9 GR8 GR7 GR6 GR5 GR4 GR3 GR2
– FL Board – IC621 PT6302LQ-010 48
47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
VSS 49 32 GR1 OSCI 50 OSCO 51
OSCILLATOR
RSTB 52
TIMING GENERATOR 1
TIMING GENERATOR 2 DUTY CONTROL
CSB 53 CLKB 54 DIN 55
8 BIT SHIFT REGISTER
VDD 56
COMMAND DECODER
PORT DRIVER
AD2 59 AD1 60
AD DRIVER
SG1 SG2 SG3 SG4
61 62 63 64
CONTROL CIRCUIT
WRITE ADDRESS COUNTER
READ ADDRESS COUNTER
ADDRESS SELECTOR
CG-RAM
SG35 SG34 SG33 SG32 SG31 SG30 SG29 SG28 SG27 SG26 SG25 SG24 SG23 SG22 SG21
SEGMENT DRIVER AD-RAM
DC-RAM
CG-ROM
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SG5 SG6 SG7 SG8 SG9 SG10 SG11 SG12 SG13 SG14 SG15 SG16 SG17 SG18 SG19 SG20
P1 57 P2 58
GRID DRIVER DIGIT CONTROL
31 30 29 28 27 26 25 24 23 22 21 20 19 18 17
45
HCD-MX500i/MX550i
– POWER Board – IC601 MIP2F20MS1SO 6.6V VDD 1 CONSTANT CURRENT SOURCE
CLAMP CIRCUIT (ILIMIT SETTING)
FB 2
VDD CLAMP CIRCUIT
ILIMIT CORRECTION CIRCUIT – + FOR DRAIN CURRENT DETECT
VCL
VCL.OUT ICL.LOW ILIMIT VARIABLE CIRCUIT
2.4V
R Q S Q
AT TURNING ON BLANKING PULSE GENERATION CIRCUIT
GENERATOR CLOCK 12kHz MAXDC
VCC OVP + –
GATE DRIVER
POWER MOSFET
S Q R Q
OVERHEAT PROTECTION
7.2V
FOR LIGHT LOAD DETECTION INTERMITTENT OSCILLATION CONTROL + –
27% 22%
IN
CL 3
8 SOURCE 7 SOURCE
RESTARTING TRIGGER
VDD UV + –
VCC UV + –
5.7V 5.0V
REGULATOR + –
5.7V
VCC 4
5 DRAIN
IC904 SI-8001FFEK
IC905 SI-3010KFEK VC 1
ON/OFF SOFT START
PREG
OVERCURRENT PROTECTION
OSCILLATOR
RESET
COMPARATOR – + – + + ERROR AMP
VIN 2 GND 3
LATCH & DRIVER
TSD – +
THERMAL PROTECTION
REF VOUT 4
REFERENCE VOLTAGE
1
2
3
4
5
IN
SW
GND
ADJ
SS
ADJ 5
46
HCD-MX500i/MX550i
• IC Pin Function Description BD96 BOARD IC101 TC94A70FG-101 (CD-MP3 PROCESSOR) (Canadian model) BD96U BOARD IC101 TC94A70FG-101 (CD-MP3 PROCESSOR) (Except Canadian model) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37
Pin Name AVSS3 RFZI RFRP SBAD FEO TEO TEZI AVDD3 FOO TRO VREF FMO DMO VSSP3 VCOI VDDP3 VDD1 VSS1 FGIN IN_SW /DFCT XVSS3 XI XO XVDD3 DVSS3 ROUT DVDD3 DVR LOUT DVSS3 VDDT3 VSS1 VDD1 VDDM1 SRAMSTB XRST
I/O I O O O O I O O I O O I I I O I O O O O I I
38 to 41
BUS0 to BUS3
I
42 43 44 45 46 47
BUCK XCCE TEST IRQ ST_REQ/CKO AOUT2
I I I I O O
48
REQ
O
49 50 51 52 53 54 55 56 57
PIO1/ST_REQ PIO2 GATE VSS1 VDDT3 SBSY FOK IPF /LOCK
O O I O O O O
Description Ground terminal RF ripple zero crossing signal input terminal RF ripple signal output terminal Sub beam addition signal output terminal Not used Focus error signal output terminal Not used Tracking error signal output terminal Tracking error zero crossing signal input terminal Power supply terminal (+3.3V) Focus coil drive signal output terminal Tracking coil drive signal output terminal Reference voltage (+1.65V) input terminal Sled motor drive signal output terminal Spindle motor drive signal output terminal Ground terminal VCO control voltage input terminal Power supply terminal (+3.3V) Power supply terminal (+1.5V) Ground terminal FG signal input terminal Not used Disc inner position detection signal input terminal Not used Ground terminal System clock input terminal (16.934 MHz) System clock output terminal (16.934 MHz) Power supply terminal (+3.3V) Ground terminal Audio data (R-ch) output to the input selector Power supply terminal (+3.3V) Reference voltage (+1.65V) output terminal Audio data (L-ch) output to the input selector Ground terminal Power supply terminal (+3.3V) Ground terminal Power supply terminal (+1.5V) Power supply terminal (+1.5V) S-RAM standby mode control signal input terminal Fixed at “L” in this set Reset signal input from the system controller “L”: reset Serial data input from the system controller (Canadian model) Serial data input from the system controller and USB controller (Except Canadian model) Serial data transfer clock signal input from the system controller Chip enable signal input from the system controller Setting terminal for test mode Normally fixed at “L” Interrupt request signal input terminal Not used Request signal output terminal Not used Audio data output terminal (Except Canadian model only) Request signal output to the system controller (Canadian model) Request signal output to the system controller and USB controller (Except Canadian model) Request signal output to the USB controller (Except Canadian model only) Not used Gate signal input terminal (Except Canadian model only) Ground terminal Power supply terminal (+3.3V) Subcode block sync signal output to the system controller Not used Not used Not used
47
HCD-MX500i/MX550i
Pin No. 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90
Pin Name ZDET GPIN MS DOUT AOUT1 BCKO LRCKO AIN BCKI LRCKI VDD1 VSS1 AWRC PVDD3 PDO TMAXS TMAX LPFN LPFO PVREF VCOF PVSS3 SLCO RFI RFRPI RFEQ0 VRO RESIN VMDIR TESTR AGCI RFO RVDD3
I/O O I I O O O O I I I O O O I O I O O I I O O O O O I O -
91
LDO
O
92 93 94 95 96 97 98 99 100
MDI RVSS3 C A D B F TNPC E
I I I I I I O I
48
Description Zero detection signal output terminal Not used Not used Micro controller interface mode selection signal input terminal Fixed at “H” in this set Digital audio data output terminal Not used Audio data output terminal Not used Bit clock signal output terminal (Except Canadian model only) L/R sampling clock signal output terminal Not used Digital audio data input terminal (Except Canadian model only) Bit clock signal input terminal (Except Canadian model only) L/R sampling clock signal input terminal (Except Canadian model only) Power supply terminal (+1.5V) Ground terminal Not used Power supply terminal (+3.3V) Phase error margin signal between EFM signal and PLCK signal output terminal TMAX detection signal output terminal Not used TMAX detection signal output terminal Inverted signal input from the operation amplifier for PLL loop filter Signal output from the operation amplifier for PLL loop filter Reference voltage (+1.65V) input terminal VCO filter output terminal Ground terminal EFM slice level output terminal RF signal input terminal RF ripple signal input terminal EFM slice level output terminal Reference voltage (+1.65V) output terminal External resistor connection terminal Reference voltage (+1.65V) output terminal for automatic power control circuit Low-pass filter terminal for RFEQO offset correction RF signal amplitude adjustment amplification input terminal RF signal generation amplification output terminal Power supply terminal (+3.3V) Laser diode on/off control signal output to the automatic power control circuit “H”: laser diode on Light amount monitor input from the laser diode of optical pick-up block Ground terminal Main beam (D) input from the optical pick-up block Main beam (B) input from the optical pick-up block Main beam (C) input from the optical pick-up block Main beam (A) input from the optical pick-up block Sub beam (F) input from the optical pick-up block External capacitor connection terminal Sub beam (E) input from the optical pick-up block
HCD-MX500i/MX550i
BD96U BOARD IC401 92CD28AFG-7FU8 (M (USB CONTROLLER) Pin No. 1 2 3, 4 5 6 7 to 9 10 11 12 13, 14 15 16 17 18 to 25 26 27 28 to 35 36 37 to 43 44 45 46 to 54 55 to 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93
Pin Name USB-RST I-USB-DI INT1, INT2 INT3 DVCC3B XT1, XT2, PWE DVSS1B DVCC1B RVOUT1 RVIN RVOUT2 DVCC1A DVSS1A D0 to D7 DVSS DVCC3A D8 to D15 A0 A1 to A7 DVSS DVCC3A A8 to A16 BUS0-U to BUS3-U BUCK-U CCE-U A23 DVSS DVCC3A RD SRWR SRLLB SRLUB TA0IN BOOT SRAM-CS LRCK AM1 X2 DVSS X1 DVCC3A USBOC USBPON D+ DAM0 X1USB DVSS O-USB-DO DATA CLK O-USB-SO I-USB-SI SPCLK SO0 SI0 BCK A-IN
I/O I I O I O I O I/O I/O O O O O O O O O O O O O I O O I O I I O I/O I/O I O O I I O I O O
Description Reset signal input from the system controller “L”: reset Ready to send signal input from the system controller Not used Function selection signal input terminal Fixed at “H” in this set Power supply terminal (+3.3V) Not used Ground terminal Power supply terminal Not used Reference voltage (+3.3V) output terminal Not used Reference voltage (+3.3V) input terminal Reference voltage (+3.3V) output terminal Not used Power supply terminal Not used Ground terminal Two-way data bus with the S-RAM Ground terminal Power supply terminal (+3.3V) Two-way data bus with the S-RAM Address signal output terminal Not used Address signal output to the S-RAM Ground terminal Power supply terminal (+3.3V) Address signal output to the S-RAM Serial data output to the CD-MP3 processor Serial data transfer clock signal output to the CD-MP3 processor Chip enable signal output to the CD-MP3 processor Not used Ground terminal Power supply terminal (+3.3V) Output enable signal output to the S-RAM Write enable signal output to the S-RAM Lower-byte control signal output to the S-RAM Upper-byte control signal output to the S-RAM Not used Boot mode selection signal input terminal “L”: boot mode Chip select signal output to the S-RAM L/R sampling clock signal output to the CD-MP3 processor Function mode selection signal input terminal Fixed at “H” in this set System clock output terminal (9 MHz) Ground terminal System clock input terminal (9 MHz) Power supply terminal (+3.3V) Over current detection signal input terminal USB VBUS power on/off control signal output terminal “H”: power on Two-way data (positive) bus with the USB connector Two-way data (negative) bus with the USB connector Function mode selection signal input terminal Fixed at “H” in this set Not used Ground terminal Clear to send signal output to the system controller Audio data input from the CD-MP3 processor Audio data transfer clock signal input from CD-MP3 processor Serial data output to the system controller Serial data input from the system controller Not used Not used Not used Bit clock signal output to the CD-MP3 processor Audio data output to the CD-MP3 processor
49
HCD-MX500i/MX550i
Pin No. 94 95 96 97 98, 99 100
50
Pin Name GATE DVCC3A REQ-U ST-REQ PG1, PG0 DVSS
I/O O I I I -
Description Gate signal output to the CD-MP3 processor Power supply terminal (+3.3V) Request signal input from the CD-MP3 processor Request signal input from the CD-MP3 processor Function selection signal input terminal Fixed at “H” in this set Ground terminal
HCD-MX500i/MX550i
MAIN BOARD IC401 R5F364AEDFA (SYSTEM CONTROLLER) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29, 30 31 32 33 34 35 36 37
I/O O O O I O I O I I I O I O I I I I O O O O O O O I O I O I O I O
Description Serial data output to the fluorescent indicator tube driver Serial data transfer clock signal output to the fluorescent indicator tube driver Chip select signal output to the fluorescent indicator tube driver SIRCS signal input from the remote control receiver Serial data output terminal Not used Serial data input terminal Not used Serial data transfer clock signal output terminal Not used External data bus width selection signal input terminal Processor mode selection signal input terminal Sub system clock input terminal (32.768 kHz) Sub system clock output terminal (32.768 kHz) System reset signal input terminal Main system clock output terminal (5 MHz) Ground terminal Main system clock input terminal (5 MHz) Power supply terminal (+3.3V) Not used RDS interrupt signal input from the tuner (FM) (MX500i: AEP/MX550i only) Subcode block sync signal input from the CD-MP3 processor AC cut on/off detection signal input terminal “L”: AC cut on Power on/off control signal output terminal Not used Serial data transfer clock signal output to the EEPROM Chip select signal output terminal Not used Serial data output to the EEPROM Reset signal output terminal Not used Reset signal output to the EEPROM System reset signal output to the USB controller “L”: reset (Except Canadian model only) Clear to send signal input from the USB controller (Except Canadian model only) Not used Serial data output to the USB controller (Except Canadian model only) Serial data input from the USB controller (Except Canadian model only) Ready to send signal output to the USB controller (Except Canadian model only) Over load detection signal input terminal Serial data output terminal for the DAB tuner module (MX550i only) Serial data input terminal for the DAB tuner module (MX550i only) PG muting on/off control signal output to stream processor
O
Soft muting on/off control signal output to stream processor
39 40 41 42 43 44 45 46 47 48
Pin Name FL/LCD DO FL/LCD SCL FL/LCD CS SIRCS BCo_SPI_DOUT BCo_SPI_DIN BCo_SPI_CLK BYTE CNVss Xcin Xcout RESET Xout Vss Xin Vcc NMI RDS-INT SBSY AC-CUT BCo_POWER iPod CP IIC SCL BCo_SPI_CS iPod CP IIC SDA BCo_RESET iPod CP RESET USB_RESET USB_CTS no use USB_TxD_OUT USB_RxD_IN USB_RTS S-MASTER_DCP DAB TxD_OUT DAB RxD_IN S-MASTER_PG_MUTE S-MASTER_ SOFT_MUTE S-MASTER_RESET S-MASTER_DATA LCD BACKLIGHT S-MASTER_SHIFT S-MASTER_LATCH S-MASTER_NSPMUTE S-MASTER_INIT STBY_LED VOL IIC_SDA/E2P-SDA VOL IIC_CLK/E2P-CLK
O O O O O O O O O O
49
DAB-POWER_3.3
O
50
DAB-POWER_1.2
O
51 52 53 54 55 56 57
ST_TUNED ST_CE ST_DO ST_CLK ST_DI/STEREO RDS_DATA CDM_OPEN_SW
I O O O I I I
Reset signal output to the digital power amplifier Serial data output to the stream processor LED drive signal output terminal Not used Serial data transfer clock signal output to the stream processor Serial data latch pulse signal output to the stream processor NSP muting on/off control signal output to stream processor Reset signal output to the stream processor LED drive signal output terminal for STANDBY indicator Serial data output to the electrical volume Serial data transfer clock signal output to the electrical volume Power supply on/off control signal output terminal for the DAB tuner module (+3.3V) (MX550i only) Power supply on/off control signal output terminal for the DAB tuner module (+1.2V) (MX550i only) Tuned detection signal input from the tuner (FM) Chip enable signal output to the tuner (FM) Serial data output to the tuner (FM) Serial data transfer clock signal output to the tuner (FM) Serial data input from the tuner (FM) RDS data input from the tuner (FM) (MX500i: AEP/MX550i only) Switch detection signal input terminal for loading section
38
51
HCD-MX500i/MX550i
Pin No. 58 59 60 61 62 63 64 65 66 67 68 69 70, 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 to 95 96 97 98 99 100
52
Pin Name CDM_CLOSE_SW CDM_LOAD_IN CDM_LOAD_OUT FL/LCD RESET Vcc POWER ON Vss SPEC_IN AUDIO_LEVEL_INPUT BCo_SPI_REQ BCo_SPI_READY AC_DET KEY_1, KEY_2 VOLUME_JOG BYPASS I_KEY WAKE UP_ POWER & DISPLAY iPod_WAKE iPod_DET iPod_TxD_OUT iPod_RxD_IN NC HP_DET HP_MUTE TA_LINE_MUTE POWER_PROTECT SINGER_ON BOLERO/iPod_ON ZIPANG_ON CD_XRST CD_DRIVER_MUTE MP3_IREQ CD CCE CD CLK DEC BUS SEL CD BUS3 to CD BUS1 Avss CD BUS0 VREF Avcc LCD_DI
I/O I O O O O I I I O I I I O
Description Switch detection signal input terminal for loading section Motor drive signal output terminal for the loading section Motor drive signal output terminal for the loading section Reset signal output to the fluorescent indicator tube driver Power supply terminal (+3.3V) Main power on/off control signal output terminal “H”: main power on Ground terminal Destination setting terminal Audio level detection signal input terminal Request signal input terminal Not used Ready signal output terminal Not used Power failure detection signal input terminal Panel key input terminal (A/D input) Jog dial pulse input from the rotary encoder (for VOLUME) System shut down signal output terminal
I
Key wake-up signal input terminal
I I O I I O I O O O O O I O O O O O I I
Wake-up signal input from the iPod/iPhone Dock iPod/iPhone detection signal input terminal Serial data output to the iPod/iPhone Dock Serial data input from the iPod/iPhone Dock Not used Headphone detection signal input terminal Not used Line muting on/off control signal output terminal Power monitor signal input terminal Power supply on/off control signal output terminal Not used Power supply on/off control signal output terminal for the USB/iPod section Power supply on/off control signal output terminal for the CD section Reset signal output to the CD-MP3 processor Motor drive on/off control signal output to the motor/coil driver Request signal input from the CD-MP3 processor Chip enable signal output to the CD-MP3 processor Serial data transfer clock signal output to the CD-MP3 processor Function selection signal output terminal Serial data output to the CD-MP3 processor Ground terminal Serial data output to the CD-MP3 processor Reference voltage (+3.3V) input terminal Power supply terminal (+3.3V) Not used
HCD-MX500i/MX550i
POWER BOARD IC11 CXD9841P (POWER CONTROL) Pin No. 1 2 3 4 5
Pin Name VSENSE F/B CT RT GND
I/O I I -
6
PROTECT
-
7 8 9 10 11 12 13 14 15 16 17 18
SS VC1 OCP VC2 P-GND VG-L VB VS VG-H VD
I I O I O I I O -
Description AC line input voltage detection signal input terminal Feedback signal input terminal for frequency modulation of oscillator External capacitor connection terminal for oscillator External resistor connection terminal for oscillator Ground terminal External capacitor connection terminal for intermittent operation timer when abnormality detecting it External capacitor connection terminal for soft start Power supply terminal for control circuit “L”: stop, “H”: operation start Over current detection signal and DIDT protection signal input terminal Power supply output terminal for driver Ground terminal for lower side driver Lower side driver drive signal output terminal Not used Power supply terminal for upper side driver Reference power supply input terminal for upper side driver Upper side driver drive signal output terminal Not used Terminal for drain kick start
53
HCD-MX500i/MX550i SECTION 6 EXPLODED VIEWS Note: • -XX and -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items.
6-1.
• The mechanical parts with no reference number in the exploded views are not supplied. • Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) ↑ ↑ Parts Color Cabinet’s Color • Abbreviation CH : Chinese model CND : Canadian model SP : Singapore model
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
CASE SECTION
6
5
5 4
5
7
4 front panel section
MAIN board section
3 1 2
Ref. No. 1 2 3 4
54
4 4
Part No.
Description
4-175-911-01 4-159-522-02 4-183-971-01 3-077-331-01
PANEL (CD) SPRING (LOADING) BASE (CD) +BV3 (3-CR)
(EXCEPT CND)
Remark
Ref. No.
Part No.
Description
5
3-704-515-22
SCREW (BV/RING)
6 7
4-175-953-01 1-457-413-11
CASE CORE, FERRITE
Remark
HCD-MX500i/MX550i
6-2.
FRONT PANEL SECTION
55 iPod dock section
not supplied (FL board)
55
55
not supplied (JACK board)
not supplied (KEY board)
not supplied
56
55
not supplied (HOLD board)
54
57
59 61 60
55 63
58
not supplied (USB board)
62 55 55
(EXCEPT CND)
52
53
51
Ref. No.
Part No.
Description
Remark
51 52 52 52 52
4-175-912-01 X-2548-810-1 X-2548-811-1 X-2549-182-1 X-2549-183-1
KNOB (VOL) PANEL (FRONT MX500 CEL) ASSY (MX500i: AEP) PANEL (FRONT MX550) ASSY (MX550i) PANEL (FRONT MX500 CA) ASSY (MX500i: CND) PANEL (FRONT MX500 SP) ASSY (MX500i: CH, SP)
53 54 55 56
3-198-753-01 4-186-748-01 3-087-053-01 4-175-914-01
FOOT (FELT) CUSHION (IP) +BVTP2.6 (3CR) BUTTON (POWER) (I/1)
Ref. No.
Part No.
Description
Remark
57
4-175-917-01
INDICATOR (POWER)
58 59 60
4-175-920-01 4-175-915-01 4-175-919-01
61 62
4-175-918-01 4-175-916-01
CAP (BUTTON) BUTTON (PLAY) (FUNCTION, u, x) BUTTON (TUNE) ( + v, V –, l m TUNE –, M L TUNE +) BUTTON (ENTER) (DSGX, TOOL MENU, ENTER) BUTTON (EJECT) (Z)
63
1-832-578-21
CABLE, FLEXIBLE FLAT (13 CORE)
55
HCD-MX500i/MX550i
6-3.
iPod DOCK SECTION
104
105 106 107 108
111 110
109
112 113
103
#1
113 102 #2
115
114
116
117
118 101
Ref. No.
Part No.
Description
101 101 102 103 104
X-2548-813-1 X-2548-821-1 4-175-945-01 4-192-357-01 X-2548-812-1
BASE (LOWER MX500) ASSY (MX500i) BASE (LOWER MX550) ASSY (MX550i) SLIDER (LOCK) SPRING (SLIDER), EXTENSION BASE (UPPER) ASSY
105 106 107 108 109
4-175-944-01 4-175-950-01 3-669-480-32 3-277-576-01 A-1760-782-A
LEVER (LOCK) SPRING (LOCK), EXTENSION + PTPWH (2X5) ESCUTCHEON IP BOARD, COMPLETE
110
4-175-938-01
PANEL (DOCK), FRONT
56
Remark
Ref. No.
Part No.
Description
111 112 113 114
1-838-389-21 4-175-952-01 3-087-053-01 3-198-753-01
CABLE, FLEXIBLE FLAT (13 CORE) SPRING (CLOSE), LEAF +BVTP2.6 (3CR) FOOT (FELT)
115 116 117 118 #1
4-175-943-01 4-175-951-01 3-047-468-01 4-175-942-01 7-685-504-19
GEAR (LOCK) SPRING (IP), TORSION DAMPER HOLDER (DAMPER) SCREW +BTP 2X6 TYPE2 N-S
#2
7-685-106-19
SCREW +P 2X10 TYPE2 NON-SLIT
Remark
HCD-MX500i/MX550i
6-4.
MAIN BOARD SECTION
153
not supplied (SP board) H
152 152
not supplied
not supplied not supplied
154
A
152
not supplied
151 E
B C F
152 152 152
152
G
152
D
152 not supplied (POWER board)
C
152 152
A
152
E B
152
F
chasis section
H G
D
Ref. No. 151 151 151 151
Part No.
Description
Remark
A-1760-771-A A-1760-784-A A-1760-905-A A-1783-490-A
MAIN BOARD, COMPLETE (MX500i: AEP) MAIN BOARD, COMPLETE (MX500i: CND) MAIN BOARD, COMPLETE (MX550i) MAIN BOARD, COMPLETE (MX500i: CH, SP)
Ref. No.
Part No.
Description
152
3-077-331-01
+BV3 (3-CR)
153 154
1-400-932-11 4-183-177-01
FILTER, CLAMP SHEET, RADIATION
Remark
57
HCD-MX500i/MX550i
6-5.
CHASSIS SECTION CN01 DAB1
213
213 212
not supplied (DAB board)
(MX550i)
not supplied
211
(MX550i)
202
202
210 202
202
202 201
not supplied
CD mechanism deck section (CDM85CD-DVBU102)
202
not supplied
202
204 209 205
202
202
not supplied (GUARD board)
not supplied
not supplied
208 203 TU1
207 206 202
202
not supplied Ref. No.
0 0 0 0
Part No.
Description
201 201 202 203 204
A-1759-698-A A-1759-699-A 3-077-331-01 3-703-244-00 1-481-419-11
BD96 BOARD, COMPLETE (CND) BD96U BOARD, COMPLETE (EXCEPT CND) +BV3 (3-CR) BUSHING (2104), CORD CORE, FERRITE
205 205 205 205 206
1-834-966-41 1-835-078-31 1-837-308-11 1-837-822-21 3-198-753-01
POWER-SUPPLY CORD (AEP, SP) CORD, POWER (UK) CORD, POWER-SUPPLY (CND) CORD, POWER-SUPPLY (CH) FOOT (FELT)
207 208 209 209
3-531-576-11 1-400-092-11 1-832-814-21 1-832-824-21
RIVET CORE, FERRITE CABLE, FLEXIBLE FLAT (9 CORE) (CND, CH, SP) CABLE, FLEXIBLE FLAT (11 CORE) (AEP, UK)
58
Remark
Ref. No.
Part No.
Description
210
2-650-108-01
NUT (MX550i)
Remark
211 211
1-832-601-21 1-832-641-21
212
1-832-554-21
CABLE, FLEXIBLE FLAT (19 CORE) (CND) CABLE, FLEXIBLE FLAT (27 CORE) (EXCEPT CND) CABLE, FLEXIBLE FLAT (9 CORE) (MX550i)
213 CN01 DAB1 TU1 TU1
3-023-547-01 1-820-441-11 1-487-958-21 1-693-780-11 1-693-781-11
SCREW (2.6X6), +BTT (MX550i) CONNECTOR, COAXIAL (F TYPE) (MX550i) MODULE (DAB TUNER) (MX550i) TUNER (FM) (SP) TUNER (FM) (CND)
TU1 TU1
1-693-787-11 1-693-788-11
TUNER (FM) (AEP, UK) TUNER (FM) (CH)
HCD-MX500i/MX550i
6-6.
CD MECHANISM DECK SECTION (CDM85CD-DVBU102)
not supplied
251 252
not supplied
not supplied MS-213 board
257 253 255 257
257 257
256
256 not supplied not supplied
254
Ref. No. 0 251 252 253 254
Part No.
Description
Remark
A-1764-002-A 3-088-371-01 1-832-539-21 1-830-688-51
CDM85 (CD) ASSY (Including MS-213 board) BELT CABLE, FLEXIBLE FLAT (5 CORE) WIRE (FLAT TYPE) (24 CORE)
Ref. No.
Part No.
Description
0 255
8-820-321-05
DEVICE, OPTICAL KHM-313CAA/C2RP
256 257
4-985-672-01 4-168-623-01
SCREW (+PTPWH M2.6), FLOATING INSULATOR (85CD)
Remark
59
HCD-MX500i/MX550i SECTION 7 ELECTRICAL PARTS LIST
BD96/BD96U Note: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable Ref. No.
• CAPACITORS uF: μF • COILS uH: μH • SEMICONDUCTORS In each case, u: μ, for example: uA. . : μA. . , uPA. . , μPA. . , uPB. . : μPB. . , uPC. . , μPC. . , uPD. . : μPD. . • Abbreviation CH : Chinese model CND : Canadian model SP : Singapore model
Part No.
Description
Remark
A-1759-698-A A-1759-699-A
BD96 BOARD, COMPLETE (CND) BD96U BOARD, COMPLETE (EXCEPT CND) ********************* < CAPACITOR >
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.
Part No.
Description
Remark
C149 C157 C158 C159 C160
1-165-908-11 1-164-937-11 1-164-937-11 1-164-937-11 1-164-937-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1uF 0.001uF 0.001uF 0.001uF 0.001uF
10% 10% 10% 10% 10%
10V 50V 50V 50V 50V
C202 C203 C204 C207 C208
1-162-964-11 1-128-995-21 1-165-908-11 1-165-908-11 1-137-710-91
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.001uF 100uF 1uF 1uF 10uF
10% 20% 10% 10% 20%
50V 10V 10V 10V 6.3V
C101 C103 C104 C105 C106
1-165-908-11 1-107-826-11 1-164-156-11 1-128-995-21 1-107-726-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP
1uF 0.1uF 0.1uF 100uF 0.01uF
20% 10%
10V 16V 25V 10V 16V
C107 C108 C109 C110 C111
1-162-925-11 1-162-964-11 1-164-245-11 1-107-726-91 1-162-966-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
68PF 0.001uF 0.015uF 0.01uF 0.0022uF
5% 10% 10% 10% 10%
50V 50V 25V 16V 50V
C210 C211 C212 C213 C214
1-165-908-11 1-107-826-11 1-107-826-11 1-107-826-11 1-137-710-91
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1uF 0.1uF 0.1uF 0.1uF 10uF
10% 10% 10% 10% 20%
10V 16V 16V 16V 6.3V
C112 C113 C114 C115 C116
1-107-826-11 1-107-826-11 1-107-726-91 1-164-245-11 1-164-677-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.01uF 0.015uF 0.033uF
10% 10% 10% 10% 10%
16V 16V 16V 25V 16V
C216 C302 C303 C305 C309
1-137-710-91 1-107-826-11 1-164-156-11 1-164-156-11 1-128-394-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP
10uF 0.1uF 0.1uF 0.1uF 220uF
20% 10%
6.3V 16V 25V 25V 10V
C118 C119 C122 C123 C124
1-162-923-11 1-164-156-11 1-164-677-11 1-164-156-11 1-164-156-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
47PF 0.1uF 0.033uF 0.1uF 0.1uF
5%
50V 25V 16V 25V 25V
C403
1-107-826-11
CERAMIC CHIP 0.1uF
C404
1-107-826-11
CERAMIC CHIP 0.1uF
C405
1-107-826-11
CERAMIC CHIP 0.1uF
C125 C126 C127 C128 C129
1-164-315-11 1-164-315-11 1-164-156-11 1-165-176-11 1-165-176-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
470PF 470PF 0.1uF 0.047uF 0.047uF
5% 5%
50V 50V 25V 16V 16V
C406
1-162-919-11
CERAMIC CHIP 22PF
C407
1-162-921-11
CERAMIC CHIP 33PF
C408
1-107-826-11
CERAMIC CHIP 0.1uF
C130 C131 C132 C133 C134
1-107-826-11 1-107-826-11 1-162-966-11 1-164-156-11 1-164-156-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.0022uF 0.1uF 0.1uF
10% 10% 10%
C409
1-107-826-11
CERAMIC CHIP 0.1uF
C410
1-124-779-00
ELECT CHIP
C411
1-107-826-11
CERAMIC CHIP 0.1uF
C135 C136 C137 C138 C139
1-164-156-11 1-162-910-11 1-164-156-11 1-162-910-11 1-164-156-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 5PF 0.1uF 5PF 0.1uF
25V 0.25PF 50V 25V 0.25PF 50V 25V
C412
1-107-826-11
CERAMIC CHIP 0.1uF
C413
1-107-826-11
CERAMIC CHIP 0.1uF
C141 C142 C143 C145 C148
1-124-778-00 1-164-156-11 1-107-826-11 1-164-156-11 1-165-908-11
ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
22uF 0.1uF 0.1uF 0.1uF 1uF
20%
C414
1-107-826-11
CERAMIC CHIP 0.1uF
C415
1-124-779-00
ELECT CHIP
C420
1-107-826-11
CERAMIC CHIP 0.1uF
60
10% 10%
Ref. No.
When indicating parts by reference number, please include the board name.
10%
10% 10%
10% 10%
16V 16V 50V 25V 25V
6.3V 25V 16V 25V 10V
10uF
10uF
20%
10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 5% 50V (EXCEPT CND) 5% 50V (EXCEPT CND) 10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 20% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 20% 16V (EXCEPT CND) 10% 16V (EXCEPT CND)
HCD-MX500i/MX550i BD96/BD96U Ref. No.
Part No.
Description
Part No.
Description
C421
1-107-826-11
CERAMIC CHIP 0.1uF
10% 16V (EXCEPT CND)
Remark
IC202 IC203
6-707-010-01 6-707-010-01
IC NJM2740V IC NJM2740V
C422
1-107-826-11
CERAMIC CHIP 0.1uF
C423
1-107-826-11
CERAMIC CHIP 0.1uF
C424
1-107-826-11
CERAMIC CHIP 0.1uF
IC301 IC401 IC402 IC403 IC404
6-710-637-01 6-715-737-01 6-704-832-01 8-759-523-03 8-759-523-03
IC IC IC IC IC
C425
1-107-826-11
CERAMIC CHIP 0.1uF
IC405 IC406
6-707-870-01 6-715-294-01
IC TC74VHC157FT (EKJ) (EXCEPT CND) IC BD2220G-TR (EXCEPT CND)
C426
1-107-826-11
CERAMIC CHIP 0.1uF
10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 10% 16V (EXCEPT CND) 10% 50V (EXCEPT CND) 10% 50V (EXCEPT CND) 10% 10V (EXCEPT CND) 10% 10V (EXCEPT CND) 10% 16V (EXCEPT CND)
Q201 Q401
C434
1-164-937-11
CERAMIC CHIP 0.001uF
C435
1-164-937-11
CERAMIC CHIP 0.001uF
C436
1-165-908-11
CERAMIC CHIP 1uF
C437
1-165-908-11
CERAMIC CHIP 1uF
C438
1-107-826-11
CERAMIC CHIP 0.1uF
C501 C502 C503 C504 C505
1-128-995-21 1-128-995-21 1-128-995-21 1-164-156-11 1-164-156-11
ELECT CHIP ELECT CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP
100uF 100uF 100uF 0.1uF 0.1uF
20% 20% 20%
C506 C507 C508 C512 C513
1-164-156-11 1-162-966-11 1-162-966-11 1-107-826-11 1-128-995-21
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP
0.1uF 0.0022uF 0.0022uF 0.1uF 100uF
25V 10% 50V 10% 50V 10% 16V 20% 10V (EXCEPT CND)
C514
1-164-156-11
CERAMIC CHIP 0.1uF
C515 C518 C521 C536
1-107-826-11 1-107-826-11 1-107-826-11 1-107-826-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
Ref. No.
Remark
BA5826HFP-E2 92CD28AFG-7FU8 (M (EXCEPT CND) IS61LV6416-10TLT (EXCEPT CND) TC74HC4066AFT (EL) (EXCEPT CND) TC74HC4066AFT (EL) (EXCEPT CND)
< TRANSISTOR > 6-551-120-01 8-729-027-43
TRANSISTOR TRANSISTOR
2SA2119K DTC114EKA-T146 (EXCEPT CND)
< RESISTOR > R101 R102 R103 R104 R105
1-216-837-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
22K 0 0 0 0
R106 R107 R108 R109 R112
1-216-864-11 1-216-864-11 1-216-835-11 1-216-864-11 1-216-851-11
SHORT CHIP SHORT CHIP METAL CHIP SHORT CHIP METAL CHIP
0 0 15K 0 330K
R113 R116 R117 R118 R119
1-216-841-11 1-216-830-11 1-216-864-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP
47K 5.6K 0 (CND) 0 (CND) 0 (CND)
R120 R121 R122 R124 R125
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-809-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP METAL CHIP
0 (EXCEPT CND) 0 (EXCEPT CND) 0 0 (EXCEPT CND) 100 5% 1/10W (EXCEPT CND)
R126
1-216-809-11
METAL CHIP
100
5%
R127 R128 R130 R131
1-216-295-00 1-216-813-11 1-216-845-11 1-216-833-11
SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
1/10W (EXCEPT CND) 0 (EXCEPT CND) 220 5% 1/10W 100K 5% 1/10W 10K 5% 1/10W
R133 R134 R135 R136 R137
1-216-833-11 1-216-857-11 1-216-821-11 1-216-295-00 1-216-857-11
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP METAL CHIP
10K 1M 1K 0 1M
5% 5% 5%
1/10W 1/10W 1/10W
5%
1/10W
DIODE DZ2J036M0L (EXCEPT CND) DIODE DZ2J036M0L (EXCEPT CND)
R138 R139 R140
1-216-857-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP
1M 100 100
5% 5% 5%
< EARTH TERMINAL >
R141
1-216-809-11
METAL CHIP
100
EARTH TERMINAL EARTH TERMINAL
R142
1-216-805-11
METAL CHIP
47
1/10W 1/10W 1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND) 5% 1/10W
R143 R144 R145 R146 R147
1-216-845-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 100K 100K 10K
5% 5% 5% 5% 5%
0.1uF 0.1uF 0.1uF 0.1uF
10V 10V 10V 25V 25V
25V (EXCEPT CND) 10% 16V 10% 16V 10% 16V 10% 16V (EXCEPT CND)
< CONNECTOR > CN201 CN301 CN401 CN402
1-815-763-32 1-770-470-21 1-779-993-11 1-764-250-11
CN501
1-794-341-41
CONNECTOR, FFC/FPC 24P PIN, CONNECTOR (PC BOARD) 6P PIN, CONNECTOR (PWB) 5P PIN, CONNECTOR (PC BOARD) 4P (EXCEPT CND) CONNECTOR, FFC/FPC 27P (EXCEPT CND)
CN502
1-820-117-41
CONNECTOR, FFC/FPC 19P (CND)
5%
1/10W
5%
1/10W
5%
1/10W
5% 5%
1/10W 1/10W
< DIODE > D401 D403
ET501 ET504
6-503-009-01 6-503-009-01
1-780-482-11 1-780-482-11
< IC > IC101 IC102 IC201
6-712-082-01 6-714-504-01 6-703-636-01
IC TC94A70FG-101 IC MM3404A15URE IC NJM13403V (TE2)
1/10W 1/10W 1/10W 1/10W 1/10W
61
HCD-MX500i/MX550i BD96/BD96U Ref. No.
Part No.
Description
R148
1-216-833-11
METAL CHIP
10K
Remark
Ref. No.
Part No.
Description
1/10W (CND) 1/10W 1/10W 1/10W
R408
1-216-845-11
METAL CHIP
R149 R150 R151 R152
1-216-845-11 1-216-845-11 1-216-809-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
100K 5% 100K 5% 100 5% 0 (EXCEPT CND)
R409
1-216-833-11
METAL CHIP
R410 R411
1-216-864-11 1-216-829-11
SHORT CHIP METAL CHIP
R153
1-216-833-11
METAL CHIP
10K
5%
R412
1-216-829-11
METAL CHIP
5% 5% 5% 5%
1/10W (CND) 1/10W 1/10W 1/10W 1/10W
R154 R155 R156 R157
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100
R413
1-216-802-11
R414
R158 R159 R201 R202 R203
1-216-809-11 1-216-809-11 1-218-446-11 1-216-791-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
100 100 1 3.3 0
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
R204 R205 R206 R207 R208
1-216-845-11 1-216-809-11 1-218-871-11 1-218-871-11 1-218-871-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100 10K 10K 10K
5% 5% 0.5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R209 R210 R211 R212 R213
1-218-871-11 1-218-871-11 1-216-821-11 1-216-821-11 1-218-871-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 1K 1K 10K
0.5% 0.5% 5% 5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R214 R215 R216 R217 R218
1-218-871-11 1-218-871-11 1-218-871-11 1-218-871-11 1-218-871-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
0.5% 0.5% 0.5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R219 R220 R221 R222 R223
1-218-871-11 1-218-871-11 1-218-871-11 1-218-871-11 1-218-871-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
0.5% 0.5% 0.5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R224 R225 R226 R227 R228
1-218-871-11 1-218-871-11 1-218-871-11 1-218-871-11 1-218-871-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 10K
0.5% 0.5% 0.5% 0.5% 0.5%
R229 R230 R231 R302 R305
1-218-871-11 1-218-871-11 1-218-871-11 1-216-833-11 1-216-835-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 15K
0.5% 0.5% 0.5% 5% 5%
R306 R308 R311 R314 R316
1-216-864-11 1-216-840-11 1-216-833-11 1-216-864-11 1-216-841-11
SHORT CHIP METAL CHIP METAL CHIP SHORT CHIP METAL CHIP
0 39K 10K 0 47K
R401 R402 R403
1-216-864-11 1-216-864-11 1-216-835-11
SHORT CHIP SHORT CHIP METAL CHIP
R404
1-216-835-11
METAL CHIP
R407
1-216-833-11
METAL CHIP
0 (EXCEPT CND) 0 (EXCEPT CND) 15K 5% 1/10W (EXCEPT CND) 15K 5% 1/10W (EXCEPT CND) 10K 5% 1/10W (EXCEPT CND)
62
5%
Remark 100K
5%
METAL CHIP
27
5%
1-216-802-11
METAL CHIP
27
5%
R415
1-216-833-11
METAL CHIP
10K
5%
R416
1-216-809-11
METAL CHIP
100
5%
R418
1-216-809-11
METAL CHIP
100
5%
R419 R420
1-216-864-11 1-216-809-11
SHORT CHIP METAL CHIP
R421
1-216-829-11
METAL CHIP
R422
1-216-833-11
METAL CHIP
R425
1-216-845-11
METAL CHIP
0 (EXCEPT CND) 100 5% 1/10W (EXCEPT CND) 4.7K 5% 1/10W (EXCEPT CND) 10K 5% 1/10W (EXCEPT CND) 100K 5% 1/10W (EXCEPT CND)
R430
1-216-829-11
METAL CHIP
4.7K
5%
R431
1-216-829-11
METAL CHIP
4.7K
5%
R432
1-216-845-11
METAL CHIP
100K
5%
R433
1-216-829-11
METAL CHIP
4.7K
5%
R434
1-216-845-11
METAL CHIP
100K
5%
R435
1-216-829-11
METAL CHIP
4.7K
5%
1/10W 1/10W 1/10W 1/10W 1/10W
R436
1-216-845-11
METAL CHIP
100K
5%
R437
1-216-829-11
METAL CHIP
4.7K
5%
R438
1-216-845-11
METAL CHIP
100K
5%
1/10W 1/10W 1/10W 1/10W 1/10W
R439
1-216-829-11
METAL CHIP
4.7K
5%
R440
1-216-833-11
METAL CHIP
10K
5%
R441
1-216-833-11
METAL CHIP
10K
5%
R442
1-216-809-11
METAL CHIP
100
5%
R443
1-216-809-11
METAL CHIP
100
5%
R444
1-216-809-11
METAL CHIP
100
5%
R445
1-216-809-11
METAL CHIP
100
5%
R446
1-216-809-11
METAL CHIP
100
R447
1-216-809-11
METAL CHIP
100
R448
1-216-809-11
METAL CHIP
100
5% 5%
1/10W 1/10W
5%
1/10W
1/10W (EXCEPT CND) 10K 5% 1/10W (EXCEPT CND) 0 (EXCEPT CND) 4.7K 5% 1/10W (EXCEPT CND) 4.7K 5% 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND)
1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND)
1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND)
HCD-MX500i/MX550i BD96/BD96U Ref. No.
Part No.
Description
R449
1-216-805-11
METAL CHIP
47
5%
1/10W (EXCEPT CND)
Remark
R450
1-216-805-11
METAL CHIP
47
5%
R451
1-216-805-11
METAL CHIP
47
5%
R452
1-216-805-11
METAL CHIP
47
5%
R453
1-216-805-11
METAL CHIP
47
5%
R454
1-216-805-11
METAL CHIP
47
5%
1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND)
R455
1-216-805-11
METAL CHIP
47
5%
R456
1-216-805-11
METAL CHIP
R457
1-216-809-11
METAL CHIP
R458
1-216-809-11
METAL CHIP
R459
1-216-295-00
SHORT CHIP
1/10W (EXCEPT CND) 47 5% 1/10W (EXCEPT CND) 100 5% 1/10W (EXCEPT CND) 100 5% 1/10W (EXCEPT CND) 0 (EXCEPT CND)
R463
1-216-805-11
METAL CHIP
47
5%
R464
1-216-805-11
METAL CHIP
47
5%
R465
1-216-805-11
METAL CHIP
47
5%
R466
1-216-805-11
METAL CHIP
47
5%
R467
1-216-805-11
METAL CHIP
47
5%
R468
1-216-805-11
METAL CHIP
47
5%
R469
1-216-805-11
METAL CHIP
47
R470
1-216-805-11
METAL CHIP
47
R471
1-216-833-11
METAL CHIP
10K
R472
1-216-864-11
SHORT CHIP
0 (CND)
R473 R474 R475 R476 R477
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 (CND) 0 (CND) 0 (CND) 0 (CND) 0 (CND)
R478 R479
1-216-864-11 1-216-821-11
SHORT CHIP METAL CHIP
0 (CND) 1K
R480
1-216-833-11
METAL CHIP
10K
R481
1-216-845-11
METAL CHIP
100K
R501
1-216-295-00
SHORT CHIP
0
R502 R503 R504 R505 R506
1-216-295-00 1-216-295-00 1-216-809-11 1-216-809-11 1-216-809-11
SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
0 0 100 100 100
5% 5% 5%
1/10W 1/10W 1/10W
R507 R508 R509 R510 R511
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND)
1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND)
Ref. No.
DAB
Part No.
Description
R512 R513 R514 R515
1-216-809-11 1-216-809-11 1-216-809-11 1-216-295-00
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
100 100 100 0
5% 5% 5%
1/10W 1/10W 1/10W
Remark
R516
1-216-809-11
METAL CHIP
100
5%
(EXCEPT CND) 1/10W (EXCEPT CND)
R518
1-216-809-11
METAL CHIP
100
5%
R519
1-216-809-11
METAL CHIP
100
R520
1-216-809-11
METAL CHIP
100
R521
1-216-809-11
METAL CHIP
100
1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND)
< VIBRATOR > X101 1-795-101-21 VIBRATOR, CERAMIC (16.934MHz) X401 1-814-400-11 QUARTZ CRYSTAL UNITS (9MHz) (EXCEPT CND) ************************************************************ DAB BOARD (MX550i) ********* < CAPACITOR > C672 C673 C674 C675 C677
1-127-715-11 1-162-970-11 1-165-908-11 1-107-826-11 1-165-908-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.22uF 0.01uF 1uF 0.1uF 1uF
10% 10% 10% 10% 10%
16V 25V 10V 16V 10V
C678 C679 C681 C682 C683
1-165-908-11 1-165-908-11 1-107-826-11 1-124-584-00 1-162-915-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
1uF 1uF 0.1uF 100uF 10PF
10% 10% 10% 20% 0.5PF
10V 10V 16V 6.3V 50V
C684 C685 C686 C688 C689
1-162-923-11 1-162-915-11 1-162-923-11 1-162-915-11 1-162-923-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
47PF 10PF 47PF 10PF 47PF
5% 0.5PF 5% 0.5PF 5%
50V 50V 50V 50V 50V
C690 C691
1-162-915-11 1-162-923-11
CERAMIC CHIP 10PF CERAMIC CHIP 47PF
0.5PF 5%
50V 50V
< CONNECTOR > 5%
1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND)
CN671 CN672
1-779-277-11 1-821-719-11
CONNECTOR, FFC (LIF (NON-ZIF)) 9P P.W.B CONNECTOR 30P < JUMPER RESISTOR >
FB671
1-216-864-11
SHORT CHIP
0
< IC > IC671 IC672
6-702-302-01 6-712-613-01
IC TK11133CSCL-G IC SI-3010KM-TLS < RESISTOR >
R672 R673 R675 R676 R677
1-216-833-11 1-216-809-11 1-216-841-11 1-216-821-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 100 47K 1K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R678
1-216-821-11
METAL CHIP
1K
5%
1/10W
63
HCD-MX500i/MX550i DAB Ref. No.
FL
IP
Part No.
Description
Remark
R679 1-216-833-11 METAL CHIP 10K 5% 1/10W R680 1-216-809-11 METAL CHIP 100 5% 1/10W R681 1-216-864-11 SHORT CHIP 0 ************************************************************ FL BOARD ********
Ref. No.
Part No.
Description
R626 R627
1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP
100 100
5% 5%
1/10W 1/10W
Remark
R628 R629 R630 R631 R632
1-216-827-11 1-216-821-11 1-216-864-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP
3.3K 1K 0 0 0
5% 5%
1/10W 1/10W
R633 R634 R635 R638 R639
1-216-837-11 1-216-837-11 1-216-805-11 1-216-825-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 22K 47 2.2K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R640 R641
1-216-833-11 1-216-829-11
METAL CHIP METAL CHIP
10K 4.7K
5% 5%
1/10W 1/10W
< CAPACITOR > C621 C623 C625 C626 C627
1-124-234-00 1-136-157-00 1-162-974-11 1-128-131-11 1-162-974-11
ELECT FILM CERAMIC CHIP ELECT CERAMIC CHIP
22uF 0.022uF 0.01uF 22uF 0.01uF
20% 5%
C628 C629 C631 C632 C633
1-162-974-11 1-162-974-11 1-162-923-11 1-162-964-11 1-162-927-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.01uF 0.01uF 47PF 0.001uF 100PF
5% 10% 5%
50V 50V 50V 50V 50V
C634 C635 C636 C637 C640
1-162-927-11 1-162-927-11 1-124-234-00 1-128-131-11 1-162-970-11
CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP
100PF 100PF 22uF 22uF 0.01uF
5% 5% 20% 20% 10%
50V 50V 16V 50V 25V
C641 C642 C645 C646
1-107-826-11 1-165-908-11 1-125-972-11 1-127-573-11
CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
0.1uF 1uF 100uF 1uF
10% 10% 20% 10%
16V 10V 16V 16V
20%
16V 50V 50V 50V 50V
< ROTARY ENCODER > RV621
1-418-725-41
< TRANSFORMER > T621 1-445-890-11 TRANSFORMER, DC-DC CONVERTER ************************************************************ A-1760-782-A
< CONNECTOR > CN621 CN622
1-779-550-21 1-564-720-11
CONNECTOR, FFC (LIF (NON-ZIF)) 13P PIN, CONNECTOR (SMALL TYPE) 4P < DIODE >
D621 D622 D623
6-500-334-01 6-500-335-01 6-502-968-01
DIODE MC2836-T112-1 DIODE MC2838-T112-1 DIODE DZ2J062M0L
1-216-295-00
SHORT CHIP
IP BOARD, COMPLETE ****************** < CAPACITOR >
C331 C332 C333 C334 C335
1-164-870-11 1-164-854-11 1-164-870-11 1-164-854-11 1-164-870-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
68PF 15PF 68PF 15PF 68PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C336 C339 C340 C342 C343
1-164-854-11 1-164-870-11 1-164-854-11 1-165-989-11 1-116-344-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
15PF 68PF 15PF 10uF 330uF
5% 5% 5% 10% 20%
50V 50V 50V 6.3V 6.3V
< CONNECTOR >
< JUMPER RESISTOR > FB621
ENCODER, ROTARY (12 TYPE) (VOLUME)
CN331 CN332
0
1-784-865-51 1-820-701-11
CONNECTOR, FFC (LIF (NON-ZIF)) 13P PIN, CONNECTOR 30P (iPod/iPhone Dock)
< IC > < RESISTOR/FERRITE BEAD > IC621 IC622
6-711-008-01 6-600-767-01
IC PT6302LQ-010 IC PNA4823M02S0 < COIL >
L621
1-412-537-31
INDUCTOR
100uH
< FLUORESCENT INDICATOR TUBE > ND621
1-519-993-21
INDICATOR TUBE, FLUORESCENT < TRANSISTOR >
Q621 Q622 Q623
6-550-065-01 8-729-620-07 8-729-027-38
TRANSISTOR TRANSISTOR TRANSISTOR
CPH5504-TL-E 2SC3052EF-T1-LEF DTA144EKA-T146
< RESISTOR > R621 R622 R625
64
1-216-789-11 1-216-825-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP
2.2 2.2K 10K
5% 5% 5%
1/10W 1/10W 1/10W
R331 R332 R333 R334 R335
1-218-892-11 1-208-935-11 1-208-935-11 1-218-892-11 1-208-935-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
75K 100K 100K 75K 100K
0.5% 0.5% 0.5% 0.5% 0.5%
1/10W 1/16W 1/16W 1/10W 1/16W
R336 R337 R338 R339 R390
1-208-935-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
100K 0 0 0 0
0.5%
1/16W
R391 R392 R393 R394 R395
1-400-050-11 1-400-050-11 1-216-864-11 1-216-864-11 1-216-864-11
INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD SHORT CHIP 0 SHORT CHIP 0 SHORT CHIP 0
R396 R397 R398
1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0
HCD-MX500i/MX550i IP Ref. No.
Part No.
Description
Remark
R399 1-216-864-11 SHORT CHIP 0 ************************************************************ JACK BOARD ********** < CAPACITOR > C155 C156 C255 C256 C302
1-162-923-11 1-162-915-11 1-162-923-11 1-162-915-11 1-164-360-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
47PF 10PF 47PF 10PF 0.1uF
5% 0.5PF 5% 0.5PF
50V 50V 50V 50V 16V
< DIODE > D302
6-500-848-01
DIODE MC2840-T112-1
Ref. No.
1-815-629-21
1-216-864-11
Part No.
Description
1-762-875-21
S625
1-771-410-21
SWITCH, KEYBOARD (lm TUNE –) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE (lm TUNE –) (CH, SP)
S626
1-762-875-21
S626 S627
1-771-410-21 1-762-875-21
S627 S628
1-771-410-21 1-762-875-21
S628 S629
1-771-410-21 1-762-875-21
S629 S630
1-771-410-21 1-762-875-21
S630
1-771-410-21
S631
1-762-875-21
SHORT CHIP
0
R160 1-216-821-11 METAL CHIP 1K 5% 1/10W R260 1-216-821-11 METAL CHIP 1K 5% 1/10W R302 1-414-385-21 INDUCTOR, FERRITE BEAD R303 1-216-864-11 SHORT CHIP 0 ************************************************************
A-1760-771-A A-1760-784-A A-1760-905-A A-1783-490-A
KEY BOARD *********
SWITCH, KEYBOARD (ML TUNE +) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE (ML TUNE +) (CH, SP) SWITCH, KEYBOARD (DSGX) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE (DSGX) (CH, SP) SWITCH, KEYBOARD (TOOL MENU) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE (TOOL MENU) (CH, SP) SWITCH, KEYBOARD ( + v) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE ( + v) (CH, SP) SWITCH, KEYBOARD (ENTER) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE (ENTER) (CH, SP)
MAIN BOARD, COMPLETE (MX500i: AEP) MAIN BOARD, COMPLETE (CND) MAIN BOARD, COMPLETE (MX550i) MAIN BOARD, COMPLETE (CH, SP) ******************** < CAPACITOR >
LED SLR-325VCT31P (STANDBY)
C101 C104 C105
1-165-908-11 1-165-908-11 1-164-230-11
CERAMIC CHIP 1uF CERAMIC CHIP 1uF CERAMIC CHIP 220PF
10% 10% 5%
< RESISTOR >
C106
1-164-230-11
CERAMIC CHIP 220PF
5%
C107
1-124-779-00
ELECT CHIP
10uF
20%
C108 C109
1-124-779-00 1-126-193-11
ELECT CHIP ELECT CHIP
10uF 1uF
20% 20%
C117 C118 C120
1-124-779-00 1-164-173-11 1-136-498-81
ELECT CHIP 10uF CERAMIC CHIP 0.0039uF FILM 0.12uF
20% 10% 5%
16V 50V (MX550i) 16V 50V 50V
C121 C124 C125 C126 C129
1-136-498-81 1-124-779-00 1-126-960-11 1-126-193-11 1-164-230-11
FILM ELECT CHIP ELECT ELECT CHIP CERAMIC CHIP
0.12uF 10uF 1uF 1uF 220PF
5% 20% 20% 20% 5%
50V 16V 50V 50V 50V
C130 C140 C141
1-164-230-11 1-162-970-11 1-164-230-11
CERAMIC CHIP 220PF CERAMIC CHIP 0.01uF CERAMIC CHIP 220PF
5% 10% 5%
C143
1-126-193-11
ELECT CHIP
1uF
20%
C144
1-126-193-11
ELECT CHIP
1uF
20%
50V 25V 50V (MX550i) 50V (MX550i) 50V (MX550i)
C146
1-126-193-11
ELECT CHIP
1uF
20%
C161 C162 C163
1-164-854-11 1-164-870-11 1-164-854-11
CERAMIC CHIP 15PF CERAMIC CHIP 68PF CERAMIC CHIP 15PF
< LED > 6-501-483-01
Remark
SWITCH, KEYBOARD (V –) (MX500i: CND, AEP/MX550i) –) (CH, SP) S631 1-771-410-21 SWITCH, TACTILE (V S632 1-762-875-21 SWITCH, KEYBOARD (Z) (MX500i: CND, AEP/MX550i) S632 1-771-410-21 SWITCH, TACTILE (Z) (CH, SP) ************************************************************
< RESISTOR/FERRITE BEAD >
D624
MAIN
JACK (AUDIO IN) < JUMPER RESISTOR >
JR301
KEY
S625
< JACK > J302
JACK
R637 R642 R643 R644 R645
1-216-817-11 1-216-821-11 1-216-825-11 1-216-825-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 1K 2.2K 2.2K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R646 R647 R648 R649 R650
1-216-833-11 1-216-821-11 1-216-825-11 1-216-825-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 1K 2.2K 2.2K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R651
1-216-833-11
METAL CHIP
10K
5%
1/10W
10V 10V 50V (MX550i) 50V (MX550i) 16V
< SWITCH > S621
1-762-875-21
S621 S622
1-771-410-21 1-762-875-21
S622 S623
1-771-410-21 1-762-875-21
S623 S624
1-771-410-21 1-762-875-21
S624
1-771-410-21
SWITCH, KEYBOARD (I/1) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE (I/1) (CH, SP) SWITCH, KEYBOARD (FUNCTION) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE (FUNCTION) (CH, SP) SWITCH, KEYBOARD (u) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE (u) (CH, SP) SWITCH, KEYBOARD (x) (MX500i: CND, AEP/MX550i) SWITCH, TACTILE (x) (CH, SP)
5% 5% 5%
50V (MX550i) 50V 50V 50V
65
HCD-MX500i/MX550i MAIN Ref. No.
Part No.
Description
Part No.
Description
C164
1-164-870-11
CERAMIC CHIP 68PF
5%
50V
C252
1-107-826-11
CERAMIC CHIP 0.1uF
10%
C165 C166 C167
1-164-854-11 1-164-870-11 1-164-854-11
CERAMIC CHIP 15PF CERAMIC CHIP 68PF CERAMIC CHIP 15PF
5% 5% 5%
C254
1-165-908-11
CERAMIC CHIP 1uF
10%
C168
1-164-870-11
CERAMIC CHIP 68PF
5%
C261 C262 C263
1-164-854-11 1-164-870-11 1-164-854-11
CERAMIC CHIP 15PF CERAMIC CHIP 68PF CERAMIC CHIP 15PF
5% 5% 5%
C169
1-164-854-11
CERAMIC CHIP 15PF
5%
50V 50V 50V (MX550i) 50V (MX550i) 50V
C170 C171 C172 C173 C174
1-164-870-11 1-164-854-11 1-164-870-11 1-164-854-11 1-164-870-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
68PF 15PF 68PF 15PF 68PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C264 C265 C266 C267
1-164-870-11 1-164-854-11 1-164-870-11 1-164-854-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
68PF 15PF 68PF 15PF
5% 5% 5% 5%
C268
1-164-870-11
CERAMIC CHIP 68PF
5%
C181 C182 C183 C184 C185
1-164-854-11 1-164-870-11 1-164-854-11 1-164-870-11 1-164-854-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
15PF 68PF 15PF 68PF 15PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C269 C270 C271 C272 C273
1-164-854-11 1-164-870-11 1-164-854-11 1-164-870-11 1-164-854-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
15PF 68PF 15PF 68PF 15PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C186 C187
1-164-870-11 1-164-854-11
CERAMIC CHIP 68PF CERAMIC CHIP 15PF
5% 5%
C188
1-164-870-11
CERAMIC CHIP 68PF
5%
C274 C281 C282 C283 C284
1-164-870-11 1-164-854-11 1-164-870-11 1-164-854-11 1-164-870-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
68PF 15PF 68PF 15PF 68PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C189
1-164-854-11
CERAMIC CHIP 15PF
5%
C190
1-164-870-11
CERAMIC CHIP 68PF
5%
50V 50V (MX550i) 50V (MX550i) 50V (MX550i) 50V (MX550i)
C285 C286 C287
1-164-854-11 1-164-870-11 1-164-854-11
CERAMIC CHIP 15PF CERAMIC CHIP 68PF CERAMIC CHIP 15PF
5% 5% 5%
C191
1-164-854-11
CERAMIC CHIP 15PF
5%
C288
1-164-870-11
CERAMIC CHIP 68PF
5%
C192
1-164-870-11
CERAMIC CHIP 68PF
5%
C289
1-164-854-11
CERAMIC CHIP 15PF
5%
C193 C194 C201
1-164-854-11 1-164-870-11 1-165-908-11
CERAMIC CHIP 15PF CERAMIC CHIP 68PF CERAMIC CHIP 1uF
5% 5% 10%
50V (MX550i) 50V (MX550i) 50V 50V 10V
50V 50V 50V (MX550i) 50V (MX550i) 50V (MX550i)
C290
1-164-870-11
CERAMIC CHIP 68PF
5%
C291
1-164-854-11
CERAMIC CHIP 15PF
5%
C204 C205
1-165-908-11 1-164-230-11
CERAMIC CHIP 1uF CERAMIC CHIP 220PF
10% 5%
C292
1-164-870-11
CERAMIC CHIP 68PF
5%
C206
1-164-230-11
CERAMIC CHIP 220PF
5%
C293 C294
1-164-854-11 1-164-870-11
CERAMIC CHIP 15PF CERAMIC CHIP 68PF
5% 5%
50V (MX550i) 50V (MX550i) 50V (MX550i) 50V 50V
C207 C208
1-124-779-00 1-124-779-00
ELECT CHIP ELECT CHIP
10uF 10uF
20% 20%
C209
1-126-193-11
ELECT CHIP
1uF
20%
C217 C218 C220 C221
1-124-779-00 1-164-173-11 1-136-498-81 1-136-498-81
ELECT CHIP CERAMIC CHIP FILM FILM
10uF 0.0039uF 0.12uF 0.12uF
20% 10% 5% 5%
50V (MX550i) 16V 50V 50V 50V
C401 C402 C403 C406 C408
1-165-908-11 1-165-908-11 1-162-970-11 1-124-779-00 1-107-826-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP
1uF 1uF 0.01uF 10uF 0.1uF
10% 10% 10% 20% 10%
10V 10V 25V 16V 16V
C224 C225 C226 C229 C230
1-124-779-00 1-126-960-11 1-126-193-11 1-164-230-11 1-164-230-11
ELECT CHIP ELECT ELECT CHIP CERAMIC CHIP CERAMIC CHIP
10uF 1uF 1uF 220PF 220PF
20% 20% 20% 5% 5%
16V 50V 50V 50V 50V
C409 C412 C416 C418 C419
1-107-826-11 1-107-826-11 1-107-826-11 1-125-837-11 1-125-837-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 1uF 1uF
10% 10% 10% 10% 10%
16V 16V 16V 6.3V 6.3V
C240 C241
1-162-970-11 1-164-230-11
CERAMIC CHIP 0.01uF CERAMIC CHIP 220PF
10% 5%
1-162-927-11 1-162-966-11 1-125-837-11 1-165-908-11 1-162-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100PF 0.0022uF 1uF 1uF 0.001uF
5% 10% 10% 10% 10%
50V 50V 6.3V 10V 50V
C242
1-126-193-11
ELECT CHIP
1uF
20%
C246
1-126-193-11
ELECT CHIP
1uF
20%
C247
1-126-193-11
ELECT CHIP
1uF
20%
25V 50V (MX550i) 50V (MX550i) 50V (MX550i) 50V (MX550i)
C420 C421 C422 C423 C424 C425 C466 C467 C468 C469
1-165-908-11 1-165-908-11 1-162-927-11 1-162-927-11 1-127-573-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1uF 1uF 100PF 100PF 1uF
10% 10% 5% 5% 10%
10V 10V 50V 50V 16V
C470 C471
1-165-908-11 1-107-826-11
CERAMIC CHIP 1uF CERAMIC CHIP 0.1uF
10% 10%
10V 16V
66
Remark
10V 50V (MX550i) 50V (MX550i) 16V 16V
Ref. No.
Remark 16V (MX550i) 10V (MX550i) 50V 50V 50V 50V 50V 50V 50V (MX550i) 50V (MX550i)
HCD-MX500i/MX550i MAIN Ref. No.
Part No.
Description
C472 C473 C474
1-162-970-11 1-164-854-11 1-164-870-11
CERAMIC CHIP 0.01uF CERAMIC CHIP 15PF CERAMIC CHIP 68PF
10% 5% 5%
Remark
C475
1-164-854-11
CERAMIC CHIP 15PF
5%
C476
1-164-870-11
CERAMIC CHIP 68PF
C477 C478 C479
1-162-970-11 1-107-826-11 1-107-826-11
CERAMIC CHIP 0.01uF CERAMIC CHIP 0.1uF CERAMIC CHIP 0.1uF
50V (EXCEPT CND) 5% 50V (EXCEPT CND) 10% 25V 10% 16V 10% 16V
C480 C481 C482 C483 C484
1-107-826-11 1-164-854-11 1-164-870-11 1-164-854-11 1-164-870-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 15PF 68PF 15PF 68PF
10% 5% 5% 5% 5%
16V 50V 50V 50V 50V
C485 C486 C487 C488 C489
1-164-854-11 1-164-870-11 1-164-854-11 1-164-870-11 1-164-854-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
15PF 68PF 15PF 68PF 15PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C490 C491 C492 C493 C494
1-164-870-11 1-164-854-11 1-164-870-11 1-164-854-11 1-164-870-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
68PF 15PF 68PF 15PF 68PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C495
1-165-908-11
CERAMIC CHIP 1uF
10%
C498 C499 C500 C501
1-107-826-11 1-107-826-11 1-107-826-11 1-117-748-81
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 10PF
10% 10% 10% 0.1PF
10V (MX550i) 16V 16V 16V 16V
C502 C503 C504 C505 C506
1-117-748-81 1-128-994-21 1-107-826-11 1-107-826-11 1-128-398-11
CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP
10PF 47uF 0.1uF 0.1uF 220uF
0.1PF 20% 10% 10% 20%
16V 10V 16V 16V 16V
C509 C510 C511 C515 C516
1-165-908-11 1-162-918-11 1-162-918-11 1-128-398-11 1-164-156-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP
1uF 18PF 18PF 220uF 0.1uF
10% 5% 5% 20%
10V 50V 50V 16V 25V
C517 C518 C519 C520 C521
1-128-394-11 1-112-717-91 1-165-908-11 1-165-908-11 1-165-908-11
ELECT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
220uF 1uF 1uF 1uF 1uF
20% 10V 10% 6.3V 10% 10V 10% 10V 10% 10V (EXCEPT CND)
C522 C523 C524
1-165-908-11 1-165-908-11 1-165-908-11
CERAMIC CHIP 1uF CERAMIC CHIP 1uF CERAMIC CHIP 1uF
C525 C526
1-216-864-11 1-107-826-11
SHORT CHIP 0 CERAMIC CHIP 0.1uF
C527 C528 C529 C530 C532
1-126-925-91 1-107-826-11 1-107-826-11 1-107-826-11 1-164-360-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
C533 C534 C535
1-107-826-11 1-126-933-11 1-107-826-11
25V 50V 50V
10% 10V 10% 10V 10% 10V (EXCEPT CND) 10%
16V
470uF 0.1uF 0.1uF 0.1uF 0.1uF
20% 10% 10% 10%
10V 16V 16V 16V 16V
CERAMIC CHIP 0.1uF ELECT 100uF CERAMIC CHIP 0.1uF
10% 20% 10%
16V 16V 16V
Ref. No.
Part No.
Description
C536 C540
1-165-908-11 1-107-826-11
CERAMIC CHIP 1uF CERAMIC CHIP 0.1uF
10% 10%
Remark
C543
1-162-927-11
CERAMIC CHIP 100PF
5%
C544
1-162-927-11
CERAMIC CHIP 100PF
C545
1-162-927-11
CERAMIC CHIP 100PF
C546
1-162-927-11
CERAMIC CHIP 100PF
C547
1-124-779-00
ELECT CHIP
10uF
50V (EXCEPT CND) 5% 50V (EXCEPT CND) 5% 50V (EXCEPT CND) 5% 50V (EXCEPT CND) 20% 16V
C551 C563 C564 C565 C566
1-107-826-11 1-100-567-81 1-165-908-11 1-107-826-11 1-107-826-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.01uF 1uF 0.1uF 0.1uF
10% 10% 10% 10% 10%
C567 C568 C569 C570
1-104-658-91 1-126-933-11 1-162-970-11 1-162-970-11
ELECT ELECT CERAMIC CHIP CERAMIC CHIP
100uF 100uF 0.01uF 0.01uF
C571
1-125-889-11
CERAMIC CHIP 2.2uF
20% 10V 20% 16V 10% 25V 10% 25V (EXCEPT CND) 10% 10V (EXCEPT CND)
C572
1-165-908-11
CERAMIC CHIP 1uF
C574 C575 C577 C578
1-125-889-11 1-165-908-11 1-124-779-00 1-126-933-11
CERAMIC CHIP CERAMIC CHIP ELECT CHIP ELECT
C579 C580 C581
1-128-995-21 1-126-933-11 1-107-826-11
ELECT CHIP 100uF ELECT 100uF CERAMIC CHIP 0.1uF
C582 C584
1-107-826-11 1-164-854-11
CERAMIC CHIP 0.1uF CERAMIC CHIP 15PF
20% 10V 20% 16V 10% 16V (EXCEPT CND) 10% 16V 5% 50V
C585 C586 C587 C590 C591
1-164-870-11 1-164-854-11 1-164-870-11 1-164-854-11 1-164-870-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
68PF 15PF 68PF 15PF 68PF
5% 5% 5% 5% 5%
50V 50V 50V 50V 50V
C592
1-164-854-11
CERAMIC CHIP 15PF
5%
C593
1-164-870-11
CERAMIC CHIP 68PF
5%
C594 C595 C596
1-164-854-11 1-164-870-11 1-164-854-11
CERAMIC CHIP 15PF CERAMIC CHIP 68PF CERAMIC CHIP 15PF
5% 5% 5%
50V (MX550i) 50V (MX550i) 50V 50V 50V
C597 C598 C599 C701 C703
1-164-870-11 1-164-854-11 1-164-870-11 1-126-193-11 1-162-970-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP
68PF 15PF 68PF 1uF 0.01uF
5% 5% 5% 20% 10%
50V 50V 50V 50V 25V
C704 C706 C707 C708 C709
1-162-964-11 1-107-826-11 1-137-807-31 1-137-807-31 1-137-807-31
CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT
0.001uF 0.1uF 100uF 100uF 100uF
10% 10% 20% 20% 20%
50V 16V 50V 50V 50V
C710 C712 C713 C718
1-137-807-31 1-107-826-11 1-115-185-11 1-115-185-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100uF 0.1uF 0.033uF 0.033uF
20% 10% 10% 10%
50V 16V 50V 50V
2.2uF 1uF 10uF 100uF
10V 16V
16V 25V 10V 16V 16V
10% 10V (EXCEPT CND) 10% 10V 10% 10V 20% 16V 20% 16V (EXCEPT CND)
67
HCD-MX500i/MX550i MAIN Ref. No.
Part No.
Description
Part No.
Description
C719
1-114-994-11
ELECT
2200uF
20%
35V
C792
1-107-826-11
CERAMIC CHIP 0.1uF
10%
16V
C720 C721 C722 C723 C724
1-131-704-11 1-165-908-11 1-162-966-11 1-162-966-11 1-162-966-11
FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1uF 1uF 0.0022uF 0.0022uF 0.0022uF
5% 10% 10% 10% 10%
50V 10V 50V 50V 50V
C793 C794 C795 C796 C797
1-165-908-11 1-125-837-11 1-165-908-11 1-107-826-11 1-107-826-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1uF 1uF 1uF 0.1uF 0.1uF
10% 10% 10% 10% 10%
10V 6.3V 10V 16V 16V
C725 C726 C727 C728 C729
1-162-966-11 1-125-838-11 1-165-908-11 1-131-704-11 1-126-949-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP FILM ELECT
0.0022uF 2.2uF 1uF 1uF 220uF
10% 10% 10% 5% 20%
50V 6.3V 10V 50V 35V
C798 C799 C801 C804 C806
1-165-722-11 1-165-908-11 1-162-970-11 1-162-964-11 1-107-826-11
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
100uF 1uF 0.01uF 0.001uF 0.1uF
20% 10% 10% 10% 10%
10V 10V 25V 50V 16V
C731 C733 C734 C735 C736
1-165-492-21 1-107-826-11 1-107-826-11 1-126-964-11 1-126-601-11
ELECT CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CHIP
100uF 0.1uF 0.1uF 10uF 2.2uF
20% 10% 10% 20% 20%
10V 16V 16V 50V 50V
C807 C808 C809 C820 C821
1-162-927-11 1-162-927-11 1-162-927-11 1-126-964-11 1-115-339-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
100PF 100PF 100PF 10uF 0.1uF
5% 5% 5% 20% 10%
50V 50V 50V 50V 50V
C737 C738 C739 C740 C741
1-162-968-11 1-124-779-00 1-165-908-11 1-137-649-31 1-107-826-11
CERAMIC CHIP ELECT CHIP CERAMIC CHIP ELECT CERAMIC CHIP
0.0047uF 10uF 1uF 220uF 0.1uF
10% 20% 10% 20% 10%
50V 16V 10V 10V 16V
C822 C823 C824 C825 C826
1-162-966-11 1-162-966-11 1-162-966-11 1-162-966-11 1-162-966-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.0022uF 0.0022uF 0.0022uF 0.0022uF 0.0022uF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C744 C745 C746 C747 C751
1-125-891-11 1-107-826-11 1-107-826-11 1-104-658-91 1-126-193-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CHIP
0.47uF 0.1uF 0.1uF 100uF 1uF
10% 10% 10% 20% 20%
10V 16V 16V 10V 50V
C827 C828 C829 C844 C845
1-162-966-11 1-162-966-11 1-162-966-11 1-162-964-11 1-162-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.0022uF 0.0022uF 0.0022uF 0.001uF 0.001uF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C752 C753 C754 C756 C757
1-107-826-11 1-165-722-11 1-162-964-11 1-107-826-11 1-126-923-91
CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT
0.1uF 100uF 0.001uF 0.1uF 220uF
10% 20% 10% 10% 20%
16V 10V 50V 16V 10V
C846 C847 C856 C857 C863
1-162-964-11 1-162-964-11 1-107-826-11 1-165-908-11 1-107-826-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.001uF 0.001uF 0.1uF 1uF 0.1uF
10% 10% 10% 10% 10%
50V 50V 16V 10V 16V
C758 C759 C761 C762 C763
1-107-826-11 1-165-908-11 1-165-908-11 1-107-826-11 1-115-185-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 1uF 1uF 0.1uF 0.033uF
10% 10% 10% 10% 10%
16V 10V 10V 16V 50V
C764 C765 C766 C767 C768
1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-115-185-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.1uF 0.1uF 0.1uF 0.033uF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C769 C770 C771 C772 C773
1-114-994-11 1-131-704-11 1-162-970-11 1-162-966-11 1-162-966-11
ELECT FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
2200uF 1uF 0.01uF 0.0022uF 0.0022uF
20% 5% 10% 10% 10%
35V 50V 25V 50V 50V
C774 C775 C776 C777 C778
1-162-966-11 1-162-966-11 1-165-908-11 1-131-704-11 1-125-838-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP FILM CERAMIC CHIP
0.0022uF 0.0022uF 1uF 1uF 2.2uF
10% 10% 10% 5% 10%
50V 50V 10V 50V 6.3V
C779 C780 C781 C784 C785
1-165-908-11 1-165-908-11 1-137-649-31 1-162-911-11 1-162-910-11
CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
1uF 1uF 220uF 6PF 5PF
10% 10% 20% 0.5PF 0.25PF
10V 10V 10V 50V 50V
C786 C787 C788 C789
1-165-908-11 1-107-826-11 1-107-826-11 1-165-908-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1uF 0.1uF 0.1uF 1uF
10% 10% 10% 10%
10V 16V 16V 10V
68
Remark
Ref. No.
Remark
< CONNECTOR > CN401 CN402 CN403 CN405 CN406
1-779-277-11 1-564-706-11 1-779-281-11 1-784-770-11 1-568-830-11
CONNECTOR, FFC (LIF (NON-ZIF)) 9P PIN, CONNECTOR (SMALL TYPE) 4P CONNECTOR, FFC (LIF (NON-ZIF)) 13P CONNECTOR, FFC 9P (CND, CH, SP) CONNECTOR, FFC 11P (MX500i: AEP/MX550i)
CN407 CN408
1-779-277-11 1-779-295-11
CN409 CN410 * CN412
1-779-281-11 1-779-273-11 1-564-711-11
CONNECTOR, FFC (LIF (NON-ZIF)) 9P (MX550i) CONNECTOR, FFC (LIF (NON-ZIF)) 27P (EXCEPT CND) CONNECTOR, FFC (LIF (NON-ZIF)) 13P CONNECTOR, FFC (LIF (NON-ZIF)) 5P PIN, CONNECTOR (SMALL TYPE) 9P
CN415 CN417 CN702 CN703 CN704
1-779-287-11 1-564-705-11 1-819-131-11 1-819-130-11 1-819-132-11
CONNECTOR, FFC (LIF (NON-ZIF)) 19P (CND) PIN, CONNECTOR (SMALL TYPE) 3P PIN, CONNECTOR 3P PIN, CONNECTOR 2P PIN, CONNECTOR 4P < DIODE >
D501 D502 D503 D705 D706
6-502-961-01 6-502-961-01 6-502-961-01 6-501-696-01 6-501-696-01
DIODE DIODE DIODE DIODE DIODE
DA2J10100L DA2J10100L DA2J10100L RSA39LTE25 RSA39LTE25
D755 D765
6-501-696-01 6-501-696-01
DIODE RSA39LTE25 DIODE RSA39LTE25
HCD-MX500i/MX550i MAIN Ref. No.
Part No.
Description
Remark
< EARTH TERMINAL > * EP501 * EP701 * EP702 ET701 ET702
1-537-738-21 1-537-738-21 1-537-738-21 1-780-482-11 1-780-482-11
TERMINAL, EARTH TERMINAL, EARTH TERMINAL, EARTH EARTH TERMINAL EARTH TERMINAL < JUMPER RESISTER >
FB101 FB201 FB502 FB504 FB505
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 (MX550i) 0
FB506 FB507 FB508 FB509 FB510
1-216-864-11 1-216-864-11 1-216-296-11 1-216-296-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
FB511 FB512 FB513 FB514 FB515
1-216-864-11 1-216-295-00 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 (EXCEPT CND) 0
FB516 FB517 FB518 FB519 FB520
1-216-864-11 1-216-864-11 1-216-864-11 1-216-296-11 1-216-296-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 (MX550i) 0 0 0 (EXCEPT CND) 0 (EXCEPT CND)
FB521 FB522 FB523 FB524 FB534
1-216-296-11 1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 (MX550i) 0 (MX550i) 0
FB535 FB701 FB702 FB703 FB704
1-216-296-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
FB705 FB706
1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP
0 0
Ref. No.
Part No.
Description
IC703 IC704 IC705
6-701-261-01 6-702-302-01 6-705-979-01
IC MC74VHC74DTR2 IC TK11133CSCL-G IC CXD9788AR
Remark
IC707 IC709 IC710 IC711 IC712
6-713-634-01 6-701-189-01 6-713-034-01 6-715-392-01 6-714-743-01
IC IC IC IC IC
CXD9965TN MC74VHC1GU04DFT1 KIA7812API-U/PF AK5358BET-E2 MM3404A18URE
< COIL > L701 L702 L703 L704 L712
1-469-967-21 1-469-967-21 1-469-967-21 1-469-967-21 1-457-579-11
INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR
10uH 10uH 10uH 10uH 10uH
L721 L762
1-469-967-21 1-457-579-11
INDUCTOR INDUCTOR
10uH 10uH
< TRANSISTOR >
< IC > IC401
A-1784-237-A
IC401 IC401 IC402 IC405
A-1784-238-A A-1784-347-A 6-713-362-01 6-702-302-01
IC R5F364AEDFA (for SERVICE) (MX500i: AEP, CH, SP) IC R5F364AEDFA (for SERVICE) (MX550i) IC R5F364AEDFA (for SERVICE) (CND) IC MFI341S2164 IC TK11133CSCL-G
IC502 IC503 IC504 IC505 IC506
6-713-384-01 8-759-278-58 6-705-337-01 6-712-613-01 6-715-266-01
IC IC IC IC IC
BD3491FS-SE2 NJM4558V-TE2 TK11150CSCL-G SI-3010KM-TLS BD8410FPS-E2 (EXCEPT CND)
IC507 IC508 IC509 IC510 IC511
8-759-598-69 6-702-302-01 6-702-302-01 6-715-266-01 8-759-278-58
IC IC IC IC IC
BA6956AN TK11133CSCL-G TK11133CSCL-G (EXCEPT CND) BD8410FPS-E2 NJM4558V-TE2 (MX550i)
IC515 IC702
8-759-278-58 6-715-134-01
IC NJM4558V-TE2 IC MM3404A33URE
Q106 Q504 Q505 Q506 Q507
8-729-043-90 8-729-027-26 8-729-027-43 8-729-027-43 8-729-027-23
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
IMX9T110 DTA114YKA-T146 DTC114EKA-T146 DTC114EKA-T146 DTA114EKA-T146
Q508 Q509 Q512 Q516 Q517
8-729-027-43 6-551-696-01 8-729-027-43 8-729-620-07 8-729-027-50
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC114EKA-T146 ISA1235AC1TP-1EF DTC114EKA-T146 2SC3052EF-T1-LEF DTC123JKA-T146
Q701 Q702 Q703 Q752 Q753
8-729-620-07 6-551-696-01 6-551-696-01 6-551-696-01 6-551-696-01
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC3052EF-T1-LEF ISA1235AC1TP-1EF ISA1235AC1TP-1EF ISA1235AC1TP-1EF ISA1235AC1TP-1EF
< RESISTOR/CAPACITOR > R101 R102 R103 R104 R108
1-216-849-11 1-216-851-11 1-216-845-11 1-216-845-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
220K 330K 100K 100K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R111 R112 R113 R114 R115
1-216-821-11 1-216-833-11 1-216-833-11 1-216-829-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 10K 10K 4.7K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W (MX550i)
R120 R121 R125 R127 R134
1-218-879-11 1-218-879-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 22K 100 100 100
0.5% 0.5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R137 R142
1-216-809-11 1-218-879-11
METAL CHIP METAL CHIP
100 22K
5% 0.5%
R143
1-218-879-11
METAL CHIP
22K
0.5%
R144
1-216-809-11
METAL CHIP
100
5%
R145
1-218-879-11
METAL CHIP
22K
0.5%
1/10W 1/10W (MX550i) 1/10W (MX550i) 1/10W (MX550i) 1/10W (MX550i)
69
HCD-MX500i/MX550i MAIN Ref. No.
Part No.
Description
R147
1-218-879-11
METAL CHIP
22K
0.5%
Part No.
Description
R157 R161 R162 R163
1-216-849-11 1-216-296-11 1-216-296-11 1-216-813-11
METAL CHIP SHORT CHIP SHORT CHIP METAL CHIP
220K 0 0 220
5%
1/10W
R367 R371 R372 R373 R374
1-216-864-11 1-216-864-11 1-216-833-11 1-216-833-11 1-216-833-11
SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
0 0 10K 10K 10K
5%
R201 R202 R203 R204 R209
1-216-849-11 1-216-851-11 1-216-845-11 1-216-845-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
220K 330K 100K 100K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R388 R389 R391 R398 R399
1-216-829-11 1-216-833-11 1-216-821-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP
R211 R212 R213 R214 R215
1-216-821-11 1-216-833-11 1-216-833-11 1-216-829-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 10K 10K 4.7K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W (MX550i)
R400 R401 R402 R403 R404
1-216-833-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
R221 R232 R233 R234 R237
1-218-879-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22K 100 100 100 100
0.5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R408 R409 R410 R411 R412
R241
1-218-879-11
METAL CHIP
22K
0.5%
R242
1-218-879-11
METAL CHIP
22K
0.5%
R243
1-216-809-11
METAL CHIP
100
5%
1/10W (MX550i) 1/10W (MX550i) 1/10W (MX550i)
R245 R246
1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP
0 0
R247 R248
1-216-809-11 1-218-879-11
METAL CHIP METAL CHIP
100 22K
5% 0.5%
R249
1-218-879-11
METAL CHIP
22K
0.5%
R250 R251
1-216-295-00 1-216-295-00
SHORT CHIP SHORT CHIP
0 0
R252 R253 R254 R255 R257
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-849-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 220K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R258 R259 R262 R349 R350
1-216-845-11 1-216-845-11 1-216-813-11 1-216-864-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP SHORT CHIP SHORT CHIP
100K 100K 220 0 0
5% 5% 5%
1/10W 1/10W 1/10W
R351 R352 R353 R354 R355
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 0 0 0 0
R356 R357 R358 R359 R360
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-107-826-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP CERAMIC CHIP
0 0 (MX500i: AEP/MX550i) 0 (MX500i: AEP/MX550i) 0 0.1uF 10% 16V
R362 R363 R364 R365 R366
1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11 1-216-864-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
0 (MX550i) 0 (MX550i) 0 0 0
70
Remark 1/10W (MX550i) 1/10W
1/10W 1/10W (MX550i) 1/10W (MX550i)
Ref. No.
Remark
5% 5% 5%
1/10W 1/10W 1/10W
4.7K 10K 1K 0 0
5% 5% 5%
1/10W 1/10W 1/10W
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
1-216-809-11 1-216-833-11 1-219-570-11 1-216-849-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 10K 10M 220K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R413 R414 R416 R417 R418
1-216-864-11 1-216-809-11 1-216-864-11 1-216-833-11 1-216-809-11
SHORT CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
0 100 5% 1/10W 0 (EXCEPT CND) 10K 5% 1/10W 100 5% 1/10W (MX500i: AEP/MX550i)
R419 R420 R422 R424 R426
1-216-809-11 1-216-841-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 47K 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R427
1-216-809-11
METAL CHIP
100
5%
R428 R429 R430 R431
1-216-809-11 1-216-829-11 1-216-829-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 4.7K 4.7K 100
5% 5% 5% 5%
1/10W (EXCEPT CND) 1/10W 1/10W 1/10W 1/10W
R432 R433 R434 R435 R436
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R437 R438 R439 R440 R441
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R442 R443 R444 R445 R446
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R447 R448 R449
1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP
100 100 100
5% 5% 5%
R450
1-216-809-11
METAL CHIP
100
5%
R451
1-216-809-11
METAL CHIP
100
5%
1/10W 1/10W 1/10W (MX550i) 1/10W (MX550i) 1/10W
R452
1-216-809-11
METAL CHIP
100
5%
1/10W
HCD-MX500i/MX550i MAIN Ref. No.
Part No.
Description
R453 R454 R455 R456
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100
Remark
R457 R458 R459 R460 R461
1-216-821-11 1-216-821-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 1K 100 100 100
5% 5% 5% 5% 5%
R462 R463 R464 R465
1-216-809-11 1-216-821-11 1-216-809-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 1K 100 1K
5% 5% 5% 5%
R465
1-216-829-11
METAL CHIP
4.7K
R466 R469 R470 R471 R472
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R473 R474 R475 R476 R477
1-216-833-11 1-216-857-11 1-216-833-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 1M 10K 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R478 R480 R482 R483 R484
1-216-809-11 1-216-821-11 1-216-809-11 1-216-821-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 1K 100 1K 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R485 R486 R487 R488 R489
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R490 R491 R492
1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP
100 100 100
5% 5% 5%
R493 R494
1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP
100 100
1/10W 1/10W 1/10W (EXCEPT CND) 5% 1/10W 5% 1/10W
R495 R496
1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP
100 100
5% 5%
R497 R498 R499
1-216-809-11 1-216-864-11 1-216-864-11
METAL CHIP SHORT CHIP SHORT CHIP
100 0 0 (EXCEPT CND)
R501 R502 R503 R505 R506
1-216-864-11 1-216-864-11 1-216-797-11 1-218-879-11 1-216-864-11
SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP SHORT CHIP
0 0 10 22K 0
R513 R514 R515 R516 R517
1-218-863-11 1-218-863-11 1-218-907-11 1-218-903-11 1-211-977-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 4.7K 330K 220K 22
0.5% 0.5% 0.5% 0.5% 0.5%
R518
1-216-841-11
METAL CHIP
47K
5%
5% 1/10W 5% 1/10W 5% 1/10W 5% 1/10W (MX500i: AEP/MX550i) 1/10W 1/10W 1/10W 1/10W 1/10W
1/10W 1/10W 1/10W 1/10W (MX500i: CND) 5% 1/10W (MX500i: AEP/MX550i)
1/10W 1/10W (EXCEPT CND) 5% 1/10W
5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (CND, CH, SP)
Ref. No.
Part No.
Description
R519 R520 R521 R522
1-216-833-11 1-216-821-11 1-216-825-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 1K 2.2K 4.7K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
Remark
R523 R524 R529 R530 R531
1-216-825-11 1-216-829-11 1-216-833-11 1-216-841-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
2.2K 4.7K 10K 47K 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R532 R533 R534 R535 R536
1-216-821-11 1-216-822-11 1-216-833-11 1-216-829-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 1.2K 10K 4.7K 47K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R537 R538 R539 R541 R542
1-218-871-11 1-218-847-11 1-218-879-11 1-216-833-11 1-218-879-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 1K 22K 10K 22K
0.5% 0.5% 0.5% 5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R546 R547 R548 R553 R555
1-216-833-11 1-216-829-11 1-216-829-11 1-218-879-11 1-216-864-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP
10K 4.7K 4.7K 22K 0
5% 5% 5% 0.5%
1/10W 1/10W 1/10W 1/10W
R556
1-216-841-11
METAL CHIP
47K
5%
R557 R558 R559 R560
1-216-833-11 1-216-833-11 1-216-864-11 1-216-845-11
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP
R561 R562 R565
1-218-863-11 1-216-845-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP
4.7K 100K 4.7K
0.5% 5% 5%
R565 R570
1-216-864-11 1-216-833-11
SHORT CHIP METAL CHIP
0 (CH, SP) 10K 5%
R571 R572 R574 R576 R577
1-216-833-11 1-216-864-11 1-216-821-11 1-216-833-11 1-216-833-11
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
10K 0 1K 10K 10K
5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
R579 R581
1-216-849-11 1-216-809-11
METAL CHIP METAL CHIP
220K 100
5% 5%
R582
1-216-809-11
METAL CHIP
100
R583 R584
1-216-833-11 1-216-833-11
METAL CHIP METAL CHIP
10K 10K
1/10W 1/10W (EXCEPT CND) 5% 1/10W (EXCEPT CND) 5% 1/10W 5% 1/10W
R585
1-216-809-11
METAL CHIP
100
5%
R586
1-216-809-11
METAL CHIP
100
5%
R587
1-216-809-11
METAL CHIP
100
5%
R588 R589
1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP
100 100
5% 5%
1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W (EXCEPT CND) 1/10W 1/10W
R590 R591 R592 R593 R594
1-216-809-11 1-216-864-11 1-216-833-11 1-216-821-11 1-216-833-11
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
100 0 10K 1K 10K
5%
1/10W
5% 5% 5%
1/10W 1/10W 1/10W
1/10W (CND, CH, SP) 10K 5% 1/10W 10K 5% 1/10W 0 (EXCEPT CND) 100K 5% 1/10W (EXCEPT CND) 1/10W 1/10W 1/10W (CND) 1/10W
71
HCD-MX500i/MX550i MAIN
MS-203
POWER
Ref. No.
Part No.
Description
Remark
R595 R596 R597 R598 R599
1-216-833-11 1-216-833-11 1-216-845-11 1-216-853-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 10K 100K 470K 100K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R600 R601 R701 R706 R711
1-216-837-11 1-216-837-11 1-216-864-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
22K 22K 0 100 100
5% 5%
1/10W 1/10W
5% 5%
1/10W 1/10W
R713 R714 R718 R724 R725
1-216-809-11 1-216-809-11 1-216-864-11 1-216-138-00 1-216-138-00
METAL CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
100 100 0 3.3 3.3
5% 5%
1/10W 1/10W
5% 5%
1/8W 1/8W
R726 R727 R728 R731 R733
1-216-845-11 1-216-845-11 1-216-845-11 1-216-805-11 1-216-805-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 100K 100K 47 47
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R736 R743 R745 R746 R747
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-817-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 470
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R751 R752 R753 R754 R756
1-216-864-11 1-216-809-11 1-216-295-00 1-216-809-11 1-216-809-11
SHORT CHIP METAL CHIP SHORT CHIP METAL CHIP METAL CHIP
0 100 0 100 100
5%
1/10W
5% 5%
1/10W 1/10W
R758 R765 R766 R767 R768
1-216-837-11 1-216-864-11 1-216-158-00 1-216-158-00 1-216-158-00
METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP
22K 0 22 22 22
5%
1/10W
5% 5% 5%
1/8W 1/8W 1/8W
R769 R774 R775 R776 R777
1-216-158-00 1-216-138-00 1-216-138-00 1-216-845-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
22 3.3 3.3 100K 100K
5% 5% 5% 5% 5%
1/8W 1/8W 1/8W 1/10W 1/10W
R778 R780 R781 R782 R783
1-216-845-11 1-216-801-11 1-216-817-11 1-216-857-11 1-216-801-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100K 22 470 1M 22
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R784 R785 R786 R787 R788
1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 100 100 100 100
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R789 R792 R793
1-216-809-11 1-216-864-11 1-216-841-11
METAL CHIP SHORT CHIP METAL CHIP
100 0 47K
5%
1/10W
5%
1/10W
Part No.
Description
Remark
MS-203 BOARD ************ When the MS-203 board is damaged, exchange the entire CDM85 (CD) ASSY. ************************************************************ POWER BOARD ************ < CAPACITOR >
< VIBRATOR > X401 1-814-067-11 OSCILLATOR, CRYSTAL (32.768KHz) X402 1-795-058-21 VIBRATOR, CERAMIC (5MHz) X703 1-814-266-11 VIBRATOR, CRYSTAL (49.152MHz) ************************************************************
72
Ref. No.
0 0 0 0 0
C1 C2 C4 C5 C10
1-165-529-11 1-165-529-11 1-119-886-51 1-119-886-51 1-100-923-21
MYLAR MYLAR CERAMIC CERAMIC ELECT
0.22uF 0.22uF 470PF 470PF 100uF
10% 250V 10% 250V 10% 250V 10% 250V 20% 450V (EXCEPT CND)
0 C11
1-100-858-11
ELECT (BLOCK) 390uF
20%
0 C12
1-100-858-11
ELECT (BLOCK) 390uF
20%
0 C13 0 C14 0 C15
1-162-970-91 1-163-275-91 1-126-964-91
CERAMIC CHIP 0.01uF CERAMIC CHIP 0.001uF ELECT 10uF
10% 5% 20%
0 0 0 0 0
C16 C17 C18 C19 C20
1-126-963-91 1-162-964-91 1-115-339-91 1-115-339-91 1-104-664-91
ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 47uF
4.7uF 20% 0.001uF 10% 0.1uF 10% 0.1uF 10% 20% 25V
50V 50V 50V 50V
0 0 0 0 0
C21 C22 C23 C24 C25
1-115-340-91 1-107-824-81 1-107-824-81 1-165-610-11 1-126-950-91
CERAMIC CHIP CERAMIC CERAMIC FILM ELECT
0.22uF 220PF 220PF 0.033uF 330uF
10% 5% 5% 3% 20%
25V 1KV 1KV 800V 35V
0 C602 0 C603 0 C604 C606 C902
1-115-339-91 1-162-966-91 1-126-960-91 1-162-970-11 1-137-649-31
CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT
0.1uF 0.0022uF 1uF 0.01uF 220uF
10% 10% 20% 10% 20%
50V 50V 50V 25V 10V
C904 C905 C906 C907 C908
1-100-597-91 1-126-916-11 1-112-231-11 1-114-994-11 1-216-864-11
CERAMIC CHIP ELECT ELECT ELECT SHORT CHIP
0.1uF 1000uF 2200uF 2200uF 0
10% 20% 20% 20%
25V 6.3V 16V 35V
C909 C910 C913 C914 C915
1-216-864-11 1-107-726-91 1-126-964-11 1-127-715-11 1-127-715-11
SHORT CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
0 0.01uF 10uF 0.22uF 0.22uF
10% 20% 10% 10%
16V 50V 16V 16V
C916 C917 C918 C919 C920
1-125-898-11 1-100-597-91 1-216-864-11 1-216-864-11 1-112-254-11
CERAMIC CHIP CERAMIC CHIP SHORT CHIP SHORT CHIP ELECT
0.22uF 0.1uF 0 0 1000uF
10% 10%
50V 25V
20%
35V
C923 C929 C930 C944 C945
1-100-597-91 1-115-340-11 1-112-222-21 1-115-340-11 1-125-898-11
CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
0.1uF 0.22uF 2200uF 0.22uF 0.22uF
10% 10% 20% 10% 10%
25V 25V 10V 25V 50V
C950 C952 C954 C956
1-127-715-11 1-126-935-11 1-127-715-11 1-100-597-91
CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP
0.22uF 470uF 0.22uF 0.1uF
10% 20% 10% 10%
16V 16V 16V 25V
250V (CND) 250V (CND) 25V 50V 50V
HCD-MX500i/MX550i POWER Ref. No.
Part No.
Description
C957
1-126-964-11
ELECT
Remark
C958 C959 C960
1-126-923-91 1-107-826-11 1-107-826-11
ELECT 220uF CERAMIC CHIP 0.1uF CERAMIC CHIP 0.1uF
10uF
20%
50V
20% 10% 10%
10V 16V 16V
Ref. No.
Part No.
Description
Remark
< COIL > L901 L904
1-412-525-31 1-400-424-21
INDUCTOR INDUCTOR
10uH 47uH
< PHOTO COUPLER > < CONNECTOR > 0 CN1
1-564-321-11
PIN, CONNECTOR (3.96mm PITCH) 2P < DIODE >
0 PH11 0 PH601 0 PH602
6-600-276-01 6-600-276-01 6-600-276-01
PHOTO COUPLER PS2561AL1-1-V-W PHOTO COUPLER PS2561AL1-1-V-W PHOTO COUPLER PS2561AL1-1-V-W < TRANSISTOR >
0 0 0 0 0
D1 D2 D3 D11 D14
8-719-077-77 8-719-081-58 8-719-081-58 8-719-979-64 6-500-567-21
DIODE DIODE DIODE DIODE DIODE
D3SB60F3 S2V60-TA (CND) S2V60-TA (CND) UF4005/23 10ERB20-TB5
0 0 0 0 0
D15 D16 D17 D602 D603
6-501-178-01 6-501-178-01 8-719-060-48 8-719-073-23 6-500-567-21
DIODE DIODE DIODE DIODE DIODE
UDZW-TE17-15B UDZW-TE17-15B RB751V-40TE-17 ST02D-200TA 10ERB20-TB5
D901 D902 D903 D904 D905
6-500-567-21 6-500-567-21 6-503-050-01 6-502-478-01 8-719-110-53
DIODE DIODE DIODE DIODE DIODE
10ERB20-TB5 10ERB20-TB5 SBT80-06LS-S FMEN-210A RD20ESB2
D906 D907 D910 D911 D913
6-503-030-01 6-502-990-01 6-503-013-01 6-500-334-01 6-500-334-01
DIODE DIODE DIODE DIODE DIODE
DZ2J160M0L SJPJ-L3VL DZ2J043M0L MC2836-T112-1 MC2836-T112-1
D914 D922 D923 D927
6-502-973-01 6-502-961-01 6-503-022-01 6-502-968-01
DIODE DIODE DIODE DIODE
DZ2J091M0L DA2J10100L DZ2J100M0L DZ2J062M0L
< EARTH TERMINAL > * EP1 * EP901 * EP902
1-537-738-21 1-537-738-21 1-537-738-21
TERMINAL, EARTH TERMINAL, EARTH TERMINAL, EARTH < FUSE >
0 F1
1-576-232-51
FUSE (H.B.C.) (T5AH/250V) < FERRITE BEAD >
0 FB11
1-410-397-31
FERRITE
1.1uH
< FUSE HOLDER > FH1 FH2
1-533-217-31 1-533-217-31
FUSE HOLDER FUSE HOLDER < IC >
0 IC11 0 IC601 IC904 IC905 IC908
6-707-749-01 6-708-726-01 6-713-826-01 6-713-793-01 6-713-031-01
IC IC IC IC IC
IC909
6-711-947-01
IC MM1431CURE
CXD9841P MIP2F20MS1SO SI-8001FFEK SI-3010KFEK KIA7805API-U/PF
0 Q011 0 Q012 0 Q601 Q901 Q902
6-551-319-01 6-551-319-01 8-729-620-07 8-729-620-07 8-729-620-07
FET FET TRANSISTOR TRANSISTOR TRANSISTOR
2SK3563 (LB2SONY) 2SK3563 (LB2SONY) 2SC3052EF-T1-LEF 2SC3052EF-T1-LEF 2SC3052EF-T1-LEF
Q903 Q904
6-551-696-01 8-729-620-07
TRANSISTOR TRANSISTOR
ISA1235AC1TP-1EF 2SC3052EF-T1-LEF
< RESISTOR > 0 R2 0 R3
1-219-512-91 1-219-759-91
METAL METAL
2.2M 1M
5% 5%
0 R4
1-219-759-91
METAL
1M
5%
0 R10 0 R11
1-218-881-91 1-216-864-91
METAL CHIP SHORT CHIP
27K 0
0.5%
1/2W F 1/2W F (CND) 1/2W F (CND) 1/10W
0 0 0 0 0
R12 R13 R14 R15 R16
1-245-502-31 1-245-502-31 1-218-911-91 1-218-887-91 1-218-823-91
METAL METAL METAL CHIP METAL CHIP METAL CHIP
4.7M 4.7M 470K 47K 100
2% 2% 0.5% 0.5% 0.5%
1/4W F 1/4W F 1/10W 1/10W 1/10W
0 0 0 0 0
R17 R18 R20 R22 R23
1-211-989-91 1-216-833-91 1-216-833-91 1-249-417-11 1-217-568-31
METAL CHIP METAL CHIP METAL CHIP CARBON METAL
68 10K 10K 1K 0.22
0.5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/4W F 2W F
0 0 0 0 0
R24 R25 R27 R29 R603
1-216-821-91 1-247-694-81 1-216-797-91 1-216-797-91 1-216-853-91
METAL CHIP CARBON METAL CHIP METAL CHIP METAL CHIP
1K 33 10 10 470K
5% 5% 5% 5% 5%
1/10W 1/4W F 1/10W 1/10W 1/10W
0 0 0 0 0
R604 R605 R606 R608 R609
1-249-401-11 1-216-835-91 1-249-381-61 1-216-821-91 1-218-899-91
CARBON METAL CHIP CARBON METAL CHIP METAL CHIP
47 15K 1 1K 150K
5% 5% 5% 5% 0.5%
1/4W F 1/10W 1/4W F 1/10W 1/10W
0 R610 R901 R902 R903 R904
1-218-907-91 1-216-821-11 1-216-817-11 1-216-821-11 1-216-845-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
330K 1K 470 1K 100K
0.5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R905 R906 R907 R908 R909
1-216-817-11 1-216-805-11 1-218-863-11 1-218-879-11 1-218-887-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
470 47 4.7K 22K 47K
5% 5% 0.5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R910 R911 R912 R913
1-216-821-11 1-216-833-11 1-216-841-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 10K 47K 10K
5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W
73
HCD-MX500i/MX550i POWER Ref. No.
SP
USB
Part No.
Description
R914
1-216-821-11
METAL CHIP
1K
5%
1/10W
Remark
R915 R916 R918 R920 R921
1-216-833-11 1-216-817-11 1-218-845-11 1-218-893-11 1-218-879-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 470 820 82K 22K
5% 5% 0.5% 0.5% 0.5%
1/10W 1/10W 1/10W 1/10W 1/10W
R922 R924 R925 R926 R927
1-218-871-11 1-218-883-11 1-218-871-11 1-218-887-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 33K 10K 47K 1K
0.5% 0.5% 0.5% 0.5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R928 R929 R930 R931 R932
1-216-829-11 1-216-829-11 1-216-821-11 1-216-827-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 4.7K 1K 3.3K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R933 R934 R948 R951 R952
1-216-833-11 1-216-821-11 1-216-833-11 1-216-833-11 1-216-829-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
10K 1K 10K 10K 4.7K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R953 R955 R960 R961 R962
1-216-821-11 1-216-821-11 1-216-825-11 1-216-821-11 1-216-821-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
1K 1K 2.2K 1K 1K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R963 R964 R965 R966 R968
1-216-829-11 1-216-821-11 1-216-821-11 1-216-827-11 1-216-833-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
4.7K 1K 1K 3.3K 10K
5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R969
1-218-867-11
METAL CHIP
6.8K
0.5%
1/10W
Ref. No. C328
Part No.
Description
1-162-964-11
CERAMIC CHIP 0.001uF
T1 T1 T031 T603
1-445-048-21 1-457-326-21 1-445-690-11 1-443-942-11
TRANSFORMER, LINE FILTER (EXCEPT CND) COIL, LINE FILTER (CND) TRANSFORMER, DC-DC CONVERTER TRANSFORMER, DC-DC CONVERTER < THERMISTOR >
0 TH1 0 TH1 0 TH2
1-802-075-11 1-805-901-11 1-805-901-11
THERMISTOR, NTC (EXCEPT CND) THERMISTOR, NTC (CND) THERMISTOR, NTC (CND) < VARISTOR >
0 VDR001 1-802-425-21 VARISTOR (TND14SV471K) (EXCEPT CND) 0 VDR001 1-811-148-21 VARISTOR (TND10SV271K) (CND) ************************************************************ SP BOARD ******** < CAPACITOR > C321 C322 C323 C324 C325
1-163-021-11 1-163-021-11 1-163-021-11 1-163-021-11 1-162-964-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.01uF 0.01uF 0.01uF 0.01uF 0.001uF
10% 10% 10% 10% 10%
50V 50V 50V 50V 50V
C326 C327
1-162-964-11 1-162-964-11
CERAMIC CHIP 0.001uF CERAMIC CHIP 0.001uF
10% 10%
50V 50V
74
50V
< TERMINAL > TB322 1-780-639-11 TERMINAL BOARD (SPEAKER) 2P (SPEAKERS) ************************************************************ USB BOARD (EXCEPT CND) ********* < CAPACITOR > C315 C316 C317
1-165-989-11 1-107-826-11 1-107-826-11
CERAMIC CHIP 10uF CERAMIC CHIP 0.1uF CERAMIC CHIP 0.1uF
10% 10% 10%
6.3V 16V 16V
< CONNECTOR > CN316 1-822-423-11 CONNECTOR, USB (A) ( ) ************************************************************* MISCELLANEOUS ************** 7 63 111 153 204
1-457-413-11 1-832-578-21 1-838-389-21 1-400-932-11 1-481-419-11
CORE, FERRITE CABLE, FLEXIBLE FLAT (13 CORE) CABLE, FLEXIBLE FLAT (13 CORE) FILTER, CLAMP CORE, FERRITE
205 205 205 205 208
1-834-966-41 1-835-078-31 1-837-308-11 1-837-822-21 1-400-092-11
POWER-SUPPLY CORD (AEP, SP) CORD, POWER (UK) CORD, POWER-SUPPLY (CND) CORD, POWER-SUPPLY (CH) CORE, FERRITE
209 209 211 211
1-832-814-21 1-832-824-21 1-832-601-21 1-832-641-21
212
1-832-554-21
CABLE, FLEXIBLE FLAT (9 CORE) (CND, CH, SP) CABLE, FLEXIBLE FLAT (11 CORE) (AEP, UK) CABLE, FLEXIBLE FLAT (19 CORE) (CND) CABLE, FLEXIBLE FLAT (27 CORE) (EXCEPT CND) CABLE, FLEXIBLE FLAT (9 CORE) (MX550i)
0 251 253 254 0 255 CN01
A-1764-002-A 1-832-539-21 1-830-688-51 8-820-321-05 1-820-441-11
CDM85 (CD) ASSY (Including MS-213 board) CABLE, FLEXIBLE FLAT (5 CORE) WIRE (FLAT TYPE) (24 CORE) DEVICE, OPTICAL KHM-313CAA/C2RP CONNECTOR, COAXIAL (F TYPE) (MX550i)
DAB1 TU1 TU1 TU1 TU1
1-487-958-21 1-693-780-11 1-693-781-11 1-693-787-11 1-693-788-11
MODULE (DAB TUNER) (MX550i) TUNER (FM) (SP) TUNER (FM) (CND) TUNER (FM) (AEP, UK) TUNER (FM) (CH)
0 0 0 0
< TRANSFORMER/COIL > 0 0 0 0
Remark 10%
HCD-MX500i/MX550i
MEMO
75
HCD-MX500i/MX550i
REVISION HISTORY Checking the version allows you to jump to the revised page. Also, clicking the version at the top of the revised page allows you to jump to the next revised page. Ver.
Date
1.0
2010.05
Description of Revision New
